2025 Ford Ranger

42 complaints on file, page 1 of 3.

1. Filed Sep 28, 2026Failure Sep 28, 2026Mesa, AZPower train

   While driving at 45 mph. The dash changed and the truck started shifting into wheel low. I had to stop and put the truck back into 2 wheel drive. This has happened 5 times since new.

   NHTSA complaint 11767346
2. Filed Sep 25, 2026Failure Sep 10, 2026Cedar City, UTElectrical system

   My 2025 Ford Ranger Raptor will shift drive modes by itself. I has tried to shift from normal drive mode to rock crawl mode or Baja mode. Rock crawl mode goes into 4 wheel drive low which would be very dangerous if it tried to shift into 4 low on the highway. It has happened multiple times. Sometime while parked, sometimes while driving.

   NHTSA complaint 11766922
3. Filed Sep 18, 2026Failure Sep 1, 2026Washington, MOPower train

   I have around 26000 miles on my 2025 Ford Ranger Lariat 2.7l V6. My drive mode has changed on its own multiple times without anyone touching the dial. Recently I was letting it idle to cool the cabin. I hopped in and heard some thunking and saw my drive mode change all the way to slippery mode. Nothing was touching the dial. It has also changed modes while I was exiting my driveway, leaving the Taco Bell drive-thru, and driving down the highway at about 50 MPH. It's scary to think I could be driving down the road and it automatically shifts into 4WD on its own. Sometimes I don't know it's in a different mode until the steering is hard to turn and the wheels chirp. Since then I have been able to trigger the drive mode changes by only pushing down the drive mode selector's bezel, not turning/twisting it. Pushing downwards on the bezel at or just below the 2H label can trigger the drive mode change for me. It's very inconsistent and won't trigger very often. But I was able capture a video of it in case someone is interested. [XXX] No modifications, No Forscan alterations, Happens before and after installing a ford performance tune Before me capturing it on video, I asked the dealer (Sunset Ford [XXX]) about getting it fixed. They told me if they cant reproduce it, then they cant do anything for me and I would be charged for the diagnosis and a car rental. My vehicle is still under factory warranty. Since I created the video I sent it to them and I had to call them multiple times to get them to look at it. I have an appt on XXX, we'll see what happens. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11765304
4. Filed Sep 17, 2026Failure Sep 16, 2026Washington, UTUnknown or other

   When I'm driving in standard mode on the highway the truck software will change to different drive modes on it own. I do not touch anything and it will try to change to crawl mode or 4 wheel low mode even going 65MPH on the freeway. One time it changed on the freeway going 65mph and switch to 4 wheel low and the tach raced up to 8K even though I had slowed down to 25mph. I had to turn the vehicle on and off to correct the issue. This is dangerous.

   NHTSA complaint 11764965
5. Filed Sep 12, 2026Failure May 15, 2026Hot Springs, ARService brakes

   Brake fault warning light stays on. It will not reset and 2 different Ford dealers cannot figure out the problem. The dealerships cannot determine if the brakes are malfunctioning. The problem forst occured May 2026.

   NHTSA complaint 11763760
6. Filed Sep 11, 2026Failure Sep 4, 2026Summerfield, FLElectrical system, Engine, Power train

   Yes this is my second time filing a complaint regarding my new truck switching drive modes on its own. The first time it tried going into 4 low while i was going over 45 mph, with only 800 miles. The next time it did it was at around 1200 miles it switched drive modes completely and tried switching into 4 wd while at hoghway speeds. This is clearly a safety issue, their are numerous threads on reddit, facebook and ranger forums regarding it. Ford cannot replicate so they dont fix, what will it take one of us getting killed before we get a recall for whatever part or module is broken.

   NHTSA complaint 11763583
7. Filed Sep 2, 2026Failure Aug 28, 2026West Allis, WIElectrical system

   2025 Ford Ranger XLT experienced an electrical short-circuit causing a persistent speaker hiss with the vehicle turned off, accompanied by an electrical burning smell. The radio and audio became very staticky and a constant hissing sound with the radio and the truck turned off. By the time the dealer looked at the vehicle it was operating normally. Dealership refused to inspect wiring or ACM due to intermittent nature of the failure.

   NHTSA complaint 11761748
8. Filed Aug 27, 2026Failure Aug 18, 2026Manakin-Sabot, VAEngine, Fuel/propulsion system, Unknown or other

   I am not a mechanic or a 'car person', so I may not know technical terms. This has occurred 4-6 times since purchasing the truck in March '26. After initial start up, it has a tendency to accelerate when applying the break. This is only within the first several minutes after startup. The most recent incident caused the truck to "roll" into the main street rather than coming to a complete stop. I was applying the break, but the truck was 'resisting' to come to a complete stop. The local Ford mechanic found this to be "undesirable, but normal characteristic". The situation that is occurring is anything BUT normal. The Ford dealer was able to replicate the situation, but deemed it to be "no further instructions on fixes or issues related to this concern and no further action can be perfomed" The truck is available for inspection. This is a major safety issue as I was unable to stop the truck before entering the main road. Yes, the truck was inspected by the dealer. There were no warning messages

   NHTSA complaint 11759914
9. Filed Aug 15, 2026Failure Aug 15, 2026Milwaukee, WIElectrical system, Engine, Power train

   Vehicle received and installed an over-the-air software update to the Body Control Module, identified on the vehicle screen as BCM-26.6.3 and associated with Safety Recall 26S29 (A-pillar/sun visor wiring, NHTSA 26V238000). The update screen displayed a status of "Not Completed." Since that update the vehicle will not start and is inoperative. Current condition: opening the driver door wakes the center infotainment screen only. The instrument cluster does not illuminate. Pressing the brake pedal produces no response - no cluster illumination, no warning lamps, no chimes, no messages, no crank. 12V power is present; the manufacturer's telematics app still reaches the vehicle and returns status. Symptoms are consistent with a Body Control Module that is powered but not communicating on the vehicle network. No warning lamps, messages, or symptoms were present before the update. The vehicle operated normally until the update was installed. Safety risk: the vehicle became immobile without warning immediately following installation of a manufacturer-pushed safety recall remedy. The transmission cannot be shifted electronically, requiring the manual park release to move or tow the vehicle. Had this occurred away from home or in a traffic lane, the vehicle would have been stranded and unable to move under its own power. The BCM also governs exterior lighting and hazard lamp function. Note: the update screen header displayed "25S29" while the body text referenced completing Safety Recall 26S29. The vehicle has a dealer-installed Ford Performance ProCal calibration. The vehicle has not yet been inspected by the dealer or manufacturer. It is available for inspection upon request.

   NHTSA complaint 11757184
10. Filed Aug 9, 2026Failure Aug 7, 2026New Braunfels, TXPower train

    Truck is randomly switching to Baja mode which engages the 4wheel drive making steering difficult

    NHTSA complaint 11755760
11. Filed Aug 4, 2026Failure Mar 1, 2026Walnut Creek, CAEngine, Power train

    I was exiting the freeway, and as I was turning off of the freeway onto a side street, at approximately 20mph, my vehicle did not respond to throttle input, and left me slowing to a stop in the middle of a busy intersection. I had to shift my vehicle into neutral and then back into drive, to get it to respond to throttle input. When I slow down at intersections, turn and then attempt to throttle my vehicle, it hesitates and struggles to output power until I throttle about halfway.

    NHTSA complaint 11754755
12. Filed Jul 29, 2026Failure Jul 29, 2026Waynesville, NCUnknown or other

    No incident occurred. This is to report a safety issue related to the activation of the rear view camera while driving forward. There are times when a vehicle (automobile/motorcycle) may be following closely, and the rear view mirrors are inadequate to see the following vehicle clearly. If the rear view camera is activated, the image projected by the camera is obscurred by a message stating "Full View Not Available". There appears to be no way to remove this message so that the image in not obsurred. See attached photo.

    NHTSA complaint 11753447
13. Filed Jul 25, 2026Failure Jul 13, 2026Drums, PAEngine, Power train

    2025 Ranger STX with 950 miles on odometer. When starting vehicle with transmission in park, a pronounced clunk/thump is heard and felt. The clunk/thump varies in intensity with the most intense episode resulting in the physical slight rearward movement of the truck. Symptom seems to be more prevalent when vehicle has been dormant for a few hours or overnight. Initially thought vehicle was going to lunge rearward by physical movement of truck. No warning lights were present with the event. Dealer appointment is scheduled later next week. vehicle is availabe for inspection upon request.

    NHTSA complaint 11752830
14. Filed Jul 19, 2026Failure Nov 30, 2025Elmwood Park, ILUnknown or other

    Rear view camera has significant delay, lag, or stutter at times, in reverse, more noticeably at faster that idle reverse speeds.

    NHTSA complaint 11751384
15. Filed Jul 14, 2026Failure Jul 11, 2026Cottage Grove, ORPower train

    I believe this is a transmission problem; however, not sure if it could be program related. The main safety issue is after taking off from a stop, the truck just stopped accelerating and hesitated, as if though it got "stuck" trying to change gears. This issue has happened a few times, once with my Wife in the truck, who looked at me like what the heck was I doing. This definitely creates a situation for a rear impact collision if the person behind you didn't hit the brakes soon enough. The transmission also seems to "clunk" real hard at times when coming to a stop, as if though it is switching gears from say 4th down to 1st, skipping 3rd and 2nd gears. I did report this to Kendall Ford of Eugene and they said it shifts just the same as all of the other Rangers with this same transmission. I received no warning lamps, symptoms, or messages.

    NHTSA complaint 11750277
16. Filed Jun 18, 2026Failure May 21, 2026Knoxville, TNElectrical system, Power train

    While driving at highway speeds vehicle changes the drive mode at random. Even attempting to go into 4 low at high speeds. If the vehicle is able to change into 4 low at high speeds this could send the vehicle into uncontrollable lock down to the drive train and potently creating uncontrollable spin out. Car has been at the dealership for this issue, but they cannot find any problems or able to replicate the issue.

    NHTSA complaint 11744966
17. Filed Jun 17, 2026Failure Apr 10, 2026Avon Park, FLEngine, Power train, Vehicle speed control

    On 6-7 separate occasions, my 2025 Ranger had a sudden and complete loss of accelerator response while slowing down to make a left turn. This also happens on occasion at traffic lights when the light turns and I attempt to turn left. The duration of loss of power has increased with each incident and is very frightening when it occurs. When attempting to accelerate across the road, there was no response or power from the engine to get me through traffic. On each occasions, the safety of everyone in my vehicle as well members of the public were at great risk. It is only by good luck that these engine failure incidents did not cause a serious crash. The local Ford dealer has been unable to identify the problem. Until and unless the Ford Dealer can replicate the problem, I am unable to get the problem resolved. In the meantime, I feel that I my life is at risk every time I drive my truck. There were no warnings from the vehicle about this loss of power and the randomness of this causes great fear when driving. The incident appears to be the same as Recall 26V343000, Loss of Drive Power from Engine Failure, which does not include my specific VIN.

    NHTSA complaint 11744742
18. Filed Jun 16, 2026Failure Jun 16, 2026Summerfield, FLEngine, Power train, Vehicle speed control

    Purchased this truck new and took on a trip over the weekend. Put on just under 800 miles no issues. This morning while driving to get my wondows tinted I noticed my truck flashing to apply brakes as it was trying to shift itself into 4wd low setting. Sure enough i looked over and the truck was switching drive modes when no one had touched it. Nothing in my cupholder either that could have accidentally bunped it either. I quickly pulled over and pressed the 2 wheel drive button and restarted the truck. I did a quick google search and found that others are having this issue too. I cant even imagine what damage it would have done to the vehicle or myself if it fully shifted over while driving at highway speeds.

    NHTSA complaint 11744564
19. Filed Jun 4, 2026Failure May 9, 2026Catheys Valley, CAElectrical system

    My Ford Ranger is on a safety recall. They sold it to us on May 9,2025 then kept the truck. June 1 they told use the recall issue was solved. We were not given documents on this. We are now seeing the parts needed are not available until the end of June. A Fedaral and State law was broken in selling us a vehicle on a safety recall. We were not aware of this issue until we research the recall. I am so frustrated. We lost a month of use of this vehicle In waiting. So frustrated.

    NHTSA complaint 11742182
20. Filed May 31, 2026Failure Apr 13, 2026Conyers, GAAir bags, Steering, Vehicle speed controlCrash1 injured

    The Ford dealership completed repairs on my vehicle and returned it by parking it in front of my garage. I have a long driveway and additional parking and needed to park the vehicle somewhere else (maybe 20-30 feet away). I reversed the truck ~20 feet and when I tapped the gas lightly to turn the car left to pull into the parking space it accelerated rapidly. I pressed the brakes repeatedly and the car didn't stop and barely slowed down after noticing that continuing to turn the steering wheel to the left did nothing. I tried cutting the wheel and the tires seemed unresponsive and the vehicle didn't stop until it hit a small tree on the right side of the parking area. Upon trying to move the vehicle back to the original parking space the vehicle seemed to only allow steering to the right and hit a tree on the right passenger front door. The airbags, part of the service work previously completed from another recall, didn't deploy despite having an 85lb passenger in the vehicle. The dash flashed with many sensors when I initially tried to stop the vehicle when it was in drive. The vehicle is available for inspection. The safety of myself and my passenger were at risk. I was transported to the ER. The problem was not confirmed by anyone yet. The vehicle was inspected by police visually and damages documented in the police report. I have not spoken to the dealer as I'm now weary of their service center practices since this occurred the first time I drove the vehicle after they made the repairs for the passenger airbag and brake recalls.

    NHTSA complaint 11741145