2021 Audi Q5

74 complaints on file, page 1 of 4.

1. Filed Sep 29, 2026Failure Sep 27, 2026Yonkers, NYElectrical system

   Vehicle Information: 2021 Audi Q5 Component Affected: Electrical System / Electronic Control Unit (Body Control Module / BCM2) Description of Safety Defect: The vehicle suffered a catastrophic failure of the Body Control Module (BCM / BCM2) caused by water ingress originating from a defective rear sunroof drainage tube assembly. The manufacturing failure of the panoramic sunroof drain allows water to pour directly down the vehicle's interior D-pillar. Because of a severe design flaw, Audi positioned this highly critical central electrical computer completely unshielded in the exact cargo cavity where this water runoff pools. When the Body Control Module shorts out due to this water ingress, it creates an immediate and severe safety hazard. The vehicle experiences sudden, unpredictable electrical malfunctions while in motion, including the risk of uncommanded engine shutdown, a total loss of exterior lighting, failure of the central locking safety systems, and a disabled key transponder system. Audi is fully aware of water ingress vulnerabilities affecting central modules in the floorboards and cargo areas of this platform (as evidenced by NHTSA Recall 90S9 for the Gateway module). However, they have failed to address this identical engineering hazard impacting the BCM in the rear cavity. Leaving an unshielded, critical vehicle operating computer vulnerable to known body leaks exposes occupants to sudden component failures at highway speeds. I am requesting that the NHTSA launch a formal investigation into Audi's BCM placement and sunroof drainage defects to compel a mandatory safety recall.

   NHTSA complaint 11767711
2. Filed Sep 24, 2026Failure Jul 1, 2026Brandon, MSPower train

   We took our 2021 Audi Q5 to the Audi dealership because our vehicle seemed to be skipping gears and making jerking motions while driving. I believe it began happening at least a couple of months ago when my wife noticed a change in driving dynamics. She is the vehicle's sole driver. After taking it to the Audi dealership and driving with the technician in the passenger seat, a diagnosis was made immediately while backing from the parking space. The technician indicated there was no need to go any further because he could determine it needed a differential fluid change. He also indicated it was a common problem with this model Q5 and it is occurring at a high rate with these vehicles. This was a $512.38 (with a 25% discount) expense that should not have occurred for a vehicle this age which was purchased new from this manufacturer. This should not be happening with this vehicle and shouldn't a recall have been made for such a frequently occurring problem? Please investigate and reply

   NHTSA complaint 11766803
3. Filed Sep 20, 2026Failure Sep 20, 2026Dunedin, FLRearview system braking, Automatic emergency braking

   When attempting a left-hand turn, despite the oncoming vehicle already passed me, the Audi auto-breaks leaving me in the center of the oncoming lane and causes the vehicle behind me to almost crash into me. Very dangerous.

   NHTSA complaint 11765676
4. Filed Aug 28, 2026Failure Jun 15, 2026San Diego, CAPower train

   VIN number: [XXX]. Audi Q5 Prestige 2021 Mileage 48,540 I have contacted Audi Corporate regarding a catastrophic Transmission Failure while driving. The dealership investigation discovered that bolts had loosened and the fluid was not getting to the transmission and it stopped dead while I was driving. I was on surface streets going to pick up my baby granddaughter from daycare. I heard what sounded like a "slip" in the gears, a yellow notification appeared stating that the car is safe to drive. A few minutes later it happened again and the same warning appeared. I continued to the daycare and in the driveway the car stopped dead with a Red warning that it is a transmission malfunction. I luckily was not in a busy intersection or the freeway as that would have been catastrophic for my life and the life of my young granddaughter. I have contacted Audi via telephone at [XXX]. They took my statement and gave me a case number: XXX. I have worked with my Audi dealership and they are giving a "goodwill" discount that requires me to pay $800 for the defective bolt replacement. I purchased the vehicle as a certified pre-owned from the Audi dealership on [XXX]. I purchased an extended warranty they refused to cover the repair as it was a manufacturing issue. I have taken the vehicle in for all maintenance. This transmission failure is nothing that I did and not the result of neglect. This failure of the bolts is a manufacturing error. The bolts are supposed to stay bolted. I want Audi to pay in full for the repair, to include replacement of the entire transmission, in addition to replacing the defective volts. I also want a letter stating that this is a permanent fix and will not happen again. I trusted the Audi name and reputation to build a safe vehicle. The abrupt stop of the transmission could have been the death of me and my young granddaughter had it happened on the freeway or a busy intersection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11760469
5. Filed Aug 20, 2026Failure Aug 3, 2026San Antonio, TXElectrical system, Power train

   On 8/3/26, my 2021 Audi Q5 began throwing numerous different malfunction/error alerts and the engine turned off while driving after a bottle of water had partially spilled onto our backseat behind the drivers side. The vehicle was towed to a nearby mechanic who determined that liquid damaged the gateway control module located under the backseat of the vehicle, as the gateway control module is placed in a "protective cover" (an unsealed plastic bag) and that bag visibly had liquid inside of it. We had immediately contacted Audi upon learning of this issue and decided not to move forward with any repairs, but to instead pay out of pocket to have it towed 70 miles to Audi/where we originally purchased the vehicle. This "protective cover" the control module was placed inside was completed as a recall service repair on our vehicle in April of 2022 due to a NHTSA recall announced in December 2021 regarding safety issues in these control modules failing from liquid spills on the backseat. We contacted Audi, explained that liquid had spilled in our backseat and entered the "protective cover" and damaged the control module. They agreed to inspect our vehicle to determine if the "protective cover" had been insufficiently installed. We paid out of pocket to have it towed to the dealership where it took them 6 days to determine the gateway control module is damaged (we had already explained this to them). Although liquid was found in the "protective cover" of this gateway control module, the dealership claims it was installed sufficiently. Upon looking into this matter further, there are numerous complaints of this exact issue (water entering and damaging the gateway control module from a liquid spill on the backseat, even with the "protective cover") on the NHTSA website, as well as a previous class action lawsuit settled out of court in regards to this EXACT issue. THE PRIOR RECALL REPAIR DOES NOT FIX THE SAFETY HAZARD AS STATED IN THE OFFICIAL NHTSA RECALL REPORT.

   NHTSA complaint 11758347
6. Filed Jun 29, 2026Failure Jun 18, 2026Chicago, ILEngine

   I was driving at highway speeds when a "Transmission Malfunction" warning appeared, and the vehicle lost the ability to accelerate. Once I was able to pull over and put the vehicle in Park, it completely lost the ability to engage Drive or Reverse, leaving me stranded. Important to note pulling over was difficult as I was on a highway driving ar 70mph speed and trying to locate safe space to stop avoid collusion. My car towed to the nearest dealership for repairs. Audi dealership confirmed the cause was broken internal transmission filter housing bolts. I was told this was premature occurrence as the vehicle only has 35,760 miles of driving and no prior work done on the transmission or visible notice of damage that could cause this issue.

   NHTSA complaint 11747226
7. Filed Jun 22, 2026Failure Jun 17, 202643,000 milesProsper, TXEngine and engine cooling

   The contact owns a 2021 Audi Q5. The contact stated that while driving approximately 55 MPH, the vehicle lost motive power and the vehicle decelerated before the vehicle stalled. During the failure, the check engine, oil, and coolant warning lights were illuminated. The vehicle was later towed to the local dealer to be diagnosed. The dealer determined that the engine bearings had failed, causing catastrophic damage to the engine. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 22V753000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 43,000.

   NHTSA complaint 11745548
8. Filed Jun 22, 2026Failure Jun 19, 2026pensacola, FLElectrical system, Engine, Fuel/propulsion system

   If I have a sensor that will malfunction due to water then there should be a water indicator alert. My sunroof vent was blocked and water went into my trunk where the core module is. I had just come to a red light to turn on to a major highway and my car began to smell like fuel. I rolled down the windows and realized the smell was not as strong as inside. The light turned green and as I stepped on the gas the car went into limp mode as I was in the middle of my turn. The power steering then went out in the turn and the wheel yanked to the left and put me half way into the lane next to me. Thankfully no one was there. I had to yank it back to the right to get off of the highway on to the side of the road. I do not think that the power steering should be associated with that module or at least a water indicator sensor should be added. What happens if someone is on the interstate is driving 75 mph and their power steering goes out. It's in the shop and there is no damage other than now I am scared to drive it

   NHTSA complaint 11745545
9. Filed Jun 11, 2026Failure Jun 3, 2026Chicago, ILWarnings, Adaptive cruise control, Automatic emergency braking

   I was driving down a regular road by my house, full sunshine, perfect road, nothing unusual. In fact, it was such a nice day, the sunroof was open and windows were down. My dog was in the back seat after just being picked up from grooming happily enjoying the day with his head out the window. I was on a road with the speed limit of 30. I was going 30 mph. Nothing unusual. Literally, out of nowhere, like my car was possessed, is the best way I put it, my car abruptly braked in an attempt to stop on a dime. My car screeched to a stop while simultaneously my windows rolled up, my sunroof closed and my seat belt tightened, locking me in place. My dog was thrown forward. It was terrifying! Luckily, no one was behind me or they would have certainly rear-ended me. Nothing was in the road. Absolutely nothing. It happened so quickly in a split second. I put my hazards on and finished the next 2 miles home. I called Audi for a service appointment. I took my car in, again going down back roads with my hazards on. Audi charged me $400 to run a diagnostic report and shows there is a fault code J428. This fault code I researched is for the front/right ACC radar sensor that powers Adaptative Cruise control and Pre-Sense braking system. The fault code erroneously detected an obstacle and did abrupt braking. Audi told me that they would charge me $4,000 to fix it. I contested that as a safety issue it should be fixed as there is also Audi TSB2063502 referencing problems. This is a major safety issue as if I was going 70 MPH, I could cause a massive accident where I could be killed, anyone in my car, as well as others behind me in a massive car pile up. I feel ethically, this must be a safety recall to replace this fault in all vehicles. I am also requesting payment to fix from Audi. As an attorney (#[XXX]), Audi is under notice that they have a major safety defect on their hands and should take steps to protect drivers safety. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11743573
10. Filed May 29, 2026Failure May 29, 2026Dallas, TXCarry handle, Shell, Base

    The car seat comes loose every month and has to be reinstalled

    NHTSA complaint 11740956
11. Filed May 8, 2026Failure May 1, 2026Hoboken, NJService brakes

    I am submitting this complaint regarding a serious brake-related safety issue involving my Audi vehicle after recent brake service performed by an authorized Audi Meadowland dealership in [XXX] . In December 2025, I brought my vehicle to an authorized Audi dealership for replacement of the brake pads. The repair was completed by the dealership, and I trusted that the vehicle was safe to drive afterward. However, only approximately six months later, and after driving only around 1,000 miles since the repair, the vehicle experienced a dangerous brake-related failure involving the brake pad assembly becoming loose/detached while the vehicle was in operation. This incident occurred while my entire family was inside the vehicle, creating a serious safety hazard and placing all occupants at risk. A brake system component should not fail after such a short period of time and limited mileage following dealership service. In addition to the safety concern itself, I am also extremely dissatisfied with the dealership’s handling of the matter. The dealership did not proactively contact me regarding the repair status, and multiple attempts to contact them by phone went unanswered. I believe this issue may involve improper installation, defective parts, insufficient inspection procedures, or other serious safety-related service failures. I respectfully request that NHTSA review and investigate this matter to determine whether similar incidents may affect other vehicles serviced under similar conditions. Thank you in advance for your review on this matter. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11736640
12. Filed Feb 24, 2026Failure Feb 16, 202637,200 milesRochester Hills, MIElectrical system, Structure

    The contact owns a 2021 Audi Q5. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated, and the vehicle stalled. Additionally, the windows independently rolled up and down, and the engine seized. While attempting to start the vehicle, the vehicle failed to start. The contact stated that the failure had occurred three times within five days. The vehicle was towed to the dealer where it was purchased. The failure was diagnosed with a failed gateway control module. The contact was informed that the gateway control module needed to be replaced. The vehicle was being repaired. The contact was informed that the plastic protective bag that covered the gateway control module was filled with water. In addition, the dealer informed the contact that the NHTSA Campaign Number: 21V947000 (Electrical System, Structure); recall repair was performed prior to the contact purchasing the vehicle. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 37,200.

    NHTSA complaint 11720211
13. Filed Feb 14, 2026Failure Nov 25, 2025Cold Spring, NYElectrical system, Unknown or other

    The safety situation happened when my wife's car got stuck while driving at about 25-30 MPH in the middle of the road.Next day At the nearest Audi service center they found that water has gotten into the rear of the trunk and damaged the electronic module which caused the car to stall.The first repair was estimate at 4600 $ .After the repair the car was inoperable.The next repair was estimated at another 4 700 $.After the second repair the car was inoperable again and the service department told me that the car needed to replace the entire transmission .Which they estimated at another 20 000 $. So the total damage is around 30 000$ .I contacted Audi USA about the whole situation when I received a negative message regarding the solution . I would like to point out that up until the moment mentioned we had no problems with the car .After my personal investigation of the problem ,I found that there was a safety recall # 21V-947 for same problem .It was not issued for my car which meets all the criteria.It looks like it was hidden by the manufacturer. Audi distances itself from the whole problem and refuses to cover the costs of the damage.Thank good this happened on the city road where the speed is low .If this happened on the highway at 60 MPH it would have had tragic consequences .Where it would never have been figured out what caused the accident. From a safety perspective ,I m reporting this dangerous and unfair treatment of customers by AUDI USA regarding the hidden recall and denial of resposability that occurred and I request an investigation .

    NHTSA complaint 11718005
14. Filed Feb 4, 2026Failure Feb 1, 2026Tracy, CAElectrical system, Engine, Power train

    Control module located under rear seat became slightly wet from spilled liquid, and failed. Engine and electrical failure as a result of control module failure. Audi refuses to cover damages as warranty period is over. Vehicle design is defective.

    NHTSA complaint 11715668
15. Filed Jan 21, 2026Failure Oct 10, 2025Harrisburg, PAAdaptive cruise control, Blind spot detection, Assist

    Following a rear collision repair at an authorized dealer collision center, multiple ADAS safety systems were not properly calibrated despite insurance payment and shop representations that repairs were complete. WHAT FAILED: Lane Change Assist, Peripheral Camera System, Side Assist, 360-Degree Camera, Front Camera, and Adaptive Cruise Control were either not calibrated or calibrated in timeframes physically incompatible with manufacturer specifications. SAFETY RISK: Driver relies on blind spot monitoring and lane change alerts that may be non-functional or inaccurate. Without proper calibration, these systems may fail to detect adjacent vehicles, provide false alerts, or create blind spots in camera coverage, increasing collision risk during lane changes and merging. DEALER CONFIRMATION: Yes. Shop manager provided diagnostic logs as proof of calibration. Analysis shows 360-degree camera calibration executed in 18 seconds versus 40-60 minute industry standard, and zero calibration events logged for Lane Change Assist and Peripheral Camera systems explicitly claimed as completed. INSURANCE INSPECTION: Insurance company explicitly DENIED Lane Change Assist and Peripheral Camera calibrations on estimate. Shop admitted in writing these items were declined and blamed insurance for non-payment. No OEM calibration logs produced despite multiple written requests. WARNING SYMPTOMS: Systems may appear normal on diagnostic scan with no active fault codes, but this does not prove calibration was performed to OEM tolerances. Physical calibration requires target board positioning, laser alignment, and environmental verification that cannot be completed in documented timeframes. PATTERN CONCERN: This may represent a systemic issue where insurers deny ADAS calibrations, shops skip calibrations due to non-payment, vehicles are released as complete, and consumers unknowingly operate vehicles with compromised safety systems. Vehicle and documentation available for inspection.

    NHTSA complaint 11712558
16. Filed Jan 12, 2026Failure Jan 8, 2026East Windsor, NJUnknown or other

    Vehicle: 2021 Audi Q5 I am submitting this complaint regarding a serious safety defect involving unintended emergency braking. On September 10, 2025 and again on January 8, 2026, my vehicle suddenly applied emergency braking while I was driving and there were no vehicles, pedestrians, or obstacles in front of me. The dashboard displayed “Auto Pre Sense” during both incidents. These unexpected braking events created a high risk of a rear-end collision and placed me and other drivers in immediate danger. This is not a driver error, but a malfunction of the safety system. Because this has occurred more than once, I am concerned that the Audi Pre Sense system in my vehicle may operate unpredictably and cause a serious accident. I respectfully request that this issue be investigated as a potential safety defect.

    NHTSA complaint 11710435
17. Filed Dec 9, 2025Failure Nov 15, 2025Frisco, TXPower train

    While driving my 2021 Audi Q5, the vehicle experienced a sudden transmission disengagement without warning. The vehicle behaved as if it had shifted into neutral while in motion. When this occurred, pressing the accelerator produced no response — the engine would not rev and the vehicle would not accelerate. This created a serious safety risk as it occurred during normal driving conditions and could have resulted in a collision. After stopping the vehicle and shifting into Park and then back into Drive, the transmission temporarily re-engaged. The issue reoccurred multiple times. Prior to one of the failures, the vehicle hesitated and bucked when starting from a stop. A warning message later appeared stating: “Transmission malfunction. You may continue to drive but will be unable to reverse.” The vehicle was taken to an authorized Audi dealership. Audi of America approved replacement of the transmission control module (mechatronic unit); however, this repair did not resolve the problem. After repeated failed adaptations and diagnostics, the dealer confirmed that the entire transmission requires replacement, citing internal gear set failure. The dealer documented that: Basic transmission settings and adaptations were attempted at least five times The failure consistently occurs at the same gear position A similar Audi Q5 case required full transmission replacement Audi Technical Assistance Center instructed the dealer to replace the transmission Despite this, Audi of America has refused further assistance due to the vehicle being slightly outside the standard warranty period, even though the mileage is extremely low and the failure is safety-related. This appears to be a defect involving the Audi S-tronic transmission, as similar complaints have been reported by other owners. The sudden loss of propulsion while driving presents a clear safety hazard. Safety Impact Sudden loss of acceleration while driving No throttle response during failure Occurred wit

    NHTSA complaint 11704035
18. Filed Nov 14, 2025Failure Nov 9, 2025Park Ridge, ILEngine

    Date of Incident: 11/09/2025 • Location: I-30 near Cumby, TX (towed to Audi Fort Worth). Daughter was stranded on busy highway in middle of nowhere. Texas State Police came to her aid and helped w tow truck which cost $650. Engine catastrophically failed at ~50k + miles due to metal shavings throughout oil — Audi Fort Worth made the statement and I have picture of metal shavings. Which is the exact defect in **NHTSA Recall 22V753 / Audi TSB 13i5** (connecting rod bearing damage from factory machining debris). **Symptoms match TSB 13i5 Pages 1, 10–11 (“NOT OK” filter examples)**: - March 2025 oil change at 50,032 miles: **no metal** or at August oil change. Neither Audi corporate or Fort Worth care. Claimed we bought used car and didn’t have oil changed at Audi dealer. This statement violates federal law: - **49 U.S.C. § 30120**: Safety recall remedy free of charge to all owners regardless of purchase history or service location. - **TSB 13i5 Page 1**: Covers **ALL 2021–2023 Q5s** (42,689 units) — **no VIN exclusions**. - **NHTSA 22V753**: Risk of engine failure, loss of motive power, potential fire** — undriveable vehicle

    NHTSA complaint 11699332
19. Filed Oct 9, 2025Failure Sep 24, 2025Concocrd, NHElectrical system, Service brakes, Steering

    The Gateway control module failed in September 2025 on my 2021 Audi Q5. Vehicle error messages included the following failures: Cruise control, Parking brake, transmission, brakes, and steering, windows rolled down, seats moved, dash and MMI black followed by a sudden loss of power, narrowly avoiding an accident (kids in car). Would not restart. Diagnosis by Audi dealer was that the Gateway control module got wet and needed to be replaced. This is Recall 90S9 from 2021 that was “repaired” in March 2022 by covering the module with a plastic bag. This proved an insufficient repair backed up by a class action lawsuit filed in January 2022 titled Gioffe, et al. v. Volkswagen Group of America, Inc., et al. (Case No. 1:22-cv-00193). I reached out to Audi USA to request a Goodwill repair which was my only available recourse given that the recall had been completed and closed. After 5 days the Regional Manager denied my request even after I emphasized the safety risk associated with this catastrophic failure as well as the recall in 2021 and class action suit filed in 2022. I paid $1485.33 to re-repair the recall. Driving home from repair my vehicle alerted me to the following messages: Vehicle starting system: malfunction! Please contact Service, and Audi pre-sense: currently limited. See owner’s manual. An OBD scan alerted 7 more codes: 1. Steering Assistance ID 44 (Terminal 30 Open circuit), 2. Central Electrics ID 09 (Garage door opener transmitter no communication), 3. Gateway ID 19 Control module for emergency call module and communication unit no communication, 4. Ethernet Notrufmodul keine Kommunikation, 5. Ethernet databus branch 1 No communication, 6. Multimedia ID SF Function restriction due to communication interruption, 7. Driver Assistance ID A5 Dynamic calibration Function limitation due to limit value exceedance.I reached out to the dealership that performed the service and was told that those are “ghost codes” and nothing to do with the work performed.

    NHTSA complaint 11692317
20. Filed Sep 24, 2025Failure Sep 18, 2025Yonkers, NYTires

    On September 18, 2025, while driving at ~65–70 mph on the Saw Mill Parkway in Mount Kisco, NY, a Michelin Latitude Tour HP tire (235/55R19) suffered a sudden circumferential tread/belt separation. The tread detached completely from the casing while the sidewall remained intact. A small screw was present in the center tread, but there was no TPMS warning or gradual pressure loss prior to the failure. This behavior is inconsistent with ordinary puncture damage and indicates a potential workmanship/materials defect. The separated tread, tire carcass, and wheel are preserved and available for inspection. The tires were installed by the dealer (Audi New Rochelle) on June 12, 2024, as part of Certified Pre-Owned reconditioning before sale. This catastrophic failure posed an immediate risk of serious crash. Tire Size: 235/55R19

    NHTSA complaint 11689439