SUV, gasoline, 4WD/4-Wheel Drive/4x4, built in United States. Owner complaints on file from Aug 6, 2017 to Sep 21, 2026.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 17V-358 | Jun 5, 2017 | In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the… | Latches and locks | 437,400 | Part replacement |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
69 complaints on file, page 1 of 4.
Odometer Fraud. The contact purchased a 2016 Hyundai Santa Fe Sport. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the Facebook Marketplace advertisement and odometer reading were 114,841 miles. However, approximately one hour later, it was discovered that the title listed the mileage at 170,395.
NHTSA complaint 11765865The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while the vehicle was parked, there was an abnormal knocking sound coming from the engine compartment. The vehicle was towed to a dealer where it was diagnosed that there was coolant in the engine and that the knock sensor detection system needed to be replaced. The dealer made the contact aware of Manufacturer Campaign Number: 953 and stated that the vehicle was not previously serviced under the campaign, so the vehicle could not be repaired. The manufacturer was notified of the failure. The failure mileage was approximately 111,000.
NHTSA complaint 11762873Was traveling along a city street with parked cars on the passenger side of my vehicle. Axle or wheel broke and veered into parked vehicle severing the engine wiring harness not allowing the airbag to deploy.
NHTSA complaint 11761994The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while driving approximately 65 MPH and attempting to overtake another vehicle, the vehicle lost automotive power and decelerated with the check engine, battery, and oil warning lights illuminated. The vehicle was parked on the shoulder of the highway, and smoke was coming from under the hood of the vehicle. The contact stated that after parking on the shoulder, the brakes erroneously activated, and the vehicle failed to move forward. The contact stated that moments later there were flames and smoke was coming from under the hood. The contact exited the vehicle. The Fire Department was called to the scene, and the flames were extinguished by the firemen. The vehicle was destroyed in the fire. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The manufacturer and local dealer were not contacted. The failure mileage was 105,225.
NHTSA complaint 11755852my BSD sensor would go on and off for the last several months when no one was around me. I work early and even when I was alone on the road the BSD would flash for 2-3 mins and go off.. then my fan for my air conditioner stopped. When I removed the glove compartment to see the wire connecting to the fan is "melted". When i called bob king hyundai, I was informed there was no recall. So, I attempted to fix the issue myself only to find the fuses (under the hood) are almost all bad. The tips of the fuses will not pull out. only the body of the fuse. With all this happening over the last several days and by the way, the vehicle passed inspection. I wanted to reach out as this is definitely a fire hazard and a huge concern.
NHTSA complaint 11753163The engine (2016 Hyundai Santa Fe 2.0L/2.4L Theta II GDI engine) suffered a catastrophic internal mechanical failure, specifically related to the known connecting rod bearing defect. The vehicle is currently un-driveable and is located at Serra Hyundai in Trussville, AL. The vehicle and its failed engine are available for inspection upon request. The engine suddenly failed and lost all power while driving at highway speeds in active traffic. I was forced to coast a dead vehicle across multiple lanes of traffic to the shoulder without any acceleration capability. Yes. The vehicle experienced a complete failure, cannot be restarted, and is currently parked at an authorized Hyundai dealership The vehicle is currently at an authorized Hyundai dealership awaiting a formal corporate inspection and evaluation for engine replacement approval. It has not been inspected by police or insurance. There were no long-term warning lamps, messages, or symptoms prior to the incident. The vehicle was operating normally until the exact moment of the failure, when the engine suddenly began knocking loudly, lost power, and stalled within seconds.
NHTSA complaint 11747757The vehicle is a 2016 Hyundai Santa Fe Sport. It had previously been included in an engine-fire-related recall/service campaign, and Hyundai replaced the engine between approximately October 2024 and January 2025 at about 113,000 miles. About 10,000 miles and 14 months later, the vehicle developed engine/performance problems. A Hyundai dealership service center performed about $6,500 in repairs, including installation of a new transmission, and represented that the engine and transmission had a lifetime guarantee. One day after the vehicle was returned from the dealership, the engine compartment caught fire while the vehicle was being driven. The fire rapidly escalated, the vehicle exploded/burned, and the vehicle was destroyed down to the frame. The occupants escaped, but the incident created an immediate risk of serious injury or death. The failed component appears to involve the engine, engine compartment, fuel/oil/electrical systems, transmission-related repair area, or another drivetrain component. The vehicle remains may be available for inspection depending on insurance/tow/storage status. The vehicle had recently been repaired and inspected by a Hyundai dealership service center. This incident raises concern that the recall-related engine-fire risk, replacement engine, recent dealership repairs, transmission installation, or related components may have failed and created a serious fire hazard.
NHTSA complaint 11745727After driving the vehicle around all day, I parked it and turned it off and then it set on fire.
NHTSA complaint 11745648The vehicle stooped running while driving and will not start, available for inspection upon request. The vehicle or component has not been inspected by the manufacturer, police, insurance representatives or others. There were no warning lamps, messages or other symptoms of the problem prior to the failure.
NHTSA complaint 11743935The engine powertrain system, specifically the internal engine lubrication, timing chain, and camshaft sensors. The vehicle's Theta II engine suffers from systemic, excessive oil consumption, which starved the engine of lubrication. This caused the timing chain to stretch and mechanically fail, and compromised the camshaft sensors. The vehicle is currently un-repaired and is available for inspection upon request at Hyundai of Downtown LA. While driving, the engine suddenly stalled and completely shut off mid-drive without warning. This caused an immediate loss of motive power and a dangerous reduction in steering and braking control while surrounded by active traffic. Operating a vehicle that randomly shuts down on public roads presents an extreme, life-threatening safety hazard to myself, my passengers, and other drivers. Furthermore, the dealership is attempting to force me to drive the vehicle for an additional 1,000 miles in this stalling, un-repaired condition to complete a corporate oil test, compounding the safety risk. The failure and safety hazard have been physically confirmed and diagnosed by an authorized dealership: Hyundai of Downtown LA (3850 S Figueroa St, Los Angeles, CA 90037). Their service department mechanically diagnosed the physical failure of the camshaft sensors, a stretched timing chain, and severe engine oil starvation. There were absolutely no dashboard warning lights, check engine lights, low oil pressure lamps, or messages prior to the engine stalling and shutting off. The vehicle computer failed to trigger any diagnostic trouble codes (DTCs) or dashboard warnings to alert me to the low oil level or the impending mechanical timing failure before the vehicle completely shut down mid-drive.
NHTSA complaint 11740491The engine seized up and hyundai refused to approve my claim al though i had the extended warranty. Reason for the denial because a recall in 2019 was not performed. I had purchased the vehicle in 2023 used from Rick case honda.
NHTSA complaint 11737803My car only has 93,000 miles on it. I was driving home from work and all of a sudden the check engine light came on while I’m on the freeway. I made it home and went to research then all of a suddenly the check engine light would just start flashing. I got it checked by a mechanic. They said that there was metal shavings in the oil which I have no clue how that would happen and that there was a code for knocking.
NHTSA complaint 11735585Connecting rod bearing failure, stated a recall was active but it hadn't been assigned to my vehicle. Vehicle went into engine failiure and does not have appropriate measures to prevent engine failiure. No warning messages prior to engine failiure.
NHTSA complaint 11730270While driving the vehicle at approximately at 55 MPH on a the 826, the engine suffered a sudden and catastrophic mechanical failure without warning. The vehicle lost all motive power in active traffic, creating an immediate safety hazard and nearly resulting in a rear-end collision. Upon inspection, it was determined that the engine assembly, which is a replacement unit provided by Hyundai under the Theta II Settlement, with less than 12,000 miles, suffered an internal breach. This breach allowed coolant to contaminate the lubrication system sort of a milky oil, which led to a connecting rod bearing seizure. Despite this being a repeat failure of a safety-recall component and the vehicle being covered under the Theta II Settlement Lifetime Warranty, Hyundai Motor America has denied the repair claim. I am reporting this as a safety defect because the sudden engine stall resulted in a loss of power-assisted steering and braking while the vehicle was in motion.
NHTSA complaint 11726371The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while the vehicle was parked and running, there was an abnormal fuel odor inside the vehicle. The contact exited the vehicle and inspected it. The hood was opened, and the engine cover was removed, and there was condensation dripping from the fuel pump. The contact’s brother inspected the vehicle and became aware of the strong fuel odor and the condensation dripping from the high-pressure fuel pump. The vehicle was then taken to a dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint 11723852The engine light started blinking and my car would not accelerate anymore. I took it to the mechanic immediately, who said that there was an engine recall. I contacted the dealership, but they cannot do an initial inspection for more than 2 months. It would likely take another 2-3 months after the inspection before the engine can be replaced. I called Hyundai and they confirmed that my vehicle should be covered under an extended warranty based on the service history and error code from my car (TXXI for the Theta 2 engine - knock sensor detection, code p1326). However, Hyundai will not provide any help until the vehicle is inspected by a dealership. The dealership completely refuses to look at my car as they are busy. I live on an island, so the only other Hyundai dealership is two hours away. They will not answer any of my calls. I'm expected to figure out how to commute to work alone for the next two months, but since I live in a rural area, there are no alternative transportation options. An independent mechanic confirmed and reproduced the issue. The car is unsafe to drive. The dealer will not inspect my component in a reasonable time frame, much less repair it despite the fact that it is covered under extended warranty. The car was driving normally prior to the issue, and I did not notice any problems until the engine light started blinking. I have the car available for inspection.
NHTSA complaint 11718660I turned off the car and went inside the house. I was outside and could smell smoke. I walked to the front of the house and saw my neighbor who was calling 911 due to flames from my engine. The flames reached the yard and my garage where minor damage occurred. The vehicle was completely engulfed in flames before the fire department extinguished it.
NHTSA complaint 11716330The contact owns a 2016 Hyundai Santa Fe Sport. While driving at an undisclosed speed, there was an abnormal odor coming from the vehicle. The contact stated that the engine was consuming an excessive amount of engine oil. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that on a separate occasion, while driving at an undisclosed speed, there was an abnormal sound coming from the engine. The vehicle was pulled over to the side of the road; and the check engine warning light illuminated. A handheld scanner was used to retrieve DTC: P1326 (KSDS – Connecting rod bearings failure). The vehicle was towed to the residence, and then towed to the dealer. The dealer diagnosed the vehicle and informed the contact that the rod bearings had failed, causing engine failure. The dealer notified the manufacturer of the failure; however, the manufacturer declined to repair the vehicle. The manufacturer informed the contact that the prior owner had submitted a complaint regarding the failure in January of 2024. The vehicle remained at the dealer unrepaired. The failure mileage was approximately 132,000.
NHTSA complaint 11714583The sunroof glass suddenly shattered while driving slowly into a parking lot.
NHTSA complaint 11713385Six weeks ago the alternator and battery had also been replaced. My Hyundai Santa Fe Sport turbo engine, exhibited a persistent rubber-like odor for approximately three weeks after the latest maintenance. During this period, the push-start button intermittently failed, requiring multiple attempts to engage, and the vehicle experienced noticeable shaking. After being parked, smoke began to emerge from under the hood, followed by visible flames. Within roughly 3-5mins minutes, the vehicle was completely engulfed in fire and blew up 6 times. Notably, the car had undergone significant repairs in the past year, including an engine replacement, starter, OEM parts, O2 sensors, brakes, valve cover gasket, new tires, and routine oil changes.
NHTSA complaint 11702863Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.