2012 Ford Explorer

829 complaints on file, page 1 of 42.

1. Filed Sep 30, 2026Failure Sep 12, 2026110,000 milesMiami Gardens, FLService brakes, Hydraulic, Steering

   The contact owns a 2012 Ford Explorer. The contact stated that while driving 50 MPH, the steering wheel seized. The contact pulled over to the side of the road, the vehicle was restarted; however, the failure persisted. The vehicle was towed to the residence, and an independent mechanic arrived to diagnose the vehicle. The contact was informed that the steering wheel had seized due to the electric power steering failure. The contact was informed that the electric power steering and ABS module needed to be replaced. The failure mileage was 110,000.

   NHTSA complaint 11768099
2. Filed Sep 29, 2026Failure Sep 25, 2026138,000 milesScottsboro, ALSteering

   The contact owns a 2012 Ford Explorer. The contact stated that while pulling out of the driveway, the power steering became inoperable, with the power steering fault message displayed. The contact stated that the steering wheel became difficult to turn while driving at slow speeds. The failure mileage was approximately 138,000.

   NHTSA complaint 11767698
3. Filed Sep 9, 2026Failure Aug 13, 2025100,000 milesClinton, MDStructure

   The contact owns a 2012 Ford Explorer. The contact stated that while driving 50 MPH, the driver's side and passenger's side exterior A-pillar trim detached. The contact used tape on the driver's side to secure the molding to the windshield. The contact stated that the passenger's side A-pillar trim detached and fell off the vehicle. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer and the vehicle was inspected. The contact was informed that parts were unavailable to repair the vehicle. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 100,000.

   NHTSA complaint 11763200
4. Filed Sep 2, 2026Failure Aug 14, 2026159,000 milesNational City, CAStructure

   The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The vehicle was taken to a local dealer, and it was realized that both front A-pillar trims were loose. The vehicle was repaired using duct tape as a temporary fix for both front A-pillar trims. The manufacturer was made aware of the failure by phone. The failure mileage was approximately 159,000.

   NHTSA complaint 11761657
5. Filed Aug 31, 2026Failure Jul 1, 2026197,000 milesBayonne, NJSteering

   The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed and making turns, the steering wheel made loud grinding sounds and was loose. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 197,000.

   NHTSA complaint 11760880
6. Filed Aug 26, 2026Failure Dec 31, 1969Thornton, ILUnknown or other

   It is actually the rearview camera on the vehicle has been going in and out sporadically for at least a year or so. Now more often than not it does not even work

   NHTSA complaint 11759654
7. Filed Aug 26, 2026Failure Dec 31, 1969Thornton, ILUnknown or other

   Right after I bought this car used, it rides down the road like it's going to fall apart! It's horrible, the slightest little bump in the road you can feel every single one heaven forbid if it's a big bump in the road or a pothole it's priced the car hasn't fallen apart yet

   NHTSA complaint 11759651
8. Filed Jul 21, 2026Failure Jul 20, 2026Wooster, OHSteering

   Loss of power steering assist . Yes it is available for inspection on request. I can't steer it . It has not been confirmed by anybody yet. It has not been inspected by anybody yet. There are no warning lights on dash .

   NHTSA complaint 11751715
9. Filed Jul 10, 2026Failure Feb 1, 202480,000 milesTompkinsville, KYStructure

   The contact owns a 2012 Ford Explorer. The contact received notification for NHTSA Campaign Number: 24V031000 (Structure); however, the part to complete the recall repair was unavailable. The contact stated that while driving at 65 MPH on a bypass, the A-pillar exterior trim detached. The owner applied duct tape to the front windshield out of concern that the front windshield would detach. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted, and confirmed that the parts were backordered. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

   NHTSA complaint 11749525
10. Filed Jun 26, 2026Failure Jun 25, 2026237,000 milesChicago, ILBack over prevention, Steering

    The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 15 MPH, the "Service Power Steering" message was displayed. The contact pulled into a parking lot, turned off and then restarted the vehicle. The failure persisted, and the power steering feature failed to operate as needed. While in reverse, the back over prevention camera display the "Service Camera - Take to Dealer" message on the screen. The dealer was contacted and confirmed that there was a recall for the failure, NHTSA Campaign Number: 14V286000 (Steering); however, the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 237,000.

    NHTSA complaint 11746616
11. Filed Jun 23, 2026Failure Jan 1, 2024Lancaster, NYBody

    Failure of the dealerships to fix recall in timely manner It’s been over two years and parts still unavailable

    NHTSA complaint 11745848
12. Filed Jun 10, 2026Failure Jan 19, 2024Middletown, OHStructure

    The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part required for the recall repair was unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was unavailable. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

    NHTSA complaint 11743199
13. Filed May 18, 2026Failure Aug 7, 2025Hanover, VABody

    I received the first recall notice for this defect from Ford Motor Co. in February 2024 and took the vehicle to Sheehy Ford in Ashland, Virginia on August 7, 2025. Sheehy Ford did the required inspection and confirmed that the vehicle had defective windshield rubber molding. The inspection required that the plastic body molding on both sides of the windshield be removed, which rendered them unusable and could not be replaced. Sheehy Ford said they had ordered the necessary replacement parts from Ford Motor Co. and would notify me when they were received. I have been following up with Sheehy Ford every couple of months since August 2025 and they say the replacement parts are still not available from Ford Motor Co. It seems to me that 9 months is an unreasonable amount of time to provide the necessary parts for this Safety Recall, especially missing the plastic windshield moldings, my car is unsellable, which I would like to do.

    NHTSA complaint 11738521
14. Filed May 13, 2026Failure May 10, 2026200,063 milesMilwaukee, WISteering

    The contact owns a 2012 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The failed power steering warning light illuminated. In addition, the steering wheel seized. The vehicle was taken to an independent mechanic, however the failure was not diagnosed. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall which had a similar failure description, however the contact's VIN was not associated. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,063.

    NHTSA complaint 11737559
15. Filed Apr 29, 2026Failure Apr 21, 2026208,974 milesPerryville, MOBack over prevention, Hazard flashing warning lights

    The contact owns a 2012 Ford Explorer. The contact stated that the hazard lights and other surrounding indicator systems were inoperable. Additionally, the rearview camera displayed a blank image while reversing. The dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 208,974.

    NHTSA complaint 11734667
16. Filed Apr 21, 2026Failure Apr 21, 2026Irmo, SCSteering, Unknown or other

    Hi! I brought my car in to the Ford dealership in Lexington, SC to get a recalled A Frame Pillar repaired. They took the part off and didn’t repair it because they didn’t have the parts in. When I called corporate to check on the status of that part, I found out they had marked the recall as “complete” which was not the case. Corporate opened the case again for me, so it should’ve read incomplete in their system. (Therefore, maybe they would call me to let me know the part was in stock. That didn’t happen.) When I called back 2 months later, they had apparently marked it as complete a second time. Which again, was false. 12 months later, they’re finally agreeing to replace the part. I also found out from corporate in that same phone call that I had a recall to a power steering component. When I called the shop, they said that had been marked as complete too so I was not eligible for a second replacement. I have a hard time trusting that the original was actually replaced now. And the steering feels like a major safety concern! Point is, I’m worried that location may be doctoring their documentation, marking recalls as repaired when repairs have clearly not been made. I’d hate for it to cause a major accident or something. Bringing this up in case it warrants an audit. I’m sure I’m not the only person they’ve done this to. I’ve opened a case with Ford’s Automatice Safety Office as well and they are investigating but I thought it prudent to mention to an outside source. Like I said, I’d hate for someone to get in accident because they thought a repair had been made when it actually never was.

    NHTSA complaint 11732810
17. Filed Apr 21, 2026Failure Apr 16, 2026155,500 milesColumbia, MOStructure

    The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed on the highway, the driver's side A-pillar trim clip became partially detached on the side of the windshield. The dealer was notified of the failure, but the vehicle was not repaired. The manufacturer was notified of the failure. The contact associated the failure with NHTSA Campaign Number: 24V031000 (Structure); however, the vehicle was previously repaired under the recall. The approximate failure mileage was 155,500.

    NHTSA complaint 11732733
18. Filed Apr 13, 2026Failure Apr 12, 2026Fort Lauderdale, FLSteering

    My car gave a “power steering fault” message on the dash while my son was driving on I-95 on April 12. The steering wheel locked up making turning impossible and could have been fatal. He had pull over and have the vehicle towed home.

    NHTSA complaint 11730731
19. Filed Apr 7, 2026Failure Apr 1, 2025Carriere, MSSteering

    The steering went out on the car and I was unable to steer. Almost causing me to have a accident. I had to have a tow truck come and pick it up off the road. Thank God I was alone and my whole family was not in the car. There needs to be a recall on this there has already been so many accidents. If it has not already happen there is going to end up causing a fatality. What is it going to take a child to loose their life before Ford does something about this?? WAKE UP FORD THIS IS CRAZY!!! Really 2 questions down you ask if there was a accident or fatality? Don't wait till someone's child or grand baby dies! It not a matter of if it is a matter of when! I have seen so many people saying online saying they have had the same problem. This is scary! I thank God daily I did not crash or even worse crash and Kill another person or an innocent baby! I can get photos and tow bill but I didn't have it handy.

    NHTSA complaint 11729579
20. Filed Feb 20, 2026Failure Feb 1, 2024Newport News, VAUnknown or other

    Recall 24V031 has not been fixed. I got my recall notice from Ford with regards to the A-pillar applique trim. I received my recall in February, 24. I have visited my local Ford dealer several times and as recently as 1 month ago. They state the parts are not available. My driver side A-pillar applique is missing. My passenger side applique is loose. Why are parts not available? After 2 years of recall notice!!

    NHTSA complaint 11719326