2020 Hyundai Sonata

178 complaints on file, page 1 of 9.

1. Filed Sep 7, 2026Failure Sep 3, 2026Van Buren, ARElectrical system

   A/C blower motor fan would stop working. Happened twice within less than a year apart. Upon further inspection, multi fuse wiring overheated and melted, ruining fuse and making A/C stop working during 100+ temperatures outside. Apparently this is a well known issue with this make and model Sonata. Electrical failure.

   NHTSA complaint 11762639
2. Filed Sep 3, 2026Failure Sep 3, 2026Angier, NCEngine

   The A/C evaporator core and the core seal needs replacing on 2020 Hyundai Sonata. Car is 6 years old. I already have a confirmed diagnosis with a PPM refrigerant leak tester at the condensate drain line The diagnosis is 100% confirmed. The evaporator is leaking heavily—we pulled 274 PPM at the drain tube and 177 PPM inside the cabin behind the glove box so refrigerent has been leaking out of the vents. My wife and I were getting headaches for no reason. Our AC has failed and this problem was discovered as the issue and I am paying out of pocket to fix something that should not have failed and has leaked out refrigerent.

   NHTSA complaint 11761990
3. Filed Sep 3, 2026Failure Aug 10, 2026Pearland, TXElectrical system, Power train

   I am submitting a safety complaint regarding a recurring, unresolved electrical defect in my 2020 Hyundai Sonata SEL. The vehicle fails to recognize when the ignition is switched off, leaving core vehicle systems active and causing severe parasitic battery drain that leaves the car immobilized. ​Description of the Problem: ​False "On" Status: After parking, turning off the engine, and exiting the vehicle, the car continues to register as though the ignition is still active/on (accessories, cluster, or vehicle network remain awake). ​ Severe Parasitic Draw: Because the vehicle fails to shut down its electrical circuits, the 12-volt battery repeatedly discharges overnight or while parked for short durations. ​Battery Replacement Did Not Resolve Issue: The 12-volt battery was replaced with a brand-new unit to eliminate typical wear, yet the drain and false "on" behavior persisted immediately. ​ Frequency: The vehicle frequently fails to start, requiring constant jump-starts or roadside assistance to operate. ​Safety Hazard: This defect creates a direct safety risk by repeatedly stranding the driver without warning in public locations, traffic stops, or remote areas. In addition, an electrical system that fails to enter a sleep state creates a potential hazard for component overheating, failure of electronic security and locking systems, or total electrical failure while attempting to restart or operate auxiliary safety equipment. Other Hyundai owners have reported identical issues where the body control modules or ignition logic fail to power down. ​Corrective Action Requested: I request that the NHTSA investigate this electrical shutdown defect across the 2020 Hyundai Sonata model year to identify whether a faulty Body Control Module (BCM), smart key receiver, or ignition switch relay requires a safety recall and software or hardware remediation. Battery replaced on 09/04/2026 Car inspected/diagnosed by Hyundai Dealership on 09/03/2026

   NHTSA complaint 11761900
4. Filed Aug 26, 2026Failure Aug 26, 2026Shelby, NCElectrical system, Automatic emergency braking, Service brakesCrash

   Parking malfunction. Parked, running car moved itself to reverse and backed up a driveway crossing a dirt road and hitting a fence and post. This car could have hit and severely injured anyone who was in the path while it was reversing on its own. Car was in reverse and all parking sensors were blaring when the car was found minutes later.

   NHTSA complaint 11759884
5. Filed Aug 23, 2026Failure Aug 1, 2024Chandler, AZCamera

   The reverse camera only shows a black screen and will put drivers in danger while not being able to see behind them while reversing. This needs to be recalled and repaired. Especially in situations where a person is reversing out of a driveway onto a major/busy road. Sometimes it works, but a lot of the time it is just a black screen with the green, yellow, and red lines to indicate how far your wheel is turned. But it doesn’t allow you to actually SEE where you’re backing up into or the cars coming from either side of you while trying to back out. It’s very dangerous and it seems to a be manufacturer’s defect that needs to be addressed by the company itself, since they’re the ones who made and installed the product incorrectly.

   NHTSA complaint 11758919
6. Filed Aug 23, 2026Failure Aug 21, 2026New Athens, ILElectrical system, Unknown or other, Visibility/wiper

   Blower motor malfunction at night. Smelled something burning. Extremely hot and humid outside. Windows fogged up inside which greatly reduced visibility. Checked the multifuse which controls the ABS, oil pump, cooling fan, & Blower. I discovered a burnt connection on one of the terminals for the blower. This is a huge safety and fire risk and needs to be addressed ASAP!!!! Upon my research, I’m finding several Hyundai Sonata vehicles having this same exact issue. Kia vehicles are being recalled for this same exact issue. Why isn’t the Hyundai Sonata??

   NHTSA complaint 11758874
7. Filed Aug 20, 2026Failure Aug 13, 2026Gulfport, FLSeats

   The driver's power seat track master assembly (Part#88500-L0030) on my 2020 Hyundai Sonata suffered a catastrophic structural failure while operating. The black plastic bracket housing and aligning the electric drive motor fractured. This caused the motor to pull out of alignment, twisting the driver's seat violently sideways and permanently jamming the tracking rails. This is a chronic, repeat safety component failure on this specific VIN. The original factory seat track assembly suffered an identical mechanical failure and was replaced by warranty on 10/3/2023 at 46,369 miles. This second factory replacement unit failed in exactly the same manner on 8/13/2026 at 82,271 miles-lasting only 35,902 miles under normal operating conditions. I weigh 95 pounds. A driver's seat structurally shifting sideways dynamically presents an immediate, severe crash hazard. It instantly alters driver ergonomics, compromises the structural crash-anchoring performance of the seat frame, and potentially restricts pedal access to the brake and accelerator. The manufacturer is actively denying product liability by classifying internal structural breakages of shielded components beneath the cushion as user "damage" rather than an engineering or climate-related material defect. This tracking component must be formally investigated for systemic failure patterns to prevent accidents.

   NHTSA complaint 11758369
8. Filed Aug 18, 2026Failure Aug 18, 2026Millville, NJElectrical system

   The AC/heating blower motor circuit on my 2020 Hyundai Sonata failed intermittently due to extreme electrical resistance overheating and melting the terminal pins inside the engine fuse box. I took it to the dealership and they inspected it said it was out of warranty but it needed part number 18980-09910-FFF and wiring kit 91300L1000-FF to repair at a cost of 780.00 including parts, tax, and labor. This matches the severe design defect acknowledged in Hyundai TSB #25-EE-002H or alternative TSB-24-EEOO-1H. I filed case number 43138757 with Hyundai corporate. For now this just affects my air conditioning. However, the root failure is a known design defect that presents a severe vehicle fire hazard and potential loss of windshield defrosting capability, lights, etc. if the whole electrical system should fail. As you should know the engine bay fuse box (which currently has melted parts) is the "brain" for the car's electrical distribution. It doesn't just power my AC fan; it holds the fuses and relays for the cars fuel pump, engine control module (ECM), headlights, and electronic power steering. If left unfixed and over time as the plastic melts, copper wires will cross and touch each other, causing a massive short circuit. My engine could suddenly cut out and stall while I am traveling at 70 mph on the highway, instantly killing my power steering and power brakes and putting me in extreme danger. Again not to mention the fire hazard this situation is likely to cause. This should be addressed via a mandatory safety recall, so that I don’t have to pay for a known engineering design defect and in case the TBS bulletin fails or further unknown damage has already occurred.

   NHTSA complaint 11757743
9. Filed Jul 30, 2026Failure Apr 21, 2026Lake Wales, FLFuel/propulsion system, Seats, Body

   Car was taken to dealership for inspection. Upon inspection, it was determined that the fuel tank had expanded and pushed towards the heat shield, and expanded upward pushing up the back seats of vehicle. It was determined to not safe to drive. Manufacturer contacted me and offered a buyback. Upon their offer of a buyback, it was determined that I would owe the manufacturer approximately $2,000. I have requested that they fix it, and they have refused to give me the paperwork I requested about the car's condition and fixability. I am in the process of negotiating and am filing this complaint for the record.

   NHTSA complaint 11753819
10. Filed Jul 22, 2026Failure Jul 16, 2026Elizabeth City, NCElectrical system

    Fan motor fuse box quit working and ac/heat no longer operational. First time was around October 21, 2025.

    NHTSA complaint 11751988
11. Filed Jul 10, 2026Failure Jul 10, 2026Lake Havasu, AZElectrical system, Engine, Power train

    My vehicle while driving, it is jerking and shaking. When I come to a stop, the cars rpms go up and down while the car is shaking. When I pressed the gas pedal to accelerate the car will not accelerate as normal and the car jerks as I’m driving it. The RPMs rev up and down without any pressure placed on the gas pedal. The check engine light came on.The miles per hour only allows me to put one digit. I wanted to clarify that the problem is occurring anywhere between 0 mph to 65 mph when these the car jerks and shakes and the RPMs go up and down without me pressure on the gas pedal.

    NHTSA complaint 11749650
12. Filed Jul 10, 2026Failure Mar 10, 202680,000 milesMillford, PAEngine

    The contact owns a 2020 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. The contact added oil to the engine. The dealer was made aware of the failure. The vehicle was taken to the dealer several times, and several oil consumption tests were performed. The contact was informed that the oil consumption test results did not indicate excessive oil consumption. The failure reoccurred. The vehicle was taken to the dealer, and the contact was informed that the oil level was a half quart low. The contact was informed that no repair options were available. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

    NHTSA complaint 11749550
13. Filed Jul 9, 2026Failure Jul 1, 2022Brevard, NCSeat belts

    The seat belt latches do not latch or will spontaneously unlatch. This has been a problem for about 4 years. I have checked for recalls and not seen any for my car. I will check with the dealer but have tried vacuuming the latches without effect. I have never experienced anything like this in any previous vehicle. The warning buzzer lets me know when the seatbelt unlatches, but I seriously doubt the belt would hold in case of an accident.

    NHTSA complaint 11749402
14. Filed Jun 26, 2026Failure Jun 24, 2026New City, NYElectrical system

    No air coming from cabin, upon further inspection found melted multifuse with melting terminal pin area in fuse box. No prior signs of warning, leaving vehicle without operable air condition for high temperatures.

    NHTSA complaint 11746626
15. Filed Jun 22, 2026Failure Jun 17, 202689,000 milesYuma, AZFuel system, Gasoline, Structure

    The contact owns a 2020 Hyundai Sonata. The contact stated that while driving at an undisclosed speed with the family inside the vehicle, a strong gasoline odor was inside the cabin of the vehicle. The contact stated that the fuel gauge was lowering quickly. Upon exiting the vehicle, the contact became aware of gasoline gushing heavily out of the vehicle onto the ground. Two months prior to the failure, the vehicle was taken to an authorized dealer due to an abnormal sound coming from the rear of the vehicle. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the recall repair was not performed because the part for the recall repair was not yet available. The vehicle was towed to a dealer where it was determined that the gas valve was not properly fixed. The abnormal sound in the rear of the vehicle was due to the fuel expansion, which caused the tank to rupture and melt. The melting caused the fuel pump to expand and melt, causing structural damage to the body of the vehicle. The structural expansion caused the rear passenger seats to raise up. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 89,000.

    NHTSA complaint 11745596
16. Filed Jun 14, 2026Failure May 18, 2026Akron, OHEngine

    My 2020 Hyundai Sonata 2.5L is experiencing excessive engine oil consumption. At approximately 88,063 miles, Great Lakes Hyundai documented that the engine oil level was 1.30 quarts below full after an oil-consumption check. The dealer topped off the oil, submitted photos and a prior-authorization/goodwill request to Hyundai, and Hyundai declined assistance. The dealer recommended combustion chamber cleaning with an estimate of $979.76. I am concerned that this excessive oil consumption could lead to sudden engine damage, loss of power, stalling, or engine failure if the oil level drops between checks. The vehicle is only a 2020 model year, and this level of oil consumption appears abnormal. I am also concerned about possible emissions/catalytic converter damage from oil burning.

    NHTSA complaint 11743992
17. Filed Jun 10, 2026Failure Apr 26, 2026Dallas, TXFuel/propulsion system

    Hyundai Motors America has failed to comply with its statutory obligations in conducting the recall campaign 25V796, and is instead engaging in behavior substantially similar to that which has been previously censured by NHTSA. My Sonata suffered irreparable damage related to this campaign as confirmed by HMA. 49 U.S.C. § 30120(a)(1)(A) allows HMA to choose one of three remedies: repair, replacement, or refund. However, they 1) say it cannot be safely repaired, 2) will not replace it, and 3) are not offering a repurchase as required by statute, i.e. "by refunding the purchase price, less a reasonable allowance for depreciation." Instead, Hyundai's case manager Aditya informed me on 5/29/2026 at 12:57 PM that they will make a repurchase offer "based on the Kelly Blue Book value." I protested and cited the statute, but he maintained that Hyundai has their process and subsequently gave an unconscionably low offer that was not based on any reasonable measure of depreciation. I insisted on a reasonable, defensible calculation. I proposed 1) using the state formula for calculating reasonable depreciation as applied in both Texas and California (HMA and my home states), or 2) using actual market values (of which I have tangible data) to determine the actual market loss in value. Hyundai has rejected both of these reasonable proposals in favor of an arbitrary formula that would leave me with thousands of dollars in lost value. On June 9, 2026, when I pressed Executive Case Manager Jenifer for an explanation of their proposed depreciation formula, she only stated that "it’s a standard calculation across the board" and that it applies "regardless of state" and they "will not change it." The NHTSA discussed this behavior in its Final Order and Determination against Fiat in Federal Register Vol. 45 No. 7, and endorsed a "reasonable" model similar to my proposal #2 above. It found Fiat non-compliant for its behavior which had a nearly similar impact.

    NHTSA complaint 11743103
18. Filed Jun 9, 2026Failure Jun 1, 2026Durham, NCEngine, Power train

    For my vehicle the Check Engine light has been on continuously throughout the last 6 months and mechanics are going to have to replace the thermostat. Multiple auto mechanics have indicated online that this is a very common problem with many Hyundai vehicles from 2020-2023 and can be a danger due to temperature control not being accurate for vehicles (Code P2181). Many owners of these Hyundai vehicles have experienced this issue leading online and this issue should be made aware to Hyundai and the general public to see if this is something that needs to be made aware for the safety of drivers to determine if their vehicle is at an accurate temperature.

    NHTSA complaint 11742918
19. Filed Jun 4, 2026Failure Jul 15, 2025108,000 milesSavannah, GAFuel system, Gasoline

    The contact owns a 2020 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (FUEL SYSTEM, GASOLINE). The contact stated that while driving 60 MPH, the vehicle was leaking fuel from the fuel tank. There was no warning light illuminated. The dealer was contacted and notified of the failure, and the vehicle was repaired. The contact stated that the failure was a recurring failure. The manufacturer was notified of the failure. The failure mileage was approximately 108,000.

    NHTSA complaint 11742138
20. Filed May 31, 2026Failure Apr 1, 2025Austin, TXEngine

    2020 Hyundai Sonata SEL Plus, VIN [XXX] . A/C system fails due to refrigerant leak that empties the system completely within 1-2 weeks of recharge. Leak cannot be located through standard external inspection. First noticed reduced cooling summer 2025. Driver's side loses cooling first, then passenger side fails days later — pattern consistent with evaporator core leak in dual-zone system. In September 2025, independent shop found system completely empty, recharged it, and attempted leak detection but could not locate source. Approximately two weeks later, system was empty again. Shop still unable to find leak. Symptom pattern — rapid total refrigerant loss, asymmetric failure (driver side before passenger), no externally detectable leak — points to evaporator core, which is enclosed in the HVAC housing behind the dashboard and invisible during standard inspection. Vehicle has 50,125 miles, still under the 60,000-mile warranty limit after 6+ years. Low-use vehicle averaging under 8,000 miles/year. 5-year calendar warranty expired approx. Jan 2025; issue first documented Sept 2025, only 8 months later. Defect was almost certainly present before warranty expiration. A class action investigation is underway (XXX) for premature A/C failures in 2018-2022 Sonata, Elantra, Palisade, Santa Fe, and Tucson vehicles. Loss of A/C in Texas climate poses risk of heat illness to occupants, especially children. This component should not fail at under 50,000 miles. Original lessee and purchaser; vehicle well maintained. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11741173