Motorcycle, gasoline, built in United States. Owner complaints on file from Sep 29, 2015 to Oct 18, 2022.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 15V-427 | Jul 6, 2015 | Affected motorcycles have saddlebag mounting receptacles that may not adequately secure the saddlebags to the motorcycle | Equipment | 185,272 | Part replacement |
| 15V-216 | Apr 13, 2015 | On July 31, 2015, Harley-Davidson expanded the recall to cover an additional 61,065 motorcycles | Powertrain | 106,966 | Not stated |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
10 complaints on file, page 1 of 1.
Saddlebag fell off while driving. Dealer inspected and did not find cause. Previous recall fix had been completed.
NHTSA complaint 11489836CLUTCH BECAME FROZEN IN GEAR REQUIRING TOWING. EVENT OCCURRED TWICE. DIFFICULTY GETTING INTO NEUTRAL. DEALER MADE REPAIRS AT MY EXPENSE. THERE WAS A RECALL FOR THESE ISSUES FOR LATER MODELS!
NHTSA complaint 11182611AFTER SITTING IN THE SUN APPROX. 8 HOURS, WHILE IN MOTION, ENGINE DIED APPROX. 2 SECONDS WHEN STOPPING, TURNING OR ACCELERATING. 1 TIME ENGINE SPUTTERED WHEN IT DIED AT A STOP, THE OTHER TIMES ENGINE JUST STOPPED RUNNING. STARTED RIGHT BACK UP. OK IF FUEL TANK AND PCM (SEAT) ARE COVERED OR BIKE IN GARAGE. BEEN TO DEALERSHIP TWICE, THEY WERE UNABLE TO VERIFY. DIED SEVERAL TIMES FROM 3/18/17.
NHTSA complaint 11143417ON INTERSTATE WATER PUMP FAILURE AT 9000 MILES ON THE BIKE. HAD THE WATER PUMP REPLACED AT DENVER HARLEY COST $810.00
NHTSA complaint 111408072015 HARLEY DAVIDSON FLHTK. CONSUMER WRITES IN REGARDS TO DISTURBING ENGINE IMPLOSION. *LD THE CONSUMER STATED WHILE DRIVING AT HIGH SPEEDS THE ENGINE ON THE VEHICLE BLEW. *JS
NHTSA complaint 11111614SPARK PLUG WIRE LEADING TO FRONT CYLINDER RUBS AGAINST THE FUEL TANK, LEADING TO ABRASION THROUGH THE INSULATION OF THE SPARK PLUG WIRE. REPLACEMENT OF PARK PLUG WIRE UNDER WARRANTY DENIED BY FORT BRAGG HARLEY DAVIDSON. ABRASION THROUGH THE INSULATION BY CONTACT OF THE FUEL TANK COULD LEAD TO FIRE OR EXPLOSION SHOULD THE WIRE ARC ON THE FUEL TANK OR IF FUEL LEAKS.
NHTSA complaint 11072438CLUTCH BEGAN SLIPPING AT 14,000 MILES WHILE IN 6TH GEAR WHILE ON INTERSTATE. RESULTED IN EVASIVE MANEUVERS BEING TAKEN BY MYSELF AND OTHER MOTORISTS TO AVOID COLLISION, AS I WAS IN THE MIDDLE LANE. DEALERSHIP STATED THAT THE CLUTCH IS NOT COVERED IN WARRANTY.
NHTSA complaint 11072437DECEMBER 23, 2016, WHILE RIDING MY HARLEY DAVIDSON FLHTK ULTRA LIMITED MOTORCYCLE AT APPROXIMATELY 45 MPH ON A STRAIGHT SECTION OF INTERSTATE 295 IN THE DISTRICT OF COLUMBIA, THE RIGHT SADDLEBAG MOUNTING PINS DETACHED FROM THE RECEPTACLES, ALLOWING THE SADDLEBAG TO DETACH FROM THE MOTORCYCLE. THIS UNWANTED EVENT CAUSED A TRAFFIC HAZARD FOR OTHER MOTORISTS. THE WEATHER WAS CLEAR AND THE ROAD SURFACE WAS DRY AND RELATIVELY EVEN. THE SADDLEBAGS WERE CHECKED APPROXIMATELY 25 MINUTES BEFORE THE EVENT, PRIOR TO OPERATING THE MOTORCYCLE, AND NOTHING UNUSUAL WAS OBSERVED. THIS EVENT OCCURRED AFTER RECALL WORK WAS PERFORMED TO REPLACE THE ORIGINAL DEFECTIVE PIN CONNECTORS (NHTSA CAMPAIGN NUMBER: 15V427000). THE REPLACEMENT DESIGN OF THE PIN CONNECTORS HAS NOT RESOLVED THE ISSUE THAT COULD LEAD TO UNWANTED DETACHMENT OF THE SADDLEBAGS. AN INSURANCE CLAIM HAS BEEN FILED WITH GEICO MOTORCYCLE AND IS IN PROCESS. PHOTOS HAVE BEEN TAKEN.
NHTSA complaint 10937407DECEMBER 23, 2016, WHILE RIDING MY HARLEY DAVIDSON FLHTK ULTRA LIMITED MOTORCYCLE AT APPROXIMATELY 45 MPH ON A STRAIGHT SECTION INTERSTATE 295 IN THE DISTRICT OF COLUMBIA, THE RIGHT SADDLEBAG PINS FROM THE RECEPTACLES, ALLOWING THE SADDLEBAG TO DETACH FROM THE MOTORCYCLE. THIS EVENT CAUSED A TRAFFIC HAZARD FOR OTHER MOTORISTS. THE WEATHER WAS CLEAR AND THE ROAD SURFACE WAS DRY AND RELATIVELY EVEN. THE SADDLEBAGS WERE CHECKED APPROXIMATELY 25 MINUTES BEFORE THE EVENT, PRIOR TO OPERATING THE MOTORCYCLE, AND NOTHING UNUSUAL WAS OBSERVED. THIS EVENT OCCURRED AFTER RECALL WORK WAS PERFORMED TO REPLACE THE ORIGINAL DEFECTIVE PIN CONNECTORS (NHTSA CAMPAIGN NUMBER: 15V427000). THE REPLACEMENT DESIGN OF THE PIN CONNECTORS HAS NOT RESOLVED THE ISSUE THAT COULD LEAD TO UNWANTED DETACHMENT OF THE SADDLEBAGS. AN INSURANCE CLAIM HAS BEEN FILED WITH GEICO MOTORCYCLE AND IS IN PROCESS. PHOTOS HAVE BEEN TAKEN AND WILL BE UPLOADED.
NHTSA complaint 10937339WHILE ON A TRIP THROUGH COLORADO I WAS DESCENDING A STEEP MOUNTAIN GRADE. I APPLIED LIGHT PRESSURE TO THE FRONT BRAKE AND FELT A VIBRATION IN THE FRONT END. AS I INCREASED THE FRONT BRAKE PRESSURE WHILE ATTEMPTING TO SLOW FOR A TIGHT TURN, THE VIBRATION INCREASED UNTIL THE ENTIRE MOTORCYCLE SHOOK. THE VIBRATION CEASED ONCE THE SPEED WAS REDUCED BELOW ABOUT 30 MPH OR BRAKE PRESSURE WAS RELEASED. THIS SITUATION CAUSED ME SURPRISE AND DISTRACTION IN A CRITICAL STAGE OF OPERATION AND IT IS MY BELIEF THAT LOSS OF CONTROL IS POSSIBLE IN CERTAIN SITUATIONS. I IMMEDIATELY CALLED MY DEALERSHIP AND AFTER SEVERAL CALLS TO HARLEY DAVIDSON FOR ADVICE THEY REPLACED THE TWO FRONT ROTORS THAT HAD BEEN CHECKED TWICE AND FOUND TO BE WITHIN "SPECS." VEHICLE NOW OPERATES NORMALLY.
NHTSA complaint 10778492Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall.