1997 Ford Explorer

1,731 complaints on file, page 1 of 87.

1. Filed May 3, 2021Failure Jul 13, 2020147,000 milesRawlins, WYEngine, Service brakes, Suspension

   TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STARTED TO SHAKE ABNORMALLY, THE CONTACT WAS UNABLE TO DRIVE IN 4 WHEEL DRIVE. THE CONTACT STATED THE CHECK GAUGE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE FRONT DRIVE SHAFT, THE CONTROL ARMS, THE FRONT OXYGEN SENSOR, AND THE FRONT AND REAR BRAKES NEEDING TO BE REPLACED. THE CONTROL ARMS WERE REPLACED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 147,000.

   NHTSA complaint 11414983
2. Filed Jun 8, 2020Failure Jun 7, 202023,000 milesJacksboro, TNEngineFire

   TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE PARKED IN HIS DRIVEWAY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HYDRAULIC FLUID WAS LEAKING DUE TO THE FAULTY CRUISE CONTROL SWITCH CAUSING THE FIRE. THE CONTACT MENTIONED THAT THE HYDRAULIC FLUID LEAKED OUT WHEN IT GETS WARM EVEN WHEN THE VEHICLE NOT RUNNING. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TESTING AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000. THE VIN WAS NOT AVAILABLE. *BF

   NHTSA complaint 11327709
3. Filed Apr 12, 2019Failure Mar 15, 2016175,000 milesBend, ORElectrical system, Electronic stability control (esc), SuspensionCrash1 injured

   MY LIGHTS DON'T WORK STABILIZING BAR IS BAD,SPEED CONTROL DOSE NOT WORK SECURITY KEY CODE NOT WORKING,DOOR CONTROLS DO NOT WORK.WIPER WORK SOMETIMES.BALL JOINT ARE BAD, TIRES WEARING BAD,,BUSHINGS ARE VERY BAD.TRANSMISSION IS STARTING TO SLIP,ALL WHEEL DRIVE DOES NOT WORK, IT GRINDING SOUND.HEAF LIGHT ONLY BRIGHTS WORK.

   NHTSA complaint 11195896
4. Filed May 29, 2018Failure Apr 26, 201828,000 milesFajardo, PRUnknown or otherCrash

   RUNNING ON THE HIGHWAY THE RIGHT AXLE OF THE DIFFERENTIAL BROKEOFF AND THE WHEEL CAME OFF WITH THE BRAKE CALIPER AND BRAKE HOSE AND BECAUSE OF THIS CAUSE LOOSE CONTROL AND CRASH .THE VEHICLE IS TOTAL LOSS.

   NHTSA complaint 11098437
5. Filed Aug 30, 2017Failure Mar 1, 2016285,000 milesEL Sobrante, CASeat belts, Seats, Vehicle speed control

   THE DRIVERS SIDE SEATBELT WILL NOT ENGAGE TO THE LOCK POSITION.

   NHTSA complaint 11020608
6. Filed Apr 3, 2017Failure Apr 3, 2017SAN Francisco, CAElectrical system

   I RECENTLY FOUND OUT MY VEHICLE HAS AN OPEN RECALL REGARDING THE POSSIBLE LEAKAGE OF THE SPEED CONTROL DEACTIVATION SWITCH, WHICH COULD CAUSE A FIRE WHETHER THE VEHICLE IS RUNNING OR NOT. THE FORD MANUFACTURER'S RECALL #09S09 AND THE NHTSA RECALL #09V399000. THIS IS STILL AN OPEN RECALL.I CONTACTED FORD RECALL CENTER TODAY AND THEY ARE REFUSING TO REMEDY THIS HAZARDOUS RECALL DUE TO THE AGE OF THE RECALL AND THE AGE AND MILES OF MY VEHICLE. THIS IS A SAFETY ISSUE AND FORD SHOULD FIX IT AS BODILY INJURY OR EVEN POSSIBLE DEATH COULD OCCUR IF THIS RECALL IS NOT REMEDIED. MY VEHICLE IS RUNNING PROPERLY FOR THE MOMENT BUT SINCE THIS IS A SAFETY ISSUE, FORD MOTOR CO. SHOULD BE REQUIRED TO FIX IT NO MATTER THE AGE OF MY VEHICLE.

   NHTSA complaint 10970153
7. Filed Dec 29, 2016Failure Dec 23, 2016220,000 milesKernersville, NCElectrical systemFire

   ON DECEMBER 23RD, 2016 I WAS COMING HOME FROM WORK AROUND 6:00 PM. MY CAR WAS A 1997 FORD EXPLORER EDDIE BAUER EDITION. I HAD JUST GOTTEN OFF OF THE HIGHWAY AND TURNED ONTO MY ROAD WHEN I BEGAN TO SMELL SMOKE, SO, I PULLED OFF INTO AN EMPTY PARKING LOT BESIDE A WALKING TRAIL. I COULD TELL THAT IT WAS AN ELECTRICAL FIRE, BUT, IT TOOK ME QUITE A WHILE TO FIGURE OUT WHERE IT WAS COMING FROM. I CHECKED UNDER THE HOOD - BUT NOTHING SEEMED TO BE WRONG THERE. THEN, I GOT BACK INTO THE CAR AND THE SMOKE KEPT GETTING HEAVIER. I BEGAN FEELING AROUND FOR SOMETHING THAT WAS HOT. I CHECKED THE DASH, THE VENTS, THE STEERING WHEEL, THE SEATS - ALMOST EVERYTHING BEFORE I CHECKED THE CENTER COMPUTER CONSOLE. IN THE MIDDLE OF MY CAR - DIRECTLY UNDER THE RADIO - THERE IS A COMPUTER MODULE THAT DISPLAYS THE GAS MILEAGE, OIL STATUS, AND IF THERE IS A PROBLEM WITH THE LIGHTS ON THE CAR. THE MODULE HAD RECENTLY STARTED DISPLAYING A "CHECK HEADLAMPS" MESSAGE. WELL - I HAD DONE SO AND THEY WERE WORKING FINE - SO I DID NOT THINK ANYTHING OF IT. TURNS OUT THAT THE FIRE HAD STARTED UNDER THE CENTER COMPUTER MODULE. I GUESS THAT THE CAR SHOULD HAVE BLOWN A FUSE BUT INSTEAD - STARTED A FIRE. I TRIED TO RIP THE COVER AND THE CONSOLE UP - BUT IT WAS SCREWED DOWN AND I HAD NO LUCK. AT THAT POINT, THE FLAMES STARTED TO SPREAD VERY QUICKLY AND THE ENTIRE CAR WENT UP IN FLAMES IN A MATTER OF MINUTES. I CALLED 911 AND GOT AS FAR AWAY AS I COULD WITH MY BELONGINGS. THE FIRE TRUCK AND FIRE FIGHTERS CAME WITHIN FIVE MINUTES OR SO AND PUT OUT THE FIRE BEFORE IT REACHED THE GAS TANK. THE BOTTOM HALF OF THE CAR REMAINED UNTOUCHED, HOWEVER, THE INTERIOR WAS COMPLETELY DESTROYED. THE SEATS HAD BURNT OFF AND THE STEERING WHEEL WAS COMPLETELY GONE. I'M STILL IN MY TEENAGE YEARS - SO I DID NOT KNOW HOW TO DEAL WITH THIS SITUATION PROPERLY. I AM JUST GLAD I AM ALIVE AND THAT I WAS ABLE TO GET OUT OF THE CAR IN TIME.

   NHTSA complaint 10938443
8. Filed Apr 23, 2015Failure Apr 1, 2015144,000 milesBiloxi, MSSeat belts

   DRIVER SIDE SEAT BELT BUCKLE WILL NO LONGER SECURELY LATCH. *TR

   NHTSA complaint 10712375
9. Filed Apr 8, 2015Failure Feb 23, 2015228,226 milesFlorence, SCService brakes, HydraulicCrash

   WITH NO WARNING OR HINT OF ANYTHING GOING WRONG ON THE BRAKE SYSTEM, AS TRAFFIC SLOWED TO STOP FOR A LIGHT, THE BRAKES WENT COMPLETELY OUT ON MY FORD EXPLORER. THE PEDAL WENT TO THE FLOOR AND PUMPING HAD NO EFFECT. I WAS IN MID DAY TRAFFIC AND HAD ALMOST 2 CAR LENGTHS BETWEEN MYSELF AND THE SUV IN FRONT OF ME, WHICH UNFORTUNATELY, WAS WHAT STOPPED ME. THANKFULLY, I WAS ONLY GOING 20 MPH AND NO ONE WAS HURT NOR DID AIR BAGS DEPLOY. AFTER THE POLICE ARRIVED AND HAD US PULL INTO A PARKING LOT, THE PEDAL FELT LIKE IT HAD THE BRAKES BACK HOWEVER, THE BRAKE PEDAL WENT TO THE FLOOR AFTER CRANKING UP. I WAS ABLE TO STOP FROM ROLLING OUT THE OTHER SIDE OF A PARKING SPACE IN THE BACK OF THE LOT BY USING THE EMERGENCY BRAKES. EVEN THOUGH THE TRUCK HAS SHOWS HIGH MILEAGE,MOST OF WHICH IS HIGHWAY MILES, THE TRUCK AS BEEN MAINTAINED. I HAD THE TRUCK TOWED TO THE SHOP AND TWO MECHANICS COULD FIND NOTHING WRONG. I HAD THE MASTER CYLINDER AND BOOSTER WAS CHANGED EVEN THOUGH I WAS ASSURED IT WAS FINE. THAT SEEMED TO HELP MY PEACE OF MIND FOR ABOUT A WEEK UNTIL I WAS STOPPED AT A LIGHT AND THE BRAKE PEDAL EASED DOWN TO THE FLOOR. I RAN AN INTERNET SEARCH TO SEE IF ANYONE ELSE HAS HAD THIS PROBLEM AND SURPRISED TO SEE IT SEEMS TO BE A COMMON PROBLEM WITH EXPLORER. I'M SURE EVERYONE WHO MENTIONED HAVING THIS PROBLEM HAS NOT REPORTED IT THAT SHOULD HAVE.

   NHTSA complaint 10704703
10. Filed Apr 8, 2015Failure Apr 16, 2011106,505 milesBrea, CABody

    THE DRIVER SIDE INTERIOR DOOR HANDLE RETURN SPRING UNSEATED RESULTING IN INTERIOR DOOR HANDLE THAT DOES NOT RETURN TO THE FULLY STOWED POSITION AFTER ACTUATION. IF THE INTERIOR DOOR HANDLE RETURN SPRING IS UNSEATED, COULD THE DOOR UNLATCH IN THE EVENT OF A SIDE IMPACT CRASH, INCREASING THE RISK OF PERSONAL INJURY? *TR

    NHTSA complaint 10704382
11. Filed Jun 30, 2014Failure Jun 25, 2014144,000 milesCarlsbad, CAElectrical system, Exterior lighting

    THE 1997 FORD EXPLORER 4D EDDIE BAUER EDITION HAS A COMPUTER CONTROLLED MESSAGE CENTER. THE MESSAGE CENTER CONTROLS AMONG OTHER THINGS THE VEHICLE HEADLIGHTS AND FOG LAMPS. THE LIGHT OUT MODULE (LOM) ALSO KNOWN AS THE INDICATOR WARNING SYSTEM CONTROL IS LOCATED INSIDE THE MESSAGE CENTER CONSOLE AND RUNS "HOT" IN TEMPERATURE BECAUSE OF A FLAWED DESIGN. THE CURRENT DESIGN LEADS TO INTERNAL ELECTRICAL SYSTEM FAILURES THAT RESULT IN A LOSS OF THE LOW BEAM HEADLIGHTS. THE SYSTEM IS DESIGNED TO NOTIFY THE DRIVER OF A HEADLIGHT OR LAMP FAILURE, ETC, HOWEVER, THE FAILURE OF THE NOTIFICATION SYSTEM CAUSES THE LOW BEAM HEADLIGHTS (AND FOG LAMPS AS THEY ARE ON THE SAME CIRCUIT) TO FAIL. ON JUNE 25, 2014, THE SECOND FAILURE OF THE SYSTEM OCCURRED (WE ARE THE ORIGINAL OWNERS AND HAVE PREVIOUSLY REPLACED THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM) AT GREAT EXPENSE). FORD MOTOR COMPANY MUST RECALL THE 1997 FORD EXPLORER EDDIE BAUER EDITION AND ANY OTHER LIKE DESIGNED FORD PRODUCT WITH A LIGHT OUT MODULE (LOM) THAT FAILS LEAVING THE DRIVER WITHOUT LOW BEAMS AND NO MEANS OF FIXING THE SAID DEFECT WITHOUT AN AUTHORIZED FORD DEALER'S REPAIR (AT GREAT EXPENSE) THAT IS LIFE THREATENING IN THE INTERIM. SUCH REPAIRS ARE NOT POSSIBLE IF ON AN EXTENDED TRIP IN RURAL SETTINGS. THE ABSENCE OF LOW BEAM HEADLIGHTS AFTER SUNSET AND BEFORE SUNRISE IS LIFE THREATENING AND UNACCEPTABLE TO THE OCCUPANTS OF A 1997 FORD EXPLORER AS WELL AS TO PEDESTRIANS AND OTHER VEHICLES WHO CANNOT SEE THE FORD EXPLORER OPERATING WITHOUT HEADLIGHTS. THE CORRECTIVE SOLUTION NEEDS A VENTING SYSTEM SUCH THAT THE MESSAGE CENTER DOES NOT CONTINUALLY MELT THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM). THANK YOU FOR YOUR SERVICE AND FOR YOUR PROMPT ATTENTION TO THIS DEFECT REQUIRING A CORRECTIVE RECALL. *TR

    NHTSA complaint 10607048
12. Filed Apr 24, 2014Failure Apr 16, 2014Flagstaff, AZTires

    ON 7/29/2013 WE PURCHASED A SET OF 4 KUMHO SOLUS KR21 TIRES. THE CAR IS USED PRIMARILY FOR HIGHWAY TRAVEL ? ONCE WEEKLY WORK COMMUTE AND FOR VACATION ROAD TRIPS. WE HAD NOT YET DRIVEN IT OFF PAVEMENT WITH THE NEW TIRES. ON 4/16/2014 I STARTED THE CAR TO GO TO WORK. I HEARD AN ODD NOISE FROM THE REAR PASSENGER SIDE, ALMOST LIKE A RHYTHMIC POPPING SOUND, BUT IT STOPPED, AND SINCE IT WASN'T IDENTIFIABLE I PROCEEDED TO LEAVE MY DRIVEWAY. ABOUT A BLOCK AWAY, I HEARD THE NOISE AGAIN, BUT AGAIN IT STOPPED. AT THIS POINT THE CAR WAS HANDLING FINE. AS SOON AS I GOT ON THE FREEWAY (APPROXIMATELY 2 MILES FROM MY HOUSE), I NOTICED I WAS HAVING TROUBLE ACCELERATING TO SPEED (65MPH). I ALSO BEGAN TO HEAR A RHYTHMIC BUMPING NOISE, SO BEGAN TO PULL OVER TO THE SHOULDER. BY THE TIME I GOT OVER, I COULD FEEL THE BUMPING AND KNEW I HAD A FLAT. THE REAR PASSENGER SIDE WHEEL HAD SUFFERED A COMPLETE SIDEWALL SEPARATION (SEE PHOTO). THE TIRES ONLY HAD 6,624 MILES ON THEM ? ALL PAVED ROAD, NO DIRT. THEY WERE SUPPOSEDLY WARRANTIED TO 85,000 MILES. IN RETROSPECT, I BELIEVE THE SOUNDS I HEARD IN MY DRIVEWAY WERE THE INITIAL SIDEWALL SEPARATION. THE SEPARATION DID NOT CAUSE IMMEDIATE LOSS OF AIR PRESSURE OR STRUCTURAL INTEGRITY; THAT ONLY HAPPENED ONCE I GOT ON THE HIGHWAY AND STARTED DRIVING AT 60MPH. THERE WAS NO EXPLOSIVE NOISE LIKE A BLOWOUT. IN SUBSEQUENTLY RESEARCHING KUMHO TIRES, I DISCOVERED THAT THIS BRAND HAS A LONG HISTORY WITH SUDDEN SIDEWALL SEPARATION AND/OR BLOWOUTS ? ALL AT LOW MILEAGES. THIS OCCURS ACROSS SEVERAL TIRE MODELS AND YEARS. THE COMPLAINTS WERE SO CONSISTENT THAT I WENT BACK TO THE TIRE DEALER AND REQUESTED A DIFFERENT BRAND. THEY REPLACED THEM AND I NOTIFIED THEM OF MY RESEARCH RESULTS. I AM VERY CONCERNED THAT KUMHO IS ALLOWED TO CONTINUE SELLING TIRES WITH SUCH A SAFETY RISK. I WAS VERY LUCKY THAT I DID NOT LOSE CONTROL AND THAT TRAFFIC AT THAT MOMENT WAS LIGHT. *TR

    NHTSA complaint 10584693
13. Filed Nov 4, 2013Failure Jun 10, 2010140,000 milesWrightwood, CAEquipment adaptive/mobility, Seat belts

    1997 FORD EXPLORER DRIVER'S SEAT BELT LATCH RECEIVER FAILURE. AFTER OWNING THE CAR FOR 12 TO 13 YEARS, THE LATCH/RECEIVER WOULD NOT ENGAGE THE STRAP. I REPLACED IT WITH ONE FROM A SALVAGE YARD AND AFTER THREE YEARS THIS REPLACEMENT LATCH/RECEIVER HAS FAILED ALSO. *TR

    NHTSA complaint 10550750
14. Filed Oct 20, 2013Failure Jul 11, 2013155,000 milesCheltenham, MDPower train

    THIS LETTER IS INTENDED TO ADDRESS INEFFECTIVE SERVICE BY AAMCO THAT LED TO FAILURE OF A TRANSMISSION IN MY VEHICLE. AS YOU SEE BY THE ATTACHED LETTER, I VOICED CONCERN ABOUT THIS LAST YEAR AND ALL AAMCO SUGGESTED WAS TO TAKE IT BACK TO THE DEALER THAT PERFORMED THE INEFFECTIVE SERVICE. I REQUESTED THE RIGHT TO TAKE THE VEHICLE TO ANOTHER AAMCO CENTER, BUT YOUR RESPONSE WAS TO TAKE IT TO THE CENTER THAT I ALREADY HAD DOUBTS ABOUT. LET ME SET THE SCENARIO AGAIN. ?WITH INITIAL GRINDING SOUNDS AND LACK OF REVERSE, I TOOK TO CLINTON TRANSMISSIONS IN 2011 AND THEY INFORMED ME THE TRANSMISSION NEEDED TO BE REBUILT. THE VEHICLE WAS PARKED UNTIL 2012. ?IN 2012, I CALLED THE WALDORF AAMCO CENTER AND THEY INFORMED ME IT MAY NOT BE THE TRANSMISSION AND TO LET THEM LOOK AT IT. IT WAS TOWED IN AND I WAS INFORMED THAT THE TRANSMISSION WAS FINE BUT THE TRANSFER CASE WAS BAD. ?ALL TOTALED, I PAID $1534.76 FOR TRANSFER CASE, $430.03 FOR PARTS, AND $600 FOR LABOR. THIS DOES NOT INCLUDE THE OTHER SERVICES THAT THE CENTER SAID I NEEDED. ?THE VEHICLE WAS TAKEN BACK TWICE FOR AN OD LIGHT THAT CAME ON AS SOON AS I LEFT THE CENTER. THEY SEEMED UNABLE TO DIAGNOSE THE PROBLEM. ?I FELT CONCERN FOR THE PERIOD I WAS DRIVING AND WROTE CORPORATE TO REQUEST ASSISTANCE. ?EARLIER THIS YEAR WHILE DRIVING TO SOUTH CAROLINA, THE GRINDING SOUND STARTED AGAIN AND REVERSE WENT OUT. I NOTIFIED CORPORATE AND THE WALDORF CENTER AND WAS TOLD TO GO TO THE NEAREST AAMCO. ?I WENT TO THE COLUMBIA, SOUTH CAROLINA AAMCO AND AFTER DIAGNOSTIC, TOLD ME THE SAME THING THAT THE CLINTON TRANSMISSION TOLD ME IN 2011. THE TRANSMISSION HAD INTERNAL DAMAGE AND NEEDED TO BE REBUILT. ?I LEFT THE VEHICLE IN COLUMBIA AND HAD TO PURCHASE A NEW VEHICLE. WITH THESE FACTS IN MIND, AAMCO CAN SURELY SEE WHERE INEFFECTIVE SERVICE LED TO A SAFETY FAILURE. *TR

    NHTSA complaint 10548626
15. Filed Oct 1, 2013Failure Oct 1, 2012170,000 milesBerrien Springs, MIWheels

    TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT STATED THAT THE RIMS WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

    NHTSA complaint 10546435
16. Filed Oct 1, 2013Failure Aug 1, 2013170,000 milesBerrien Springs, MITires

    TL* THE CONTACT OWNS A 1997 FORD EXPLORER WITH WINSTON WIN WINNER AT TIRES, SIZE: 255/70R16. THE CONTACT STATED THAT THE SIDE WALL OF THE FRONT PASSENGER'S SIDE WAS LEAKING AND THE OTHER THREE TIRES HAD DEVELOPED CRACKS THROUGHOUT THE TIRES. THE VEHICLE WAS NOT DIAGNOSED AND THE TIRES WERE REPLACED BY THE CONTACT. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE OF THE VEHICLE AND TIRES WAS 170,000. THE DOT NUMBER WAS NOT AVAILABLE.

    NHTSA complaint 10546433
17. Filed Sep 20, 2013Failure Sep 20, 2013215,000 milesHermigage, TNVehicle speed control

    TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ACCELERATOR PEDAL BECAME DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 215,000.

    NHTSA complaint 10544625
18. Filed Jun 28, 2013Failure Jul 24, 201269,600 milesWestland, MIElectrical systemFire

    APPROX. 2AM, THE VEHICLE CAUGHT ON FIRE. FIRE DEPT. REPORT CONFIRMED ELECTRICAL FIRE. *TR

    NHTSA complaint 10522315
19. Filed Jun 5, 2013Failure Jun 1, 2012180,000 milesST. George, UTExterior lighting, Body

    I OWN A FORD EXPLORER XLT 1997 AND THE REAR PASSENGER DOOR ON THE DRIVERS SIDE ONLY OPENS FROM THE INSIDE WHILE THE OTHER REAR PASSENGER DOOR WILL NOT OPEN FROM THE INSIDE OR OUT (CHILD LOCK NOT ACTIVATED). THE DRIVERS DOOR DOESN'T LOCK AND WHEN IT DOES LOCK, IT DOESN'T UNLOCK OR STICKS SO BAD IT HAS BE UNLOCKED WITH PLIERS, CAUSING THE DRIVER TO HAVE TO GET IN AND OUT OF THE CAR THROUGH THE FRONT PASSENGER SIDE DOOR. THE INTERIOR MAP LIGHT AND REAR INTERIOR DOOR LIGHT ABOVE THE BACKSEATS STAY ON CONSTANTLY EVEN WHEN SWITCHED OFF AND THE LIGHTBULBS HAD TO BE REMOVED BECAUSE THEY WOULDN'T TURN OFF AND WERE OVERHEATING. *TR

    NHTSA complaint 10515198
20. Filed Apr 12, 2013Failure Apr 1, 2013100,000 milesOnedia, TNVehicle speed control, Accelerator pedal

    TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH ON A STEEP UPHILL GRADE, THE BRACKET THAT SUPPORTED THE GAS PEDAL SUDDENLY BROKE AWAY FROM THE FIREWALL AND THE BRACKET AND GAS PEDAL SLID INTO THE FLOOR BOARD AND UNDER THE SEAT. THE VEHICLE WAS BACKED DOWN THE HILL IN NEUTRAL AND MANEUVERED TO THE SIDE OF THE ROAD IN LIGHT ONCOMING TRAFFIC. ASSISTANCE WAS SUMMONED AND UPON INSPECTION THE GAS PEDAL WAS FOUND WITH THE BRACKET THAT ATTACHED TO THE FIREWALL IN A NEW LIKE CONDITION, EXCEPT WHERE THREE SPOT WELDS ATTACHED TO THE GAS PEDAL BRACKET TO THE FIREWALL HAD BROKEN AWAY. THE VEHICLE WAS RIGGED TO A RUNNING CONDITION TO TRAVEL APPROXIMATELY TWO MILES OR LESS TO THE OWNERS RESIDENCE WHERE A MORE RELIABLE REPAIR WAS MADE. THE REPAIR WAS OVER SEEN BY A LICENSED A&P MECHANIC. THE MANUFACTURER WAS NOTIFIED BY THE OWNER OF THE WELD FAILURE. THE APPROXIMATE MILEAGE WAS WELL OVER 100,00 AND IS CURRENTLY BACK IN SERVICE. UPDATED 06/18/13*LJ

    NHTSA complaint 10508046