2000 BMW 540I

31 complaints on file, page 1 of 2.

1. Filed Oct 5, 2024Failure Sep 27, 2024Redmond, WAExterior lighting

   The audio suddenly stops and my turn signals also stop working. When this happens when I'm in traffic, this is very frightening because I cannot signal lane changes or turns. Turning off the ignition and restarting the car always fixes the turn signals but only sometimes fixes the audio. It usually takes several restarts before the audio works. When in the failed condition with no audio and no turn signals and the engine running, disconnecting the Dynavin D9 "ibus box" from the vehicle instantly fixes the turn signals but not the audio. It has not been reproduced or confirmed nor has it been inspected. There is never any warning before the problem appears. I have been in continuous contact with the manufacturer in California. They sent a new ibus box, hoping that would fix the problem but it did not.

   NHTSA complaint 11618240
2. Filed Aug 20, 2023Failure Jul 22, 2023Lebanon, ORAir bags

   Car had sat for about a week since I had driven it. I opened the driver door, inserted the key, and turned the key to the starting position. It failed to crank after the dash lights lit up and then the driver steering wheel airbag deployed in my face. The car was on flat ground and the temperature was not extremely hot or extremely cold. The previous several times I had driven the car there was no indication of an SRS light and the car started perfectly every time.

   NHTSA complaint 11539678
3. Filed Jul 6, 2023Failure Jul 6, 2023Walpole, MAAir bags

   I needed to move the car after it was sitting for about 3 weeks. It would not start due to the battery was run down. As soon as I started charging the battery, the front passenger airbag exploded causing extensive damage to the dashboard and windshield. Thank god my wife was not sitting in the car. I have not contacted anyone about this. It happened a few hours ago. It is about 93 degrees with very high humidity. I am sending this report because someone could have been killed.

   NHTSA complaint 11530722
4. Filed Mar 14, 2014Failure Dec 11, 2013130,000 milesLewes, DEEngine

   TL* THE CONTACT OWNS A 2000 BMW 540I. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, SHE HEARD A LOUD NOISE AS METAL SHARDS STARTED TO FALL FROM THE ENGINE COMPARTMENT. THE CONTACT MENTIONED THAT THE CHECK ENGINE AND THE COOLANT WARNING LAMPS WERE ILLUMINATED BEFORE THE VEHICLE STALLED. THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE, SHE NOTICED THAT THE CLUTCH FAN HAD BECOME SEPARATED AND COOLANT WAS LEAKING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE CLUTCH FAN WAS FRACTURED AND CUTTING THROUGH THE ENGINE COMPARTMENT. THE MANUFACTURER MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 130,000.

   NHTSA complaint 10569285
5. Filed Nov 14, 2013Failure Oct 22, 201399,021 milesTucson, AZExterior lightingFire

   TL* THE CONTACT OWNS A 2000 BMW 540I. THE CONTACT STATED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED, CAUSING THEM TO OVERHEAT AND MELT THE CASING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 00V048000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 99,021.

   NHTSA complaint 10552200
6. Filed Jun 12, 2013Failure Jun 10, 2013180,000 milesElizabeth, NJEngine

   TL* THE CONTACT OWNS A 2000 BMW 540I. THE CONTACT STATED THAT AFTER SHIFTING INTO REVERSE, THE ENGINE SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE VEHICLE EXPERIENCED A HYDRO-LOCK FAILURE. THE VEHICLE WAS NOT REPAIRED AND MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. *TR

   NHTSA complaint 10519549
7. Filed Dec 16, 2012Failure Nov 15, 2012104,000 milesPittsburgh, PAElectrical system, Exterior lighting, Unknown or other

   WIRING HARNESS IN LOOM AT CONNECTION BETWEEN BODY AND TRUNK LID IS SHOWING CRACKED WIRES WHICH CAN LEAD TO A VARIETY OF SYMPTOMS WHEN WIRES SHORT. TRUNK WILL ONLY OPEN MANUALLY WITH KEY. KEY FOB REMOTE AND INSIDE VEHICLE TRUNK RELEASE DO NOT WORK. TRUNK CANNOT BE OPENED WHEN DOORS ARE UNLOCKED USING TRUNK HANDLE. OTHER SYMPTOMS INCLUDE MANY FALSE DASHBOARD WARNING INDICATORS RANGING FROM LOW COOLANT, TRUNK LID NOT CLOSED, ETC. WIRING SHORT COULD BE FIRE HAZARD. MANY EXAMPLE CASES CAN BE FOUND HERE HTTP://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=397245. *TR

   NHTSA complaint 10488935
8. Filed Dec 2, 2011Failure Nov 30, 2011Groton, CTSteering

   LUCKY I WAS STOPPED WHEN THIS OCCURRED. MY ENGINE MADE A TERRIBLE NOISE AND CUT OUT. I WENT TO RESTART MY ENGINE AND NOTICED THAT ALL MY INDICATOR LIGHTS WERE ON. I WENT TO DRIVE AND MY POWER STEERING WAS COMPLETELY SHOT. COME TO FIND OUT THAT MY POWER STEERING PUMP BROKE WITH NO REAL WARNING. IF I HAD BEEN AT A HIGH SPEED THIS COULD HAVE LEAD TO A SERIOUS INJURY. *TR

   NHTSA complaint 10438144
9. Filed Oct 27, 2011Failure Oct 27, 201180,000 milesPhoenix, AZElectrical system

   LIKE 80% OF OWNERS OF BMW 540I, 740I, 740IL, X5 OWNERS FROM YEARS 1999-2003 SUFFER FROM FACTORY DEFECT VARIABLE VALVE TIMING UNITS OR AS BMW CALLS IT VANOS. THE PARTS ON THE INSIDE CAUSE TERRIBLE DIESEL TYPE NOISES. I'VE TALKED TO MANY CERTIFIED MECHANICS WHO HAVE TOLD ME IF AFFECTS HOW THE ENGINE RUNS AND PERFORMS. *TT

   NHTSA complaint 10432977
10. Filed Mar 18, 2011Failure Feb 27, 2011120,000 milesFranklin Lakes, NJAir bagsCrash1 injured

    TL* THE CONTACT OWNS A 2000 BMW 540I. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN ROAD DEBRIS CRASHED INTO THE FRONT DRIVER SIDE DOOR AND THE FRONT DRIVER SIDE AIR BAG DEPLOYED. THE VEHICLE WAS PULLED OVER AND SHUT OFF. A POLICE REPORT WAS NOT FILED BUT THE CONTACT SUSTAINED MINOR INJURIES FROM THE AIR BAG DEPLOYMENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS TOLD THAT THE IMPACT FROM THE DEBRIS WAS NOT SUFFICIENT TO WARRANT AIR BAG DEPLOYMENT. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

    NHTSA complaint 10392144
11. Filed Feb 19, 2011Failure Oct 14, 2010141,000 milesNY, NYAir bags

    BOUGHT A BMW WITH THE AIRBAG SIGN ON FROM A CAR DEALERSHIP. *TR

    NHTSA complaint 10383332
12. Filed Nov 18, 2010Failure Nov 17, 2010111,000 milesOAK Brook, ILFan

    TL*THE CONTACT OWNS A 2000 BMW 540I. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 1 MPH IN THE DRIVEWAY, THERE WAS A LOUD ROARING NOISE OUTSIDE OF THE VEHICLE. IMMEDIATELY, THE ENGINE WAS TURNED OFF. THE RADIATOR FAN BLADES DETACHED, DENTED THE HOOD, WHICH CAUSED THE PAINT TO PEEL AND THEN FELL TO THE GROUND.. THE FAILURE MILEAGE WAS 111,000. THE CONTACT WAS IN THE PROCESS OF TOWING THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS APPROXIMATELY 111,000.

    NHTSA complaint 10366668
13. Filed Oct 26, 2010Failure Oct 8, 2010109,000 milesDIX Hills, NYElectrical system, Cooling systemFire

    ENGINE FIRE: ELECTRONIC THERMOSTAT WIRES OVERHEATED AND CAUSED WIRES AND ELECTRICAL CONNECTORS TO BURN. SMOKE ENTERED THE CABIN WHILE DRIVING AND VEHICLE PERFORMANCE HAS BEEN DEGRADED. *TR

    NHTSA complaint 10362407
14. Filed Mar 9, 2010Failure Feb 8, 201091,000 milesNEW Britain, CTInstrument cluster/panel, Service brakes, Antilock/traction control/electronic limited slip

    TL*THE CONTACT OWNS A 2000 BMW 540I. WHEN THE BRAKES WERE DEPRESSED, THE TRACTION DID NOT HOLD OR CONTROL THE VEHICLE. THE INSTRUMENT PANEL GAUGE ALSO FAILED TO FUNCTION PROPERLY WHEN THE ABS FAILED. THE BMW MANUFACTURER WAS CALLED AND INFORMED THE CONTACT THAT HIS WARRANTY HAD EXPIRED AND HE WOULD BE RESPONSIBLE FOR THE REPAIR COST. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 91,000.

    NHTSA complaint 10318153
15. Filed Jan 26, 2010Failure Oct 10, 200036,206 milesLAS Crisis, NMFrontal, 12v/24v/48v battery

    TL*THE CONTACT OWNS A 2000 BMW 540I. SHE STATED THAT THE BATTERY CONTINUED TO FAIL ON THE VEHICLE WHICH CAUSED SEVERAL UNDISCLOSED ELECTRICAL FAILURES. THE VEHICLE WAS TAKEN TO THE DEALER NINE TIMES TO CORRECT THE FAULTY BATTERY ISSUE, TO NO AVAIL. ON A SEPARATE OCCASION, WHILE THE VEHICLE WAS SITTING IDLE THE FRONTAL DRIVER'S AND PASSENGER'S SIDE AIR BAGS DEPLOYED WHICH CAUSED ALL OF THE WINDOWS TO SHATTER. NO ONE WAS IN THE VEHICLE AT THE TIME OF FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REFUSED TO REPAIR THE VEHICLE SINCE THE BATTERY WAS PURCHASED FROM A THIRD PARTY. NO REPAIRS WERE MADE TO THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 36,206.

    NHTSA complaint 10302396
16. Filed Oct 27, 2008Failure Jan 10, 2008140,000 milesTyngseoro, MAElectrical system

    TL*THE CONTACT OWNS A 2000 BMW 540I. WHILE DRIVING LESS THAN 70 MPH, THE PASSENGER COMPARTMENT IN THE VEHICLE FILLED WITH SMOKE. THE CONTACT PULLED THE VEHICLE OVER AND CALLED THE POLICE AND FIRE DEPARTMENTS. IT WAS DETERMINED THAT THERE WAS AN ELECTRICAL PROBLEM. THE INSURANCE COMPANY REFUSED TO PAY FOR ANY DAMAGE BECAUSE THERE WERE NO FLAMES. AN ANALYSIS WAS PERFORMED BY BMW. THE CURRENT MILEAGE WAS 149,900. UPDATED 12/11/08. *LJ UPDATED 12/11/08

    NHTSA complaint 10246860
17. Filed Apr 4, 2008Failure Mar 28, 2008103,300 milesCanyon Country, CAFront underhood

    I HAVE A 2000 BMW 540I (E39). MY CAR WAS IN A PRISTINE CONDITION, AND ALL OF SUDDEN, THE "ENGINE FAILSAFE PROG" MESSAGE CAME UP, AND THE CAR SHUTDOWN. I TOOK IT TO A DEALERSHIP, AND I WAS TOLD THE THERMOSTAT WAS BURNED BADLY, CAUSING THE ENGINE WIRING HARNESS AND DME BURNED AS WELL. I BELIEVE THIS IS A BIG SAFETY CONCERN FOR THOSE THAT OWN THIS VEHICLE. I WAS QUOTED $3500 TO FIX THIS ISSUE, AND CURRENTLY IT'S BEING REPAIRED AT BMW SEATTLE. *TR

    NHTSA complaint 10223331
18. Filed Nov 26, 2007Failure Dec 23, 200570,000 milesPotomac, MDModule

    I WAS MOVING MY CAR IN ORDER TO PARK IT SOMEWHERE ELSE. THE CAR STARTED THEN COMPLETE FAILURE. THE CAR CUT OFF, NO POWER BRAKES, NO POWER STEERING. I HAD TO PRESS THE BRAKES VERY HARD TO GET STOPPAGE. THE THERMOSTAT SHORTED OUT AND BURNED OUT THE MAIN COMPUTER. THE CAR WOULD NOT START. THE MAIN COMPUTER WAS REPLACED, THE WIRING HARNESS WAS BURNED OUT AND SEVERAL OTHER ELECTRONIC PARTS WERE REPLACED. THE ALUMINUM THERMOSTAT HOUSING WAS MELTED AND WAS REPLACED! TOTAL OF OVER $5,000 WAS REQUIRED TO FIX. IF A FUSE HAD BEEN THERE IT WOULD HAVE BEEN A COUPLE OF HUNDRED DOLLARS AND IF THIS HAD BEEN ON THE ROAD AS SPEED IT COULD HAVE BEEN EXTREMELY DANGEROUS. *TR

    NHTSA complaint 10209879
19. Filed Mar 10, 2005Failure Feb 6, 200543,000 milesNEW York, NYFrontal

    WHILE DRIVING 45 MPH DRIVERS AIR BAG INADVERTENTLY DEPLOYED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

    NHTSA complaint 10114929
20. Filed Mar 10, 2005Failure Feb 8, 200543,000 milesNEW York, NYFrontal

    WHILE DRIVING 45 MPH DRIVER'S AIR BAG INADVERTENTLY DEPLOYED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

    NHTSA complaint 10114924