2019 Ford F-350 SD

467 complaints on file, page 1 of 24.

1. Filed Sep 25, 2026Failure Sep 23, 2026Crossville, TNPower train

   My 2019 Ford F350 fully power stroke deisel super duty started making a terrible grinding and grinding noise when I let off the accelerator. There’s specifically fluid leaking from rear axle in the center where the drive shaft meets the heavy duty Dana M300 axle. And all over the inside rear passenger tire. There’s a burnt gear oil smell coming from the truck as a result and the truck can’t be driven .

   NHTSA complaint 11766850
2. Filed Aug 28, 2026Failure Aug 28, 2026Las Vegas, NVEngine, Fuel/propulsion system, Power trainFire

   Wife was driving the truck(I was the passenger) while towing our dump trailer. After approx 100 miles into this trip the dash showed a "Reduced Engine Power Warning", and then shuddered. That was immediately followed by a "Service Engine Soon" warning on the dash, and the truck shut down as we were pulling to the shoulder. I smelled diesel fuel as we slowed to a stop. I got out and saw some smoke coming from under the hood. I looked under the truck and saw burning material falling from underneath, I shouted fire, and my wife exited while I retrieved our dog from the back seat. The cab was filling with smoke. Wife called [XXX] while I retrieved a few more small items from back seat. We stepped back and the truck was fully engulfed in flames in a few minutes. Fire crews were on scene after several more minutes, and by that time the truck was burnt to the ground. This truck was in excellent condition with no prior running issues or warnings of mechanical problems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11760494
3. Filed Aug 11, 2026Failure Jul 28, 202671,000 milesTooele, UTPower train

   The contact owns a 2019 Ford F-350 SD. The contact stated that while the vehicle was parked, her husband attempted to turn the key in the ignition, but the vehicle failed to operate as intended. The messages "Service Advanced Trac", "Oil Change Required", and "Hill Start Assist" were displayed. The ABS and check engine warning lights were illuminated. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000.

   NHTSA complaint 11756333
4. Filed Aug 11, 2026Failure Aug 9, 2026130,000 milesTyner, KYPower train

   The contact owns a 2019 Ford F-350 SD. The contact stated that while driving at an undisclosed speed, the contact became aware that the transmission was slipping. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with torque converter failure. The contact was informed that the transmission needed to be replaced. The vehicle was in the process of being repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall associated with the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

   NHTSA complaint 11756142
5. Filed Jul 22, 2026Failure Jul 13, 2026120,000 milesHuron, SDEngine and engine cooling, Fuel system, Diesel, OtherFire

   The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

   NHTSA complaint 11752108
6. Filed Jun 26, 2026Failure Jun 24, 2026Birdsboro, PAFuel/propulsion system

   This model has the same Bosh CP4 high pressure fuel pump as the recalled models 2020-2022 and in fact being older the catastrophic failure risk is higher due to additional mileage. If this part fails the engine shuts off with loss of steering and braking even when pulling 15-20K pounds. The safety concern for this year is the same or greater then newer models.

   NHTSA complaint 11746669
7. Filed Apr 20, 2026Failure Jan 20, 2026Logan, UTWarning, Steering

   A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go straight down the road in order to fix it you have to replace the entire steering wheel which is about 3,400 or so.

   NHTSA complaint 11732454
8. Filed Apr 12, 2026Failure Nov 30, 2025Crescent, IAEngine, Fuel/propulsion system

   While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, It soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then blew off again. I had to replace the entire fuel line at a cost of around $1000. Prior to the first event the filter had been on the truck and was being serviced every other oil change in line with the manufactured guidelines. When looking on line this is a major problem with the fuel line and under hood filters causing fires. This needs a repair before more people are hurt

   NHTSA complaint 11730641
9. Filed Mar 27, 2026Failure Mar 23, 2026Springfield, MAWarnings

   My rearview camera is showing a distorted image and then goes blank while in reverse creating a safety issue while backing up. The camera is doing everything listed in the following recall campaigns: 20C19/22V252 20C19/24V188 20C19/20V575 but Ford says my truck does not qualify for the recall because my VIN is not listed in the recall.

   NHTSA complaint 11727398
10. Filed Feb 2, 2026Failure Jan 1, 2026Box Elder, SDFuel/propulsion systemFire

    Failed component was the upper fuel filter/ fuel filter connecting lines located on top of the 6.7 power stroke engine broke and poured diesel all over the engine and into the valley causing the engine and engine bay to catch on fire while driving down the road. Safety was the fact that our entire truck burnt down and there was extreme risk of loss of life and ended up total loss of property. There have been multiple cases of power strokes from 2011-2026 equipped with the 6.7L power stroke diesel engine having this exact same problem due to the poor placement and inadequate materials to be used in high pressure fuel lines and filters. The vehicle was inspected by insurance and they did determine that was the cause of the fire. There were no warnings, we started smelling something and then smoke began coming through the vents. Pulled over and by then the engine bay was on fire and even the fire extinguisher could not put the diesel out and the entire truck was engulfed in flames in a matter of minutes. Ford needs to fix this issue with the placement of their upper fuel filters and should be held accountable to their customers who have suffered loss for this.

    NHTSA complaint 11715122
11. Filed Jan 28, 2026Failure Jan 23, 2026Palos Hills, ILEngine

    I have about 54000 miles on a 2019 ford super duty 350 with the Power stroke 6.7. Engine light went on and its at Willowbrook ford in Illinois. Emission problem with Particular Sensor code 22e02. The cost of repair is between $816 plus another $1259 if it is cracked. This is absolutely ridiculous. After researching this is a big Ford problem. So they sold some trucks without them and have eliminated them on their 22 models. I think Ford should be responsible for the cost.

    NHTSA complaint 11713899
12. Filed Sep 25, 2025Failure Sep 24, 2025Kimberly, IDVisibility/wiper

    Rear window shattered when rear window defrost was activated.

    NHTSA complaint 11689714
13. Filed Sep 22, 2025Failure Sep 22, 202544,000 milesRohnert Park, CAEngine, Fuel system, Gasoline

    The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The contact stated that after the vehicle was parked and turned off, there was fuel leaking from the engine compartment. The contact became aware that the fuel line was inoperable, causing fuel to leak onto the engine and the exhaust system. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 44,000.

    NHTSA complaint 11689016
14. Filed Aug 31, 2025Failure Aug 31, 2025Cromwell, INElectrical system, Visibility/wiper

    My back up camera is not working.

    NHTSA complaint 11684218
15. Filed Jul 15, 2025Failure Jul 15, 202540,000 milesEldon, MOBack over prevention

    The contact owns a 2019 Ford F-350. The contact stated that while reversing, the rearview camera failed to display a rearview image. The contact stated that the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V442000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

    NHTSA complaint 11673739
16. Filed Jul 15, 2025Failure Jul 15, 202540,000 milesEldon, MOBack over prevention

    The contact owns a 2019 Ford F-350. The contact stated that while reversing, the rearview camera failed to display a rearview image. The contact stated that the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V442000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

    NHTSA complaint 11673738
17. Filed Jun 30, 2025Failure May 25, 202537,000 milesStanwood, WASteering, Suspension

    The contact owns a 2019 Ford F-350. The contact stated that on three occasions while driving approximately 60 MPH, the front end of the vehicle started to wobble violently. The contact stated that when the brake pedal was depressed and the vehicle decelerated below 30 MPH, the wobbling ceased. The contact stated that there were no warning lights illuminated. The contact’s wife observed an unknown recall that might be associated with the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.

    NHTSA complaint 11670258
18. Filed Jun 20, 2025Failure Jun 20, 2025Sturgis, MIUnknown or other

    Rear backup camera foggy, can barely see the lines. I understand there is a possible recall but my vehicle doesn't show it

    NHTSA complaint 11668062
19. Filed Jun 18, 2025Failure Jun 18, 202566,500 milesNorth Port, FLSteering, Suspension

    The contact owns a 2019 Ford F-350. The contact stated that while driving on the highway at 75 MPH, the vehicle started shaking violently. There was no warning light illuminated. The contact pulled over to inspect the vehicle; however, the contact found no fault with the vehicle. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was informed that the VIN was not under recall. The manufacturer was notified of the failure. The approximate failure mileage was 66,500.

    NHTSA complaint 11667804
20. Filed Jun 6, 2025Failure Feb 6, 2025Bountiful, UTFuel system, Diesel

    The contact owns a 2019 Ford F-350. The contact stated that the vehicle was taken to the dealer to be inspected; however, the dealer refused to inspect the vehicle. The contact related the issue to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, neither the VIN nor the model year vehicle was included in the recall. No warning lights were illuminated. The manufacturer was made aware of the issue and referred the contact the NHTSA Hotline for assistance. The vehicle was not inspected or repaired. The contact had not experienced a failure. VIN tool showed no open recall.

    NHTSA complaint 11665293