2024 Kia EV9

208 complaints on file, page 1 of 11.

1. Filed Oct 1, 2026Failure Sep 10, 2026Helendale, CARearview system braking

   On September 10, 2026, while driving my Kia EV9 on a public roadway, I experienced a suspected unintended and excessive activation of the vehicle's collision-avoidance/automatic emergency braking system. I was traveling straight in my lane when another vehicle approached from the right side and crossed/moved into the roadway ahead. The other vehicle continued moving away from my immediate path; however, my EV9 suddenly applied substantial braking without me commanding that degree of braking. The incident was captured on my front dash camera. The recording shows my vehicle traveling approximately 31 MPH shortly before the event. The recorded speed decreases from approximately 30 MPH to 28 MPH, then rapidly to approximately 15 MPH and approximately 7 MPH within only a few seconds. The unexpected braking created a serious safety concern because a vehicle traveling closely behind me could have struck the rear of my vehicle. There was no collision, and fortunately no vehicle was immediately behind me. I retained the original dash-cam recording and can provide it for inspection upon request. The vehicle is also available for inspection. I have since disabled the collision-avoidance feature because I am concerned that another unintended braking event could occur at highway or roadway speeds. I am reporting this incident because the driver-assistance system appeared to intervene more aggressively than the traffic situation required and temporarily took braking control away from the driver. I am requesting that NHTSA document and evaluate this incident for possible similar complaints involving Kia EV9 collision-avoidance or automatic emergency braking systems.

   NHTSA complaint 11768236
2. Filed Aug 28, 2026Failure Jul 9, 2026Arvada, COUnknown or other

   Beginning sometime after purchase, our 2024 Kia EV9 (VIN: [XXX]) developed a recurring failure of the multimedia display system (head unit). The screen goes completely dark after approximately 5 minutes of drive time and only restores after a full vehicle restart. This failure occurred approximately 10 to 14 times before we brought the vehicle in for service. Critically, when the multimedia screen goes dark, the rearview camera display is also rendered completely unavailable. As the rearview camera is federally mandated safety equipment under FMVSS 111, this failure left us unable to use the camera while backing up on multiple occasions, creating a serious safety hazard to pedestrians, cyclists, and other vehicles behind our car. The vehicle was dropped off at Grand Kia (Wheat Ridge, CO) on XXX for diagnosis. The service technician disassembled and reassembled the head unit and contacted Kia Techline for an action plan. We were told a replacement part was on order. As of the date of this complaint, the vehicle has been out of service for over six weeks with no confirmed repair timeline and minimal communication from the dealer or Kia America. This is our second significant warranty-related repair issue with this vehicle. We are filing this complaint to create a federal record of a safety defect involving the loss of federally mandated rearview camera functionality, and to request that NHTSA investigate whether this failure pattern exists across other 2024 Kia EV9 vehicles. Requested Action: Investigation of potential safety defect involving multimedia/head unit failure causing loss of rearview camera in 2024 Kia EV9 vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11760318
3. Filed Aug 21, 2026Failure Aug 21, 202625,600 milesGermantown, MDSeat belts

   The contact owns a 2024 Kia EV9. The contact stated that while attempting to release the rear seat belt to install a child safety seat, a significant amount of effort was required. The contact stated that after struggling with the seat belts over several months of use, the seat belt became fully jammed and no longer was able to be extended. The dealer was notified of the failure on several occasions. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 25,600.

   NHTSA complaint 11758624
4. Filed Aug 5, 2026Failure Aug 5, 2026Falls Church, VAService brakes

   When I started the car up, I noticed a little bit of chattering on the brake pedal, which seemed very unusual. I drove the car forward a little bit and then all of a sudden, all these lights displays and stop vehicle and check brake system now message showed up. The car was very sluggish to drive and had almost no brake pressure. I was able to drive it out of the parking lot (slowly and carefully). When I called a tow truck, I left the vehicle off for about 20 or 30 minutes, and then when I turned it back on, everything was fine no error messages and I had plenty of brake pressure. Post dealership update: They confirmed the issue and DTC code. Found that it was a ground wire that had a 3 ohm resistance (something about a “plastic coating” was mentioned in the paperwork!). They replaced the cable via SC360, and I’ve put about 800 miles on it since then with no issues.

   NHTSA complaint 11755146
5. Filed Jun 16, 2026Failure Jun 16, 2026Montgomery, OHTires

   For several weeks the car has felt out of balance and I had it in the shop once to be balanced. The balance felt it lasted a very short time. I took the car in today to be checked out and the passenger rear tire couldn’t hold a balance. Mechanic removed tire and the interior sound deadening foam had detached on greater than 50% of the diameter of the tire. This has been widely commented on as a common failure mode for these Hankook tires on EV9 vehicles. I wanted the remaining tires inspected but as they would hold a balance the dealer had no reason to put in the labor of removing and inspecting the foam. 285/45 R21

   NHTSA complaint 11744641
6. Filed Jun 13, 2026Failure May 24, 2026Carlsbad, CASeats

   When making left turn or going over bumps, driver seat pops and feel shifted.

   NHTSA complaint 11743840
7. Filed May 29, 2026Failure May 29, 2026Woodbridge, VASeats

   In October 2025, my drivers seat began to move forward and fold on its own. I was sitting in the seat and crushed. I was able to free myself. I might have photos. I did call Kia. For a second time maybe a month ago, I was undoing my son's car seat from the latch and the seat began to fold up and pinned my neck and arm. I thought I was going to die. This was a rear passenger seat.

   NHTSA complaint 11740877
8. Filed May 29, 2026Failure May 29, 2026Woodbridge, VAElectrical system, Suspension, Wheels

   We were driving in the middle lane, going straight approximately 25 MPH. The car lurched and almost flipped. We were able to pull over, the wheel was no longer spinning with the car and the tie rod snapped at a weld point. We could have been killed had we been going faster. My son was thankfully not in the car. I am desperately trying to get the car inspected but the dealership will not unless we pay. There were no warnings, but a whining sound began yesterday and we were on the way to the dealership this morning. Now there are warnings. There have been so many safety issues with this car. I will be filing 2 other reports for the seats.

   NHTSA complaint 11740875
9. Filed May 29, 2026Failure May 24, 2026Arnold, MDUnknown or other

   What component or system failed or malfunctioned, and is it available for inspection upon request? Tire Pressure Monitoring System (TPMS) failed to detect or warn of any tire pressure abnormality before or after the blowout. Following the blowout, the vehicle’s diagnostics screen displayed “All Systems OK” while the instrument cluster simultaneously showed a “Low Tire Pressure” warning. How was your safety or the safety of others put at risk? A tire blowout at 65 MPH on a highway created an immediate risk of loss of vehicle control, collision, or rollover. Two minor children were passengers in the vehicle at the time. The simultaneous TPMS failure provided no advance warning, eliminating any opportunity to safely reduce speed or pull over before the blowout occurred. The vehicle had been in my possession for approximately four hours at the time of the incident. Has the problem been reproduced or confirmed by a dealer or independent service center? UNKNOWN Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?UNKNOWN Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO

   NHTSA complaint 11740769
10. Filed May 29, 2026Failure May 24, 2026Arnold, MDWheels

    What component or system failed or malfunctioned, and is it available for inspection upon request? Two components failed simultaneously: (1) the rear passenger side tire experienced a catastrophic blowout while traveling at 65 MPH on the highway, and (2) the Tire Pressure Monitoring System (TPMS) failed to detect or warn of any tire pressure abnormality before or after the blowout. Following the blowout, the vehicle’s diagnostics screen displayed “All Systems OK” while the instrument cluster simultaneously showed a “Low Tire Pressure” warning — indicating a TPMS malfunction. The original blown tire has been retained and is available for inspection upon request. All four tires have since been replaced. How was your safety or the safety of others put at risk? A tire blowout at 65 MPH on a highway created an immediate risk, I briefly lost control of the vehicle as it became wobbly and unstable to steer, we were at at risk of collision, or rollover. Two minor children were passengers in the vehicle at the time. The simultaneous TPMS failure provided no advance warning, eliminating any opportunity to safely reduce speed or pull over before the blowout occurred. The vehicle had been in my possession for approximately two-three hours at the time of the incident. Has the problem been reproduced or confirmed by a dealer or independent service center? UNKNOWN Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? UNKNOWN Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps, messages, or symptoms appeared prior to the tire blowout. The TPMS provided zero advance warning. After the blowout had already occurred and the vehicle was stopped on the roadside, the instrument cluster displayed a “Low Tire Pressure” warning. However, simultaneously, the Vehicle Diagnostics screen displayed “All Systems OK” with a green check-mark.

    NHTSA complaint 11740767
11. Filed Apr 30, 2026Failure Mar 26, 2026Heath, TXTires

    Purchased new all four tires (P 285 / 45 R 21 113V XL) in Dec, 2025 after confirming fits my vehicle. Warranty 60,000 miles. About 4 months later and about 1,800 miles of use, both rear tires have lost most of their tread and steel belts are showing per auto dealer. Front tires have also los quite a bit of tread. Vehicle had 4 wheel alignment before these tires were installed. Dealer & vehicle manufacturer representative confirmed no issue with vehicle. Also noted on 4/29/2026 that tire manufacturer web site states that these tires are no longer available for my vehicle. This is a significant safety hazard in its present state and worse yet subject to sudden tire failure.

    NHTSA complaint 11734782
12. Filed Mar 31, 2026Failure Mar 29, 2026Portland, ORSeats

    The front drivers seat slightly shifts during tight turns. There is a slight click in the lumbar towards the center of the car.

    NHTSA complaint 11728258
13. Filed Mar 8, 2026Failure Mar 7, 2026Riverview, FLElectrical system

    BPM warning in the KIA app. Apparently, ICCU and battery failures are t known issues with the KIA EV9s.

    NHTSA complaint 11722786
14. Filed Feb 26, 2026Failure Feb 20, 2026winter park, FLElectrical system, Automatic emergency braking, Power train

    [XXX] Message says warning "check ev system". they then sent a letter saying it had to go to the dealer, or the car would need A tow potentially. I can't get an appointment as they are way too busy to do anything other than tell me they will get back to me, repeatedly stating they will do so in one business day. it has been a week. My wife is scared to drive the car. I think it is bogus as no recall has been issued. I have had the car for 19 months with no such warning. Two days after it shows up on the screen in the car i receive the letter. This is fishy. it is either a recall, or it isn't. if it is why is it not in your data base? The vagueness of the message is inappropriate, and it implies danger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11720691
15. Filed Feb 6, 2026Failure Feb 5, 2026Erie, PAVisibility/wiper

    Windshield wipers stopped working in middle of bad snow storm. I had to pull over, wait for the weather to improve before proceeding. I have a minor child and safety is a concern to me. Thought it was the wiper so I went to AutoZone to replace it and was told the problem is the wiper motor and that I needed to take to the dealership for repair

    NHTSA complaint 11716100
16. Filed Jan 28, 2026Failure Dec 12, 2025Charlotte, NCBody, Suspension

    I recently purchase my 2024 EV9 from Carvana with 9578 miles listed on 12/12/25. Doing my 7 days to purchase this SUV. I had some concerns about the violent wobble when I drove over a bump. With some concerns about this SUV, I google to see if anyone else had this same issue. To my surprise I founded a lot of complaints and ways to resolved the issue. One consumer stated he had his EV9 aligned and reduce some of the wobble but not completely. I drove to Courage KIA in Gastonia NC. When I drove their system performed a per inspection on your vehicle. The alignment was way out of alignment. Had the alignment taken care of however it still a wobble. On 12/24/26 doing the snow and ice storm here in Charlotte, I attempted to make a trip to the store. The roads were wet but no snow or ice was on the roads. However when I hit a bump the rear end violently wobble and the rear end moved to the left and right farther it did before. I thought I was going to spin out of control.Now that I think about the very low mileage on this SUV. This perhaps is why they sold it. ly wobble

    NHTSA complaint 11714058
17. Filed Jan 28, 2026Failure Dec 29, 202512,668 milesLecanto, FLSuspension

    The contact owns a 2024 Kia EV9. The contact stated that while driving approximately 20 MPH, there was an abnormal slapping sound coming from the rear passenger’s side of the vehicle. While observing the tires, the contact became aware that the rear tires were bald, and the steel belts were coming from the inside of the tires. The contact used Fix a Flat inside the tires and was able to drive the vehicle to the residence. The following day, the vehicle was towed to the dealer, and the dealer that it was a known issue with the original tires on the vehicle. The contact was informed that the failure was caused by the battery, causing the vehicle to be too heavy for the vehicle. The inclination, tilt, or angle of suspension components with the shocks, struts, or control arms, known as the CANT, caused the tires to tilt outward approximately 2 or more inches. The dealer diagnosed that the suspension could have failed. The cant, suspension, and tires were replaced, and the wheels were aligned. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was 12,668.

    NHTSA complaint 11713901
18. Filed Jan 20, 2026Failure Jan 18, 2026Cottonwood Heights, UTElectrical system

    My vehicle popped up a red vehicle warning to check the electric vehicle system. It would no longer charge, was taken to the dealership where the emergency notification was sent :suspected condition with your EV9's Battery Management System has been detected and charging has been limited. A full system check is recommended. Please schedule an appointment with your local Kia dealership as soon as possible. And another CRITICAL EV WARNING your EV battery has a critical issue contact roadside assistance. This is a 2024 and has a total battery failure.

    NHTSA complaint 11712208
19. Filed Jan 20, 2026Failure Jan 19, 202620,000 milesShorewood, WIFirerelatedFire

    The contact owns a 2024 Kia EV9. The contact stated that while her husband was driving at an undisclosed speed, a burning odor was detected. The contact pressed the recirculate air button, but the burning odor intensified. No warning light was illuminated. The contact noticed flames coming from underneath the front driver's seat. The contact's husband pulled over and parked the vehicle. The contact, her husband, and their child were able to safely exit the vehicle. A vehilcle who had been driving behind stopped to assist, and since it was cold weather conditions, the contact and family waited for the Fire Department inside that owner's vehicle. There was no medical attention was received. When firefighters and police arrived, the fire had been self-extinguished. The contact was unaware of any reports filed by police or the fire department; however, the fire department informed the contact that there was no evidence of the lithium battery catching fire. The origin of the fire was unknown. The vehicle was towed to a tow yard, but it had not yet been declared totaled by the insurance company. The contact stated that upon inspection, the wire beneath the front driver's seat had melted. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.

    NHTSA complaint 11712169
20. Filed Jan 13, 2026Failure Oct 11, 2025Williston, VTSuspension, Wheels

    2024 Kia EV9 has destroyed two complete tire sets in 4 months (October 2025, January 2026) despite two professional alignments (May 2025, October 2025). Dealer service manager admitted on recorded call (1/7/26) seeing multiple EV9s "under 18,000 miles" destroy tires, confirming fleet-wide pattern. Multiple owner forums report the exact same issue. MY CASE: - [XXX] (11,860 mi): Steering misalignment, independent shop (Town Fair Tire) confirmed alignment issue - June 2025 - Vehicle inspected and tires rotated by authorized Kia dealership - Berlin City in Vermont - October 2025 (22,736 mi): Left rear BLOWOUT while driving. ALL FOUR OEM tires (113 load rating - "correct" per Kia) worn to bare threads. Tires had ~18,000 miles on them. October 2025: Snow tires were installed in October 2025, with 10/32" tread (were driven ~4,000 miles the previous winter). Dealer performed alignment, no before/after documentation provided [XXX] (25,486 mi): Same winter tires that drove 4,000 mi perfectly first winter destroyed in 2,700 mi second winter DEFINITIVE PROOF - Multi-Point Inspection (1/5/26): On 1/5/2026: Rear Left: 1/32" tread (destroyed in 2,700 miles from Oct. '25 to Jan. '26) Rear Right: 1/32" tread (destroyed in 2,700 miles from Oct. '25 to Jan. '26) Front Left: 10/32" tread Front Right: 10/32" tread Rear-only catastrophic wear on AWD vehicle is definitive proof of rear suspension or alignment defect. If load rating or overloading were the cause, all four tires would wear equally. SAFETY HAZARDS: Left rear tire BLOWOUT October 2025 while driving at 35 mph. Service Manager Pat (1/7/26): "Under 18,000 miles I've seen" other EV9s destroy tires - CONFIRMS FLEET-WIDE PATTERN Service Manager: "I can't tell you why the alignment is out" - CANNOT DIAGNOSE ROOT CAUSE Service Advisor John (1/6/26): "There's got to be an elephant in the room somewhere" - ADMITS UNDIAGNOSED DEFECT EXISTS Service Advisor: "I wouldn't feel safe putting my guys in it" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

    NHTSA complaint 11710718