2009 Audi Q5

31 complaints on file, page 1 of 2.

1. Filed Sep 9, 2026Failure Sep 9, 2026Dayton, OHBody

   I am reporting a potentially serious safety defect involving the rear subframe/crossmember of my 2009 Audi Q5. I discovered significant corrosion on the vehicle's rear subframe, which is a structural component supporting the rear suspension and rear axle assembly. The corrosion is substantially more than normal superficial surface rust. There is visible rust scaling and loss of material in areas of the rear subframe. The affected area was partially concealed by the factory-installed plastic stone guards/shields. Because these plastic covers obscure the subframe, the extent of the corrosion is difficult to identify during a normal visual inspection unless the covers are removed. I am concerned that continued corrosion could reduce the structural integrity of the rear subframe and potentially compromise the mounting points for the rear suspension or rear axle components. A structural failure of the rear subframe could result in unexpected changes in wheel alignment, suspension movement, loss of vehicle control, or other serious safety consequences. This issue is particularly concerning because the corrosion can develop underneath the plastic protective covers and may not be visible to the vehicle owner during normal operation. Safety Concern The rear subframe is not merely a cosmetic body panel. It is a structural component associated with the rear suspension and axle assembly. If corrosion continues to remove structural material, a suspension mounting point or section of the subframe could potentially weaken or fail under normal driving loads. A failure while the vehicle is being driven, particularly at highway speed, could potentially result in loss of vehicle control. There were no dashboard warning lights or electronic warnings indicating this condition. The problem was discovered through physical inspection of the underside of the vehicle. Possible Design/Corrosion Mechanism The factory-installed plastic stone guards appear to cover portions of the rea

   NHTSA complaint 11763236
2. Filed Sep 17, 2023Failure Sep 8, 2023Pasadena, CATether, Lower anchor (on car seat or vehicle)

   Cybex Sirona S is marketed as a 360 car seat that rotates and swivels, but when in forward-facing mode for functionality it does not tether. The guidance is to use the load leg to keep the swivel and rotation but then not use the tether. The tether strap is critical for safety and part of CPST guidance. People purchasing this seat are being made to compromise safety for functionality.

   NHTSA complaint 11545067
3. Filed Feb 17, 2023Failure Jan 4, 2023Escalante, UTAir bagsCrash1 injured

   I was in an accident where I hit a herd of elk. My car was totaled. The airbags did not deploy and they definitely should have. It was hit on the front, and both front sides. There is no way the airbags shouldn’t have deployed.

   NHTSA complaint 11507755
4. Filed Nov 17, 2022Failure May 1, 2022140,000 milesLouisville, KYEngine and engine cooling, Service brakes, Air, Accelerator pedal

   The contact owns a 2009 Audi Q5. The contact stated that the vehicle was smoking. There was antifreeze and oil leaking from the vehicle. While driving, the accelerator pedal and brake pedal became stuck, and the vehicle stalled. There was an abnormal oil burning odor, fuel, and antifreeze. The vehicle was also consuming an excessive amount of fuel. The gear shifter button was also stuck. The gear box malfunctioned, and a message to restart vehicle was displayed. Additionally, the tailgate seized while going up and down. The vehicle was taken to an independent mechanic where additional oil was added several days. The vehicle was taken to an unknown local dealer where the antifreeze was changed. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 140,000.

   NHTSA complaint 11493915
5. Filed May 29, 2022Failure May 28, 2022Houston, TXUnknown or other

   I got in my car at about 6pm on Saturday May 28, 2022. Started it up and proceeded to start opening the sunroof when I noticed it was cracked. I was thinking some kids had hit it with a ball until I traced the spiderwebbing right back to to the center of the panoramic sunroof. You could wind noise really bad when driving.

   NHTSA complaint 11466569
6. Filed Jul 14, 2021Failure Jul 14, 2021San Tan Valley, AZAir bags

   Front left door pillar is becoming soaked from an apparent water leak possibly coming from the panoramic sunroof or windshield. Regardless it has to be running into the pillar airbag and has to be a safety concern.

   NHTSA complaint 11424741
7. Filed Nov 20, 2020Failure Nov 1, 2020Accokeek,, MDFuel/propulsion system

   FUEL LEAKING FROM FUEL PUMP UNDER PASSENGER 'S SEAT AFRAID TO DRIVER IT BECAUSE AS LONG AS THE ENGINE IS RUNNING THE FUEL CONTINUE TOO LEAK WHETHER THE CAR IS MOVING OR STATIONARY!!

   NHTSA complaint 11375670
8. Filed Nov 16, 2020Failure Nov 1, 2020Accokeek, MDFuel/propulsion system

   FUEL LEAKING ON RIGHT SIDE JUST UNDER THE PASSENGER'S SEAT ON GROUND WHEN CAR IS RUNNING

   NHTSA complaint 11374880
9. Filed Jul 4, 2020Failure Jul 10, 2019Deer Park, WAAir bags

   RIGHT SIDE PASSENGER TRIM FOR AIRBAG IS LOOSE AND HAS BEEN DETECTED IN OTHER CASES TO HAVE POSSIBILITY OF BEING INEFFECTIVE IN DEPLOYING.

   NHTSA complaint 11337443
10. Filed Dec 27, 2019Failure Oct 1, 2019106,000 milesWoodinville, WAEngine

    ON 7/02/09 MY AUDI Q5 (VIN# [XXX]) WAS PURCHASED FROM, AND SERVICED BY BARRIER AUDI BELLEVUE, WASHINGTON; NOW DOING BUSINESS AS AUDI BELLEVUE A DEALERSHIP OWNED AND OPERATED BY AUTO NATION. TECHNICAL SERVICE BULLETINS [TSB] WERE SENT TO SOME AUDI OWNERS ON 12/6/2013 CONCERNING REPAIR AND CLEANING OF THE SECONDARY AIR CONTROL VALVE WITH A WARRANTY EXTENDING THROUGH 07/02/2019. THIS PROBLEM WAS INITIALLY CORRECTED ON 12/27/2013 @44,445 MILES, MY LAST SERVICE WITH BARRIER WAS 09/13/2018 AND AT NO TIME HAD I RECEIVED NOTICE THAT THE PROBLEM COULD RESURFACE. THE TSB PROVIDES : "THE SECONDARY AIR SYSTEM ON THESE VEHICLES IS USED TO HEAT UP THE CATALYTIC CONVERTERS QUICKLY DURING COLD-START CONDITIONS?. OVER TIME, AND DEPENDING ON DRIVING STYLES, CARBON WILL BUILD UP IN THESE SMALL 10MM PORTS AND CAUSE FAULTS IN THE ENGINE CONTROL MODULE FOR SECONDARY AIR, BANK1/BANK2 INSUFFICIENT FLOW? SOME MODELS DO HAVE A WARRANTY EXTENSION, WHICH COVERS THE SECONDARY AIR PORT CLEANING UP TO 10 YEAR/110,000 MILES. PLEASE CHECK WITH YOUR LOCAL DEALER FOR DETAILS. KEEP IN MIND, IF ANY OF THE CONTROL VALVES, COMBI VALVES, OR SUPPLY LINES ARE DAMAGED, OR FAULTY, THOSE ITEMS ARE NOT COVERED UNDER THE WARRANTY EXTENSION, AND WOULD HAVE TO BE REPLACED BEFORE THE PORT CLEANING CAN BE PERFORMED." ON 10/01/ 2019, AN ENGINE WARNING LIGHT WAS DETECTED ON THE Q5 WITH APPROXIMATELY 106,000 MILES ON THE ODOMETER. ON 10/28/2019 A CLAIM [#190822437]` WAS FILED WITH AUDI USA AND DENIED AS UNTIMELY FILED. AUDI BELLEVUE CARRIED OUT REPAIRS AT MY EXPENSE FOR $ 2045.75. GIVEN THE FACT THAT THERE WAS NO NOTICE, THE CONTINUED WARRANTY PERIOD SHOULD BE EXTENDED BY AUDI USA AND THE COSTS OF REPAIR REIMBURSED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

    NHTSA complaint 11291459
11. Filed May 31, 2019Failure Feb 1, 2018Rochester, NYAir bags

    TL* THE CONTACT OWNS A 2009 AUDI Q5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V082000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AUDI ROCHESTER (3955 W HENRIETTA RD, ROCHESTER, NY 14623, (585) 334-1600) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

    NHTSA complaint 11217077
12. Filed Dec 13, 2018Failure Oct 20, 2018LAS Vegas, NVFuel/propulsion system, Unknown or other

    THE CAR GAS A STRONG GAS SMELL IN THE CABIN OF THE CAR, EVERYDAY, ALL DAY. TOOK IT TO AUDI AND THEY SAID THEY FIXED THE "PROBLEM". THE CAR CAN'T BE DRIVEN. ITS CAUSING NAUSEA AND HEADACHES WHEN DRIVING MORE THAN 5 MINS. I DON'T FEEL SAFE DRIVING A CAR THAT IS PRODUCING A GAS SMELL. I BELIEVE THAT GAS FLANGE RECALL CREATED MORE ISSUES TO MY CAR THAT AUDI MADE ME PAY FOR AND NEVER FIXED THE GAS SMELL.

    NHTSA complaint 11161068
13. Filed May 3, 2018Failure May 1, 2018SAN Francisco, CAAir bags

    THE DRIVER AIRBAG MAY EXPLODE IN A CRASH WITH AIRBAG DEPLOYMENT. SHARP METAL FRAGMENTS CAN HIT PEOPLE AND CAUSE SERIOUS INJURY OR DEATH. THE DRIVER AIRBAG MAY EXPLODE IN A CRASH WITH AIRBAG DEPLOYMENT. SHARP METAL FRAGMENTS CAN HIT PEOPLE AND CAUSE SERIOUS INJURY OR DEATH. OWNERS SHOULD SCHEDULE THIS RECALL REPAIR IMMEDIATELY, EVEN IF AN INTERIM REPAIR WAS RECENTLY DONE. I HAVE RECEIVED MANY LETTERS ABOUT BRINGING MY CAR IN FOR THE REPAIRS BUT WHENEVER I CALL AUDI AND TRY SCHEDULE SOMETHING THEY KEEP SAYING THAT THE PARTS HAVE NOT ARRIVED. THE ISSUE HAS GONE MORE THAN A YEAR. MY AUDI DEALER IS ROYAL AUTOMOTIVE GROUP OF SAN FRANCISCO. I HAVE CALLED MANY TIMES AND THEY TOLD ME TO KEEP WAITING.

    NHTSA complaint 11091615
14. Filed Apr 16, 2018Failure Apr 1, 2015Norman, OKAir bags

    TL* TAKATA RECALL. THE CONTACT OWNS A 2009 AUDI Q5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V082000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE LOCAL DEALER (BOB MOORE AUDI IN OKLAHOMA CITY, OKLAHOMA) WAS MADE AWARE OF THE RECALL AND STATED THAT THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

    NHTSA complaint 11088471
15. Filed Mar 8, 2018Failure Feb 1, 2016Renton, WAAir bags

    TL* TAKATA RECALL. THE CONTACT OWNS A 2009 AUDI Q5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V082000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AUDI SEATTLE IN SEATTLE, WASHINGTON AND AUDI BELLEVUE IN BELLEVUE, WASHINGTON WERE MADE AWARE OF THE RECALL AND STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

    NHTSA complaint 11078227
16. Filed May 9, 2017Failure Feb 25, 2017Atlanta, GAAir bags

    TL* TAKATA RECALL. THE CONTACT OWNS A 2009 AUDI Q5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

    NHTSA complaint 10984504
17. Filed Apr 20, 2017Failure Apr 17, 2017Renton, WAAir bags

    TAKATA RECALL IT HAS BEEN OVER A YEAR SINCE I FIRST REQUESTED THAT AUDI OF BELLEVUE HANDLE MY AIRBAG RECALL. I CALLED IN MARCH 2016 AND WAS TOLD THEY WOULD HAVE THE PARTS "BY THE END OF THE YEAR." I REQUESTED A LOANER CAR UNTIL IT WAS FIXED AND WAS TRANSFERRED TO A SALES MANAGER WHO DID NOT TAKE MY CALL. I LEFT A MESSAGE EXPLAINING THAT MY CAR SPENT 3 YEARS IN TEXAS AND I HAVE A SMALL CHILD AND WAS NOT COMFORTABLE DRIVING MY CAR WITH THE RECALL. HE NEVER RETURNED MY CALL. I RECENTLY TOOK MY CAR IN FOR REGULAR SERVICE. WHEN I MADE MY APPOINTMENT, I AGAIN REQUESTED THE AIRBAG BE REPLACED AND WAS TOLD THEY STILL DON'T HAVE THE PARTS AND, IN FACT NOBODY IN THE AREA HAD THEM. OUR HONDA WAS FIXED LAST JUNE. I RECEIVED ANOTHER "URGENT" RECALL NOTICE IN THE MAIL THIS WEEK, URGING ME TO CONTACT MY DEALERSHIP IMMEDIATELY. I CALLED AUDI USA TO EXPLAIN THE EXPERIENCE I JUST HAD AND INQUIRE FURTHER. I WAS TOLD THAT THEY WERE HOPING TO GET PARTS TO MY AREA BY SEPTEMBER (IT IS APRIL) AND THAT THE DECISION TO NOT MAKE REPLACEMENT PARTS AVAILABLE TO MY AREA WAS BEING DIRECTED BY THE NHTSA. I EXPLAINED MY CONCERNS ABOUT THE 3 YEARS MY CAR SPENT IN TEXAS AND WAS TOLD THEY WOULD MAKE A NOTE ON MY VEHICLE, BUT THE ONLY ADVICE I WAS GIVEN WAS TO KEEP CHECKING IN WITH MY DEALERSHIP.

    NHTSA complaint 10979704
18. Filed Apr 14, 2017Failure Oct 11, 201664,000 milesWest Hills, CASuspension

    FRONT DRIVER SIDE WHEEL MAKES A LOUD KNOCKING NOISE WHEN BRAKING AND OVER ANY SMALL BUMPS ON THE ROAD.

    NHTSA complaint 10972360
19. Filed Feb 9, 2017Failure Apr 18, 2016Sherman Oaks, CAAir bags

    TL* THE CONTACT OWNS A 2009 AUDI Q5. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V078000 (AIR BAGS) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

    NHTSA complaint 10953700
20. Filed Jan 20, 2017Failure Feb 9, 201645,000 milesOceamside, NYAir bags

    TAKATA RECALL CANNOT GET REPLACEMENT AIRBAG,

    NHTSA complaint 10946707