1997 Chevrolet Express

29 complaints on file, page 1 of 2.

1. Filed Feb 22, 2016Failure Dec 1, 2015Boston, MAFuel/propulsion system

   TL* THE CONTACT OWNS A 1997 CHEVROLET EXPRESS. THE CONTACT STATED THAT A FUEL ODOR CAME FROM THE VEHICLE AND THE VEHICLE LEAKED FUEL ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE. UPDATED 04/22/16*LJ UPDATED 05/31/18*JB

   NHTSA complaint 10837621
2. Filed Mar 28, 2006Failure Mar 28, 2006200,000 milesOcala, FLStructure1 injured

   DT*: THE CONTACT STATED THERE IS A HOOK ON THE REAR PASSENGER SIDE DOOR. THE CONTACT'S HEAD STRUCK THE HOOK, WHICH RESULTED IN THE CONTACT LOSING CONSCIOUSNESS AND HERNIATING TWO DISCS. THE MANUFACTURER SENT A REPRESENTATIVE, WHICH DETERMINED THIS IS HOW THE VEHICLE WAS DESIGNED.

   NHTSA complaint 10153907
3. Filed Mar 20, 2006Failure Feb 13, 200667,000 milesTucson, AZTread/belt

   DT*: THE CONTACT STATED WHILE TRAVELING 75 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER INTO THE MEDIAN AND THE TIRE WAS CHANGED. TWO HUNDRED MILES LATER, THE PASSENGER SIDE REAR TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER TO THE SHOULDER AND THE TIRE WAS REPLACED. THE TIRES WERE SENT TO THE MANUFACTURER WHICH DETERMINED THE BLOWOUTS WERE A RESULT OF ROAD HAZARDS. UPDATED 4/6/2006 - THE CONSUMER BELIEVES THE FAILURE WAS DUE TO TREAD SEPARATION. *NM

   NHTSA complaint 10153221
4. Filed Feb 22, 2006Failure Jun 15, 2005Albuquerque, NMAutomatic transmission

   THE TRANSMISSION HAD AN OVERHEATING PROBLEM THAT CAUSED THE VEHICLE TO SWITCH TO "SAFE" MODE. SAFE MODE COMPENSATED THE TRANSMISSION HEAT PROBLEM BY HARD SHIFTING. THE VEHICLE WAS TAKEN TO A TRANSMISSION SPECIALTY REPAIR SHOP WHERE I LEARNED THAT THE PROBLEM WAS IN THE DESIGN OF THE TRANSMISSION. IT WAS THE OPINION OF THE REPAIR SHOP THAT GM KNEW OF THE PROBLEM BUT WOULD NOT ISSUE A RECALL BECAUSE THE ISSUE WAS NOT LIFE THREATENING. COST OF MODIFICATION WAS $1,600.*JB

   NHTSA complaint 10150952
5. Filed Sep 21, 2005Failure Sep 15, 200578,900 milesNEW Berlin, WIEmission control, Automatic transmission, Service brakes, Antilock/traction control/electronic limited slip

   DT: WHILE DRIVING SERVICE ENGINE LIGHT ILLUMINATED ON THE DASH PANEL. THE CONSUMER TOOK THE VEHICLE TO A CHEVROLET DEALER, WHO PERFORMED A DIAGNOSTIC TEST WHICH SHOWED THAT TRANSMISSION WAS SLIPPING. THE DEALER NOTED THE NEXT STEP WOULD BE TO CHECK THE TRANSMISSION FLUID. DUE TO THE COLOR OF THE FLUID IT WAS DETERMINED A NEW TRANSMISSION WOULD BE NEEDED. THE DEALER REFERRED THE CONSUMER TO OTHER INDEPENDENT SHOPS, AND THEY TOO CONFIRMED WHAT THE DEALER SAID. THE CONSUMER TOOK THE VEHICLE HOME AND PARKED IT. NO CORRECTIONS OR REPAIRS WERE MADE. THE CONSUMER CALLED CHEVROLET MANUFACTURER, AND THEY SAID THERE WAS NOTHING THEY COULD DO. THE CONSUMER CONTACTED CHEVROLET AGAIN, AND THEY ESCALATED HIS CONCERNS BUT OFFERED NO FURTHER ASSISTANCE. *AK UPDATED 05/06/08 *BF THE CONSUMER STATED THE ABS AND MASS AIR FLOW SENSOR FAILED. UPDATED 05/06/08

   NHTSA complaint 10137203
6. Filed Sep 16, 2005Failure Sep 13, 200582,000 milesBoca Raton, FLTail lights

   TAIL LIGHT SOCKET FAILURE, NEW SOCKETS ARE GOING TO BE INSTALLED. *JB

   NHTSA complaint 10136757
7. Filed May 16, 2005Failure Mar 2, 2005185,000 milesCape Coral, FLSeat belts

   DEFECTIVE SEAT BELT WAS MOUNTED ON MIDDLE CAPTIAN CHAIR, STARCRAFT CONVERSION VAN. CABLE BROKE FROM NORMAL USAGE?

   NHTSA complaint 10121014
8. Filed Oct 4, 2004Failure Oct 4, 2004Thonotosassa, FLAutomatic transmission

   WHILE SHIFTING TRANSMISSION DOWN SHIFTED ON ITS OWN. A LOUD NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT TRANSMISSION NEEDED TO BE REPLACED. *AK

   NHTSA complaint 10095028
9. Filed Apr 25, 2004Failure Feb 10, 200480,750 milesGrapevine, TXFuel system, Fuel gauge system

   FUEL GUAGE FAILURE ON MY 1997 EXPRESS VAN. GUAGE SHOWED FUEL TANK EMPTY. ESTIMATED REPAIRS= $600.00. THIS HAS HAPPENED TO FRIENDS WITH SAME YEAR CHEVROLETS. INTERNET FULL OF COMPLAINTS FOR 1997 AND 2000 YEARS. THIS IS A SERIOUS SAFETY ISSUE, AND A VERY COSTLY REPAIR THAT MANY CANNOT AFFORD. PLEASE, PLEASE HELP. I AM SUBMITTING THE SAME FUEL GUAGE FAILURE COMPLAINT FOR A 2000 CHEVROLET BLAZER REGARDING AN INCIDENT THAT PUT MY TEENAGER IN SERIOUS JEOPARDY!*AK

   NHTSA complaint 10067766
10. Filed Jan 15, 2004Failure Sep 15, 200383,599 milesFredonia, WIElectrical

    THIS PROBLEM AFFECTS 1996-2002 G-SERIES VANS (CHEVY EXPRESS AND GMC SAVANA). THE POWERTRAIN CONTROL MODULE/VEHICLE CONTROL MODULE (PCM/VCM) CORRODES OVER TIME AND THE CASE ENCLOSING THE COMPUTER SPLITS OPEN ALLOWING WATER TO ENTER THE VEHICLE'S ELECTRICAL SYSTEM. GM HAS ACKNOWLEDGED THIS PROBLEM IN TECHNICAL SERVICE BULLETIN 02-06-04-020, ATTRIBUTING IT TO LOCATION OF THE PCM/VCM AND DESIGN OF THE ENGINE WIRING HARNESS DEFLECTOR. THIS DEFLECTOR ACTS MUCH LIKE A "RAIN GUTTER" TO ROUTE WATER AWAY FROM THE COMPUTER. IT WAS POORLY DESIGNED AND INSTEAD DUMPS WATER DIRECTLY ON TO THE COMPUTER TRIGGERING CORROSION. THE CORROSION MAY ALSO BE THE RESULT OF GALVANIC ACTION (TWO DISSIMILAR METALS GENERATING AN ELECTRICAL CHARGE) AS THE COMPUTER CASE IS ALUMIONUM AND SCREWS HOLDING IT TOGETHER ARE STEEL. A SMALL CLAIMS COURT ACTION FILED AGAINST GM AND THE DEALERSHIP IMMEDIATELY RESULTED IN AN OFFER FROM GM TO PAY FOR ALL REPAIRS (PRIOR TO ANY HEARINGS). THIS LEADS US TO BELIEVE THEY ARE VERY AWARE OF THIS PROBLEM AND MAY IN EFFECT HAVE A "SECRET WARRANTY" IN PLACE. TOTAL REPAIR COST WAS $1,400 BUT IT COULD HAVE BEEN MUCH MORE SINCE WE CHOSE TO "DRY OUT" THE ELECTRICAL SYSTEM RATHER THAN REPLACE THE ENTIRE WIRING HARNESS (MORE THAN $2,000 PARTS AND LABOR).

    NHTSA complaint 10070875
11. Filed Jan 15, 2004Failure Dec 24, 2003Willoughby, OHWheelsCrash

    WHILE DRIVING THE VEHICLE'S RIGHT FRONT WHEEL CAME OFF WITH THE LUG NUTS STILL ATTACHED TO THE HUB. AS A RESULT THE VEHICLE JERKED TO THE RIGHT AND RAN INTO A WALL. THE MANUFACTURER HAS BEEN CONTACTED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

    NHTSA complaint 10054197
12. Filed Jan 15, 2004Failure Dec 24, 2003Willoughby, OHWheelsCrash

    WHILE DRIVING THE VEHICLE'S RIGHT FRONT WHEEL CAME OFF WITH THE LUG NUTS STILL ATTACHED TO THE HUB. AS A RESULT THE VEHICLE JERKED TO THE RIGHT AND RAN INTO A WALL. THE MANUFACTURER HAS BEEN CONTACTED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

    NHTSA complaint 10054196
13. Filed Dec 30, 2001Failure Dec 29, 2001Coal City, ILAutomatic transmission

    ON 12-02-01 WHILE TRAVELING AT 70 MPH DOWN THE HIGHWAY AT 5 A.M. ON MY WAY TO WORK THERE WAS A VERY LOUD SCREECHING NOISE AND I LOST ALL POWER TO THE VAN, TRANSMISSION GONE . VEHICLE TOWED TO MARK BASS CHEVROLET DEALER IN COAL CITY,IL. MILEAGE AT 107060. NO LONGER COVERED UNDER WARRANTY, TRANSMISSION REPLACED AT A COST OF $1863.34 TO CONSUMER PLUS TOW BILL AND RENTAL CAR FOR 1 WEEK. ON 12-29-01 DRIVING DOWN THE HIGHWAY WITH THE CRUISE AGAIN SET AT 68 MPH I AGAIN LOST THE TRANSMISSION. MILEAGE NOW AT 108219 AND VEHICLE AGAIN TOWED TO DEALERSHIP FOR REPAIRS. VEHICLE IS EQUIPPED WITH A TRANS COOLER WHICH WAS INSTALLED UPON PURCHASE BY THE DEALERSHIP AND HAS TOWED A BOAT FOR A TOTAL OF 30 MILES. 99% OF THE MILES ARE INTERSTATE MILES DUE TO WORK DISTANCE OF 100 MILES PER DAY AND TRAVELING TO VISIT MY CHILDREN AND FATHER WHO LIVE IN TEXAS AND COLORADO. VEHICLE ALSO SEEMS TO GO THROUGH AN EXCESSIVE NUMBER OF BRAKES WHICH SEEM TO BE CONTINUELY GOING OUT AND HAVE BEEN REPLACED ABOUT 6 TIMES ALL THE WAY AROUND. I PURCHAED THIS VEHICLE BECAUSE OF THE NEED FOR COMFORT AND DEPENDABILITY IN MAKING LONG DISTANCE TRIPS WHERE I AM MOSTLY ALONE. IT HAS BEEN SERVICED ON A REGULAR BASIS AND IS IN VERY GOOD CONDITION. IT HAS ONLY BEEN DRIVEN BY ONE OTHER PERSON AND HAS NOT BEEN MIS-USED IN ANY WAY.*AK

    NHTSA complaint 756199
14. Filed Dec 4, 2001Failure Jul 15, 1997Ormond Beach, FLExterior

    OUTSIDE MIRRORS VIBRATE. BECAUSE OF VIBRATION DRIVER CANNOT SEE VEHICLE IN THE REAR. CONTACTED DEALER, AND DEALER STATED ITWAS A NON REPAIRABLE ITEM. PLEASE ADD VIN. *AK

    NHTSA complaint 899820
15. Filed Nov 13, 2001Failure Nov 5, 2001Indiannapolis, INTread/belt

    FIRESTONE, 245 75 R16, DOT # AN11B1A517, ORIGINAL EQUIPMENT, 30000 MILES MOUNTED ON A 1996, CHEVROLET, EXPRESS. WHILE DRIVING AT HIGHWAY SPEEDS THERE WAS SOME TREAD SEPARATION ON BACK LEFT TIRE.*AK *SLC

    NHTSA complaint 899050
16. Filed Aug 22, 2001Failure May 26, 1998Wantagh, NYService brakes, Master cylinder, Antilock/traction control/electronic limited slip

    CONSUMER STATED VEHICLE WILL NOT MAKE A SHORT PANIC STOP AT LOW SPEEDS, EXTREME PEDAL PRESSURE HAS LITTLE EFFECT AS THE VEHICLE APPROACHES 15 TO 10 MPH AND SLOWER, CONSUMER STATED THE ABS CONTROL IS SUPPOSE TO DROP OFF AND PERMIT THE BRAKES TO STOP THE VEHICLE WITHOUT LIMITATION, CONSUMER WAS INFORMED BY DEALER HE SHOULD ALLOW FOR GREATER STOPPING DISTANCE WITH ABS AND THAT THE PROBLEM COULD NOT BE DUPLICATED, ALSO CONSUMER DISCOVERED BRAKE FLUID UNDER THE MASTER CYLINDER, THE DEALER REPLACED THE CAP SEAL DUE TO IT NOT SEALING PROPERLY. *JB

    NHTSA complaint 562622
17. Filed Jun 7, 2001Failure May 7, 2001Charleston, SCFuel system, Hoses, Lines/piping, And fittings

    CONSUMER CONTACTED DEALER ON MAY 07,2001 IN REFERENCE TO RECALL# 00V110000 AND MANUFACTURER'S RECALL 00031. DEALER STATED THAT PARTS WERE NOT AVAILABLE ,AND NO FUTURE DATE WAS GIVEN ON WHEN PARTS WILL BE AVAILABLE.*AK

    NHTSA complaint 889955
18. Filed May 16, 2001Failure May 1, 2001EL Mirage, AZBuckle assembly

    REAR SEAT BELTS FAIL TO FUNCTION PROPERLY. MIDDLE LAP BELT FAILS TO STAY BUCKLED. ALSO, SHOULDER BELT ON PASSENGER'S SIDE IN REAR FAILS TO PULL OUT. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK

    NHTSA complaint 888369
19. Filed Mar 16, 2001Failure Jan 10, 2001Baton Rouge, LAAutomatic transmission

    THE REACTION SHELL BROKE IN THE TRANSMISSION, DISABLING THE VEHICLE COMPLETELY WHILE IN TRAFFIC. THIS CAUSED MY WIFE WHO WAS DRIVING IT TO ESSENTIALLY STALL OUT. FORTUNATELY, NO ONE WAS HURT, BUT THE REPAIRS TO A VEHICLE WITH SUCH LOW MILEAGE TOTALED OVER $2200.00. MIGHTY POOR QUALITY. THANKFULLY THE FAILURE DID NOT TAKE PLACE WHILE SHE WAS PASSING SOMEONE, OR GOING UPHILL.*AK

    NHTSA complaint 742544
20. Filed Mar 14, 2001Failure Feb 15, 2001Neptune, NJEmission control

    VEHICLE IS CURRENTLY IN SHOP FOR PLUG ON EMISSION FUEL LEAKING INTO VCM WIRING, ALLOWING FUEL TO COME BACK UP. A RECALL ID # 00V110000/MANUFACTURER'S RECALL #00031 HASN'T BEEN ANNOUCED TO SEE IF OTHER COMPANY VEHICLE ARE AFFECTED.*AK

    NHTSA complaint 882976