2022 Hyundai Sonata

93 complaints on file, page 1 of 5.

1. Filed Sep 20, 2026Failure Jul 22, 2026Lewisville, TXElectrical systemFire

   Fuse for A/C was blown, caught on fire, and melted components.

   NHTSA complaint 11765593
2. Filed Sep 15, 2026Failure Aug 1, 2026140,000 milesST. Martinville, LAEngine, Fuel system, Gasoline, Service brakes

   The contact owns a 2022 Hyundai Sonata. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, while driving 70 MPH and depressing the accelerator pedal, the vehicle decelerated unintendedly. The check engine warning light illuminated. The contact stated that upon depressing the brake pedal, the brakes failed to respond as intended. The manufacturer was notified of the failure and stated that the contact would receive a callback. The failure mileage was 140,000.

   NHTSA complaint 11764526
3. Filed Aug 4, 2026Failure Jun 2, 2026Mentor, OHFuel/propulsion system

   RECALL REMEDY FAILURE AND MANUFACTURER COERCION My Certified Pre-Owned 2022 Hyundai Sonata Limited has been held completely out of service at an authorized Hyundai facility since June 2, 2026, due to severe fuel tank expansion under active NHTSA Safety Recall 25V-796 (Hyundai Campaign 286).The dealership confirmed that the defective expanding plastic fuel tank ballooned with enough force to structurally warp and buckle the unibody center floor pan and frame rails. Rather than providing a safe, timely remedy under federal recall guidelines, Hyundai Corporate and the dealership are attempting to coerce me into an unfair, non-statutory "voluntary trade-in" that simply pays off my remaining loan balance ($22,000) while completely wiping out the $9,000 in cash equity ($3,000 down payment and $6,000 in monthly payments) I have invested into the car. Upon rejecting this predatory trade-in offer, the manufacturer immediately threatened an additional 6 to 8-week delay to attempt a massive structural frame and unibody pull, which would bring the total out-of-service time to over 90 to 110 cumulative days. Furthermore, the dealership is actively withholding the internal diagnostic write-ups and structural alignment prints from me. I am requesting that the NHTSA investigate this recall remedy failure. Hyundai is using extreme delays (90+ days) and structural frame threats to force consumers to abandon their financial equity rather than issuing lawful, purchase-price repurchases for vehicles deemed structurally unsafe due to a manufacturing defect. I can't provide any documents as they have refused being able to provide me with any. Was told I would be emailed a copy from the dealership several times and they never end up sending over any information.

   NHTSA complaint 11754635
4. Filed Jul 28, 2026Failure Jul 26, 202661,000 milesArlington, TXStructure

   The contact owns a 2022 Hyundai Sonata. The contact stated that while driving approximately 65 MPH, there was an abnormally loud bang coming from the vehicle. Upon inspection, the contact became aware that the sunroof windshield visor had shattered. The vehicle was taken to a local dealer where it remained for further inspection. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,000.

   NHTSA complaint 11753318
5. Filed Jul 28, 2026Failure Jun 16, 2023Dupont, WASeats

   The driver's power seat drive cable on the left-hand track rail snapped internally. The motor only advances the right side, causing the seat to twist violently to the left and jam. This mechanical failure occurred prematurely at 9,000 miles. Because the seat framework is structurally compromised and twisting out of alignment, it poses a severe occupant safety hazard in a collision. And interferes with positioning the seat to operate the vehicle safely. The dealer has inspected the complaint and was able to reproduce the complaint. But did not cover it under warranty. There where no warning signs before the premature failure.

   NHTSA complaint 11753307
6. Filed Jul 8, 2026Failure May 31, 2025Upper Marlboro, MDEngine

   The engine on a 2022 Hyundai Sonata developed rod knock at approximately 99,460 miles. The vehicle had been serviced exclusively at an authorized Hyundai dealership for its entire life with 12 documented service visits. What failed: The engine lubrication system. Two prior events at the dealership are documented in the service records: (1) approximately 20,000 miles before the rod knock, a dealership technician damaged the oil filter cap during a service visit, causing an active engine oil leak while the vehicle was being driven. The dealership repaired this at no charge, indicating fault. (2) The dealership placed an oil change reminder sticker in the vehicle specifying an interval that their own service advisor later acknowledged was set incorrectly. The vehicle was brought in approximately 660 miles past that sticker date. Safety risk: Rod knock indicates internal engine bearing failure. The engine continued to be driven at the dealership's instruction ("keep driving, come back if you hear it again") with unresolved internal damage. The knocking sound has since returned, creating risk of sudden engine failure while in operation. Confirmed by dealer: Yes. The rod knock was confirmed by the dealership's technician on the date of the diagnostic visit. The diagnosis noted the engine was low on oil and recommended an oil change, but no repair was performed. Warning lamps/prior symptoms: The engine oil warning light illuminated during the prior oil filter cap leak incident. At the rod knock visit, the knocking sound was the presenting symptom. No oil pressure warning light was noted at that visit. Inspection status: Inspected by authorized Hyundai dealership. Warranty claim was denied by dealership and no response has been received from Hyundai Motor America after formal escalation.

   NHTSA complaint 11749200
7. Filed Jun 26, 2026Failure Jun 26, 2026Lake Whales, FLFuel system, Gasoline

   The contact owns a 2022 Hyundai Sonata. The contact received notification of NTHSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

   NHTSA complaint 11746780
8. Filed Jun 17, 2026Failure Jun 9, 2026Irving, TXFuel/propulsion system, Seats

   The vehicle’s fuel tank system failed catastrophically. The vehicle is currently grounded and has been inspected at the Hyundai dealership service center where it was towed. My safety and the safety of everyone on the road was put at extreme risk due to a severe fire and explosion hazard. Additionally, the defect caused the vehicle to suddenly lose power, sputter, and threaten to stall out while driving on a major interstate, creating an immediate risk of a high-speed rear-end collision. When attempting to add fuel, the pressurized tank forcefully spit gasoline back out of the filler neck, creating an active chemical and fire hazard at a public gas station. I was able to drive it home and called via Hyundai Roadside Assistance to have it towed to an authorized Hyundai dealership service department. On June 15th, 2026, the dealership service technicians officially confirmed the failure, stating that the fuel tank had expanded, the back floor base of the car was melting, and the vehicle was on the verge of exploding.

   NHTSA complaint 11744661
9. Filed May 31, 2026Failure Jan 14, 2026Wood-Ridge, NJService brakes, Vehicle speed control, WheelsCrash

   Hyundai Sonata SEL - 2022 Both Leg break and hand break didnt work while driving. its a very severe issue in this model.

   NHTSA complaint 11741184
10. Filed May 28, 2026Failure Nov 24, 2025Mcdonough, GAElectrical system, Power train

    2022 Hyundai Sonata N Line, VIN [XXX] , purchased August 15, 2025 with low mileage under original manufacturer warranty. Within 3 months, recurring transmission and drivability failures began. Six repair visits since November 2025; 71+ cumulative days out of service within 8 months. Visit 1 (11/24/25, 14,748 mi): Hesitation/failure to accelerate from stop. Could not duplicate. Visit 2 (12/4/25, 14,800 mi): Same concern. Fault codes found; auxiliary pump and relay replaced. Visit 3 (1/19/26, 15,982 mi): Check engine light, jerking. External oil pump leaking; replacement required. Visit 4 (1/30/26, 16,025 mi): Check engine light. TCU update, DCT learning performed; declared resolved. Visit 5 (2/19/26, 16,119 mi): Check engine light returned. Transmission oil pump failed; replaced. Visit 6 (4/14/26, 16,945 mi — OPEN 44+ days): Post-repair lurching, infotainment failure, ongoing jerking. On 5/28/26, the service manager at McDonough Hyundai (McDonough, GA) stated the vehicle likely requires a complete transmission replacement and disclosed approximately 4 additional vehicles at the same dealership with identical unresolved issues. Hyundai Motor America refuses to authorize repairs or Techline escalation unless the dealership confirms the intermittent concern — a structural barrier that prevents warranty resolution. Safety concern: repeated failure to accelerate normally from a stop creates direct risk of rear-end collision or inability to clear intersections. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11740755
11. Filed May 28, 2026Failure May 28, 202670,000 milesRomeoville, ILElectrical system

    The contact owns a 2022 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the HVAC blower motor became inoperable with no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the blower motor fuse had melted and failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

    NHTSA complaint 11740717
12. Filed May 14, 2026Failure May 14, 2026Chicopee, MAElectrical system, Unknown or other

    The cars fan is constantly running even when the car is cool. I think it has to do with the ITMS I contacted the dealer and they said there’s nothing they can do about it this happens every time the vehicle is started even when I am parked. The fan is constantly running at 100%.

    NHTSA complaint 11737873
13. Filed May 4, 2026Failure Feb 7, 2026Texarkana, TXElectrical system, Engine, Fuel/propulsion system

    Our 2022 Hyundai Sonata experienced multiple issues related to recalls affecting the vehicle’s reliability and operation. Due to these ongoing problems, the vehicle was taken to a dealership and has remained out of service and in dealership possession for approximately 90 days. The issues were confirmed by the dealership, and Hyundai Motor America was involved in the case. As a result, Hyundai approved a full buyback of the vehicle, indicating the problems could not be resolved in a reasonable timeframe. Despite this, the vehicle remains out of service and unusable. Hyundai has failed to complete the buyback process and has not provided a resolution within a reasonable time. There have been repeated delays and missed timelines. The extended period without a functioning vehicle creates reliability concerns and potential safety risks, as the vehicle could not be safely depended on for regular use prior to being removed from service. The vehicle is currently still in dealership possession and unavailable for use.

    NHTSA complaint 11735677
14. Filed May 2, 2026Failure Dec 23, 2025Raleigh, NCFuel/propulsion system

    I brought this car 2022 Hyundai Sonata with 41k miles on it and only had it for 6 months. It has cut off 3x so far after putting gas in the tank. Always the same thing, oh nothing is wrong. Obviously there is and I see there is a recall on this car however my VIN isn’t coming up as a recall. This has to be fixed.

    NHTSA complaint 11735239
15. Filed Mar 16, 2026Failure Mar 9, 2026Lima, OHAutomatic emergency braking

    I purchased the car new and three times since then, the latest last week, the automatic brakes kicked in briefly for no apparent reason. I feel that if a vehicle would have been directly behind me this could very well have caused an accident. Each time it happened it was during daylight and fair weather although I can't remember if the sun was shinning. After the second time it happened I reported it to the dealer and they said they had no recalls on it and no explanation but if it happened again I should record all circumstances to investigate the cause. A couple years went by and it didn't happen again until last week. Now the warranty has expired on my car. No one has inspected my car; It has driven fine except for when the automatic braking problem occurs. There were no warning or indicator lights that I noticed at the time.

    NHTSA complaint 11724526
16. Filed Mar 9, 2026Failure Mar 9, 2026Chesterfield, VARearview system braking, Automatic emergency braking, Fuel/propulsion system

    The Full stereo system with cameras and most sensors and the car is currently at the dealership as 03/09 @11:00 am and I took It to them as well so that they can repair the other pending recall I have at the moment and they stated that It was a " point to point check recall " and that they would change it whether it would need to be or not and I raised concerns about another possible recall on the car and if they could check it out which is my stereo system they tried to charge me almost $200 and " the symptoms or warnings " was that sometimes it would happen but Instead of It going out completely I was able to troubleshoot it by pressing on the little button under the volume button

    NHTSA complaint 11722956
17. Filed Mar 5, 2026Failure Feb 7, 2026100,000 milesTexarkana, TXFuel system, Gasoline

    The contact owns a 2022 Hyundai Sonata. The contact stated that while his daughter was driving at an undisclosed speed, the vehicle failed to accelerate as intended. The vehicle was taken to the local dealer, who determined that the failure was associated with NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 100,000.

    NHTSA complaint 11722271
18. Filed Feb 17, 2026Failure Sep 17, 202560,000 milesNewton, NJFuel system, Gasoline

    The contact owns a 2022 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was idling, and while driving at various speeds, the engine revved unintendedly, and the vehicle jerked. The ABS, traction control, and several unknown warning lights were illuminated. The message "Front Collision Avoidance Deactivated" was displayed. The vehicle was taken to the dealer, where a valve and gasket were replaced. The vehicle was repaired; however, the dealer informed the contact that the recall was not completed because the part was not yet available. The contact expressed concerns due to a fire risk associated with the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

    NHTSA complaint 11718520
19. Filed Feb 12, 2026Failure Feb 12, 2026Abilene, KSVisibility/wiper

    My windshield cracked with no discernable impact or reason. The windshields for the vehicle are too thin for use on a highway and crack too easily. This puts my safety and the safety of others at risk, as well as affecting safety mechanisms related to or mounted to the windshield. It has been replicated by myself as it's happened twice in the last 4 months of owning the car. The first windshield was replaced by my dealer at Laird Noller in Topeka.

    NHTSA complaint 11717646
20. Filed Feb 11, 2026Failure Feb 11, 202650,000 milesDuncan, SCFuel system, Gasoline

    The contact owns a 2022 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the vehicle stalled. The vehicle was restarted and taken to the dealer, where it was diagnosed, and it was determined that the spark plugs had failed. The dealer replaced the spark plugs; however, the failure progressively worsened. The vehicle failed to restart and became undrivable. The vehicle was towed to the dealer on several occasions, and the dealer cleared the diagnostic trouble codes; however, the failure persisted. The manufacturer was notified of the failure and informed the contact that the part for the recall repair was not yet available. The failure mileage was approximately 50,000.

    NHTSA complaint 11717187