2018 BMW 328D

10 complaints on file, page 1 of 1.

1. Filed Aug 30, 2026Failure Aug 16, 2026My Shasta, CAEngine

   Engine seized on freeway. Car has 99,000 miles. Dealership says engine seized and has to be replaced at a higher cost than the car is worth. Unknown warning lights.

   NHTSA complaint 11760824
2. Filed Aug 22, 2026Failure Aug 21, 2026Batesville, ARFuel/propulsion system, Power train

   While driving down the road my car gave me a notification “DRIVETRAIN MALFUNCTION” said full engine output not available then it just stopped and shut off (limp mode) it has done this multiple times and the shop says that it may be the High Pressure Fuel Pump. This has happened on a busy city road with high traffic and curvy roads where my car would not move and people could not see me when coming over the hill until last minute narrowly missing my car. Luckily there wasn’t oncoming traffic. I had to switch ignition off and on (it then said “transmission not in park”) when it was in park. Finally started back after having to shut ignition off and on twice. Then anytime I got above 40 it went back into limp mode.

   NHTSA complaint 11758698
3. Filed Jul 8, 2026Failure Jul 16, 2025Memphis, TNFuel/propulsion system

   In 2021, my vehicle had the high-pressure fuel pump replaced by an authorized BMW dealership under Safety Recall 21V-586 (BMW SIB 13 01 21). At the time of the recall, my vehicle had approximately 43,000 miles, and I was not experiencing any fuel system or drivability issues. The high-pressure fuel pump was replaced solely because BMW determined the original component posed a safety risk. My vehicle now has approximately 128,000 miles. The replacement high-pressure fuel pump installed as part of the recall has failed. Two independent repair facilities have diagnosed the high-pressure fuel pump as the cause of the no-start/fuel delivery issue. When I took the vehicle to a BMW dealership, I was informed that additional diagnostic work was needed to inspect for possible metal contamination from the fuel pump, but I have not yet been provided with a final written diagnosis. I am concerned that the replacement part installed as the recall remedy has failed in the same manner as the original recalled component. If confirmed, this raises concerns about the durability and effectiveness of the recall repair. I respectfully request that NHTSA review whether similar failures have been reported involving replacement high-pressure fuel pumps installed under Recall 21V-586. I am submitting this complaint so the issue can be documented and evaluated as a potential safety concern.

   NHTSA complaint 11748959
4. Filed Jun 29, 2025Failure Mar 20, 2025Simi Valley, CAFuel/propulsion system, Power train

   Car just shut off when driving at 65mph and never started back up, took it in and repair was a bad fuel pump and fuel rail line causing metal shards to go through fuel tank and injectors.

   NHTSA complaint 11670096
5. Filed Jan 23, 2025Failure Jan 10, 2025102,000 milesSanta Clarita, CAFuel system, Diesel

   The contact owns a 2018 BMW 328D. The contact stated while driving 50 MPH, the vehicle started shuddering significantly. The contact was able to pull over and the check engine warning light illuminated. The vehicle was towed to the contact's workplace. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that there was no record of a recall on the VIN. However, the contact stated that he received notification of NHTSA Campaign Number: 21V586000 (FUEL SYSTEM, DIESEL). The vehicle remained at the workplace and had not been driven since. The approximate failure mileage was 102,000.

   NHTSA complaint 11637952
6. Filed Dec 9, 2021Failure Aug 15, 2021norton, MAFuel system, Diesel

   The contact owns a 2018 BMW 328d. The contact received notification of NHTSA Campaign Number: 21V586000 (Fuel System, Diesel) however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was contacted and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

   NHTSA complaint 11443208
7. Filed Nov 1, 2021Failure Sep 1, 2021Wilkes Barre, PAFuel system, Diesel

   The contact owns a 2018 BMW 328D. The contact was informed by a third party that his vehicle was included in NHTSA Campaign Number: 21V568000 (Fuel System, Diesel) however, the part for the recall repair was unavailable. The dealer was made aware of the issue and informed the contact that the part was not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

   NHTSA complaint 11438911
8. Filed Oct 26, 2021Failure Aug 11, 2021Newport Beach, CAFuel system, Diesel

   The contact owns a 2018 BMW 328D. The contact stated that the vehicle failed to start up without warning. Due to the failure, the contact had the vehicle towed to an independent mechanic who was unable to diagnose the failure. The vehicle was then towed to a dealer where they replaced the fuel pump; however, the fuel pump failed during the test drive. The contact was also informed by the dealer that the vehicle was included in NHTSA Campaign Number: 21V586000 (Fuel System, Diesel) however, the part for the recall repair was unavailable. The manufacturer had not been notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was unknown. The vehicle remained in the possession of the dealer. VIN tool confirms parts are not available.

   NHTSA complaint 11438264
9. Filed Oct 1, 2021Failure Feb 17, 202134,914 milesLos Angeles, CAFuel system, Fuel pump

   The contact owns a 2018 BMW 328D. The contact stated while driving 50 MPH, the vehicle inadvertently stalled. An unknown warning light illuminated the instrument panel. The contact veered to the side of the road. The vehicle was towed to the dealer to be diagnosed. The contact was informed that the high-pressure pump had exploded, and the explosion had damaged other parts of the vehicle. The contact stated the vehicle was repaired. The contact received a recall notification for NHTSA Campaign Number: 21V586000 (Fuel System, Diesel) however, the part for the recall repair was not yet available. The manufacturer was notified of the failure. The contact stated recall has been repaired. The approximate failure mileage was 34,914.

   NHTSA complaint 11435138
10. Filed Sep 18, 2019Failure Aug 28, 20197,400 milesPortland, ORFuel/propulsion system

    CAR WAS IN MOTION ON A STREET. ENGINE STALLED. CAR WOULDN'T START. TOWED TO BMW DEALERSHIP. CATASTROPHIC HIGH PRESSURE FUEL PUMP FAILURE AT APPROXIMATELY 7400 MILES. METAL SHAVINGS THROUGHOUT ENTIRE FUEL SYSTEM. INJECTORS, FUEL LINES, FUEL PUMP, AND FUEL TANK NEEDED TO BE REPLACED.

    NHTSA complaint 11256481