2011 Ford F-250 SD

122 complaints on file, page 1 of 7.

1. Filed Jun 26, 2019Failure Jun 22, 2019100,000 milesPerdido, ALSteering, Suspension

   I WAS TRAVELLING DOWN THE INTERSTATE AT APPROXIMATELY 72MPH AND THE VEHICLE STARTED SHAKING VIOLENT AND I ALMOST LOST CONTROL. MY WIFE DROVE IT AND I WAS BESIDE HER ON THE INTERSTATE AND IT HAPPENED TO HER ALMOST CAUSING HER TO WRECK THE VEHICLE. I HAD TO CALL HER TO CALM HER DOWN. PLEASE HELP FIX THIS PROBLEM BEFORE SOMEONE GETS KILLED.

   NHTSA complaint 11222820
2. Filed May 25, 2019Failure May 25, 2019132,214 milesBrownstown, ILFuel/propulsion system

   THE FUEL RAIL PRESSURE SENSOR STARTED SPRAYING DIESEL FUEL ALL OVER THE TOP OF THE MOTOR . THE FUEL IS COMING OUT OF THE TOP OF THE SENSOR .THIS IS ON 05/25/19 .. THIS TRUCK ONLY HAS 132214 ON THE MILEAGE . I AM GETTING TIRED OF PAYING FOR A BROKEN TRUCK EVERY WEEK . LAST WEEK ON 05/05/17/19 THE INNER COOLER BOOT DUCT BLEW APART . THAT WAS A $480 FIX .

   NHTSA complaint 11209949
3. Filed Apr 29, 2019Failure Dec 4, 201845,423 milesEaston, PASuspension

   TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE 'DEATH WOBBLE' WHEN DRIVING HIGHWAY SPEEDS AND OVER UNLEVELED LAND. THE VEHICLE WAS UNSAFE TO DRIVE OVER 35 MPH DUE TO THE VIOLENT SHAKING AND VIBRATION. AN INDEPENDENT MECHANIC DIAGNOSED THE FAILURE AS THE 'DEATH WOBBLE' AND REPLACED THE TRACT BAR, BALL JOINTS, STEERING STABILIZER, STEERING DAMPER, AND PERFORMED AN ALIGNMENT; HOWEVER, THE FAILURES CONTINUED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,423.

   NHTSA complaint 11204371
4. Filed Apr 28, 2019Failure Apr 28, 2019Anchorage, AKSteering, Suspension, WheelsCrash2 injured1 killed

   TRUCK CONTINUES TO HAVE THE DEATH WOBBLE AS I DRIVE AT HIGHWAY SPEEDS AND HIT A SMALL PORTHOLE OR BUMP IN THE ROAD. THE WOBBLE BECOMES SO SEVERE THAT I HAVE LITTLE TO NO CONTROL OVER THE TRUCK. THIS HAS BEEN GOING ON AFTER 6MONTHS FROM PURCHASE DATE (NEW) BUT FORD SAYS THEY CAN NOT DUPLICATE. IT HAPPENS ABOUT 1-5X A WEEK AND I'VE NEARLY HIT SEVERAL OTHER VEHICLES ON THE HIGHWAY EACH TIME BY SWIRLING DURING THE WOBBLE. I LOOSE DIRECTIONAL CONTROL. I HAVE HAD A CRASH AS A RESULT OF THIS.

   NHTSA complaint 11204247
5. Filed Jan 21, 2019Failure Jul 8, 201869,000 milesWalnut Creek, CASteering

   EXTREME SHAKING OF THE STEERING WHEEL WHEN ENCOUNTERING A SHIFT IN ROAD SURFACE SUCH AS AN EXPANSION JOINT, ETC AT AROUND 55 MPH AND TURNING SLIGHTLY LEFT. THIS HAS OCCURRED ON FREEWAYS, HIGHWAYS AND ROADS. LINK TO VIDEO: HTTPS://WWW.YOUTUBE.COM/WATCH?V=UVTUQV60JNU

   NHTSA complaint 11171153
6. Filed Nov 8, 2018Failure Oct 31, 201858,000 milesDayton, OHSteering, Suspension

   TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING OVER UNEVEN LAND AND BUMPS IN THE ROAD, THE VEHICLE SHOOK VIOLENTLY. ALSO, THE STEERING WHEEL VIBRATED AND THERE WAS A STRONG VIBRATION FELT IN THE FRONT OF THE VEHICLE WHILE DRIVING HIGHWAY SPEEDS. GERMAIN FORD OF BEAVERCREEK (2356 HELLER DR, DAYTON, OH 45434, 1-(937) 429-1300) WAS NOTIFIED OF THE FAILURE AND COULD NOT DETERMINE THE CAUSE OF THE FAILURE WITHOUT GUIDELINES FROM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

   NHTSA complaint 11150119
7. Filed Oct 12, 2018Failure Oct 1, 201874,000 milesSAN Antonio, TXTires

   MICHELIN LTX MS/S2 275/70 R18 TIRE WITH LESS THAN 25K HAD TO BE REPLACED BECAUSE OF TREAD SEPARATION. WHILE AT DISCOUNT TIRE, SPOKE WITH ANOTHER CUSTOMER WITH SAME VEHICLE - 2012 INSTEAD OF 2011 F-250 WHO HAD 3 TIRES WITH TREAD SEPARATION ISSUES.

   NHTSA complaint 11139904
8. Filed Apr 23, 2018Failure Apr 23, 2018Martinsville, VAWheels

   MY FORD WAS PURCHASED AS A ONE OWNER TRUCK WITH 44,000 MILES FROM A DEALERSHIP IN FLORIDA. OWNED BY A PERSON BRAND NEW ALSO IN FLORIDA. I LIVE IN SOUTH WESTERN VA PLEASE TAKE A LOOK AT MY BRAKE CALIPERS. I NEVER SEEN ANYTHING LIKE THIS. HUGE DANGER ESPECIALLY WHEN THIS TRUCK IS MADE TO PULL HEAVY WEIGHT THAT NEEDS GOOD BRAKES. MY TRUCK HAS 107,000 MILES FOUND OUT BY REPLACING BRAKE PADS FOR SECOND TIME

   NHTSA complaint 11089575
9. Filed Apr 5, 2018Failure Apr 2, 201420,000 milesAuburn, WABody

   EXHAUST BEING DRAWN INTO CABIN BY VENTILATION SYSTEM WHEN STOPPED.

   NHTSA complaint 11083355
10. Filed Jan 22, 2018Failure Jan 21, 2018100,000 milesAnchorage, AKSuspension

    FROM DAY 1 I HAVE HAD ISSUES WHERE THE FRONT END WOULD BOUNCE UNCONTROLLABLY AT HIGHWAY SPEEDS AFTER HITTING A POTHOLE OR BRIDGE EXPANSION JOINT. IT'S GETTING WORSE. THE DEALERSHIP CANNNOT FIND ANY PROBLEMS. THEY TOLD ME AT ONE TIME TO REPLACE MY TIRES BUT THAT DID NOT FIX THE ISSUE. I ALMOST RAN OFF THE ROAD 4 TIMES IN ONE TRIP BECAUSE OF THIS AS I COULD NOT MAINTAIN CONTROL. THIS WILL KILL SOMEONE IF NOT RESEARCHED AND CORRECTED BY FORD.

    NHTSA complaint 11064272
11. Filed Dec 12, 2017Failure Dec 9, 201780 milesGillette, WYEngine

    WHILE DRIVING AT A SPEED OF 50 MILES PER HOUR THE TRUCK STARTED LOSING POWER, WAS ABLE TO GET TO SIDE OF THE HIGHWAY AS IT LOST ALL POWER AND SHUT DOWN WAS UNABLE TO RESTART TRUCK. GOT TRUCK TOWED HOME AND WENT CHECKING THE MOTOR AND THE ANTIFREEZE WAS COMPLETELY DRY BUT NO LEAKING UNDER MOTOR AND NO WARNINGS OF LIGHTS FLASHED WHEN TRUCK SHUT DOWN.. TRUCK IS SERVICED EVERY 3 MONTHS AND CHECKED AT HOME REGULARLY. TRUCK WAS LOOKED AT BY A ASE MECHANIC AND THE MOTOR SEIZED

    NHTSA complaint 11054132
12. Filed Sep 6, 2017Failure Aug 8, 2017133,000 milesHarlingen, TXBody

    TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT HEARD AN ABNORMAL RATTLING NOISE COMING FROM THE VEHICLE WITHOUT WARNING. THE CONTACT OBSERVED UNDER THE VEHICLE THAT THERE WAS MULTIPLE RUBBER MOUNTING PIECES THAT WERE MISSING OR DETACHED DUE TO DETERIORATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (BOGGUS FORD MCALLEN, 1400 E EXPY 83, MCALLEN, TX) WHERE IT WAS DIAGNOSED AND CONFIRMED THAT THE RUBBER MOUNTS FAILED AND/OR WERE MISSING, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WAS NO RECALL AT THE TIME AND NO ADDITIONAL ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS APPROXIMATELY 133,000. .. .UPDATED 10/04/17 *BF *TT

    NHTSA complaint 11021802
13. Filed Jul 17, 2017Failure Jul 7, 201779,530 milesLerona, WVEngine, Fuel/propulsion system

    7/7/17 - 2011 FORD F250, 6.7L DIESEL ENGINE, MILEAGE 79530. (PURCHASED DECEMBER 2010). I WAS PULLING A SMALL TRAILER UP AN INCLINE (8%) ON I-64 IN WV. ON THIS PORTION OF THE INTERSTATE THERE WAS NO EMERGENCY PULL OFF SHOULDER. THE TRUCK OPERATED NORMALLY FOR THE FIRST 3 MILES ASCENDING THE HILL. DURING THE 4TH MILE, THE TRUCK BEGAN TO GRADUALLY, BUT PROGRESSIVELY LOSE POWER, GOING FROM 70 MPH DOWN TO 0. AT APPROXIMATELY 30 MPH, THE TRUCK BEGAN TO SHUTTER SLIGHTLY, AND CONTINUED TO DO SO UNTIL IT STOPPED IN THE LANE OF TRAFFIC AND STALLED. THERE WERE NO WARNING LAMPS OR CHIMES THAT WENT OFF BEFORE THE ENGINE STALLED. THIS VEHICLE IS EQUIPPED WITH A 'STOP SAFELY NOW' WARNING, ALONG WITH MANY OTHER WARNING INDICATORS ' BUT IT DIDN'T ILLUMINATE. THE TRUCK WOULD NOT RESTART. I IMMEDIATELY CALL 911 TO REPORT THAT MY VEHICLE WAS DISABLED IN THE ROADWAY. AFTER BEING STUCK IN THE LANE OF TRAFFIC FOR ABOUT 10 MINUTES, I WAS ABLE TO DRIFT THE TRUCK AND THE TRAILER BACKWARDS SAFELY, OFF OF THE ROADWAY, INTO THE DRAINAGE DITCH, AFTER A BREAK IN TRAFFIC. UPON HAVING IT TOWED TO A FORD DEALERSHIP, I WAS INFORMED THAT IT WAS GOING TO NEED A MOTOR, AND IT SOUNDED LIKE IT HAD SPUN THE BEARINGS ON ONE OF THE ENGINE RODS. THE ENGINE WOULD RESTART AT THE FORD DEALERSHIP, BUT IDLED VERY ROUGH. I CONFIRMED THAT THERE WERE IN FACT METAL SHAVINGS IN THE OIL. THE FUEL WAS NOT CHECKED FOR CONTAMINATION. THIS VEHICLE HAS BEEN MAINTAINED ACCORDING TO FORD'S RECOMMENDED SERVICE GUIDELINES. BECAUSE OF THE COST TO ME TO REPAIR ($16,000 OR MORE), I'VE ELECTED NOT TO CONTINUE WITH DIAGNOSIS (AT $120 PER HOUR) TO DETERMINE REASON FOR FAILURE. AGAIN, THERE WAS NO WARNING SYSTEMS ACTIVE AT THE TIME THE ENGINE STALLED. THIS WAS AN ORIGINAL OWNER, PERSONAL VEHICLE, AND ONLY TOWED A TRAILER ON OCCASION. I HAVE VIDEO FROM DASH CAM W/AUDIO OF THIS EVENT.

    NHTSA complaint 11005821
14. Filed Jun 29, 2017Failure Jun 15, 201786,000 milesSO Casco, MEFuel/propulsion system

    2011 FORD SUPER [XXX], 6.7L FIRE HAZARD, FUEL INJECTOR HOLD DOWN FAILURE WHILE IDLING IN YARD, SPRAYING FUEL ALL OVER PLACE, TOWED TO DEALER, RECOMMENDS REPLACING ALL HOLD DOWNS DO TO FAULTY PART. TSP ON IT.. 1600.00 NOT COVERED UNDER WARRANTY 86,000 MILES. FIRE HAZARD. GLAD I'M NOT THE ONE THAT'S GOING TO BURN IN THE SUPER [XXX] TRUCK RECOMMEND YOU HAVE FORD RECALL ALL 2011 6.7 LITERS TO REPLACE THE DEFECTIVE PARTS. SELL FORD STOCK. FIRE PROFESSOR AND ENGINEERING STUDENTS. COME ON PEOPLE REALLY!!!!!!!!!!!!!!!!!!!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

    NHTSA complaint 11002411
15. Filed Jan 16, 2017Failure Jan 13, 201765,000 milesBaton Rouge, LASteering, Suspension, Wheels

    FOR THE PAST 3-4 YEARS MY TRUCK HAS EXPERIENCED THE "DEATH WOBBLE." WHEN DRIVING (STRAIGHT OR IN SLIGHT TURN) APPROXIMATELY 55 MPH OR HIGHER AND HITTING A TYPICAL BUMP IN THE ROAD, MY TRUCK BEGINS A VIOLENT SHAKING THAT STOPS WHEN I REDUCE THE SPEED ENOUGH TO REGAIN CONTROL. I HAVE ATTEMPTED REPAIRS AT TWO LOCAL FORD DEALERSHIPS AS WELL AS A LOCAL REPAIR SHOP, BUT NOTHING DONE HAS CORRECTED THE ISSUE. *TR

    NHTSA complaint 10945494
16. Filed Dec 9, 2016Failure Apr 16, 201565,000 milesRedway, CAElectrical system, Engine

    TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING, THE "PULL OVER SAFELY NOW" WARNING INDICATOR ILLUMINATED AND THE ENGINE SHUT OFF WITHOUT WARNING. THE CONTACT WAS ABLE TO MANUALLY BYPASS THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE EGT SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

    NHTSA complaint 10934147
17. Filed Dec 2, 2016Failure Aug 5, 2016200,000 milesSouth Haven, MISuspension

    TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS OVER A BUMP IN THE ROAD, THE FRONT END OF THE VEHICLE WOBBLED VERY VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER ON NUMEROUS OCCASIONS FOR A DIAGNOSTIC TESTING AND REPAIR. THE CONTACT STATED THAT THE BALL JOINTS, SHOCK ABSORBERS, AND OTHER UNKNOWN COMPONENTS WERE REPLACED OR REPAIRED BY THE DEALER, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

    NHTSA complaint 10929658
18. Filed Dec 1, 2016Failure Oct 1, 201690,000 milesRose, OKSuspension

    TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOBBLED UNCONTROLLABLY. THE BRAKE PEDAL HAD TO BE DEPRESSED AND THE VEHICLE HAD TO ALMOST COME TO A COMPLETE STOP TO KEEP IT FROM WOBBLING. THE DEALER CONFIRMED THAT THERE WAS A WOBBLE IN THE FRONT END OF THE VEHICLE AND THAT A WOBBLE BAR WOULD NEED TO BE PLACED ON THE VEHICLE; HOWEVER, THERE WAS NO GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 01/26/17*LJ UPDATED 7/12/18*JB *TR

    NHTSA complaint 10928968
19. Filed Oct 27, 2016Failure Jul 23, 20116 milesMarietta, GALabels

    I PURCHASED A NEW DIESEL 2011 F-250 LARIAT 4X4 CREW CAB 172' WB. I BOUGHT THE TRUCK BASED ON THE CHARTS IN A FORD BROCHURE. ACCORDING TO THE PAYLOAD CHART ON PAGE 39 OF THE BROCHURE, THE PAYLOAD FOR MY TRUCK SHOULD HAVE BEEN 2,210 LBS. ACCORDING TO THE TOWING CHART, THE PAYLOAD FOR MY TRUCK SHOULD HAVE BEEN 15% OF 15,700 LBS., WHICH IS 2,355 LBS. I DID NOT DISCOVER THE DISCREPANCY BETWEEN FORD'S PUBLISHED RATINGS AND THE ACTUAL CAPACITY OF THE TRUCK AT THE TIME OF PURCHASE BECAUSE THERE WERE NO FOOT NOTES IN THE PRINTED BROCHURE INDICATING THE PUBLISHED RATINGS WOULD NOT APPLY TO MY TRUCK AND BECAUSE OF WHERE FORD PLACED THE TIRE AND LOADING INFORMATION LABEL. ACCORDING TO THE NHTSA, FOR 'VEHICLES OTHER THAN MOTORCYCLES OR TRAILERS, THE LABEL MUST BE AFFIXED TO EITHER THE HINGE PILLAR, DOOR-LATCH POST, OR THE DOOR EDGE THAT MEETS THE DOOR-LATCH POST, NEXT TO THE DRIVER'S SEATING POSITION.' FORD PLACED THE LABEL ON THE BODY BELOW THE B PILLAR AND FACING DOWN. THE LABEL COULD NOT BE READ WHEN ENTERING THE VEHICLE AND COULD ONLY BE READ BY SITTING OR KNEELING ON THE GROUND. I DISCOVERED A JULY 30, 2014 ARTICLE IN AUTOMOTIVE NEWS THAT REVEALED STANDARD EQUIPMENT PARTS WERE REMOVED FROM SUPER DUTY TRUCKS BEGINNING WITH THE 2011 MODEL YEAR WHEN DETERMINING THE MAXIMUM PAYLOAD. THE PARTS INCLUDED, BUT WERE NOT LIMITED TO, THE SPARE TIRE, TIRE JACK, RADIO, AND CENTER CONSOLE. THE FORD BROCHURE DID NOT INDICATE THAT THE RATINGS WERE ESTABLISHED BY REMOVING STANDARD EQUIPMENT. WHEN I CONTACTED FORD ABOUT THE ISSUE, I WAS TOLD THAT THE DISCREPANCY BETWEEN THE PUBLISHED RATINGS AND MY TRUCK'S ACTUAL PAYLOAD WAS DUE TO 'OPTIONS.' FORD'S BROCHURE NEITHER FOOT NOTED THE RATINGS CHARTS NOR DISCLOSED THAT FORD HAD REMOVED STANDARD EQUIPMENT TO ESTABLISH THE RATINGS IN THE CHARTS. *TR *TR

    NHTSA complaint 10919659
20. Filed Oct 21, 2016Failure Oct 21, 201632,000 milesKeyport, WASuspension

    WHEN TRAVELLING 45-50 MPH TWICE MY TRUCK HAS EXPERIENCED THE DEATH WOBBLE. NOW AT SPEEDS AT 62 MPH OR GREATER THE WHEELS SHIMMY BACK AND FORTH CAUSING THE STEERING WHEEL TO MOVE BACK AND FORTH ABOUT 4". IT GETS CRAZIER IF I HIT A BUMP. THIS MAKES FOR A SCARY RIDE. IT ONLY HAS 35K MILES ON IT. IT IS COMPLETELY STOCK

    NHTSA complaint 10917909