2019 Ford Ranger

268 complaints on file, page 1 of 14.

1. Filed Sep 26, 2026Failure Jan 1, 2026Haymarket, VAVisibility/wiper

   Defective heat/ac blend box assembly. No heat or, more importantly, windshield defroster. Appears to be a common issue on this vehicle model.

   NHTSA complaint 11767201
2. Filed Sep 22, 2026Failure Sep 22, 2024Rock Falls, ILSuspension

   Driver side rear leaf spring cracked at front mount. This happened with low mileage 20k and no towing or off-road driving. In town driving only.

   NHTSA complaint 11766034
3. Filed Sep 4, 2026Failure Aug 3, 2026Northport, NYPower train

   My 2019 Ford Ranger with 10 speed transmission has been harsh shifting and will not always find the right gears. It will sometimes Surge forward or at other time not respond to acceleration. It has 100,000 miles. Never used it for towing or hawling heavy items.

   NHTSA complaint 11762203
4. Filed Sep 3, 2026Failure Aug 31, 2026North Huntingdon, PAPower train

   My 2019 Ford Ranger, VIN 1FTER4FH2KLA63893, experienced a major transmission failure at approximately 35,000 miles. I took the vehicle to a Ford dealership for diagnosis and was advised that the transmission required major repair/replacement, with an estimated cost approaching $9,000. I also obtained an independent transmission repair estimate of approximately $6,700–$7,000. Given the extremely low mileage and the repair cost relative to the vehicle’s value, repairing the truck no longer made financial sense. The transmission failure substantially reduced its trade value and is forcing me to replace a vehicle that I otherwise intended to keep. I estimate the resulting loss of equity at approximately $7,000, in addition to the financial impact of prematurely taking on another vehicle and associated financing. After the failure, I learned of ongoing litigation involving Ford’s 10R80 10-speed transmission, including allegations involving 2019 and 2020 Ford Rangers. I am reporting my experience so this failure is formally documented and can be considered in connection with any investigation, litigation, warranty extension, recall, or other potential remedy involving the 10R80 transmission.

   NHTSA complaint 11761924
5. Filed Aug 13, 2026Failure Jul 29, 2026Aztec, NMElectrical system, Engine, Unknown or other

   The cooling fan clutch control wire is supported by a "wire support hose" between the engine block and the fan clutch. the cooling fan clutch control freely rotates on a raceway on the drive shaft. The purpose of the support hose is to prevent the fan clutch control from freely rotating, but allows the control a limited range of movement as the drive shaft changes speed with engine RPM. The idea is that this hose prevents undue stress on the control wire. Hose is normally a consumable part that may need replaced with age, heat, etc. The hose is not sold as a replacement part and can only be obtained by purchasing a new fan clutch. When the hose fails, the control wraps around the drive shaft causing damage to the fan clutch control and wiring requiring replacement. The circuit on which the fan clutch control sits is integrated with no less than 6 other critical vehicle systems including oil pressure. When the incident occurs, all these systems generate errors that put the vehicle into limp mode until repair can be made. The fan clutch control wiring support hose should be a bracket with a different mechanical linkage solution to support wire while allowing the necessary limited movement. This low-tech hose solution causes outsized damage when it fails, effectively disabling the vehicle which creates a safety concern and undue hardship from an unnecessarily cascading damage effect. Ford acknowledges this defect by redesigning this feature for 6G Rangers but will not proactively correct through manufacturer recall 5G Rangers. If Ford will not correct, I believe the NHTSA should get involved and force Ford's hand at addressing this repair.

   NHTSA complaint 11756686
6. Filed Aug 5, 2026Failure Aug 1, 2026Cincinnati, OHPower train

   Auto transmission is failing to shift when taking off from a stop or hesitating to shift to next year causing traffic behind me to get close to rear bumper.

   NHTSA complaint 11755076
7. Filed Jul 25, 2026Failure Jul 23, 2026Franklinton, NCPower train

   1st I reported to Ford that when my truck was in park and off, it started rolling down a hill. I jumped in and stopped it. Ford said they see nothing and everything looks fine. Since then I use the emergency break every time. 2nd, you feel the transmission shifting hard. Jerks truck. Also, if you drive around 25 mph, the truck starts jerking like it cant make up its mind what gear to be in.

   NHTSA complaint 11752783
8. Filed Jul 24, 2026Failure Jul 1, 2026Avon Lake, OHSuspension

   Weak steel from connection point of rear leaf springs failed, leaving the springs unconnected at front eye of connection point

   NHTSA complaint 11752638
9. Filed Jul 1, 2026Failure May 23, 2026Lincoln, CAElectrical system, Engine

   I was driving the vehicle, when I started to fell a " Shuddering " sensation on acceleration. I let off the gas pedal and the Shuddering went away. A few miles down the road the check engine light came on and was flashing. I immediately pulled and shut the vehicle off. After sitting for 10 minutes I restarted the vehicle and the check engine light was no longer on, but the " Shuddering " sensation was still present. I took it to Dupratt Ford in Auburn,Ca. and they diagnosed it as a Cylinder 1 mis-fire. Upon further inspection they found water in the Cylinder 1 spark plug well. After doing some research I found out the Ford issued TSB 23-2011for this exact issue, but did not order a recall to fix the faulty windshield cowl which is the problem. I found thousands of complaints and numerous Ranger owners who have had the exact same issue and had to pay out of pocket to get the issue and damaged fixed. Meanwhile Ford knew about the issue and did absolutely nothing, did not even alert the owners of the issue. I was lucky and did not have to replace the cylinder head, but others have not been so lucky. I had to pay over $1800 to have the mis-fire issue fixed and had to do my own preventative measures to seal the windshield cowl. I contacted Ford and they were only willing to reimburse me $725 dollars of my repair bill which was 100% their fault.

   NHTSA complaint 11747696
10. Filed Jul 1, 2026Failure Jan 1, 2022Petersburg, ILPower train

    The Ford 10R60 and 10R80 transmission has become a hazard on the road. Please see TSB 23-2250. My Ranger only has 43,000 miles on it and is dangerous to drive because of the stuttering and lunging of the transmission. Ford is perfectly aware of this situation but won't fix vehicles that are out of the 5 year warranty at no cost to the owner. No transmission should be faulty after only 43,000 miles. I am requesting that you please investigate this situation as I believe it should be a recall. - Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11747616
11. Filed Jun 26, 2026Failure Jun 26, 2026Fort Thomas, KYPower train

    The transmission has issues not shifting gears and having loss of power when pulling out into intersections that are getting worse with time.

    NHTSA complaint 11746830
12. Filed Jun 22, 2026Failure Jun 20, 2026Arlington, VASuspension

    I am submitting this complaint regarding my 2019 Ford Ranger because I discovered what I believe to be a serious safety defect involving the rear leaf spring mounting system. My vehicle has approximately 55,000 miles and has been used primarily as a commuter vehicle for driving to and from work in the city. The truck is originally from Virginia and has very minimal rust exposure. While replacing my rear brake pads, I noticed that the area where the rear leaf spring connects to the body/frame of the truck had broken away and was no longer properly attached. This was completely unexpected. A critical suspension component such as the leaf spring mounting point should not fail on a relatively low-mileage vehicle with only 55,000 miles, especially one that has not been subjected to severe corrosion or extreme use. Had I not been performing brake maintenance myself, I likely would not have discovered this defect. I fear that many other Ford Ranger owners may be driving their vehicles unaware that they could be experiencing the same dangerous condition. A failure involving the leaf spring mounting system has the potential to affect vehicle stability, handling, braking, and overall control. This creates a significant safety risk not only for the driver and passengers of the affected vehicle, but also for everyone sharing the roadway. I respectfully urge your agency to investigate this issue and determine whether a broader defect exists involving the rear leaf spring mounting components on 2019 Ford Rangers. If warranted, I ask that Ford be required to issue a recall to inspect and repair affected vehicles before a catastrophic failure results in serious injury or loss of life. Thank you for your attention to this matter and for your efforts to protect the safety of the driving public.

    NHTSA complaint 11745640
13. Filed Jun 10, 2026Failure Jun 4, 2026Flushing, NYPower train

    Hash Shifting and at times kicks into gear hard at a stop light nearly hitting vehicle in front of me

    NHTSA complaint 11743330
14. Filed May 18, 2026Failure Apr 19, 202697,000 milesCedartown, GATread/belt

    The contact owns a 2019 Ford Ranger equipped with Dunlop Tires. Tire Line: AT2O, Tire Size : 265/65R17 110HI, DOT number DAAH D31R. The contact stated that while driving 65 MPH, the passenger-side rear tire blew out. The thread separated and was on the roadway. The contact was able to continue to drive. The contact called a tire center, but they failed to respond. The local dealer was not contacted. The manufacturer was not contacted. The tire mileage was unknown. The failure mileage was approximately 97,000.

    NHTSA complaint 11738570
15. Filed May 7, 2026Failure Dec 18, 2025Bellingham, WAPower train

    My 2019 Ford Ranger is equipped with the 10R80 10-speed automatic transmission that experiences hard/erratic shifting (as if it can't decide what gear it wants to be in), jerking/lunging especially in 1-2 gear when making a brief stop-and-go (stop sign or a crosswalk). The first couple time it happened, it felt like I got rearended or hit a curb.

    NHTSA complaint 11736221
16. Filed May 2, 2026Failure Feb 27, 2026Alzada, MTEngine, Service brakes

    The brakes failed within hours of owning the Certified, WARRANTIED VEHICLE. ALMOST had an accident. Within <5 weeks of owning this warrantied certified vehicle, was stranded on Rine Ridge Indian Reservation and on the highway. Engine jerk so bad feels like I a derby car. Then just stalls. The dont comply with their own 172 point certified inspection. They claim two keys for specified vehicle. They gave me two 1 starts the vehicle the other errors no key in ignition when you insert into ignition. NOW I have to pay bills to get a warrantied certified vehicle repaired plus loaner car because Ford McKie k owing sold an Unsafe vehicle under deceptive pretense. Multiple engine and brake failures which was supposedly certified inspected.

    NHTSA complaint 11735236
17. Filed Apr 27, 2026Failure Mar 18, 2025Payette, IDPower train

    Mileage is at 86980. I have been having issues for a good 10k miles that are slowly getting worse. Transmission is slamming into reverse from park. Shifting is slow from 1st to 2nd gear. Has begun revving engine but not engaging. I have had the transmission fluid changed 3x and flushed and changed the last time. No leakage or overheating. I do not drive her hard, off road or tow. She always gets warmed up before driving. My mechanic believes it is the PCM.

    NHTSA complaint 11734116
18. Filed Apr 26, 2026Failure Apr 11, 2026Thomasville, NCSuspension

    Rear rear leaf spring broken/cracked completely and disconnected from vehicle. The vehicle was unsafe to drive as the axle was not not connected to the vehicle on one side. The defective component was inspected by Firestone Auto and submitted and approved by SilverRock automotive for warranty replacement and is currently at a Ford Dealership completing repairs because Firestone Auto failed to complete the repair properly. There were no warning lamps or messages and it the problem was only noticeable when the vehicle was on a lift or floor jack. The incident is unknown and it the broken part was poor design/materials.

    NHTSA complaint 11733822
19. Filed Apr 20, 2026Failure Apr 19, 2026Huntley, MTSuspension

    JULY 2024 THE RIGHT SIDE BACK LEAF SPRING WAS BROKEN. WAS REPLACED UNDER WARRANTY. APRIL 2026 THE LEFT SIDE BACK LEAF SPRING IS BROKE. WAITING TO HEAR FROM FORD IF IT WILL BE COVERED OR NOT. LEAF SPRINGS SHOULD NOT BE BREAKING. I DO NOT HAUL THINGS OR EVEN GO OFF ROAD WITH MY 2019 RANGER. IT HAS 74012.10 MILES ON IT NOW.

    NHTSA complaint 11732372
20. Filed Apr 17, 2026Failure Feb 27, 2019951 milesMorganton, NCPower train

    The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle hesitated, and the transmission was shifting hard. Additionally, the vehicle vibrated abnormally while shifting from 1st to 3rd gear. The vehicle was taken to the dealer, where the TCM was reprogrammed, and various fluids were replaced; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 951.

    NHTSA complaint 11731902