Pickup, hybrid, 4x2, built in Mexico. Owner complaints on file from Jan 11, 2022 to Sep 28, 2026.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 25V-881 | Dec 18, 2025 | Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power | Powertrain | 87 | Software update |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
466 complaints on file, page 1 of 24.
The contact owns a 2022 Ford Maverick. The contact stated that while driving 40 MPH, the engine light turned on and off and then several unknown warning lights illuminated and the vehicle abruptly decelerated. The driver pulled over, and the vehicle was restarted. The vehicle was then driven 20 MPH. The vehicle was taken to the local dealer, and it was determined the failure was caused by the calipers and a software update. The dealer informed the contact that the VIN was not under recall. The manufacturer was contacted. The failure mileage was approximately 122,000.
NHTSA complaint 11767376Engine long block assembly needed replacement. TPMS continues to fail. Axles make vehicle shake when going freeway speeds.
NHTSA complaint 11766429While driving, the dashboard very quickly flashed the words "Charging System Service Soon" so fast I almost couldn't read it. Normally messages remain on the screen until I acknowledge them, but this was not the case. This happened at least 3 times within 30 minutes. When I got home, I parked and turned off the car. When I needed to turn the car back on shortly after, the vehicle would not turn on. I was able to get it jump started and immediately drove it to the Ford Service Center. The tech notes indicated: "Found SSM for concern. Required some module updates. During update, the PCM bricked due to low power. Through nearly 7 hours of testing, found the soldered connection of the main battery cable from battery to battery junction box is no longer connected and has caused a short circuit through the whole harness. There was a recall that expired in 2024 that was for this exact concern. (22B39) Recommendation is to replace full wiring harness and verify all modules are programmed properly. Pending customer approval.”" This is a safety concern in the sense that the disconnected battery cable could have led to the vehicle losing power while driving. Losing the ability to control the vehicle in this manner is a serious danger to me and other drivers, and I am grateful I was not driving when it lost power due to the disconnection.
NHTSA complaint 11766234the factory installed lead acid battery is not sufficient to support the electrical hybrid system. my vehicle died and went into deep sleep mode after 1 week of ownership ( i am the original owner). I was stranded in another state and had to call Ford roadside assistance to come jump start the battery. after approximately 4 months of consistent deep sleep mode issues ( i had since carried a jump box with me to avoid being stranded after first incident) i brought veicle to the Ford dealership and their fix was to replace the factory installed battery, which was reading low voltage, with the same new motorcraft battery. the issues continued after new battery install and after several attempts with different Ford dealerships for a permanent fix, i referenced recall 25s02, i was told my vehicles vin did not fall within the recall even though my vehicle exhibited the same problem. the recall 25s02 called for the dealer to replace the factory lead acid battery with an AGM battery and perform a battery relearn. i was unable to get any Ford dealer to perform the recall on my vehicle and was forced to purchase an AGM battery and install same myself and perform a battery relearn. since installing said AGM battery I have not any deep sleep issues with the vehicle or any incidents where the vehicle needed to be jump started. I feel that my vehicle should have fallen under this recall as it exhibited the same problems as mentioned above and fixing it myself with the recalls solution (replacing lead acid with AGM battery) has fixed said issue.
NHTSA complaint 11766171The contact’s husband who owns a 2022 Ford Maverick. The contact stated that while her husband was reversing to complete a 3-point turn, the brakes failed to respond while the brake pedal was depressed, causing the vehicle to drive into a ditch and then crashed into a large boulder alongside the driveway. The contact stated that the pre-crash alert illuminated prior to the crash. The rear passenger's side bumper was damaged, and wires were hanging down. The vehicle was towed to a dealer, where the contact was informed that no brake failure was found. The contact stated that the insurance company had inspected the vehicle. The driver had emotional distress and might have sustained a bruise. The failure mileage was approximately 46,100.
NHTSA complaint 11764978I have already had the cv axles replaced under the extended customer satisfaction program in January 2026, but today while doing a cross country move, the outer boot on the drivers side showed significant grease loss, and the inner boot on the passenger side tore off with a very severe clunk, noise, and shake while braking and accelerating. Thankfully the cv axle did not separate, but a failure could have resulted in a loss of control. This will be going to the dealership tomorrow. No warning lights, messages, or symptoms that I could observe before the 1000 mile trip across yesterday and today.
NHTSA complaint 11764584My 2022 Ford Maverick Hybrid has twice suddenly entered limp mode and experienced a substantial loss of power. The first incident occurred on or about XXX. After leaving my subdivision, I turned onto [XXX], which has a posted speed limit of 55 mph. The vehicle immediately lost power and entered limp mode, and the engine and wrench warning lights appeared. The weather was clear and sunny. I was able to drive several miles at substantially reduced power and return home. On XXX, at 83,600 miles, Louisburg Ford retrieved DTC P1061, determined that Ford TSB 25-2454 applied, and reprogrammed the required modules. The second incident occurred on 9/13/2026. My husband and I were returning home after traveling through [XXX], [XXX], and [XXX]. We were driving northbound on I-35 near mile marker 182 at the [XXX] exit, just south of [XXX]. It was completely dark and storming, with rain and lightning, when the vehicle again entered limp mode and lost power in highway traffic. We were fortunate to have cellular service and a gas station nearby. Otherwise, we could have been stranded in dangerous conditions. On XXX, at 106,338 miles, the same dealer retrieved the same P1061 code and again applied TSB 25-2454 by reprogramming the PCM. The same loss-of-power condition, code, and Ford-prescribed repair recurred within approximately 11 months and 22,738 miles. The dealer advised that there is no guarantee it will not happen again. I am concerned that this sudden loss of acceleration or motive power could recur at highway speed and cause a crash. I request that NHTSA investigate this recurring condition and whether TSB [XXX] provides an adequate remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11764238What component or system failed, and is it available for inspection? The right frame engine mount, differential/rear mount, and upper engine mount were all torn or broken. Both front CV axle shafts also needed replacement. Repaired 8/17/2026 by Miami County Auto, Louisburg, KS (invoice #13092). No, I don't have the parts anymore. How was your safety or the safety of others put at risk? The vehicle developed a wobble/vibration under acceleration that was reported as "getting worse" — pronounced enough to visibly shake objects in the cabin. The shop noted the engine mounts were torn/broken, allowing excess engine movement, which increases risk of further mount or drivetrain component failure and loss of vehicle control, especially at highway speeds or during hard acceleration. Has the problem been reproduced or confirmed by a dealer or independent shop? Yes — confirmed and repaired by an independent shop (Miami County Auto) on 8/17/2026 at 104,205–104,211 miles. Not taken to a Ford dealer. Has the vehicle been inspected by the manufacturer, police, insurance, or others? No — only inspected and repaired by the independent repair shop noted above. Were there warning symptoms before failure, and when did they first appear? Yes — a wobble/vibration under acceleration that subsided when off the throttle, and progressively worsened over time before the repair. Originally I thought it was a recently repaired tire that was unbalanced. Took it to Ford dealership to rebalance. They said there was no wobble (there was) and took it the independent shop.
NHTSA complaint 11760577On 7-2-26, my 2022 Ford Maverick Hybrid was brought to College Station Ford to receive the remedy for mandatory Safety Recall 24S59 (NHTSA Campaign 24V684000) regarding the frozen Rear View Camera display image. Prior to this service, the vehicle’s electrical, starting, and hybrid systems functioned flawlessly without error.Immediately following the completion of the recall service, which required a software flash of the Connected Touch Radio/Audio Control Module (ACM), the vehicle suffered a catastrophic module network failure resulting in a permanent no-start condition. The vehicle's Powertrain Control Module (PCM) and Body Control Module (BCM) have glitched into a permanent High-Voltage System Isolation Lockout loop.Independent professional laboratory load-testing has certified that the vehicle's low-voltage 12V auxiliary battery is healthy, fully charged, and completely functional. However, the vehicle can currently only be turned on by attaching an external 12V jump-pack directly to the battery system. This external voltage spike manually overrides the corrupted software communication loop, forcing the vehicle's electrical relays to close.The dealership has refused to remedy this botched recall programming, claiming the physical hybrid high-voltage lines have suddenly failed. Because a low-voltage 12V jump-pack cannot power or repair broken high-voltage traction lines, the vehicle is suffering from a software-induced safety lockout directly caused by the failed execution of Recall 24S59.This presents an active, extreme safety hazard. A hybrid powertrain suffering from un-remedied module communication failures and high-voltage isolation fault lockouts risks a sudden, unexpected, and catastrophic loss of motive power while operating at highway speeds on public roads.I am filing this report because the manufacturer's official recall remedy has introduced a dangerous, debilitating safety flaw to the vehicle's primary powertrain loop.
NHTSA complaint 11755155Driving on highway, approximately 65mph when all of a sudden the "door ajar" symbol on instrument panel lit / sound dinged, and the passenger who had their elbow on the door screamed. The passenger side door unlocked and "opened" as in it unlatched. It did not open all the way for her to fall out, but it was no longer fully closed. This is a 2022 vehicle. This happened for the first time in 2026 after 34k miles. There is an active recall for the same make / model but for some reason my VIN is not included. I'm pretty sure it should be after this experience.
NHTSA complaint 11750284While driving at normal speeds. Car completely stopped working. Dashboard flashed to get to safe area. I could not shift the car neutral. Steering became stiff. The lights and infotainment was still on but the car had no power to accelerate. Had this been on the highway I would have been in a collision since my car went to the right very quick. Once car was stopped could not shift to neutral.
NHTSA complaint 11743262Front end of vehicle suddenly started to shake violently when accelerating. Issue was reproduced any time when accelerating. No warning was indicated by the vehicle. Car was undrivable above 50 mph. Vehicle had 25K miles. Dealer reproduced issue. Diagnosed it as a catastrophic failure of both CV joints and front bearing(s). Dealer would not release vehicle as it was undrivable due to extreme safety issue. Parts arrived after a week and both CV joints & front bearing(s) were replaced. Online reporting for this vehicle shows this is a repeated issue which the manufacturer has a customer satisfaction bulletin but no recall.
NHTSA complaint 11739604Truck has stalled out multiple times, has been left in middle or road due to electrical drainage of battery. Person needed to get jumper cables to move truck.
NHTSA complaint 11738075brake issue when coming to a stop, sometimes the brakes (mainly front) feel like they go free for a rotation. this is a random problem, and the dealer didn't find an issue.
NHTSA complaint 11737736Fuel leaking from pressurized tank, strong fuel smell. Photo attached shows pattern of fuel leak.
NHTSA complaint 11736859The contact owns a 2022 Ford Maverick. The contact stated that while her husband was driving 55-65 MPH, the vehicle shut off. The driver was unable to pull over to the side of the road. The driver was able to jumpstart the vehicle and continued driving. The contact stated that the failure recurred while pulling into a parking lot. The dealer was contacted and informed the contact that the vehicle could not be picked up due to safety concerns. The vehicle was towed to the dealer, where it was diagnosed, and determined that a new 12-Volt battery cable overlay was needed, and the current battery cable needed to be disabled. The dealer related the failure to the Ford Customer Satisfaction Program: 22B39 (2022 Maverick HEV No Start Condition), but the contact was informed that the Customer Satisfaction Program had expired. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure but denied assistance. The failure mileage was 80,000.
NHTSA complaint 11731614Had a service electrical system soon message, the had total failure while driving on interstate, lost all power and manuvered truck to side of the road, waited 15 minutes, restarted. Now, complete dead battery, replaced battery, still no start. There was a tsb for 2022 mavericks for bad battery cable but not for the time mine was built, but has same bad battery cable connection. Confirmed by dealer and in for replacement now, but my build month and they tsb ended in june 2023
NHTSA complaint 11725823My 2022 ford Maverick is constantly sometimes several times a day and sometimes several times a week , but since 6 weeks after purchase I have been getting powertrain fault , engine fault and hybrid battery fault alerts from my ford pass my check engine light comes on my s service wrench light comes on also and my vehicle has reduced power. As well as my battery is constantly needing to be jumped. The dealership says my Battery is fine although I’ve already replaced it twice at my exspence. I’ve had to pay for diagnostics and pcm updates supposedly to fix these problems but no resolve. My vehicle goes into reduced power while driving 75 mph up the interstate and will not excellerate causeing the vehicle to coast to a stop. After sitting a while it can be started and driven. Today I received all three faults at 10:20 am so I went to my ford.com and done a health check and it says my vehicle is healthy with no engine or power train faults. But my ford pass alerts , my dashboard warning lights , and the performance of my vehicle says otherwise. I have been put in many situations on high speed roads and my vehicle will not accelerate. Often times it is necessary to jump my battery for I can move my vehicle. These issues are a constant safety hazard to all the drivers on the road when a vehicle suddenly loses power at high speeds. After 4 years of fighting with ford for a resolve I need help. I have seen numerous recalls issued addressing these very issues but they are not issued for my vin although the data on the recall states the recall pertains to vehicles made at the hermacillo Mexico plant . Which mine was on Dec 2021. I feel like my vin somehow is being overlooked and I’m not recieving the recall for the repairs. I also believe that due to the electrical issue my truck can not retain the obd codes. I have taken my vehicle to several dealerships all telling me different resolve which I pay for and no resolve. Please help
NHTSA complaint 11723301Just picked up vehicle after having a new battery installed. Was getting pop up on dashboard every few seconds that electrical saving mode was active. Then all of a sudden the truck shut off while driving about 45 mph on a busy road. Dash said switch to neutral to start vehicle which i tried but nothing happened. Truck coasted to a stop and would not start or even shift into neutral to push it off of the road. The dashboard was flashing pretty much every warning possible including stop safety, shift system failure, parking brake , battery saver active etc. The truck continued to not start or shift. Tow truck was called and it was towed home.
NHTSA complaint 11723267Experienced excessive wobbling/shaking during acceleration. Ford replaced both axles at 38K miles. 30K miles later I am experiencing same issue. Replacing axles this frequent is abnormal and is an indicator that parts being used are not meeting the requirements needed for this vehicle.
NHTSA complaint 11717927Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall.