2020 Hyundai Veloster

24 complaints on file, page 1 of 2.

1. Filed Sep 14, 2026Failure Aug 24, 2026okmulgee, OKElectrical system, Engine, Power train

   The engine/engine management system malfunctioned. The vehicle began repeatedly stalling and shutting off while I was driving and while stopped in traffic. The vehicle is now no longer able to start and run and will need to be towed to a Hyundai dealer. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because the engine shut off unexpectedly in active traffic. When the engine stalled, I lost the ability to continue accelerating and had to put the vehicle in Park and restart it. This occurred more than once and could have caused a collision, especially in intersections or congested traffic. An independent diagnostic scan was performed and showed engine misfire faults, although it did not identify a specific cylinder. The vehicle has not yet been fully inspected by Hyundai because it is currently inoperable and needs to be towed to the dealer. Hyundai has confirmed that there is an active software/campaign update associated with my VIN. I am also aware of Hyundai engine-related campaigns involving certain 2019–2021 Veloster vehicles with the 2.0L Nu engine, and my vehicle is experiencing similar symptoms, including stalling and engine shutdown. I am requesting that the vehicle be inspected by Hyundai to determine the cause. Prior to the complete no-start condition, the vehicle had symptoms including rough running, misfiring, stalling at stops, and the engine shutting off while driving. A diagnostic test confirmed misfire faults. The condition progressively worsened until the vehicle would no longer start and remain running

   NHTSA complaint 11764077
2. Filed Oct 18, 2025Failure Oct 18, 2025Gainesville, GAEngine

   My spark plugs misfired

   NHTSA complaint 11694293
3. Filed Sep 11, 2025Failure Aug 8, 2025Los Angeles, CAFuel/propulsion system

   Gas was shooting out of my gas tank cap, strong gasoline smells in and out side the vehicle, popping noise coming from the back from the gas tank expanding so much it pushed up the rear seat. This puts me and others at risk of fire, explosion and toxic exposure. This problem has been reproduced. The vehicle has been inspected by the dealer. A check engine light came on for a evap sensor but the next day it was gone.

   NHTSA complaint 11686504
4. Filed Jun 21, 2025Failure Jun 21, 2025Huntington Beach, CABody

   Glass roof spontaneously shattered. Car was sitting in direct California sun. Nothing touched the roof but heat, the entire panel shattered and the car is undriveable.Thankfully my car was unoccupied at the time. I have heard there had been class action lawsuits in the past regarding this vehicle make and model involving years up to 2018 but models including 2020 like mine have also had complaints reported. Just adding this to the list of complaints filed.

   NHTSA complaint 11668350
5. Filed Apr 25, 2025Failure Apr 25, 202590,000 milesToms River, NJEngine

   The contact owns a 2020 Hyundai Veloster. The contact stated that while driving 40 MPH, there was an abnormal knocking sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the piston oil rings, resulting in damages to the engine. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V301000 (Engine). The VIN was included in the recall, but the vehicle was already repaired under the recall. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 90,000.

   NHTSA complaint 11656796
6. Filed Apr 25, 2025Failure Apr 23, 2025Tom’s river, NJEngine

   I have a 2020 Hyundai veloster 2.0L and their is a knocking noise coming for the engine for the piston haven’t been properly heated right and when I search the vin up on here it come up as a different car in the picture

   NHTSA complaint 11656722
7. Filed Aug 3, 2024Failure Feb 14, 2024Jonesboro, GAWarnings, Power train

   ON 2/14/2024, my car started not to accelerate after the Crash Collision light came on. My car pulled off like it was a snail but picked up speed after I drove a bit. I had to put my hazard flasher lights on in order for other car not run over me, which was a major safety issues and put me and my grandson at risk of being hurt. There was no check engine light coming up just the warning flashed (only for a second) up (crash collision) and the symbol of car crashing into another vehicle with triangle symbol then it went away after awhile. I managed to make it to the car dealership but it took almost a month before they determine it was the camera and crank shaft. They repaired the vehicle from 2/14/2024 but two weeks ago the Crash Collision light flashed up again.(7/18/2024) I made it to the dealership again but now my car has been sitting for three weeks because they only have one technician. *Also, I am having a problem with the molding or plastic on my window. The molding on the window that stops rain for flowing down in your door has melted off on both window. The plastic/rubber molding is literally melting off and smearing on my window

   NHTSA complaint 11606255
8. Filed Jun 20, 2024Failure Jun 4, 2024Lynchburg, VAAssist, Steering

   While driving my steering wheel will lock up and I’ll get an error message for lane keep assist on the dash. I never use lane keep assist so even when it’s off it does this. I have to keep turning my car off and back on for my steering wheel to unlock and the error will disappear.

   NHTSA complaint 11595539
9. Filed Feb 8, 2024Failure Sep 1, 202239,000 milesNewbury Park, CAFuel system, Gasoline

   The contact's son owns a 2020 Hyundai Veloster. The contact stated that while her son was driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light illuminated. The contact's son pulled over and restarted the vehicle. The vehicle was taken to the contact's family-owned auto repair shop, where the high-pressure fuel pump was replaced; however, the failure recurred. The contact stated that the high-pressure fuel pump needed to be replaced for the second time. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 39,000.

   NHTSA complaint 11570820
10. Filed Jun 2, 2023Failure May 3, 2023Fort Lauderdale, FLUnknown or other

    When driving the car, it will intermittingly hesitate and as I press on the pedal the engine revs up but does not increase in speed. This has happened multiple times in the past month and is extremely dangerous. The other day I almost got hit by the car behind me and luckily there was an inlet I was able to pull into, stop and put into park, then when I put it into drive it worked again. As I came to next traffic light, it did it again and I was unable to pull over due to traffic, I put vehicle into neutral and then back into drive and it worked again to get me home. It took me 3 weeks to get an appointment with dealership and they say there is nothing wrong with it because it is not coming up on the computer. Very scared every time I need to drive it as I do not know when or where it will happen again.

    NHTSA complaint 11525099
11. Filed Nov 18, 2022Failure Nov 18, 2022Garland, TXPower train, Unknown or other

    In the manual car to get in reverse there is a "lock out" sling that only allows you to go in reverse when you pull up on it. When the manual stick shift goes back to neutral the lock out valve pops closed only allowing gears 1-6 The lock out is not coming down and is sticking so you think you are going into 1st gear but you are still in reverse. Basically imagine you go into reverse in a parking lot, putting it in drive and when you give the car gas it goes backwards. I have had almost 15 incidents in the last 2 weeks after I figured out what was happening. This is dangerous and has caused many close calls hitting other vehicles. I am bringing the car back to Huffhines Hyundai but only after a week of not being offered a loaner car and allowing me to drive in this car after at least 3 direct calls about the problem and the danger of having to drive the vehicle.

    NHTSA complaint 11494192
12. Filed Nov 14, 2022Failure Oct 24, 202217,990 milesGolden, COSteering

    The contact owns a 2020 Hyundai Veloster. The contact stated while driving 15-20 MPH, the power steering warning light illuminated, and the power steering failed. The contact stated that he was able to drive to his residence by using physical strength to steer the vehicle. The dealer was notified of the failure and informed the contact that they could not duplicate the failure unless the warning light was illuminated. The contact stated that the failure reoccurred while driving. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the dealer. The failure mileage was approximately 17,990.

    NHTSA complaint 11493545
13. Filed Jan 5, 2022Failure Jan 4, 2022Glen Arm, MDElectrical system, Body, Unknown or other

    During cold temperatures (sub 32F), the driver's side door will not open from the outside. Occasionally the passenger door is affected as well. This required crawling through the hatch to open the doors from the inside. When the key fob is actuated you can hear and audible click in the area of the door lock, but it can't be opened. Once the weather warms and the car warms up the doors perform normally. This has never occurred during the warmer months.

    NHTSA complaint 11446275
14. Filed Nov 25, 2021Failure Feb 26, 2021Fredericksburg, VAUnknown or other

    My engine on three separate occasions has stalled out on me on busy roadways. Since then the problem has no been duplicated but the engine light is on and has been unresolved and engine performance is below average.

    NHTSA complaint 11441672
15. Filed Aug 8, 2021Failure Aug 7, 2021Norfolk, VAUnknown or other

    When I was driving and got up to to the front gates, my car stalled. I knew I didn’t stall my car myself so I was curious what happened and didn’t think much of it so I just turned my car back on. Then the check engine light came on. As I started my car again it would act weird and just start to hesitate kind of. I went to park and as I came back the car would not turn on. It would just keep trying to turn over at really low rpms then shut off. After that it would not turn on what so ever. Hyundai is currently in the process of looking at it.

    NHTSA complaint 11428204
16. Filed Jul 19, 2021Failure May 1, 2021Miami, FLEngine

    The contact owns a 2020 Hyundai Veloster. The contact received a notification for NHTSA Campaign Number: 21V301000 (Engine) however, the part to do the recall repair was unavailable. The contact mentioned that the oil light illuminated on the instrument panel soon after receiving an oil change. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was unknown. Parts distribution disconnect.

    NHTSA complaint 11425462
17. Filed Jul 17, 2021Failure Jul 17, 2021Riverside, CASeats

    - Lumbar support on driver seat cracked or snapped and no longer is functional what so ever - The seat itself feels sunken and nothing like the passenger seat which does not have lumbar support - Unknown - No inspection of vehicle yet - No prior notifications or signs of failure

    NHTSA complaint 11425277
18. Filed Jul 1, 2021Failure Jun 1, 2021Ozark, MOEngine, Vehicle speed control

    When pressing the gas pedal at a lower speed, the engine would hesitate and the car would not increase in speed...regardless of how hard I pressed. This has been randomly happening for the past few weeks. Today I received a recall notice in the mail and will be bringing the vehicle in. Just wanted to make sure that the company was aware for reporting purposes. Thank you.

    NHTSA complaint 11423034
19. Filed Jun 30, 2021Failure Jun 30, 2021St. Cloud, FLEngine

    The contact owns a 2020 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 21V301000 (Engine) however, the part to do the recall repair was not yet available. The contact towed the vehicle to the local dealer, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

    NHTSA complaint 11422965
20. Filed Jun 21, 2021Failure Jun 11, 2021stevensons ranch, CAEngine

    On June 11th, 2021, as I was driving on the freeway my car lost all power. I was doing 65 in the second lane on the right. The sudden loss of power almost caused a semitruck to hit me. This was do to engine problems laid out in the current recall. I didnt know about the recall, Hyundai still hasnt notified their customers. My car has 13k miles and I've had Valvoline change my oil every 3k miles (last oil change at 10k). In a matter of 3k miles my car burnt all engine oil. (there were no oil leaks). No dashboard lights came on to inform me my oil was low.

    NHTSA complaint 11421676