2017 BMW M3

3 complaints on file, page 1 of 1.

1. Filed Jul 28, 2024Failure May 21, 2024Pelham, ALFuel system, Gasoline

   My car was leaking fuel. This has been reported in numerous vehicles of the same make and model. There is an active warranty extension for this issue, I have attached the bulletin from BMW. My car is not covered for some reason although earlier years of my exact same car are covered. My car was was manufactured a few months after the latest covered date in the attached bulletin. This is a huge safety concern. There was always fuel dripping from my car. This resulted in puddles of fuel if my car was parked for longer than 30 mins. The slightest spark or someones cigarette could have lit up my entire vehicle in flames. Not only is it a safety concern, it should be an environmental concern as well. Everywhere I parked, fuel would be on the ground. Picture of my fuel tank attached. It is consistent with the issue in the bulletin. Photo is from the dealership that repaired my car.

   NHTSA complaint 11605001
2. Filed Nov 10, 2021Failure Nov 5, 202153,000 milessalinas, CADriveshaft

   The contact owns a 2017 BMW M3. The contact stated that while driving at approximately 25 MPH, there was an abnormal banging sound coming from the vehicle. In addition, the vehicle failed to operate as designed, without warning. The vehicle was towed to the dealer where it was diagnosed that the driveshaft was fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The VIN was not included in NHTSA Campaign Number: 18V713000 (Power Train). The approximate failure mileage was 53,000.

   NHTSA complaint 11440045
3. Filed Jan 23, 2020Failure Jan 10, 20206,352 milesSolon, OHElectrical system

   VEHICLE IS A 2017 BMW M3 WITH 6352 MILES. IN THIS PARTICULAR CASE THE VEHICLE HAD STARTED AND HAD BEEN OPERATING NORMALLY THE DAY PRIOR. THE FOLLOWING DAY THE CAR WAS STATIONARY AND WOULD NOT START.IT WAS CLEAR THERE WAS NO POWER GETTING TO THE ELECTRONICS EVEN THOUGH THE BATTERY WAS FULLY CHARGED. THE VEHICLE WAS TRANSPORTED BY FLATBED TRUCK TO THE LOCAL DEALERSHIP TO DIAGNOSE THE ISSUE. THE DEALERSHIP INVESTIGATED THE ROOT CAUSE AND FOUND THE PRIMARY BATTERY CABLE CONNECTOR TO THE ELECTRICAL DISTRIBUTION BOX HAD FAILED WHERE THERE WAS NO LONGER ELECTRICAL CONTACT BETWEEN THE CABLE END AND THE DISTRIBUTION BOX TERMINAL. THE DEALERSHIP HAD NOT INITIALLY DISCLOSED THAT THEY HAD DONE REPAIR WORK ON OTHER MODELS FOR THE SIMILAR TYPE ELECTRICAL FAILURE. UPON FURTHER RESEARCH IT WAS FOUND THAT THERE HAVE BEEN NUMEROUS RECALLS FOR MANY DIFFERENT MODELS OF BMW INCLUDING 1 SERIES, 3 SERIES AND Z SERIES FOR THE SIMILAR FAILURE MODE OF ELECTRICAL CONNECTION FAILURE AT THE BATTERY CABLE/ DISTRIBUTION BOX CONNECTION. THE FOLLOWING ARE SO FAR THE KNOWN RECALLS RELATED TO THE BATTERY CABLE CONNECTOR FAILURE: 18V-314 FOR MODEL YEARS 2010-2011. OVER 7000 VEHICLES AFFECTED 19V-472 FOR MODEL YEARS 2008-2012 13V-044 FOR MODEL YEARS 2008-2012 OVER 500,000 VEHICLES AFFECTED IT WAS EVENTUALLY CONFIRMED BY THE MECHANICS AT THE DEALERSHIP THAT THIS WAS A SIMILAR FAILURE MODE OF THE CONNECTOR THAT THEY HAD SEEN IN THE PAST HOWEVER THEY COMMENTED THAT THIS WAS THE FIRST 2017 MODEL THAT THEY HAD SEEN WITH THIS FAILURE. THE CONCLUSION CAN BE DRAWN ON THAT THE BATTERY CABLE/ELECTRICAL DISTRIBUTION BOX CONNECTOR DESIGN IS SIMILAR TO THAT USED IN PREVIOUS MODEL YEARS AND THEREFORE WILL FAIL IN A SIMILAR MANNER AND THAT ADDITIONAL MODEL YEARS SHOULD BE ADDED TO THE RECALL SO THAT THE DEFECT CAN BE IDENTIFIED AND REMEDIED AS SOON AS POSSIBLE.

   NHTSA complaint 11301469