2004 BMW M3

31 complaints on file, page 1 of 2.

1. Filed Jun 22, 2026Failure Nov 14, 2024Lonaconing, MDAir bags, Electrical system

   Below is a partial email to a BMW Dealer that replaced an airbag 2 1/2 years ago per a recall. The airbag light, convertible top light were both illuminated when I left the dealer. I have sent emails and contacted BMW USA. A friend scanned the car with a Snap-On scanner that showed that the light has been illuminated because of the air bag that they replaced. They continue to avoid the issue and they made my car unsafe and allowed me to leave with it. What can be done to resolve this issue? From: [XXX] <[XXX]> Sent: Friday, May 10, 2024 10:06 AM To: '[XXX]' <[XXX]> Subject: Issues with service during an airbag replacement Good morning [XXX], I took my 2004 M3 to BMW of Fort Lauderdale in November 2023 for a passenger-airbag replacement. The airbag light on the dash was illuminated when I received the car. I notified the service manager who stated that the light was not on when he initially got in the car after my arrival. The car was returned to the garage to determine the issue. The car was returned 30 – 45 minutes later and the airbag light continued to illuminate. The service manage told me that the driver’s side airbag which was replaced at a different dealership was causing the issue. I got in the car and notice that an oil pressure and voltage gauge that I installed after rebuilding the engine were not working. Therefore, I notified the service manager of the issue. He asked another manager to talk to me. I asked how they replaced the airbag so I would know where to start troubleshooting the cause. He told me that they were NOT in the fuse box because they removed the airbag from the top of the dash. The airbag light has been constantly illuminated since the airbag was replaced at BMW of Fort Lauderdale. I attached an image that shows two passenger side airbag errors that were displayed on a Snap-on scanner on May 8, 2024. This was caused by work done at BMW of Fort Lauderdale. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11745653
2. Filed Mar 23, 2022Failure Mar 22, 2022Rancho Cucamonga, CABody

   Passenger side rear sub-frame crack observed . Vehicle has never been in any accident or collision. It's a commonly know problem about BMW 3 series made between 1999 to 2006 that happens naturally without cause due to manufacture issue, so I decided to look under my car to look for any cracks as described. I identified at least one crack. After calling BMW USA for assitance, I was instructed to bring the car to have it inspected and confirmed by the BMW dealership in Ontario, CA. Dispite me telling them the location of the crack, they concluded there is no crack and nothing needed to be done. Not satified with their inspection, I went to get a second opinion from an independent machanic/ body shop and they confirmed that there is indeed a crack and took clear pictures to show that. If left untreated, these subframe cracks will spread and the rear of the car can fall off along with the rear axel and rear wheels leading to accidents. The cost of fixing such manufacture issure is also costly, $2500 to over $10000 from the estimates I collected.

   NHTSA complaint 11457998
3. Filed Apr 19, 2019Failure Apr 12, 2017100,000 milesPortland, ORExterior lighting

   WIRING PROBLEM WITH FACTORY HEADLIGHTS. THIS ISSUE CAUSES HEADLIGHTS TO FLICKER AND EVENTUALLY TURN OFF. IT HAPPENS WHILE THE VEHICLE IS IN MOTION AND SITTING STILL.

   NHTSA complaint 11197351
4. Filed Sep 9, 2016Failure May 27, 2016Apalchin, NYAir bags

   TL* THE CONTACT OWNS A 2004 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

   NHTSA complaint 10904927
5. Filed Aug 29, 2016Failure Jul 15, 2014Fall City, WAAir bags

   TAKATA RECALL -- IT'S BEEN 2 YEARS SINCE THE RECALL WAS ISSUED, BUT THE MANUFACTURER / DEALERSHIP DO NOT SEEM TO BE ABLE TO GET THE PARTS TO REPAIR MY CAR. THIS ESSENTIALLY RENDERS MY CAR UNSAFE, AND IN MANY WAYS, UNUSABLE. I STILL HAVE NOT HEARD ABOUT A DATE BY WHEN THE PARTS WILL BE AVAILABLE / REPAIR WILL BE DONE.

   NHTSA complaint 10899259
6. Filed May 13, 2016Failure Jul 1, 201591,000 milesOrange, CAAir bags

   TAKADA RECALL: NOTIFIED BY BMW JULY 2015 DRIVER-SIDE AIR BAG MODULE DEFECTIVE. IN MAY 2016, BMW ADVISED THEY DID NOT KNOW WHEN AIR BAG WOULD BEFIXED. SINCE THEN ANOTHER PERSON HAS DIED. CONCERNED ABOUT SAFETY AND LENGTH OF TIME WAITING FOR FIX.

   NHTSA complaint 10864851
7. Filed Mar 8, 2016Failure Jul 11, 2015Puyallup, WAAir bags

   TL* TAKATA RECALL. THE CONTACT OWNS A 2004 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

   NHTSA complaint 10845549
8. Filed Mar 7, 2016Failure Jul 30, 2015Portland, ORAir bags

   TL* TAKATA RECALL. THE CONTACT OWNS A 2004 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT WAS PLACED ON A WAITING LIST. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VIN WAS UNAVAILALBE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

   NHTSA complaint 10840347
9. Filed Dec 8, 2015Failure Dec 8, 2015DIX Hills, NYAir bags

   TL* TAKATA RECALL. THE CONTACT OWNS A 2004 BMW M3. THE CONTACT STATED THAT AFTER THE VEHICLE WAS STARTED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMED PARTS NOT AVAILABLE......UPDATED 02/11/16 *BF *TR

   NHTSA complaint 10809118
10. Filed Apr 6, 2015Failure Sep 1, 2014Branford, CTAir bags

    NO ACCIDENT. JUST WAITING SINCE SEPTEMBER 2014 TO HAVE MY PASSENGER SIDE AIRBAG REPLACED. I CAN'T DRIVE THE CAR WITH A PASSENGER BECAUSE THE AIRBAG IS AFFECTED BY A RECALL AND THE BMW DEALERS DON'T HAVE THE PARTS TO REPLACE IT. *TR

    NHTSA complaint 10703842
11. Filed Nov 5, 2014Failure Sep 1, 2014Fort Lauderdale, FLAir bags

    TL* THE CONTACT OWNS A 2004 BMW M3 CONVERTIBLE. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V428000 (AIR BAGS). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

    NHTSA complaint 10652773
12. Filed Jun 25, 2014Failure Jun 25, 201460,800 milesMorton Grove, ILTires, Rim1 injured

    I WAS DRIVING MY CAR ON LAKE SHORE DRIVE AND I HIT A POT HOLE NEAR LAWRENCE AVE. I ENDED UP GETTING FLAT ON BOTH OF MY RIGHT TIRES. IT POSSIBLY BENT MY RIM, SUSPENSION ISSUES, AND TIRE HAVE BEEN FLAT. *TR

    NHTSA complaint 10606001
13. Filed Apr 20, 2014Failure Apr 16, 2014110,201 milesLOS Angeles, CAPower train

    FAULTY SMG PUMP POSSIBLY CAUSED BY A CULMINATION OF OTHER FAILING PARTS IN SMG SYSTEM. CAR IS RENDERED INOPERABLE IN POTENTIALLY HAZARDOUS DRIVING SITUATIONS THAT WOULD OTHERWISE BE CIRCUMVENTED BY A SYSTEM MORE CAPABLE OF WARNING THE OWNER OF AN IMPENDING FAILURE. THE REMEDY THE MAJORITY OF DEALERSHIPS ARE USING ARE REPLACEMENT OF THE ENTIRE SMG SYSTEM, WHICH COSTS UP TO $7,000.00. AS HIDEOUS AS THIS SOUNDS, THERE MORE THAN LIKELY IS A VERY SMALL FACTOR OR PART THAT IS CAUSING THE ENTIRE SYSTEM TO FAIL. BMW NEEDS TO ADDRESS THIS IMMEDIATELY. *TR

    NHTSA complaint 10583717
14. Filed Apr 11, 2014Failure Mar 8, 2014102,786 milesSimi Valley, CAEngine

    ONE OF THE VANOS EXHAUST HUB TAB BROKE AND DAMAGED THE OIL PUMP DISC. I HAD TO REPLACE THE VANOS EXHAUST HUB AND OIL PUMP DISC. *JS

    NHTSA complaint 10579266
15. Filed Sep 6, 2013Failure Jun 3, 201365,000 milesQueen Creek, AZEngine, Fuel/propulsion system, Power train

    VEHICLE DROPS OUT OF GEAR RANDOMLY. AS I WAS TAKING A LEFT TURN, THE VEHICLE DROPPED INTO 0 GEAR AND ON COMING TRAFFIC ALMOST RAN INTO ME HEAD ON. I HAD NO WAY OF MOVING THE CAR DUE TO TRANSMISSION BEING SHIFTED INTO NEUTRAL. THIS IS DUE TO A DEFECTIVE TEMPERATURE SENSOR ON THE SMG PUMP. BMW IGNORES THE ISSUE.

    NHTSA complaint 10542312
16. Filed Aug 14, 2013Failure Aug 10, 201231,000 milesCenter Valley, PAExterior lighting

    THE REAR LAMPS IN MY BODY PANEL THAT HOUSE THE BRAKE LAMP, TURN SIGNAL, AND TAIL LAMP STOPPED WORKING AND NEEDED TO BE FULLY REPLACED. MY CAR IS A LOW MILEAGE VEHICLE. THIS SAME ISSUE WAS THE SUBJECT OF NHTSA #11V438000. HOWEVER, THIS RECALL DID NOT INCLUDE THE M3, JUST ALL OF THE OTHER 3 SERIES BMWS. PLEASE INVESTIGATE. THIS IS A SAFETY ISSUE AND A COSTLY REPAIR FOR ME. THIS IS THE REFERENCE FOUND ON YOUR WEBSITE AND MY ISSUES ARE IDENTICAL TO THIS SUMMARY: NHTSA CAMPAIGN NUMBER: 11V438000 REAR LAMPS IN BODY PANEL SUMMARY: BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING. THANK YOU FOR LOOKING INTO THIS. *TR

    NHTSA complaint 10535258
17. Filed Jul 2, 2013Failure Jul 1, 201354,462 milesHolyoke, MAPower train, Vehicle speed control

    THIS IS THE SECOND TIME THIS HAPPENED TO MY CAR THE SMG (SEQUENTIAL MANUAL GEAR) LIGHT COMES ON AND THEN MY SERVICE ENGINE LIGHT COMES ON AS WELL EVERY TIME IN THAT ORDER , ALSO MY CAR SHIFTS ITSELF INTO NEUTRAL ALL ON ITS OWN AND I CAN,T CONTROL THE ACCELERATION ON THE HIGHWAY OR ANYWHERE ELSE SO THE CAR BEGINS TOP SLOW DOWN, MANY PEOPLE HAVE ADDRESSED THIS ISSUE TO BMW N.A. AND NOTHING AND IT ONLY HAPPENS DURING HOT WEATHER, AND BMW RAN A DIAGNOSTIC ON MY CAR AND THEY GAVE ME MULTIPLE THINGS THAT CAN CAUSE IT SO THEY EXPECT ME TO PAY FOR ALL OF THEM EVEN IF THEY ARE NOT ALL THE CULPRITS. THIS IS A VERY DANGEROUS ISSUE ESPECIALLY ON THE HIGHWAY AND I HAVE KIDS SO IT MAKES ME EVEN MORE WORRIED THAT SOMETHING MIGHT HAPPEN BECAUSE OF THIS AND BMW'S NEGLIGENCE TO THE ISSUE. *TR

    NHTSA complaint 10522847
18. Filed Jun 25, 2013Failure Jun 18, 2013128,000 milesHerndon, VAStructure, Underbody shields

    I INSPECTED THE TRUNK FLOORPAN AND NOTICED BUCKLING, CRACKING OF THE TRUNK FLOOR AND WELDED SEAMS COMING APART. THE REAR SUBFRAME MOUNTS WERE CRACKED ON BOTH SIDES. THE REAR SUBFRAME IS RIPPING ITSELF OUT OF THE CAR AND I'M VERY LUCKY I FOUND THIS WHILE THE CAR WAS AT REST AND NOT DRIVING AT SPEED. BMW KNOWS THIS IS FAULTY ENGINEERING BUT SOMEHOW THEIR LAWYERS FANGLED A WAY TO ONLY COVER THE REPAIRS FOR THE E46 CARS FOR 1 YEAR (2010), EVERYONE ELSE IS SCREWED. THESE CARS SHOULD BE OUTLAWED, OR AT LEAST A GIANT SIGN SHOULD HAVE TO BE PLACED IN THE WINDSHIELD EXPLAINING THIS PROBLEM TO POTENTIAL BUYERS AND THEY SHOULD BE FORCED TO SIGN A WAIVER IF THEY ARE DUMB ENOUGH TO BUY IT ANYWAYS. I BOUGHT THE CAR 2 MONTHS AGO UNDER THE IMPRESSION M3S HAD RE-ENFORCEMENT IN THIS AREA ABOVE AND BEYOND THE REGULAR E46, I WAS WRONG TO THE TUNE OF 3500.00 REPAIR BILL (AND I GOT OFF LIGHT). WHAT A MESS, THAT LITTLE BABY CHASSIS CAN'T EVEN HANDLE 333HP WITHOUT RIPPING ITSELF APART. MY BUICK GN MAKES 550HP AND THE FRAME HOLDS TOGETHER JUST FINE. *TR

    NHTSA complaint 10521755
19. Filed May 21, 2013Failure May 20, 201383,488 milesSparks, MDVisibility/wiper

    GOT INTO MY CAR IN THE AFTERNOON AND NOTICED THE REAR VIEW MIRROR WAS DISTORTED. AFTER INSPECTING, REALIZED THAT THE LIQUID HAD SEPARATED BEHIND MIRROR. HAD TO RUN AN ERRAND. STARTED DRIVING AND THEN HEARD A LOUD "POP" NOISE. LOOKED AT MIRROR AND THE LIQUID WAS VERY VISIBLE MOVING BEHIND GLASS. GOT TO MY DESTINATION AND NOTICED FLUID ALL OVER SEAT AND CENTER CONSOLE. IMMEDIATELY WIPED UP AND IT HAD ALREADY DAMAGED CENTER CONSOLE IN SEVERAL PLACES. GOT IT OFF SEAT BEFORE IT DAMAGED THE LEATHER. HAD TO WRAP TOWEL AROUND MIRROR TO CATCH THE REST OF THE FLUID LEAKING OUT OF THE BOTTOM. THIS FLUID WAS EXTREMELY CAUSTIC AND DID DAMAGE TO CONSOLE IN LESS THAN A MINUTE. I'M GLAD I WAS IN CAR WHEN IT HAPPENED, I AM SURE THE DAMAGE FROM THE FLUID WOULD OF BEEN A LOT WORSE! *TR

    NHTSA complaint 10513011
20. Filed Nov 15, 2012Failure Nov 8, 201272,500 milesSuwanee, GAPower train

    AUTOMATIC TRANSMISSION SMG HYDRAULIC PUMP FAILED. *TR

    NHTSA complaint 10484753