Minivan, plug-in hybrid, FWD/Front-Wheel Drive, built in Canada. Owner complaints on file from Feb 20, 2019 to Jun 18, 2025.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 24V-538 | Jul 18, 2024 | Battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" positionPark outside | Hybrid and electric propulsion | 3,606 | Software update |
| 20V-334 | Jun 9, 2020 | 12 volt isolator post located behind the driver's seat may develop high resistance | Electrical system | 23,079 | Remedy pending |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
45 complaints on file, page 1 of 3.
The contact owns a 2019 Chrysler Pacifica Plug-In Hybrid. The contact stated while driving 75 MPH down a winding mountain road, the message “Pull Over Immediately - Vehicle will Shut down Soon” was displayed. The contact pulled over and was able to restart the vehicle. The contact stated that the message was displayed three times. The vehicle was driven to the local dealer, where it was diagnosed that a software update and transmission rebuild were needed. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 70,200.
NHTSA complaint 11667607We received multiple reminders for the recalls to be addressed, but each time we make an appointment at various service centers, they say that they cannot address the recall due to staff shortage and parts not being available. This has been persisting for over 4 years. Chrysler does not make a good faith effort to address these recalls. Most recently, we had an appointment and they (Spring Autonation in Spring, TX) told us that they would have to hold the car for weeks before being able to get to it due to shortage of staff as they only have two service members who can address it. Helfman Dodge said they holding time would be 3-4 weeks before being able to get to it. Teh reminders for the three recalls are coming from the dealerships, and yet they are not able to address them.
NHTSA complaint 11646603UNKNOWN/RECALL NOT BEING FIXABLE FOR MONTHS: due to a recall from mid-2024 which cannot be fixed, the vehicle is no longer safe to have parked in my garage, near my home, next to other vehicles, and is now not able to be used as intended. The risk of fire and/or explosion should require a manufacturer buyback. These vehicles have been dangerous for MONTHS.
NHTSA complaint 11641773The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V538000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint 11639605The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V538000 (HYBRID PROPULSION SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint 11638090While driving the car down a busy 4 lane road at 55mph on [XXX] around [XXX] in Irvine, CA, the car began to shake as the steering locked up and alerts came up on the dash that the power steering had failed. After turning the car off and on it did not fix it. Leaving it off for 15 mins seemed to make the error go away. We had it towed to Tustin Tuttle Chrysler dealership for service. The dealership found the fault code in the log, it was a power steering control failure. They could not replicate the circumstance and insist on releasing the car as safe to drive; putting my family and the public at great risk. The dealership refuse to even run diagnostics on the faulty identified part. They said if they cannot recreate the problem they won’t fix it, even though they see the error code on their scanner. They shouldn’t be telling me the car is safe when it is clearly not. They only drove it 30 miles and did not check wiring or even pop the hood. They have done no work to deem it safe and this is fraud. Rochelle, the service manager, has told us over the phone that she will not work on the car, because she believes she will not be reimbursed for the work. She has said she has had the car for too long and wants it picked up. Her service advisor Erik, has read us the codes found over the phone and also told us that no one has worked on it and only has test driven it. Our greatest concern is the dealership is not servicing or repairing vehicles and putting very dangerous cars on the road. This is a public safety issue for all of Southern California. Additionally, this car was purchased with a full manufacturer’s bumper-to-bumper warranty, of which it is still in its covered in the next 3 years or 40,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11628082Van engine failed during driving. This is a known issue by Chrysler and they will not repair the underlying problem - this is related to a prior recall. Instead, it only suggested replacing the battery which is a temporary fix. Separately, this van has a pending recall due to a fire risk. Unable to use the plug-in hybrid function of the van nor park it in a garage due to the recall issue. It has been almost four months since the recall notice without any news of when Chrysler will fix this problem. I requested a buy back due to the inherent risk of severe injury from simply being inside this van but was denied.
NHTSA complaint 11625196Chrysler issued recall 72B back in July but has failed to provide a repair solution to the issue of a high voltage battery fire. They have advised to park the vehicle away from structures and to not charge. It's disappointing not to have a resolution or fix for this issue, especially going into the colder months and not being able to use the vehicle as intended.
NHTSA complaint 11624172On [XXX] around 12:00 PM, while traveling northbound in the HOV lane at 70 MPH on [XXX] near [XXX] , with two small children in the passenger row and two adults in the front, the following error suddenly appeared on the dashboard: "Stop Safely -- Vehicle Will Shut Off Soon." Power to the engine stopped as a result and the car coasted. A "red turtle" warning and a "Check Engine" error also displayed. No other errors, unfamiliar sounds, or mechanical noises preceded these errors, nor had there been any other recent problems with the car. We pulled over to the shoulder immediately and turned the car off for approximately 5 minutes to see whether the errors would persist. With the "Stop Safely" error no longer on the dashboard, we turned the car on again and drove it to the dealership. On that drive, the previous errors appeared a second time. The dealership, Carl Burger Dodge Chrysler Jeep RAM World (La Mesa CA), has confirmed that the transmission needs to be replaced and that it is unsafe to drive the vehicle until the transmission is replaced. On August 30, 2024, the dealership said that they are waiting for Stellantis to release the transmission and "that won't happen any time soon." As of today, September 2, 2024, Carl Burger has failed to provide a timeline for the replacement and have informed us that we must deal with Stellantis in order to get the case escalated and the car repaired. They have also refused to offer us a replacement/loaner vehicle while ours is in the shop. Mileage: 51,000 Stellantis Case Number [XXX] Dealership: https://www.carlburger.com/ INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11612113Check engine light cam on then a message "Stop safely Vehicle will shut off soon" This is related to recall 23V-010
NHTSA complaint 11605054Got on freeway on ramp. About 3/4 of a mile later, warning came on “Stop Safely, vehicle will shut off soon” - red turtle appeared, and service engine soon light came on. 1. Transmission - it is at this point, but part has been ordered to replace 2.Going freeway speeds (73MPH) and had to immediately slow and pull over with little warning. If the traffic would have been heavier, there is a good chance a collision would have occurred. 3. Yes - it was taken to a dealership today (5-9-24) and they indicated it is a transmission issue, and are ordering parts to correct this issue 4. No warnings prior to it coming on when I was driving.
NHTSA complaint 11587898The contact owns a 2019 Chrysler Pacifica Hybrid. The contact stated while driving approximately 35 MPH, and ascending a medium grade in the road, the contact heard a "pinging" sound and the "Stop Safely - Vehicle will Shut Off Soon" warning light and a turtle symbol and the check engine warning light was illuminated. The vehicle lost motive power but was able to drive to the side of the road and shut off the vehicle. The contact stated that she was able to restart the vehicle, but the check engine warning light and the turtle symbol remained illuminated. The contact turned off and restarted the vehicle, and only the check engine warning light was illuminated. The contact was able to drive to her destination. The contact had previously received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) and the recall repair was completed at a local dealer. The contact had not taken the vehicle to a local dealer or independent mechanic for the recent failure. The vehicle was diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 55,000. The contact stated the dealership insisted on replacing the power inverter even though they were told others who had the loss of motive power requires a new transmission. Also, the vehicle shut down once again after the repairs.
NHTSA complaint 11585166The electrical system for the Chrysler Pacificas are dangerous. Beyond the other dangerous recalls, my Horn and cruise control no long work intermittently. I learned this while trying to warn a driver that was cutting into my lane without seeing my vehicle and I couldn’t warn them that they were about to hit me. Also Cruise control stops randomly. This all started after previous recall repairs. Since I am unable to use my horn in an emergency, I am nervous that my airbag no longer functions. This is a common issue reported online. This all started after previous recall repairs
NHTSA complaint 11568907While driving a message appeared on the dash "SERVICE CHARGING SYSTEM" and vehicle doesn't even accelerate(we stay in Des Moines and visited my cousin in Dallas,TX, this is where this issue happened). Luckily I was on local road I was able to pull off, what would be the situation if it happens on interstate with such high speed travelling vehicles behind me. I was driving with my 2 kids and wife and I feel it's more dangerous to take a trip with this vehicle. Please try to find a solution or issue an recall and doesn't want this situation to happen to anybody.
NHTSA complaint 11562818We had put a ladder on the roof of our van to return to Home Depot, and I opened our rear gate. I didn't know it at the time, but the van's rear gate could not open all the way at the top because of the ladder, which hung a few inches over the top of the gate. Because I didn't know the ladder was in the way, when the rear gate opened, I bent over inside the van with my small dog to put her in her crate. Immediately, I heard the warning beeper start to go off, but before I could move out of the way, the gate came zooming down fast on my head and I had to squeeze to the size and fell into my driveway bushes trying to get out of the way. Thankfully, neither I nor my dog were harmed, but we could have both been seriously injured or killed. I have no idea why a rear gate would descend so fast or not sense that I and my dog were present.
NHTSA complaint 11554562Loss of Motive Power reoccurrences (2 incidents) AFTER 1803A182 Safety Recall 03A correction was performed, 9 May 2023, by reprogramming Hybrid Control Processor/Aux Hybrid Control Processor on 2019 Chrysler Pacifica Plug-In Hybrid (mileage: 35,180) Experienced a sudden loss of power twice; 16 and 17 September 2023. - 16 SEPTEMBER: Having just merged into one lane from two and speeding up hill (from approx. 20 mph) to merge onto highway, a sudden loss of power occurred without an adequate shoulder to pull off, resulting in time critical crash avoidance maneuvers by all vehicles behind us. No known crashes occurred within our viewing range. ADDITIONAL DETAILS: Unable to shut down vehicle for 2-3 minutes Check Engine Light illuminated Dash Diagnostic screen: “Service Charging System” error Electric Power available: 56% Fuel: 3/8th) - 17 SEPTEMBER: After running a preliminary diagnostic test with my personal OBD tester, I noticed that the Check Engine Light turned off after the connection activated. I did NOT clear any codes. After printing the list of faults generated from the evening prior, I chose to take it for a short test drive. While waiting at a stop light within a mile from my house, the same issue occurred again, “Service Charging System” error followed by two additional alternating notification on the dash, “Service Shifter” error and “Service Shifter Stop Safely Shut Off Vehicle to Engage Park,” with the transmission indicator selector knob lost illumination and became non-responsive. (as seen in attached pictures from previous incidents) Luckily, everyone was stopped this time. Within 20-30 seconds, the entire vehicle, including dashboard went completely dead then blipped back on as if nothing had happened, allowing me to make it home safely.
NHTSA complaint 11545450Hood has rusted throughout most of the entire hood UNDER the paint. no accident has occurred , but extremely concerned hood may break apart and crash into windshield and cause a severe dangerous accident. Other vehicles of this kind may have same serious problem.
NHTSA complaint 11536673The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint 11516477While driving down the road at approximately 45 mph, the car suddenly shut down with no power. The display said there was a charging error and to put the vehicle in park. I parked the vehicle on the shoulder, turned it off, and restarted. The engine started and I drove off, but 5 minutes later it suddenly shut off once again. I repeated this process 2 times until the final time, the vehicle would not restart, and we were stranded on the shoulder of a busy road in icy conditions. A mechanic ran a diagnostic on the vehicle and there are no error codes, but it will not start and says there is a charging error, even though it is not plugged in. The sudden stops are very dangerous, especially in snowy/icy conditions. We are 600 miles away from home and do not feel safe operating this vehicle on a long road trip on busy highways.
NHTSA complaint 115091252019 CHRYSLER PACIFICA. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 23V-010. THE CONSUMER STATED THE REMEDY FOR THE RECALL UPDATING THE PIM SOFTWARE UPDATE OPPOSED TO REPAIRING THE WIRE HARNESS IS UNSATISFACTORY.
NHTSA complaint 11506556Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.