2000 Ford F-350 SD

157 complaints on file, page 1 of 8.

1. Filed Nov 6, 2016Failure Oct 14, 2016107,000 milesGibsonburg, OHPower train

   MANUAL TRANSMISSION KEEPING HANGING UP AND IS HARD SHIFTING INTO GEARS

   NHTSA complaint 10924549
2. Filed Mar 28, 2016Failure Nov 10, 2015102,000 milesHillsboro, WVFuel/propulsion system

   TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT LOCATED UNDER THE FUEL FILTER, THE O-RING AND THE DRAIN LINE FAILED ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN TWICE AND THEY WERE NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE DRAIN LINE AND INDICATED THAT THERE WAS TOO MUCH PRESSURE FLOWING INTO THE FUEL FILTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. UPDATED 05/10/16*LJ UPDATED 11/3/2017*JS

   NHTSA complaint 10851896
3. Filed Oct 22, 2015Failure Oct 1, 2015Dothan, ALTires

   FORD F-350. CONSUMER WRITES IN REGARDS TO VEHICLE TIRE INFLATION PRESSURE PROBLEMS. *SMD THE CONSUMER STATED THE TIRE WAS INFLATED TO 55 PSI TO SOFTEN THE RIDE. LATER, WHILE HAULING TRACTOR THE TREAD ON ONE OF THE TIRES PEELED OFF. THE CONSUMER PUT THE SPARE ON THE TRUCK. THE CONSUMER WAS ADVISED TO RUN THE TIRES AT THE MAXIMUM INFLATION PRESSURE FOR THE BEST WEAR, MAXIMUM LOAD CAPACITY, BEST MILEAGE AND LONGEST LIFE. EACH OF THE TIRES EVENTUALLY FAILED ONE AT A TIME. WHEN THE CONSUMER PURCHASED NEW TIRES, THEY WERE INFLATED 60 PSI FOR THE FRONT AND 50 PSI FOR THE REAR, INSTEAD OF 80 PSI. EVERYTHING WAS FINE FOR A WHILE, UNTIL THE CONSUMER STARTED TO EXPERIENCE ROUGH RIDING AND NOISY TIRES AS A RESULT OF IMPROPER INFLATION. THE RETAILER STATED THE INFLATED THE TIRES ACCORDING TO WHAT WAS PRINTED ON THE DOOR STICKER. THE UNDER INFLATION CAUSED EXCESSIVE SIDEWALL FLEX, REDUCED MILEAGE, SHORTENED LIFE AND SEVERAL TIRE FAILURES. *JB *CN

   NHTSA complaint 10806829
4. Filed Sep 4, 2015Failure Feb 12, 2015156,300 milesLivingston, TXWheels

   AS WE WERE RETURNING HOME FROM A ROAD TRIP, WE HEARD A SCREECHING NOISE COMING FROM THE LEFT WHEEL WELL AREA WHEN WE MADE WIDE SWEEPING TURNS AND HIGHWAY CURVES. WE PULLED OVER AND, UPON INSPECTION, SAW OUR ORIGINAL ALLOY WHEEL ON OUR TRUCK WAS CRACKED. ONE OF THE WHEELS WAS DANGEROUSLY CLOSE TO COMING OFF THE HUB. PHOTOS DOCUMENT HOW SEVERE THE CRACKING OF THE WHEELS WAS - THREE OF FOUR WHEELS WERE FOUND TO HAVE CRACKS AND CHUCKS OF METAL MISSING,COMPROMISING THE INTEGRITY OF THE WHEELS AND THE SAFETY OF OUR VEHICLE. WE HAD TO PURCHASE NEW WHEELS AT A COST OF ALMOST $1,300.

   NHTSA complaint 10761675
5. Filed Jun 16, 2014Failure Jun 16, 2011130,000 milesST Louis, MOFuel/propulsion system

   TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE STALLED ALTHOUGH THE FUEL LEVEL WAS AT CAPACITY. THE CONTACT TOOK HIS VEHICLE TO AN INDEPENDENT MECHANIC AND THE DEALER WHO BOTH STATED THAT HAVING LESS THEN 5% BIO DIESEL WOULD CAUSE THE FAILURE TO OCCUR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 130,000. THE CURRENT MILEAGE WAS 200,000.

   NHTSA complaint 10598654
6. Filed Dec 11, 2013Failure Jun 4, 2013160,000 milesEllington, CTVehicle speed control

   TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE WIRES THAT WERE CONNECTED TO THE MASTER CYLINDER AND ONTO THE ELECTRICAL CONNECTOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 160,000.

   NHTSA complaint 10555724
7. Filed Jun 29, 2013Failure Jun 27, 2013247,560 milesNicollet, MNPower trainFire

   DRIVING DOWN THE ROAD THE OTHER DAY IN ARE 2000 F-350 7.3 DIESEL REG CAB CHASSIS TRUCK PULLING 25,000 LB GOOSENECK TRAILER WAS DIS ENGAGING THE CLUTCH WHEN THE CLUTCH ASSEMBLY BROKE THE BUSHINGS WENT OUT AND BROKE LEAVING THE CLUTCH USELESS DRIVING IN BUSY TRAFFIC CLUTCH STAYED STICKING CAUSED A FIRE UNDER VEHICLE. *TR

   NHTSA complaint 10522341
8. Filed Jun 25, 2013Failure Apr 19, 2013175,000 milesRoberts, ILFuel system, Gasoline

   I WAS TRAVELING DOWN THE HIGHWAY AT 60 MILES PER HOUR WHEN I HEARD A LARGE BANG. I STOPPED AND DIDN'T SEE ANYTHING UNTIL I STOPPED FOR GAS. GAS WAS LEAKING OUT THE FILL HOSE AND I LOOKED UNDER THE TRUCK AND THE GAS TANK STRAP HAD BROKE AND THE TANK WAS VERILY HANGING ON. I PURCHASED TWO STRAPS TO HOLD THE TANK IN PLACE UNTIL I COULD GET TO A FORD DEALERSHIP. THIS IS THE SAME PROBLEM THAT FORD RECALLED THE 150 AND 250 MODELS FOR. LUCKILY FOR ME THE TANK DID NOT RUPTURE AND CATCH FIRE. THE 350 NEEDS TO BE RECALLED TO FIX THIS PROBLEM BEFORE SOMEONE IS KILLED. *TR

   NHTSA complaint 10521716
9. Filed Jun 18, 2013Failure Jan 14, 201386,000 milesKernersville, NCEngine, Fuel system, Diesel

   THIS ISSUE WAS ON A 2000 FORD F350 RESCUE TRUCK ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO GARAGE IN KING NC AND $900.00 LATER AFTER NEW FUEL TANK FUEL FILTER AND FUEL PUMP TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

   NHTSA complaint 10520505
10. Filed Jun 18, 2013Failure Jun 8, 2013160,000 milesKernersville, NCEngine, Fuel system, Diesel

    THIS ISSUE WAS ON A 2000 FORD F350 AMBULANCE ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO TABS GARAGE IN KING NC AND $1700.00 LATER AFTER NEW FUEL TANK FUEL PUMP 3 INJECTORS DUE TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

    NHTSA complaint 10520498
11. Filed Oct 25, 2012Failure Oct 24, 2012253,000 milesTrevose, PASteeringCrash

    TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH AND MAKING A RIGHT HAND TURN, HE LOST CONTROL OF THE VEHICLE CAUSING HIM TO CRASH INTO SOMEONE'S MAILBOX. THE CONTACT STATED THAT THE POWER STEERING BECAME EXTREMELY LOOSE AND THE BRAKES ALSO FAILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS LATER TOWED HOME. THE TOW TRUCK DRIVER INFORMED THE CONTACT THAT THE POWER STEERING HOSE LOOKS AS IF IT FRACTURED, WHICH MAY HAVE POSSIBLY CAUSED THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 253,000.

    NHTSA complaint 10482170
12. Filed Jun 19, 2012Failure Apr 15, 2012237,000 milesOneco, FLBody

    TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT ATTEMPTED TO OPEN THE REAR DRIVER AND PASSENGER SIDE DOORS BUT NOTICED THAT THE TOP DOOR LATCH WOULD NOT RELEASE. THE BOTTOM LATCH RELEASED WITHOUT FAILURE. THE CONTACT WAS UNABLE TO OPEN THE REAR DOORS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN ADVISED THAT THE DOOR ASSEMBLY WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 237,000.

    NHTSA complaint 10462300
13. Filed Jun 18, 2012Failure Jun 17, 2012224,430 milesGreensboro, SCWheels

    TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT THE FRONT PASSENGER WHEEL WAS CRACKED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 224,430 AND THE CURRENT MILEAGE 224,455.

    NHTSA complaint 10462041
14. Filed Feb 11, 2012Failure Feb 10, 2012156,972 milesBismarck, NDElectrical system, Engine and engine cooling, Power train

    THE SPARK PLUG LOCATED AT THE REAR OF THE RIGHT CYLINDER BANK OF A 6.8 LITER GASOLINE ENGINE WAS EJECTED. THE SPARK PLUGS IN THIS ENGINE HAVE NEVER BEEN CHANGED TO MY KNOWLEDGE SO THIS IS NOT A RESULT OF IMPROPER TORQUING PROCEDURES. THE ENGINE HAD BEEN OPERATING PROPERLY AND VERY SELDOM HAS GONE OVER 70 MPH. ACCELERATION AT THE TIME OF FAILURE WAS LIGHT AND THE VEHICLE WAS NOT TOWING. NO FIRE ENSUED ALTHOUGH THERE WAS A FAINT GASOLINE ODOR UNDER THE HOOD RIGHT AFTER I SHUT THE ENGINE DOWN. THE FAILURE WAS OBVIOUS BECAUSE THE SPARK PLUG AND ATTACHED COIL PACK WAS LYING ON TOP OF THE CYLINDER HEAD. THE FORD DEALER ACKNOWLEDGED THAT THIS HAS BEEN A PROBLEM IN THESE ENGINES. *TR

    NHTSA complaint 10447480
15. Filed Oct 14, 2011Failure Oct 14, 2011Goffstown, NHBody, Suspension

    2000 F350 RUST : 8 FT. BED, RAILS UNDER BED, CAB RUST, CROSS MEMBER UNDER BED FROM RIGHT FRAME TO LEFT FRAME, RUNNING BOARDS. REPLACED OIL PAN BECAUSE OF RUST YEARS EARLIER. *TR

    NHTSA complaint 10430199
16. Filed Oct 14, 2011Failure Sep 15, 2011118,000 milesGoffstown, NHFrame and members

    TL* THE CONTACT OWNS A 2000 FORD F-350 DIESEL. THE CONTACT NOTICED THERE WAS A EXCESSIVE RUST ON THE FRAME AND THE EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT HE NEEDED A FRAME, TRUCK BED, ETC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000. UPDATED 12/05/11

    NHTSA complaint 10430184
17. Filed Oct 6, 2011Failure Oct 2, 2011145,000 milesTitusville, PAFuel system, Tank assembly

    TL* THE CONTACT OWNS A 2000 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD A NOISE FROM THE REAR OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE TO INSPECT THE NOISE AND NOTICED THAT THE FRONT FUEL TANK STRAP WAS CORRODED AND FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) THAT AND CONTACTED THE MANUFACTURER BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. UPDATED 11/03/11*LJ UPDATED 12/02/11

    NHTSA complaint 10428904
18. Filed May 31, 2011Failure Apr 12, 2011151,000 milesSapulpa, OKPower train

    TL* THE CONTACT OWNS A 2000 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE CLUTCH ARM BROKE WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH. THE VEHICLE WAS REPAIRED BY THE CONTACT. THE MANUFACTURER AND DEALER WERE CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 154,000. UPDATED 08/31/11*LJ UPDATED 2/9/12 *CN

    NHTSA complaint 10403830
19. Filed May 29, 2011Failure May 27, 2011174,000 milesFostoria, MIService brakes, Hydraulic

    2000 FORD F350 CREW CAB 4X4 BRAKE LINE WAS CORRODED FROM DIFFERENT METALS USED. HAD HOLE IN LINE AND BRAKE PEDAL WENT TO THE FLOOR CAUSING ME TO HAVE NO BRAKES. EXTREMELY DANGEROUS!!! *TR

    NHTSA complaint 10403672
20. Filed May 10, 2011Failure Apr 18, 2011120,000 milesChelmsford, MAFuel system, Gasoline

    FUEL TANK STRAP HAS BROKEN AGAIN.2ND TIME FOR THE REAR STRAP,FRONT REPLACED 1 TIME. ALSO REPLACED GAS TANK IN 2006 DUE TO LEAK FROM RUSTING AT SEAM,TANK IS STARTING TO LEAK AGAIN. TANK DROPPED TO THE STREET WHEN STRAP GAVE WAY LAST TIME,LUCKILY I WAS GOING SLOW ON A SIDE STREET. SPEAKING WITH OTHER OWNERS OF THESE TRUCKS,F-350 SUPERDUTY 2000 CAB AND CHASSIS MOST ARE HAVING OR HAVE HAD THE SAME ISSUES I AM HAVING. *TR

    NHTSA complaint 10399900