2000 Chevrolet Astro

175 complaints on file, page 1 of 9.

1. Filed Oct 30, 2020Failure Oct 20, 20201 milesBuffalo, NYEngine, Service brakes

   WHILE DRIVING THE 2000 CHEVY ASTRO THE ENGINE SHUT OFF AND NO BRAKES. HAPPENED TO ME IN TWO WEEKS. LIFE OR DEATH SITUATION.

   NHTSA complaint 11372342
2. Filed Aug 18, 2014Failure Aug 12, 2014240,840 milesWaukegan, ILService brakesCrash

   I ENTERED A PARKING LOT AT 10 MPH AND SLOWED TO 5 MPH AND TURNED LEFT INTO A PARKING SPACE AND TRIED TO STOP. THE BRAKES DID NOT WORK AND I CRASHED INTO THE VEHICLE NEXT TO ME. I IMMEDIATELY CHECKED THE BRAKE FLUID LEVEL AND IT WAS FULL. NO ABS LIGHT HAS EVER BEEN ON, AND I JUST RECENTLY PASSED MY VEHICLE SAFETY CHECK WITH NO CODES ON THE SYSTEM. *TR

   NHTSA complaint 10626165
3. Filed Jun 24, 2014Failure Jun 14, 2011NEW Port Richey, FLAir bags, Horn

   TL* THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE CONTACT STATED THE HORN ACTIVATED INDEPENDENTLY WHILE PARKED OR WHEN MAKING TURNS. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FAILURE WAS DUE TO THE HORN AND THE AIRBAG INTERACTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE AND THE CURRENT MILEAGE WAS 98,000. UPDATED 09/22/2014*LJ THE CONSUMER STATED THAT THE HORN WAS DEACTIVATED. UPDATED 2/12/15*JS

   NHTSA complaint 10605645
4. Filed May 21, 2014Failure Oct 1, 2013155,000 milesTiffin, OHFuel/propulsion system, Service brakes, Steering

   HI, I WAS DRIVING THIS VAN WHEN ALL OF A SUDDEN IT STOPS. I HAD A VERY HARD PROBLEM OF TRYING TO GET OFF THE ROAD WITH NO BRAKES OR STEERING. I HAD IT TOWED INTO SERVICE. THEY REPLACED EVERYTHING FUEL PUMP, SENDING UNIT, FUEL FILTER, PLUGS, PLUG WIRES, DISTRIBUTOR AND RESET THE TIMING. IT NEVER DID SHOW UP A CHECK ENGINE LIGHT OR SHOWED A CODE THAT SOMETHING WAS WRONG. I DROVE IT TWO DAYS LATER AND IT DID THE SAME THING. THEY CHECKED IT OUT AND DROVE IT AGAIN FOR A WEEK AND IT HAPPEN AGAIN. I SPENT $1200 TRYING TO GET THIS SAFE TO DRIVE. IT IS AS IF THE KEY WAS SHUT OFF. FINALLY WITH SOME OF MY KNOWLEDGE ABOUT WHAT CAN CAUSE THIS TO HAPPEN I CHECKED THE BATTERY. IT WAS ONLY ONE YEAR OLD. IT SHOWED UP AS BAD UNDER A LOAD. WHEN I TOOK THE VAN BACK TO THE REPAIR SHOP THEY SAID BATTERY SHOWED GOOD. FINALLY I TOOK THE BATTERY BACK TO AUTO ZONE THEY SHOWED IT AS BAD ALSO AND REPLACED IT. NEVER HAD A PROBLEM AFTER THAT. SO THE PROBLEM YOU ARE HAVING WITH THE KEY SWITCH IN ALL THOSE CARS YOU MAY HAVE TO DOUBLE CHECK THE BATTERY'S. VOLTAGE TO THE MICROPROCESSOR SHOULD STAY WITHIN LIMITS OF APX 8 VOLTS. THIS MIGHT BE MORE OF A PROBLEM THAN THE KEY SWITCH. THANKS FOR READING THIS LETTER. *TR

   NHTSA complaint 10593059
5. Filed Mar 20, 2014Failure Feb 28, 201489,000 milesHouston, TXElectrical system, Fuel system, Gasoline

   VAN SHUT DOWN WHILE DRIVING AND WE LOSS BRAKES. *TR

   NHTSA complaint 10573886
6. Filed Sep 24, 2013Failure Nov 1, 201182,257 milesTroy, MIFuel system, Gasoline, Service brakes

   TL* THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT FUEL FUMES WERE EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE HE NOTICED THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING 25 MPH, HE ATTEMPTED TO ENGAGE THE BRAKES BUT THE BRAKE PEDAL SUNK INTO THE FLOOR BOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE BRAKES LINES WERE ALSO CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 82,257 AND THE CURRENT MILEAGE WAS 88,000. UPDATED 12/30/13*CN THE CONSUMER ALSO STATED RUST CAUSED THE ABS TO ENGAGE AT LOW SPEEDS ON DRY PAVEMENT, CAUSING THE VEHICLE TO CONTINUE TO MOVE, EVEN THOUGH THE BRAKE PEDAL WAS DEPRESSED.

   NHTSA complaint 10545126
7. Filed Mar 13, 2013Failure Mar 11, 2013176,000 milesChesterfield Township, MIService brakesCrash

   ABS SYSTEM ACTIVATED ON DRY PAVEMENT WHILE PARKING THE CAR. BRAKE PEDDLE WENT TO THE FLOOR CAR KEPT MOVING IT SEEM TO WANT TO ACCELERATE. IT HIT THE OPPOSING PARKED VEHICLE. THIS HAS BEEN A INTERMITTENT PROBLEM. MECHANICS COULD NOT FIND PROBLEM PRIOR TO ACCIDENT AFTER ACCIDENT HAD VEHICLE REPAIRED AT CHEVY DEALER HUBS AND SENSORS REPLACED THIS VEHICLE IS VERY SCARY TO DRIVE.EVEN AFTER REPAIRS THE ABS SYSTEM CAN STILL FUNCTION INAPPROPRIATELY WITHOUT ANY WARNING. *TR

   NHTSA complaint 10502726
8. Filed Aug 16, 2011Failure Aug 1, 2011222,297 milesPark Ridge, ILUnknown or other

   OEM CARPET COVERING THE INTERIOR ENGINE COWLING IS CURLING UP, CAUSING IT TO INTERFERE WITH THE TRAVEL OF THE GAS PEDAL. GAS PEDAL CANNOT COME BACK TO ITS RESTING POSITION, CAUSING THE VEHICLE TO CONTINUE TO ACCELERATE. *KB

   NHTSA complaint 10419730
9. Filed May 2, 2011Failure Jul 9, 2009Waskom, TXElectrical system

   REAR A/C SWITCH BURNED UP. SMELLED PLASTIC BURNING , SAW SMOKE CAME OUT OF REAR A/C SWITCH ON DASH. POPPED OFF SWITCH AND FOUND BURNED SWITCH AND WIRES. *TR

   NHTSA complaint 10398678
10. Filed May 2, 2011Failure May 23, 200980,000 milesLAS Vegas, NVService brakes, Antilock/traction control/electronic limited slipCrash1 injured

    TL* THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE CONTACT STATED WHEN BRAKING ON ANY UNEVEN ROAD SURFACE, THE ANTI-LOCK BRAKE SYSTEM WOULD ACTIVATE INDEPENDENTLY WITH THE ILLUMINATION OF THE ABS WARNING LIGHT MAKING IT DIFFICULT TO STOP THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN THREE SEPARATE CRASHES AS A RESULT OF THE FAILURE. ON ONE OCCASION WHILE TRAVELING 45 MPH, THE BRAKES WERE APPLIED ABRUPTLY BUT DID NOT RESPOND AND THE CONTACT CRASHED INTO ANOTHER VEHICLE. THERE WAS ONE REPORTED INJURY AND A POLICE REPORT WAS FILED. THE CONTACT STATED THAT THE ABS WAS ACTIVATED AT THE TIME OF THE CRASH. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE 151,000.

    NHTSA complaint 10398617
11. Filed Oct 22, 2010Failure Oct 22, 2010134,000 milesFenwick, MIService brakes, Hydraulic

    2000 CHEVY ASTRO VAN ABS PROBLEM. WHILE TRAVELING AT LOW SPEED CITIES, PARKING LOTS ETC... WHEN ATTEMPTING TO STOP THE ABS APPEARS TO KICK ON CAUSING FAILURE TO STOP. I HAVE HAD SEVERAL NEAR ACCIDENTS WITH MY CHILDREN IN THE VAN RECENTLY. MECHANICS SAY MAYBE MASTER CYLINDER, MAYBE BELTS, MAYBE???? CAN ANYONE SAY RECALL??? *TR

    NHTSA complaint 10361769
12. Filed Aug 12, 2010Failure Jul 6, 200972,000 milesLakewood, OHRetractor

    TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE CONTACT WAS UNABLE TO PULL THE FRONT PASSENGER SEAT BELT OUT OF THE RETRACTOR. THE DEALER AND WANTED $250 TO REPAIR IT. THE CONTACT STATED THAT SINCE THIS WAS A SAFETY ISSUE IT SHOULD BE REPAIRED AT NO COST. THE FAILURE MILEAGE WAS 72,000. THE CURRENT MILEAGE WAS 80,000. THE VIN UNKNOWN.

    NHTSA complaint 10349016
13. Filed Mar 18, 2010Failure Mar 14, 2010108,000 milesMedford, MAFuel system, Gasoline, Automatic transmission, Vehicle speed controlFire

    WHILE TRAVELING AT HIGHWAY SPEEDS THE ACCELERATOR PEDAL BECAME STUCK. VEHICLE CONTINUED TO ACCELERATE IN A RUN-AWAY MODE. VEHICLE WAS EVENTUALLY STOPPED THROUGH COMBINATION OF BRAKES AND TRAVELING INTO MUD. UPON STOPPING IT WAS NOTICED THAT THE FRONT BRAKES WERE FLAMING - MOST LIKELY DUE TO EXCESSIVE HEAT. *TR

    NHTSA complaint 10320625
14. Filed Mar 11, 2010Failure Dec 1, 2009130,000 milesGray, MEVehicle speed control

    TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN. WHILE THE CRUISE CONTROL WAS SET AT SPEEDS OF 65 MPH, THE BRAKE PEDAL WAS APPLIED TO DISENGAGE THE CRUISE CONTROL. HOWEVER, THERE WAS NO RESPONSE. THE VEHICLE CONTINUED TO ABNORMALLY ACCELERATE WHILE THE BRAKES WERE APPLIED. THERE WAS AN EXTREMELY LOUD ROARING NOISE COMING FROM THE ENGINE WITH AN INCREASE IN THE RPMS. THE VEHICLE WAS RAPIDLY APPROACHING A TRAFFIC LIGHT AND THE GEAR WAS SHIFTED INTO NEUTRAL POSITION. THE ENGINE WAS TURNED OFF. THE VEHICLE WAS COASTED TO A STOP WITH VERY LIMITED BRAKING POWER. AFTER SEVERAL MOMENTS, THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS ABLE TO RESUME OPERATION. THE VEHICLE WAS TAKEN TO THE DEALER. THE CPU (CENTRAL PROCESSING UNIT) AND OPTICAL WHEEL SENSORS WERE INTERMITTENTLY FAULTY WHICH REQUIRED REPLACEMENT. THE SENSORS WERE CLEANED TO CORRECT THE PROBLEM. THE IDENTICAL FAILURE OCCURRED ON A SEPARATE OCCASION. THE VEHICLE WAS TAKEN BACK TO THE DEALER THAT ADVISED THE REPLACEMENT OF THE ENTIRE CPU. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 130,000. UPDATED 4/26/10 *CN UPDATED 06/17/10*JB

    NHTSA complaint 10319064
15. Filed Aug 17, 2009Failure Jul 31, 2009370,000 milesPalmdale, CATires

    TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN WITH DELTA ESTEEM XLE TIRES. WITHIN A MONTH AFTER TWO TIRES WERE PURCHASED BY THE SAME MANUFACTURE. HE WAS TRAVELING AT 75 MPH THE VEHICLE STARTED TO SEVERELY SHAKE. HE PULLED OVER TO INSPECT THE TIRES BUT WAS UNABLE TO FIND THE FAILURE. HE THEN PRECEDED TO DRIVE AT 50 MPH AND TOOK THE VEHICLE STRAIGHT TO A DEALER. THE MECHANIC THERE INSPECTED THE VEHICLE AND NOTICED SEVERE THREAD SEPARATION AND BUBBLES ON THE SIDE OF THE FRONT DRIVER SIDE TIRE. THE TIRE WAS THEN REPLACED. A FEW MONTHS LATER HE WAS TRAVELING AT 75MPH WHEN THE VEHICLE STARTED SHAKING. BEFORE ATTEMPTING TO PULL OVER TO THE SIDE OF THE ROAD THE REMAINING DELTA TIRE THAT WAS LOCATED ON THE FRONT PASSENGER SIDE BLEW OUT. HE REPLACED THE TIRE BUT HE BELIEVES THAT THE TIRES WHERE DEFECTED AND SHOULD BE RECALLED. THE FAILURE MILEAGE WAS 370,000. THE CURRENT MILEAGE IS 380,000. -

    NHTSA complaint 10280695
16. Filed Dec 24, 2008Failure Dec 23, 200896,034 milesMarquette, MIFuel system, Gasoline

    MY 2000 CHEVROLET ASTRO HAS AN ACCELERATOR THAT DOES NOT STOP ITS ACCELERATION WHEN THE GAS PEDAL IS RELEASED. DEPENDING ON THE SLOPE OF THE ROAD, THE VEHICLE MAY GAIN SPEED UNTIL IT IS SHIFTED INTO NEUTRAL. IT IS NOT A BIG EVENT ON DRY ROADS, BUT YESTERDAY WHEN IT HAPPENED IN THE SNOW, IT ALMOST CAUSED A CRASH. I HAVE HAD IT SERVICED BY DIFFERENT DEALERS 3 TIMES AND AM STILL HAVING THE SAME PROBLEM. IT IS READY TO BE PICKED UP AFTER TAKING IT IN AGAIN YESTERDAY FOR THE SAME PROBLEM. IT DOES THIS ON OCCASION, BUT VERY OFTEN AFTER BEING ON CRUISE CONTROL. *TR

    NHTSA complaint 10252717
17. Filed Jul 8, 2008Failure Jul 8, 2008151,547 milesIrvine, CATires

    TL*THE CONTACT OWNS 2000 CHEVROLET ASTRO VAN. THE DEFECTIVE TIRE WAS A PEP BOYS FUTURA, SCRAMBLER AP, TIRE SIZE P215/75R/15. THE DOT NUMBER IS 3DHFPANM3104. WHILE DRIVING APPROXIMATELY 55 MPH, THE TIRE TREAD SEPARATED FROM THE LEFT REAR TIRE. THE TIRE SEPERATED FROM THE VEHICLE AND LEFT RUBBER MARKS IN THE MIDDLE OF THE REAR PANEL. THERE WAS NO TRACTION WHEN THE INCIDENT OCCURRED. THERE WERE NO INJURIES OR PRIOR WARNINGS TO THE FAILURE. THE TIRE MANUFACTURER STATED THAT THE FAILURE WAS RELATED TO TIRE TREAD SEPARATION. THE TIRE WAS REPLACED. THE DOT AND ADDITIONAL TIRE INFORMATION WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 151,547.

    NHTSA complaint 10233582
18. Filed Mar 15, 2008Failure Mar 14, 2006159,000 milesOrlando, FMAutomatic transmission

    MY AC FAILED TO BLOW COLD AFTER I NOTED SOME OIL (NOT MOTOR OIL) UNDER THE FRONT PASSENGER SIDE OF THE VEHICLE. THE DEALERSHIP RECHARGED THE SYSTEM WHICH WAS APPARENTLY EMPTY INCLUDING DYE FOR WHICH I BORE THE COST ($200+). LESS THAN 12 HRS LATER THE SYSTEM NO LONGER BLEW COLD AND NO FLUID WAS NOTED UNDER THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP FOR INSPECTION OF THE DYE. THE MECHANIC REMOVED THEN INTERIOR ENGINE HOOD AND FOUND THAT THE AC LINE HAD RUBBED AGAINST THE TRANSMISSION FILLER TUBE (NOW METAL ON METAL). A HOLE THE SIZE OF A DIME TO NICKEL WAS IN THE FILLER TUBE AND THE AC LINE ALSO HAD A HOLE IN IT. I ALSO HAVE ANOTHER 2K CHEVY ASTRO THAT WAS DIAG'D SEVERAL YEARS AGO FOR THE SAME HOLE IN THE AC LINE BUT IT HAD NOT WORN A HOLE IN THE TRANSMISSION FILLER TUBE. THE MECHANIC HAD INDICATED THAT THE AC LINE WAS "RUN THAT WAY FROM THE FACTORY". AT THIS POINT FOREIGN MATTER HAS FALLEN INTO THE TRANSMISSION INCLUDING THE METAL FROM THE FILLER TUBE, THE BLACK FOAM COVER ON THE AC LINE AND APPARENTLY THE FREON FROM THE DYE RECHARGE. I HAVE TO PRESUME OTHER FOREIGN MATTER HAS MADE ITS WAY IN TO FILLER TUBE AS WELL. I AM NOW ATTEMPTING THE HAVE GM COVER THE $1K REPAIR TO THE AC LINE AND TRANSMISSION FILLER TUBE. *TR

    NHTSA complaint 10221301
19. Filed Mar 7, 2008Failure Mar 4, 2008100,000 milesGriffin, GAInstrument cluster/panel

    I RECENTLY HEARD OF A RECALL ON THE TAHOES AND GM TRUCKS REGARDING THE GAUGE PANEL OR CLUSTER PANEL. I DRIVE A 1990 CHEVY ASTRO VAN WHICH IS ON A TAHOE FRAME. I AM HAVING THE SAME TYPES OF PROBLEMS WITH MY GAUGE PANEL AS DESCRIBED IN THE RECALL. MY ABS/BRAKE LIGHT COMES ON AT VARIOUS TIMES FOR NO REASON. MY TEMP AND OIL GAUGES CHANGE FROM HOT TO COLD AND BACK AGAIN FOR NO REASON AND THE CHECK GAUGE LIGHT WILL LIGHT UP. NOW THE GAS HAD WILL CHANGE EVEN WHEN THE CAR IS NOT ON. AS A WOMAN I NEED TO BE ABLE TO DEPEND ON MY CARS GAUGES TO LET ME KNOW IF THERE IS A PROBLEM. I TOOK THE CAR TO THE SHOP YESTERDAY AND THEY COULD NOT FIND A REASON FOR MY CAR TO BE DOING THESE THINGS. I CALLED OUR CHEVY DEALER HERE IN GRIFFIN WHERE THE CAR WAS PURCHASED AND THEY DID NOT WANT TO HELP ME. I AM NOW ASKING YOU FOR HELP. SINCERELY, DANA D. HORTMAN *TR

    NHTSA complaint 10220384
20. Filed Feb 27, 2008Failure Jan 2, 200896,500 milesNEW Fairfield, CTService brakes, Wheel speed sensor/tone ring

    UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSING INCREASED STOPPING DISTANCE. *TR

    NHTSA complaint 10219264