Pickup, electric, AWD/All-Wheel Drive, built in United States. Owner complaints on file from Aug 25, 2024 to Mar 3, 2026.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 25V-015 | Jan 16, 2025 | Bolt that secures the rear center seat belt assembly to the seat structure may not have been properly tightened | Seat belts | 5 | Repair or modification |
| 24V-320 | May 9, 2024 | Electric motors in the rear drive units may have insufficiently insulated wires that can contact each other, resulting in a loss of drive power | Electrical system | 10 | Part replacement |
| 24V-087 | Feb 8, 2024 | Incorrect seat belt bezel on the second-row center seat belt may damage or tear the seat belt in the event of a crash | Seat belts | 338 | Part replacement |
| 23V-786 | Nov 22, 2023 | Left or right front seat belt buckle attachment bolts may not be tightened properly | Seat belts | 115 | Repair or modification |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
25 complaints on file, page 1 of 2.
I own a 2024 Chevrolet Silverado EV WT equipped with the OEM soft tonneau cover. The original cover and its warranty replacement have both failed in the same way. The cover material appears to shrink over time so that the side flaps will no longer reach and stay attached to the Velcro along the bed rails. At highway speeds the cover flaps and “balloons” upward, and the Velcro strips will not stay connected even when properly installed and tightened. The dealer has already replaced the cover once under warranty, but the replacement has the same problems. This suggests a design or materials defect, not a one‑time bad part or installation error. In my opinion, the flapping and ballooning could allow the cover to come loose or detach at speed, which could create a road hazard for other drivers. I am asking NHTSA to track these failures and evaluate whether the OEM soft tonneau cover on the Silverado EV presents a safety risk similar to prior GM tonneau cover issues where covers detached while driving.
NHTSA complaint 11721788The contact owns a 2024 Chevrolet Silverado EV. The contact stated that while operating the vehicle in sub-zero temperatures, the HVAC unit failed to blow hot air through the vents. During the failur,e the contact was unable to defrost the windows. The vehicle was taken to the local dealer who determined that the heater control module was inoperable and needed to be replaced. The vehicle was not repaired. The contact was informed that the heater control module part was on a national back order and currently not available. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 13,000.
NHTSA complaint 11714425When charging my Silverado EV at Level 3 DC Fast chargers it is not charging at the same Voltage / Power as it has been in the past at the same stations (roughly half the power). I have taken it to the service center for diagnostics but they were unable to isolate the component that caused this problem, only reproduce the problem. Further details below. What component or system failed or malfunctioned, and is it available for inspection upon request? - The Level 3 DC high voltage charging is not charging at the same voltage as a comparable Silverado EV. (Pictures attached) - I can demonstrate the problem with my car on request, I have attached pictures of a new Silverado EV charging as well. How was your safety or the safety of others put at risk? - I would not consider it safe for level 3 DC charging which involves high current and high voltage to not be working as designed. It is also unsafe to not have any warning lights indicating that the charging is not working as designed. Has the problem been reproduced or confirmed by a dealer or independent service center? Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - The problem has been reproduced and confirmed by John Heister Chevrolet of Fuquay Varina NC. They were unable to isolate a component that is causing the issue and have sent log files of the car to the engineers at Chevy to further diagnose this issue. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - There are no warning lights / messages indicating that there is a problem even now. Only the symptom of not charging at the expected Voltage / Power level. - Symptoms were first observed by me on December 16, 2026
NHTSA complaint 11713924On 1/20/26, we purchased a ‘24 Chevy Silverado EV from a Chevrolet dealership. 2 days later, on 1/22/26, while my husband was driving on the interstate, the tonneau cover partially detached and flew backwards lifting upwards and flapping violently. One of the metal crossbars detached completely from the tonneau cover and flew off the truck, and a second crossbar began to tear away. The cover was flapping forcefully which created a highly unstable and dangerous condition. My husband pulled over on the side of the interstate to remove the tonneau cover to prevent it from fully detaching. He placed the cover into the truck bed. This incident occurred suddenly, with no warning. This was a near-miss incident with potentially catastrophic consequences. If the tonneau cover had fully detached, it could have become airborne and struck another vehicle. The crossbar that flew off, could have struck another vehicle, easily penetrating a windshield, causing another driver to lose control, or result in a multi-vehicle collision. The risk of serious injury or fatality was significant. The next day, on 1/23/26, we took the truck and damaged tonneau cover to our local Chevrolet dealership for inspection. The service manager visually inspected the cover and documented the failure. We scheduled an appointment for repair at their soonest availability, 2/4/26. We will not feel comfortable using a new cover unless a modification is made to adequately secure the cover to prevent this from occurring again. We also called the Chevrolet dealership where we purchased the vehicle from and spoke with the general manager to let them know what happened, as they have sold close to 100 of these Chevy Silverado EV’s. They said this has happened to others and they speculate that GM is already aware of this concern. We urge the NHTSA and GM to take immediate action. Please open an investigation and issue a recall before someone is seriously injured or killed. Thank you NHTSA!
NHTSA complaint 11713445The contact owned a 2024 Chevrolet Silverado EV. The contact stated that when idle, the vehicle would hesitate before accelerating. Continuing to drive at approximately 55 MPH, the accelerator was released, and the vehicle continued to accelerate. The vehicle veered off the road, where the vehicle flipped a total of 5 times before coming to a stop. The contact received injuries to their back, whipflash, and a contusion of the stomach. Medical treatment was needed and had been ongoing. The vehicle was towed and totaled. A police report was filed. The manufacturer was not informed of the failure. The failure mileage was unknown.
NHTSA complaint 11700039See attached document for complaint.
NHTSA complaint 11699349Under heavy acceleration the vehicle swerves from lane to lane and the operator is unable to counter the steering. The behavior continues until the acceleration is halted. The vehicle was grounded due to it being deemed unsafe by the originating dealership technician and repairs were attempted but were unsuccessful. The dealership had another vehicle like mine in inventory so they tested that one and found the same erratic behavior but rather than deeming it to be a problem they declared the steering issue it to be normal for that model. This is section 4 of the attached dealership service report.
NHTSA complaint 11691009On multiple occasion parking sensors activate for no reason. Emergency braking occurred while backing as well as while driving for no reason at all. High possibility of a crash occurring. Gm refuses to repair or replace. Gm stated dealer says vehicle has completed repairs and vehicle ready for pickup. Dealer has not repaired or replaced any items or parts.
NHTSA complaint 11690887The front trunk latch mechanism repeatedly fails. When this occurs, the vehicle believes the trunk is open and will not let you drive in normal mode. It forces you to proceed in limp mode which is dangerous. The 12v battery has to be reset to have the sensor redetect the close latch. Reports from multiple forum sources show this to be a widespread problem and currently dealer are replacing with the same mechanism and the problems reoccur.
NHTSA complaint 11687225The soft tonneau cover that was installed on the vehicle was faulty and became detached from the metal tension bar and cant be reattached.
NHTSA complaint 11681681The exterior passenger side mirror is manufactured with flat glass and not convex glass. The flat glass field of view is not nearly wide enough for this large truck. This flat glass combined with the width (distance from the driver's head/eyes to the passenger door mirror), height, and length of the truck creates a substantial risk for an accident while traveling on any roadway or even maneuvering while parking. It is impossible to adjust the flat glass mirror to bring a smaller car to the right side of this truck into the driver's field of view, and at the same time, approaching traffic from the right rear. This is particularly dangerous when needing to make a quick "glance and maneuver". GM Parts has advised there is no alternative replacement mirror for this truck. Replacing the flat glass mirror on the passenger side with the commonly used passenger convex mirror glass would correct this hazardous situation.
NHTSA complaint 11675505While in traffic over 45 miles per hour, the vehicle placed itself into a hazard mode due to the electric vehicle propulsion system. This happened so fast and the deceleration rate was so quick that it risked a rear end collision. This is the second time this has happened and both were following a heavy rain storm. I drove through a modest puddle that did not even submerge half of the tire wall making contact with the road and did so slowly. Less than five miles later, the vehicle goes into what my service advisor calls "limp mode." I have asked General Motors to give me an even exchange or, in lieu of the fear this vehicle gave me, an upgrade to a Cadillac Escalade IQ.
NHTSA complaint 11674751The backup camera stopped working around July 1. I took the vehicle to the dealer and the dealer could not fix the problem. The dealer says GM is aware that some vehicles have their backup camera stop working and is working on a software fix. Backup cameras have been a required safety item on all cars sold in the US since 2018. An inoperable camera thus is a safety risk. There are no warning lights or other messages.
NHTSA complaint 11673207Frunk compartment of Silverado ev won’t close and puts the car in “limp” mode. Dealership has replaced it twice. Still happens making the car not drive able and unsafe. Multiple people have had this issue and needs to be addressed please
NHTSA complaint 11667033I am 6'2" tall. The shoulder straps on both the drivers and passenger side do not adjust up far enough to protect me in the event of a crash. The straps slip down below my shoulder. This is due to the fact that the WT model does not have power seats, so I am unable to lower my seating position to a safe level. If the seat could be lowered, the shoulder straps would sit properly above my shoulder. In the event of a crash the shoulder strap will be totally useless.
NHTSA complaint 11665989There is apparently a known issue on the WT "Work Truck" trim of the Silverado EV trucks where the factory wiring harness was assembled incorrectly. This prevents the truck from knowing when the rear doors are open vs closed. If only one (or even both) rear doors are open, all the doors may automatically lock (depending on auto-locking settings), potentially locking the driver out of the vehicle. As a first responder I immediately recognize this as a significant child safety issue: if a parent were to get out to check on their child in the back seat, finish what they were doing, then close the doors to get back in the front, they could find themselves locked out with their child locked inside. Because this would also mean the truck would be shut down, the climate controls would be turned off when this happens, and could easily result in heat injury or death of a child. This door issue also causes a safety issue as the dome lights do not come on when the rear doors are opened, and a door could potentially be partially or even wide open without the truck alerting the driver. The dash clearly shows and identifies the front driver and front passenger door open indicators, but does not show either of the rear doors. I have not taken my truck into the dealer for correction of this issue yet, but I have confirmed this is an issue with multiple other Silverado EV drivers who have the WT trim (both 3WT and 4WT packages). While I will be working with GM to address the issue on my vehicle, I feel the potential risks of this issue are significant enough that the NHTSA should intervene for all affected vehicles. To save a little time, here is a forum post on the matter. Post #16 has a service description from a Chevrolet tech about this issue on another truck: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11654001The rear door sensors do not function, doors are always indicated as being closed, even if they are open. The car gives no warning if door open and vehicle put into drive. Also with walk away lock the vehicle can lock while rear door is in the open state resulting in accidentally locking a occupant in the vehicle. The walk away locked engaged while I was at the rear of the vehicle unloading my dog from the back seats. Others have reported the issue in this forum [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11649628Vehicle fails to determine if either passenger or driver rear doors are open. The vehicle is missing some functionality where the door can be opened and vehicle can be driven. My child can open the door and there will be no warning about the door being open. The interior lights do not come on when any of rear doors are open.
NHTSA complaint 11638821See attached document for complaint
NHTSA complaint 11636110Rear door sensors do not work. No dash light or dome light to indicate if a door is open or adjar. If a child is in the back seat doors could be left open and the driver would not know.
NHTSA complaint 11631539Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.