2004 Ford Focus

387 complaints on file, page 1 of 20.

1. Filed Jan 13, 2026Failure Oct 31, 2025200,010 milesDetroit, MICrankcase (pcv)

   The contact owns a 2004 Ford Focus. The contact stated while driving on several occasions at various speeds, the check engine warning light illuminated, and the vehicle jerked abnormally. There were three clicks before the vehicle stalled. The vehicle was restarted after approximately 10 minutes. The contact stated that on one occasion while driving at an undisclosed speed, the vehicle stalled nearby train tracks. The contact waited for 10 minutes, restarted the vehicle, and drove the vehicle to safety. The vehicle was then towed to an independent mechanic where a handheld diagnostic test indicated that the PCV valve needed to be replaced. The vehicle was then taken to an independent mechanic where it was diagnosed that an ignition coil needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately a month later. The vehicle was taken to the same independent mechanic where it was diagnosed that the fuel relay fuse needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately three weeks later. The manufacturer was not notified of the failure. The failure mileage was approximately 200,010.

   NHTSA complaint 11710614
2. Filed Apr 5, 2023Failure Mar 31, 2023Spring hill, FLElectrical system, Engine, Unknown or otherFire

   As I was stopped at red light it stalled as I drove thru. So I pulled over. Got out to open hood. It was smoking.struggled to open hood. Ran around to get towel to smother the fire. But it was too far gone. Man told me just leave it. It was total loss.

   NHTSA complaint 11515638
3. Filed Oct 7, 2022Failure Oct 7, 2022South Dartmouth, MAUnknown or other

   2004 ford focus started bucking a few years ago, on occasions only. For months there was no problem and than it would buck. If I shut off the engine and waited a few minutes and started it, it would drive without bucking. Recently, it stalled while driving. Fortunately, I was on a country road and could pull over to safety. Now, on occasion, it wont start. Locks in park. After a while, I can get it out of park and start it. I do not drive it on highways since I am fearful of it shutting off. I have been to three garages for service and they cannot figure it out. I even wrote to the corporate office to ask them to let me know what the problem is. On line many people with 2004 ford focus have the same problem. It isnt just my car. Corporate office answered my letter requesting the vin number on which I gave them. After that, I did not hear from them again. I would think that they would have followed through on this since I told them that it has happened to others with the same vehicle. It stalled again a few days ago as I drove in my driveway. Everytime I try to start it, I hear the clicking sound. I go out once in a while to see if it will start. Sometimes, while in park, it wont start. Another time checking it our, it will start. But, I am not driving it anywhere. I am having it towed to another garage to see if they can figure it out. This car has less than 60,000 miles on it and everything else is good. I have spent a lot of money trying to get this resolved. It has been on diagnostic machines and it doesnt show anything. All I wanted from the corporate office was an engineer to let me know how to fix it. They must have heard the complaints since there are many. A recall wont do me any good since I will be having it looked at again this week. I am doing this for others who have the same problem. However, I would like to know exactly what has caused this.

   NHTSA complaint 11488334
4. Filed Jun 13, 2022Failure Nov 11, 2018Elma, WAAir bags, Unknown or otherCrash

   I was coming home one night, in my 2004 Ford focus, when another driver comes speeding up behind me. He then proceeds to pass me during a corner, cutting me off. I hit the brakes and lost control. Ended up rolling my vehicle with my 8 month old daughter and i. Back window exploded, and not a single air bags had deployed when I got into my accident.

   NHTSA complaint 11468967
5. Filed Jun 4, 2022Failure Apr 14, 2021Worth, ILBody

   rear passenger door wont latch shut.Door flies open when making turns

   NHTSA complaint 11467507
6. Filed Mar 10, 2020Failure Jan 4, 2020125,000 milesDandridge, TNService brakes, BodyCrash

   IN JANUARY, I WAS INVOLVED IN A TRAFFIC CRASH. I APPLIED THE BREAKS TO MY VEHICLE (GIVING PLENTY OF TIME TO COME TO A STOP AND ONLY TRAVELING 20 MPH ) BUT THE VEHICLE DID NOT COME TO A COMPLETE STOP. AS A RESULT, I HIT A VEHICLE IN FRONT OF ME. I DO NOT KNOW WHAT THE VEHICLE WOULD NOT STOP. IT WAS AS IF THE BREAKS WERE NOT WORKING CORRECTLY.

   NHTSA complaint 11317279
7. Filed Aug 22, 2019Failure Jan 1, 2017250,000 milesMarietta, SCSwitch, Fuel/propulsion system, Power train, Door

   TL* THE CONTACT OWNS A 2004 FORD FOCUS. WHILE DRIVING VARIOUS SPEEDS, A LOUD NOISE WAS DETECTED FROM THE FRONT OF THE VEHICLE AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE KEY OVERHEATED IN THE IGNITION SWITCH AND THE VEHICLE HESITATED TO DRIVE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT FURTHER MENTIONED THAT THE VEHICLE'S FUEL CONSUMPTION WAS HIGHER THAN NORMAL. THE CONTACT ALSO MENTIONED THAT BOTH PASSENGER DOORS WERE INOPERABLE. THE CONTACT MENTIONED THAT THE DRIVER'S SIDE DOOR NEEDED EXTRA STRENGTH TO OPEN AND THE REAR PASSENGER DOOR WAS STUCK AND WOULD NOT OPEN. THE VEHICLE WAS TAKEN TO MULTIPLE UNKNOWN DEALERS WHERE THE CONTACT WAS INFORMED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED AND THE ENGINE VALVE WAS STUCK. THE CAUSE OF THE OTHER FAILURES WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 250,000.

   NHTSA complaint 11245773
8. Filed Jul 24, 2019Failure Jul 1, 2019125,550 milesMiddleboro, MAElectrical system, Engine, Service brakes

   MY BATTERY LIGHT SEEMS TO FLASH WHEN THE CAR IS OFF. CAR HAS STALLED SEVERAL TIMES WHILE DRIVING TRY TO ACCELERATE OVER 50 MILES AN HOUR CAR WILL SHUT OFF. BACK HATCH ON WAGON SEEMS TO RELEASE ITSELF WHILE DRIVING WELL UNLOCK AUTOMATICALLY. HAVE REPLACED THREE THERMOSTAT AND THERMOSTAT HOUSING DUE TO OVERHEATING CAR WILL NOT TELL ME IS OVERHEATING IT WILL BOIL IN THE OVERFLOW RETURN TANK PRESSURIZE AND SHOOT THE CAP OFF?...

   NHTSA complaint 11234370
9. Filed Jul 19, 2019Failure Jul 13, 2019Goldendale, WAFuel/propulsion system, Latches/locks/linkages

   TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURES LISTED IN NHTSA CAMPAIGN NUMBER: 06E056000 (FUEL SYSTEM, GASOLINE) AND NHTSA CAMPAIGN NUMBER: 05V030000 (LATCHES/LOCKS/LINKAGES). SHE STATED THAT DUE TO POOR DESIGN, THE QUICK CONNECTORS WOULD NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR WAS FULLY ATTACHED. THE CONTACT ALSO STATED THAT SHE WAS UNABLE TO OPEN THE FRONT DRIVER'S SIDE AND BOTH REAR DOORS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.

   NHTSA complaint 11233491
10. Filed Jul 10, 2019Failure May 23, 2019Newport News, VAElectrical system, Engine

    RECENTLY MY VEHICLE STEREO HAS BEEN MESSING UP. IT SOMETIMES SMELL A LITTLE BURNT. IT IS THE PASSENGER DOOR SPEAKER. IT SOUNDS AS IF IT'S A SHORTAGE INSIDE OF IT. SOMETIMES THE RADIO DASH FADES OUT. THE CAR HAS HESITATES SOMETIMES TO START. ONCE THE AC IS ON THE CAR STARTS RUNNING REALLY ROUGH AND YOU HEAR A KIND OF CLICK IS HARD TO EXPLAIN BUT I KNOW IT'S NOT NORMAL. AT SOMETIMES I AM UNABLE TO RUN THE AC MY WHOLE TRIP. MY ENGINE LIGHT HAS RECENTLY CAME ON I DID REPLACE THE COIL PACKS. ENGINE LIGHT IS STILL ON.

    NHTSA complaint 11230782
11. Filed Jul 7, 2019Failure Jun 15, 2019180,000 milesDelta, OHElectrical system

    "TAKATA RECALL" TRUNK LID POPS WHEN BRAKES ARE APPLIED. I'M AFRAID THAT IF I HIT A BUMP IN THE ROAD THE LID WILL FLY UP. ALSO IF I POP THE LID WITH KEY FOB BREAK LIGHTS COME ON.

    NHTSA complaint 11229934
12. Filed Apr 12, 2019Failure Dec 22, 2017180,000 milesWillits, CAEngine

    TL* THE CONTACT OWNED A 2004 FORD FOCUS. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE HESITATED AND STALLED. ALSO, THE OXYGEN SENSOR, MASS AIR FLOW SENSOR, AND THROTTLE BODY SENSOR WARNING INDICATORS ILLUMINATED. SINCE 2016, THE CONTACT ALSO STATED THAT THE FAILURE ONLY OCCURRED WHEN THE VEHICLE WAS PARKED ON AN INCLINE, FACING UPWARDS. THE CONTACT HAD THE VEHICLE DIAGNOSED BY A SCHOOL TEACHER WHO WAS A CERTIFIED MECHANIC. IT WAS DETERMINED THAT THE AIR INTAKE WAS LOCATED IN THE FRONT OF THE VEHICLE AND WATER ENTERED, WHICH DAMAGED THE SENSORS.T HE AIR INTAKE NEEDS TO BE POINTED DOWN TO PREVENT WATER FROM COMING IN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. THE VIN IS INVALID. *TT*JB

    NHTSA complaint 11195904
13. Filed Feb 20, 2019Failure Feb 19, 2019122,000 milesKailua Kona, HIElectrical system

    WHEN PUTTING THE KEY IN THE IGNITION THE KEY WILL NOT TURN AND START THE CAR. IT WILL NOT START AFTER PULLING THE KEY OUT OF THE IGNITION. I AM PREGNANT EXPECTING A BABY. THIS IS A SAFETY HAZARD FOR ME AND MY BABY. IF I GO INTO LABOR AND NEED TO LEAVE TO THE HOSPITAL I CANNOT RISK THE CAR WILL NOT START BECAUSE THE KEY WON'T TURN THE IGNITION ON.

    NHTSA complaint 11181269
14. Filed Jul 16, 2018Failure Jul 9, 201875,000 milesPittsburgh, PASteering

    TL* THE CONTACT OWNS A 2004 FORD FOCUS. THE CONTACT STATED THAT THE STEERING COLUMN JAMMED WITHOUT WARNING. THE DEALER (DAY FORD, 3696 WILLIAM PENN HWY, MONROEVILLE, PA) AND MANUFACTURER WERE CONTACTED, BUT DID NOT ASSIST BECAUSE THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.

    NHTSA complaint 11111687
15. Filed Jul 2, 2018Failure Jun 28, 201830,000 milesVisalia, CAElectrical system, Exterior lighting, Steering

    MY VEHICLE INSTRUMENT CLUSTER FAILED CAUSING ALTERNATOR TO DIE AND FALSE READINGS ON THE DASH WITH MULTIPLE ALERTS SUCH AS BATTERY, AIRBAG , OIL AND INCORRECT SPEED DIAL. THE VEHICLE INSTRUMENT FAILED AT 30,000 MILES AND IF YOU SEARCH IT IS A VERY COMMON ISSUE WITH THE FORD FOCUS VEHICLE'S. THE VEHICLE STALED AND DIED WHILE BEING DROVE IN TOWN AND THANK GOD IT DID NOT HAPPEN WHILE ON THE HIGHWAY.

    NHTSA complaint 11105102
16. Filed Mar 19, 2018Failure Oct 31, 2013110,000 milesSacramento, CAElectrical system

    ALL OF THE BACKLIGHTING ON THE GAUGE CLUSTER AND BUTTONS BESIDE THE RADIO SCREEN IS INTERMITTENT. I DO NOT DRIVE THE VEHICLE AT NIGHT BECAUSE OF THIS ISSUE. DUE TO THE RISK OF NOT BEING ABLE TO SEE WHAT SPEED I AM TRAVELING AT. I HAVE BEEN THE SOLE OWNER OF THIS VEHICLE AND I BOUGHT IT BRAND NEW FROM THE DEALERSHIP BACK IN 2004. NOTHING HAS BEEN MODIFIED ON THIS VEHICLE.

    NHTSA complaint 11080204
17. Filed Nov 13, 2017Failure Oct 15, 2017151,239 milesCreston, ILSuspension

    THE BOTTOM OF MY SUBFRAME IS COMPLETELY RUSTED OUT. I CALLED FORD DEALER AND THEY TOLD ME IT IS BECAUSE OF THE AREA I LIVE IN THE VEHICLE HAS 151239 MILES

    NHTSA complaint 11045793
18. Filed Aug 7, 2017Failure Feb 6, 2017150,000 milesCortaro, AZElectrical systemFire

    ALTERNATOR CAUGHT FIRE, FEB 2017. REPLACED AND CHECKED SYSTEM. JULY 30, 17 ALTERNATOR SMOKED AND MELTED INSIDE. , POSITIVE TERMINAL ON BATTERY WAS SO HOT THAT THE CONNECTOR WAS TOO HOT TO TOUCH. REPLACED. ALTERNATOR AND BATTERY. PICKED UP CAR FROM REPAIR SHOP AND WITHIN ONE MILE THE ALTERNATOR MELTED ITS INTERNAL WIRING WIRING AND SMOKED. CAR IS BACK IN SHOP. EACH TIME THIS HAPPENED THE CAR WAS BEING DRIVEN.

    NHTSA complaint 11013323
19. Filed Jun 27, 2017Failure Jun 23, 2017155,000 milesLake Oriion, MICruise controlFire

    TL* THE CONTACT OWNED A 2004 FORD FOCUS. THE CONTACT HEARD A CAR HORN SOUND WHILE BEING AWAY FROM THE VEHICLE. UPON INSPECTION, THE CONTACT NOTICED FLAMES UNDERNEATH THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FLAMES. AN INVESTIGATOR DIAGNOSED THAT THE FAILURE ORIGINATED FROM THE CRUISE CONTROL SWITCH. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A SALVAGE YARD WHERE IT WAS DEEMED DESTROYED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.

    NHTSA complaint 11001698
20. Filed Mar 31, 2017Failure Sep 1, 201375,000 milesTheresa, NYUnknown or other

    A/C RECALL I BOUGHT MY CAR USED AND THE A/C WAS WORKING. THEN A FEW MONTHS LATER, IT STOPPED WORKING. I TOOK IT TO THE MECHANICS AND THEY COULDN'T ORDER THE AIR HOSE IT NEEDED TO FIX IT BECAUSE THEY SAID THEY WEREN'T SELLING THEM ANYMORE. WE TRIED HOSES FROM SIMILAR MODEL CARS, BUT COULDN'T FIX IT.

    NHTSA complaint 10969659