2011 Audi Q5

143 complaints on file, page 1 of 8.

1. Filed Aug 25, 2026Failure Aug 20, 2026Houston, TXSuspension

   1) The rear structural subframe (crossmember) has completely rotted, perforated, and failed due to severe corrosion. The factory-installed plastic underbody rock shields trapped road salt and water, causing the frame to rust from the inside out. The corrosion has spread, completely fusing and compromising the rear suspension mounting points and the rear differential brackets. The vehicle is fully available for physical inspection upon request. 2) My safety and the safety of others on the road was severely put at risk because the structural integrity of the rear suspension is completely compromised. The rusted metal anchors could snap under driving loads, causing a catastrophic rear suspension collapse, loss of vehicle control, or a high-speed wheel separation on the highway. 3) Yes. The structural failure was independently confirmed by two independent automotive service centers and an authorized Audi dealership service center (Audi Dallas). 4) Yes. An authorized Audi dealership representing the manufacturer physically inspected the vehicle on the lift during a goodwill evaluation. They confirmed the extensive structural damage and issued an official diagnostic repair quote of $20,873.78 to completely rebuild the failed rear subframe, effectively totaling the vehicle. 5) No. There were absolutely no dashboard warning lamps, electronic messages, or obvious driving symptoms prior to the inspection. Because the factory plastic underbody shields completely hidden the metal frame from view, the structural rot developed entirely out of sight until the vehicle was placed on a mechanical lift.

   NHTSA complaint 11759438
2. Filed Aug 5, 2026Failure Jul 10, 2026Andover, MASuspension

   During an inspection of my 2011 Audi Q5 at Audi Burlington, severe corrosion was discovered on the rear subframe, which supports rear suspension components. The corrosion was substantially worse than normal surface rust and may compromise the structural integrity of the subframe and suspension mounting points. The condition was not readily visible during ordinary vehicle use because portions of the subframe are covered. The vehicle has been operated in the northeastern United States, where road salt is used. I was advised that the rear subframe requires replacement at an estimated cost of approximately $5,884. I am concerned that continued deterioration could result in separation or movement of a suspension mounting point and a loss of vehicle control. Audi has not issued a recall or offered to cover the repair. I am aware of similar reports involving Audi Q5 rear subframe corrosion and request that NHTSA investigate whether the design permits moisture, salt and debris to remain against the subframe and cause premature structural corrosion.

   NHTSA complaint 11755002
3. Filed Apr 17, 2025Failure Apr 16, 2025Hudson, NHSuspension

   Rear subframe rust causing car to fail state inspection. This vehicle has been maintained well and always parked in garage. The rear subframe rusted most, then front subframe. This is a common compliant among Audi forum users.

   NHTSA complaint 11655321
4. Filed Apr 13, 2025Failure Mar 17, 2025Fremont, CAElectrical system

   Rear driver side door will not unlock when keypad, nor inside unlock button is pressed. Once inside, door will not unlock in sequence with other doors when vehicle is shut off and it is time to exit the vehicle.

   NHTSA complaint 11654307
5. Filed Jan 18, 2025Failure Jan 1, 2025Council Bluffs, IAElectrical system, Engine, Fuel/propulsion system

   Audi q5 shows no recalls on my vehicle. My car stops randomly while driving even while being on highways and interstates. As well as the passenger side leaking due to sunroof drainage coming to the inside (which may affect the air bags). This Car has not had any repairs on recalls that I know of personally.

   NHTSA complaint 11636788
6. Filed Jan 30, 2023Failure Dec 28, 2022Richmond, VAAir bagsCrash1 injured

   Accident head on collision with wall airbags didn't deploy

   NHTSA complaint 11504366
7. Filed Nov 4, 2022Failure Oct 4, 20221,270,000 milesSacramento, CAFuel system, Gasoline

   The contact's wife owns a 2011 Audi Q5. The contact stated that after he parked the vehicle in his garage, he smelled a fuel odor outside of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the flange had cracked and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and advise the contact to call the manufacturer. The manufacturer was notified of the failure and the contact was informed that the recall was previously performed under the NHTSA Campaign Number: 18V818000 (Fuel System, Gasoline) but no further assistance was provided. The failure mileage was approximately 127,000. The contact stated that the dealership was able to resolve the issue.

   NHTSA complaint 11492317
8. Filed Aug 25, 2022Failure Jun 10, 2020Aliso Viejo, CAEngine, Fuel/propulsion system

   Audi offered a warranty extension for intake manifold & fuel injectors in certain 2008-2011 Model Year Audi Vehicles with 2.0 TFSI Engine. Audi rejected our claim for a faulty fuel injector in our 2011 car citing that “vehicle does not have the extended warranty for fuel injectors and the information that was submitted was only for 2.0 TFSI Engine's with the Engine code of CBFA & CCTA. The engine in your vehicle is a 3.2 FSI with the Engine code CALB. So this warranty extension would not be applicable to your vehicle.” Our Audi dealership diagnosed our car with the same fuel injector issue listed by Audi in this warranty extension as well as stating that this is a very common issue with our make, model and year. Our Audi is a 2011 model, less than 120,000 miles, and less than 10 years when the malfunction indicator lamp appeared. Their letter does not stand to prove that a faulty fuel injector was not placed in our car that was built in 2011, the same year that they installed faulty fuel injectors in their 2.0 TFSI engines. Audi dealership diagnosed our car as suffering from misfire conditions that in turn cause the malfunction indicator lamp to appear. The dealership indicates that this is a common issue with Audis during our production year. This is the same issue that Audi listed in their warranty extension letter to consumers with 2.0 TFSI engines. Our car meets all the requirements in Audi’s warranty extension letter (2011 model, less than 120,000 miles, and less than 10 years when the malfunction indicator lamp appeared) except that our car is a 3.2 FSI vs 2.0 TFSI. Audi is not able show that they did not install a faulty fuel injector into our car. Fuel injector problems in cars with mileage under 100,000 miles and less than 10 years of age is very uncommon. This plus Audi’s history of installing faulty fuel injectors into cars built in our year lead us to believe that Audi also installed a faulty fuel injector into our car.

   NHTSA complaint 11481103
9. Filed May 20, 2022Failure May 20, 2022Bedford, NHUnknown or other

   During a routine inspection my mechanic noticed the subframe of my 2011 Audi Q5 was rusted through in numerous spots. It seemed odd that a vehicle bought new and garaged since it was purchased had such extensive rust. Pictures of the rusted subframe were taken and shown to the local Audi dealer. The dealer then asked to bring the vehicle in so they could take their own pictures. Contacted Audi NA and spoke with rep about problem. The phone call ended abruptly when the Audi NA rep refused to file a claim and hung up on me.

   NHTSA complaint 11465454
10. Filed Nov 3, 2021Failure Nov 1, 2021palos park, ILEngine, Vehicle speed control

    VARIABLE SPEED CONTROL PROBLEMS- ACCELERATES AND DECELERATES IRREGULARLY.

    NHTSA complaint 11439251
11. Filed Oct 29, 2021Failure Oct 18, 2021Desoto, TXFuel/propulsion system

    My car smells like gas, I took it to the dealership ans they said my fuel pump flange is leaking gas

    NHTSA complaint 11438656
12. Filed Dec 24, 2020Failure Dec 23, 202094,250 milesMissouri City, TXEngine, Steering, Suspension

    AUDI Q5 94,000. I WILL NEVER NEVER BUY AUDI VEHICLE AGAIN. FIRST STARTED WITH OIL LEAK, REPLACED VALVE COVER GASKET, THEN HOOD LATCH SENSOR (GERMAN GENIUS). HOW IN THE WORLD THIS BAD SENSOR MEASURES OIL LEVEL. RACK AND PINION LEAK, THEN TIMING COVER GASKET LEAK. THEN MY MECHANIC REPLACED DRIVER SIDE UPPER CONTROL ARM. NOW REAR SHOCK IS BAD. ALREADY SPENT OVER $3000 FINE, THE WORST ISSUE I HAVE IS TRACTION CONTROL LIGHT. THE DEALER (STEALER) GAVE ME ESTIMATE OF $1700 TO FIX THIS. THE LAST SERIOUS ONE ON 12/23/20 WHILE DRIVING WITH 2 MORE PASSENGERS ON BUSY ARE IN HOUSTON NEAR MED.CENTER, CAR ENGINE LOST POWER, SHAKING VIOLENTLY, THEN I DROVE VERY SLOWLY AT AROUND 30 MPH. THIS IS AUDI Q5 IS NIGHTMARE. NHTSA PLEASE DO SOMETHING, MAKE AUDI SETTLE THESE ISSUES. THANK YOU.

    NHTSA complaint 11384772
13. Filed Nov 12, 2020Failure Nov 1, 202081,000 milesKihei, HIFuel system, Gasoline

    TL* THE CONTACT OWNS A 2011 AUDI Q5. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, HE STARTED SMELLING FUEL INSIDE THE CABIN OF THE VEHICLE. THE CONTACT CALLED THE LOCAL DEALER KARMART OF MAUI (411 HUKU LII PL #103, KIHEI, HI 96753, (808) 419-7400) AND THE DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED BY PREVIOUS OWNER UNDER NHTSA CAMPAIGN NUMBER: 16V660000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 81,000.

    NHTSA complaint 11374321
14. Filed Sep 16, 2020Failure Apr 16, 2020120,000 milesElloree, SCService brakes

    TOOK MY VEHICLE TO THE DEALER FOR NEW BRAKE PADS BRAKES AND ROTORS. UPON LEAVING THE CAR WAS MAKING A LOUD NOISE ON THE RIGHT SIDE. I CALLED THE DEALER TO COMPLAIN AND WAS TOLD IT WILL WEAR OFF. EXT FEW TIMES I DROVE THE BRAKES FAILED. I CALLED AUDI AND BROUGHT MY CAR BACK AND NOW THEY WANT ME TO BY BACK BRAKES AND CALLI ER FOR BOTH SIDES WHEN THE WORK WASN'T DONE PROPERLY TO BEGIN WITH.

    NHTSA complaint 11355375
15. Filed Sep 16, 2020Failure Apr 2, 2020120,000 milesElloree, SCFuel/propulsion system

    MY CAR STARTED TO SMELL LIKE GAS AND WHEN I TOOK IT TO THE DEALER THE SAID IT WAS THE FLANGE/ FUEL PUMP AND THAT THE RECALL WAS ALREADY DONE BUT THE SAME ISSUE PERSIST. THE YET ME DRIVE HOME WITH GAS POURING OUT OF MY CAR AFTER SEEING IT AND WANT TO CHARGE ME 1800 FOR A RECALLED PART. I WAS TERRIBLY SCARED AND CANNOT DRIVE AN UNSAFE CAR.

    NHTSA complaint 11355370
16. Filed Jun 6, 2020Failure Mar 16, 2020133,000 milesPalmyra, NJEngine

    MY WIFE AND I HAD THE VEHICLE SERVICES AT AUDI OF TURNERSVILLE FOR $8000.00 AT THE SERVICE WRITERS SUGGESTION. WE NEEDED A NEW TURBO WITH THE ACCESSORIES. AFTER THAT THE VEHICLE RAN FINE FOR A COUPLE OF WEEKS. ON THE BEGINNING OF THE NEXT MONTH THE VEHICLE STARTED HAVING PROBLEMS AGAIN! NOT STARTING WELL...AND STALLING DURING OPERATION! *TR

    NHTSA complaint 11327559
17. Filed Jun 1, 2020Failure Jun 1, 202075,000 milesCape Coral, FLEngine

    MY CAR WOULD NOT START AND I HAD MY CAR TOWED TO FORT MYERS AUDI. AFTER THE DIAGNOSTICS THEY SAID THE TIMING CHAIN HAD FAILED AND CAUSED A CYLINDER HEAD TO CRACK AND THE TURBO HAD ISSUES AS WELL. THEY TOLD US THAT AUDI WILL COVER THE TIMING CHAIN AND ONLY 50% OF THE CYLINDER HEAD. THE QUOTE GIVEN FOR THE CYLINDER HEAD WAS $5,810 (WITH AUDI COVERING $2,905). TO REPAIR THE TURBO CHARGER IT WILL COST $2,175. LOOKING ON THIS WEBSITE, I HAVE SEEN SEVERAL OTHERS HAVING THE SAME ISSUE, WITH THE SAME RESULTING PROBLEMS. *TR

    NHTSA complaint 11326809
18. Filed May 12, 2020Failure May 11, 2020120,000 milesPortland, ORElectrical system, Unknown or other

    MY CAR HAS HAD ELECTRICAL ISSUES THAT THE DEALER HAS NOT BEEN ABLE TO RESOLVE. THINGS HAVE GOTTEN WORSE. YESTERDAY MY SON THROUGH A FIT WHILE DRIVING ON THE FREEWAY AND OPENED THE BACK DOOR WHILE I WAS GOING OVER 60 MILES AN HOUR AND THE DOOR LOCK LIGHT WAS LIT. I FEEL THAT UNDER NO CIRCUMSTANCE SHOULD IT BE POSSIBLE OF THE DOOR TO BE ABLE TO OPEN WHILE DRIVING AT HIGH SPEEDS. I HAVE DISCUSSED THIS WITH AUDI CORPORATE BUT THEY WERE MORE CONCERNED ABOUT ME BEING ABLE TO PAY FOR THIS TO BE FIXED THAN THE ISSUE ITSELF. *TR

    NHTSA complaint 11324269
19. Filed Feb 28, 2020Failure Feb 14, 202089,000 milesChicago, ILEngine, Steering

    I HAVE BEEN DRIVING ON THE HIGHWAY AND CITY AND IT APPEARS THE STEERING IS SOMETIMES STIFF AND THEN SOFT , I HAVE CHECKED THE POWER STEERING FLUID LEVEL AND ITS FULL. THIS IS AN ISSUE BECAUSE ITS HARD TO MAKE TURNS AS THE STEERING WHEEL STIFFENS UP. ANOTHER ISSUE IS THE CAR CONSUMES ABOUT 1 QUART OF OIL EVERY 300 MILES, IT WAS PART OF A LAWSUIT SETTLEMENT BUT THE VEHICLE WAS NEVER REPAIRED

    NHTSA complaint 11312004
20. Filed Dec 23, 2019Failure Dec 5, 201997,000 milesChicago, ILEngine

    MY 2011 AUDI Q5 WOULD NOT START ONE MORNING WHEN TRYING TO START THE CAR IN MY GARAGE (DEC 2019). I HAD IT TOWED TO THE FLETCHER JONES AUDI DEALERSHIP IN CHICAGO IL WHERE I HAVE BEEN A LOYAL CUSTOMER SINCE MOVING HERE IN 2014. THEY PERFORMED A DIAGNOSTIC AND IDENTIFIED THAT THE TIMING CHAIN TENSIONER HAD SLIPPED, AND MAY HAVE CAUSED "CATASTROPHIC" FAILURE TO MY ENGINE. THEY PROCEEDED TO ASK FOR ANOTHER $1,500 TO DIAGNOSE THE ENGINE FOR THE FAILURE, AND MENTIONED IF IF HAD FAILED IT COULD BE UP TO $10,000 TO FIX THE PROBLEM. AFTER A SHORT BIT OF RESEARCH, IT TURNS OUT THERE IS A WARRANTY THAT THERE WAS A RECALL ISSUED FOR THIS PROBLEM AND AN EXTENDED WARRANTY. MY DEALERSHIP NEVER TOLD ME THIS, AND WAS JUST EXPECTING ME TO PAY OUT OF POCKET. ALSO, I HAD MY CAR SERVICED THERE 4 DIFFERENT TIMES SINCE THE RECALL HAD BEEN ANNOUNCED. THEY NEVER ONCE INFORMED ME OF THIS. I CALLED TO ASK WHY THEY HADN'T MENTIONED THIS WARRANTY OR THIS ISSUE, AND THERE WAS NOT A GOOD ANSWER. FLETCHER JONES ALSO SAID THEY CHECK MY VIN EVERY TIME I BRING IT IN TO SEE IF THERE IS ANYTHING OUTSTANDING REGARDING RECALLS ETC ON THE CAR, WHICH MEANS THEY COULD HAVE ALERTED ME TO THIS MULTIPLE TIMES WHEN I BROUGHT THE CAR IN PRIOR, BUT THEY DID NOT. THEY COULD HAVE PREVENTED THIS ISSUE. FAST FORWARD TO NOW, AUDI WILL ONLY COVER 25% OF THE ISSUE, AND FLETCHER JONES IS BARELY MAKING AN EFFORT TO HELP OUT ON THEIR END. I WILL BE OUT NEARLY $5,000 TO REPAIR THIS PROBLEM, WHICH IS NO FAULT OF MINE AND A CATASTROPHIC FAILURE OF ENGINEERING ON THE PART OF AUDI. IT ISN'T RIGHT THAT AUDI DOES NOT FULLY COVER THIS EXPENSE. AND MOREOVER, THE DEALERSHIP SHOULD HAVE A DUTY OF CARE TO DISCLOSE THEM ITEMS SUCH THAT WE CAN TAKE THE STEPS TO PREVENT THEM. FLETCHER JONES DID WRONG BY ME BY NOT DISCLOSING THIS, AND IS LIKELY DEFRAUDING AND MANIPULATING MORE CLIENTS EVERY DAY THEY REMAIN IN OPERATION.

    NHTSA complaint 11290908