Trailer, Not Applicable, built in United States. Owner complaints on file from May 28, 2019 to Jun 2, 2025.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 19V-570 | Aug 2, 2019 | Pin boxes may have been equipped with bolts 1-3/4" in length when they should be equipped with 2" long bolts | Trailer hitches | 1,809 | Part replacement |
| 19V-317 | Apr 19, 2019 | Wiring for the front bedroom air conditioning may have been improperly installed and may come in contact with the heat strip in the air conditioner | Electrical system | 10 | Repair or modification |
| 19V-084 | Feb 8, 2019 | Bunk bed door latch fasteners that secure the bunk bed door closed may fail, allowing the door to open while moving | Latches and locks | 85 | Repair or modification |
| 19V-069 | Feb 1, 2019 | Break-away safety switch may be improperly wired, and as a result, the trailer brakes will not apply in the event that the trailer disconnects… | Brakes | 2,454 | Repair or modification |
| 18V-678 | Sep 27, 2018 | Brake mounting flanges on the torsion axles may be incorrectly oriented, which can result in premature brake failure | Suspension | 1,785 | Part replacement |
| 18V-475 | Jul 18, 2018 | Inner wheel bearings may seize, which can cause the trailer wheels to lock-up | Suspension | 164 | Part replacement |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
7 complaints on file, page 1 of 1.
I setup my camper and turn the hot water heater on using the propane setting. I left the camper and came back and could smell something hot/burning inside the camper. I looked at the rubber propane line connected to the hot water heater was on fire. I opened the cover to the hot water heater and blew the flame out. Propane was leaking from the rubber line that was cracked. I turned the gas off to prevent additional fire. The gas line appeared to by dry rotted. The camper would have burned if I didnt catch the line on fire. The line was replaced, but should have been a better line. I made the repair myself and did not report it to the manufacturer or anyone. There was no warning of the fire until I bought the fire outside.
NHTSA complaint 11664455The Castle Rock spare tire failed while on the rim mounted to spare tire holder. Tire was covered 24/7. Size st 205/75r14 Failure was in belts on tread. Large bubble on inside of tire under treads with outside of tire deformed. Pictures available Tire was never used. Air pressure checked with other tires before usage.
NHTSA complaint 11524032Tire blowout on single axel travel trailer ST205/75 R14
NHTSA complaint 11481872Two of the Frame Bolts underneath the front of our E-Pro 19FBS camper are partly rusted and missing a nut (one on driver side and one on passenger side). The bolt on the passenger side is out of the metal frame hole it should be in, and the metal frame is slightly bent. Both bolts are at a slight angle. The other 10 Frame Bolts are not visibly rusted and there is a nut on each one but a few are loose enough to twist off by hand. The others seem tight enough but we can’t be sure without knowing what torque number they should be tightened to. We double checked the Forest River owner’s manual but there is no mention of Frame Bolts in the 'maintenance' list or anywhere else. Also, there are no lock washers on the frame bolts to prevent self-loosening. This is surprising because it seems these frame bolts are the only thing holding the body of our camper to its frame. We have owned our camper a little over 3 years and we use it 3 to 5 times a year to travel short distances, all on main roads and major highways for camping only on paved or gravel leveled lots. We have never taken the camper off road or towed a heavy load. Our frame bolts should not be so loose that two bolt nuts fell off and a few can be twisted off by hand. We are reporting this Frame Bolt failure because it is something that can cause separation of the RV box from its frame while in motion. We routinely check everything on the camper but not everyone does unless there is a reason to. Maybe what we found is not a common issue but it is worth reporting because paying special attention to Frame Bolts during production (Forest River) , at point of sale (Dealership) and as part of routine maintenance (RV Owner) could save a life. We sent an email to Forest River yesterday describing the problem and requesting they cover the cost of repair. Nobody has inspected our camper except for us because we just discovered the issue last weekend during routine camper maintenance.
NHTSA complaint 11463794The contact owns a 2019 Forest River Flagstaff Micro Lite equipped with Lionshead Tires, Tire Line: Castle Rock, Tire Size: 205/75/R14, DOT number: UJTYMT418. The contact stated that while driving 40-55 MPH, the driver's side rear tire went flat. The tire pressure monitoring system was beeping. The vehicle was taken to an independent mechanic and the contact was informed that the tread was separating. The tire was replaced however while driving at an undisclosed speed the TPMS was beeping and the driver heard an abnormal sound. The contact pulled over and noticed that the passenger’s side rear tire was flat. The contact stated that while the vehicle was parked, the passenger’s side front tire went flat. The manufacturer was not contacted. The tire failure mileage was approximately 700.
NHTSA complaint 11438421. THE STABILIZING JACKS ARE DEFINITELY JUST FOR STABILIZING. WE THOUGHT THEY WOULD TAKE THE LOAD OF THE RV. 4 JACKS TO SUPPORT 1 RV. THE WARNING ON THE JACKS IS LOCATED ON THE TOPSIDE OF THE JACK, SO A CLUELESS, NEW RV OWNER WOULD NOT SEE THEM UNTIL THE JACKS ARE DOWN. ALSO THE DOCUMENTATION DOES NOT SAY THE JACKS ARE NOT LOAD BEARING. MY ONLY EXPERIENCE WITH A SCREW JACK IS FROM MY CAR AND CHANGING A TIRE. LONG STORY SHORT, WE BENT 2 OF THE 4 JACKS B/C WE THOUGHT THEY COULD TAKE THE RV LOAD TO LEVEL THE RV ON UN-EVEN GROUND. LUCKILY NO ONE WAS HURT AND NO OTHER DAMAGE. *TR
NHTSA complaint 11327695TL* THE CONTACT OWNS A 2019 FOREST RIVER FLAGSTAFF E-PRO. THE CONTACT STATED THAT BIKE RACK PINS WERE CORRODED. THE CONTACT STATED THAT THE BIKE RACK WAS UNUSABLE AND SHE WAS CONCERNED THAT THE RACK WOULD DETACH FROM THE TRAILER. THE TRAILER WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REQUESTED THE CONTACT TO SEND PICTURES OF THE FAILURE. THE CONTACT STATED THAT THE MANUFACTURER OFFERED NO RESOLUTION OF THE FAILURE AFTER SEVERAL MONTHS OF COMMUNICATION. THE VIN WAS UNKNOWN. THERE WAS NO MILEAGE.
NHTSA complaint 11210344Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall.