SUV, hybrid, 4WD/4-Wheel Drive/4x4, built in South Korea. Owner complaints on file from Sep 1, 2022 to Sep 29, 2026.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 23V-298 | Apr 26, 2023 | Instrument cluster may fail to display any information when the vehicle is started | Electrical system | 108,936 | Software update |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
99 complaints on file, page 1 of 5.
Was driving my child to school when the Hybrid System alert came on, I only had a few seconds to try and pull over before the car completely shut down, we lost all motive power. I was on a downward incline right in front of an uncontrolled intersection with very little shoulder as I live in a rural mountain town. Since the parking brake is part of the integrated system I did not feel I had full control of the car while pulled to the side and even moved a bit while trying to wait to restart the system via the 12volt re-set button. This was a very serious safety issue, the difference of less than a minute could have led to my child and I being helpless in the middle of a highway intersection. This is a reoccurrence of a previously documented problem from April of 2026. We took it to an authorized dealership for repair who stated it was due to two battery cells reading higher (diagnotic codes P1B200 and P0A1B), they performed a BMS cell balance and reset the values. Despite the repair the same situation occurred again in a significantly more dangerous situation. I was able to drive the car home with no reoccurrence but due to the unpredictable nature and severity of the issue the car Kia provided a tow back to the dealership as it was deemed unsafe to drive. Allstar Kia in San Bernadino has stated it could be 7-10 days before they can look at the car, they have declined to provide alternative driving assistance while they determine if this is covered by warranty, even though the previous issue was.
NHTSA complaint 11767869The contact owns a 2023 Kia Sportage. The contact stated that while driving 30 MPH, the message "Brake Carefully" was displayed. The contact slightly depressed the brake pedal to test the brakes and continued driving; however, the vehicle lost motive power. The vehicle was towed to an independent mechanic, where the contact was informed that the failure was an electrical issue. The vehicle was then towed to a dealer, where it was diagnosed and DTC: P1BB200 was retrieved. The contact was informed that the hybrid braking system had failed and needed to be replaced. The vehicle was repaired. The contact associated the failure with NHTSA Campaign Number: 23V410000 (Service Brakes, Hydraulic). The manufacturer was notified of the failure. The failure mileage was 43,000.
NHTSA complaint 11764793I was driving my 2023 Kia Sportage Hybrid when the vehicle displayed a "Check Hybrid System"/ "Stop Safely" warning and suddenly lost motive power/acceleration. I was unable to accelerate normally. I had luckily pulled of the road that I was going 55 mph into a parking lot prior to the lass of power or I would have stopped right on the roadway with cars going the same speed directly behind me. This created a serious safety concern because if this had occurred while traveling at highway speed or in heavy traffic, the sudden loss of power could have resulted in a collision. There had been no indication to me that the vehicle was about to lose motive power before the hybrid-system warning appeared. The vehicle is currently at an authorized Kia dealership for inspection and diagnosis. The cause has not yet been provided to me. The vehicle is available for inspection. I am reporting this because a sudden loss of motive power associated with a broad-system warning presents a significant safety risk. I have also learned that other Kia Sportgage Hybrid owners have reported similar hybrid-system warning and loss-of-ower incidents.
NHTSA complaint 117600982023 Kia Sportage Hybrid. Drop in power/acceleration! Upsetting, stressful & unsafe. Purchased brand new, Nov 2023. When this occurred approx. 35695 miles. I left work, got on the freeway, (only maybe 1-2 miles away) and was trying to accelerate to merge with traffic flow and could only go approx. 52-54 MPH. I tried to "floor" the pedal, but with no further acceleration. No check engine light turned on, only display message noting depleted battery/drained warning. Since power was limited, and unsure of safety of driving further or if the car would literally stop, I pulled to the shoulder of the freeway. It is a miracle that I was in the slow lane already! Unsettling! It was towed to a Kia Dealership. They had it for 2 days. The technician said there were two error codes (P017100 - System Too Lean, and P019100 Fuel Rail Pressure Sensor Circuit Range/Performance). They were unsure how/why this incident occurred. They said some kind of glitch in the system. I asked if they have had other cars with this similar issue brought in, and the technician said he did not know of any. The issue was not replicated upon initial diagnostics. Technician cleared codes, reset the engine adaptive values and road tested, and deemed the vehicle "safe to drive". But said if it occurs again, try turning off the engine, wait a bit and try driving! WHAT?! Also if it occurs again to bring it back and a technical ticket should be opened to investigate further. I have read online forums of this SAME issue, and it is a KNOWN ISSUE "especially early-production 2023-2024 models, and hard for dealers to reproduce issue after a reset". It is also noted that "many cases resolve with the free BMS software update or related module/control unit work under warranty. Some report reoccurrence even after updates". I found this information AFTER the fact, otherwise I would have pushed for the software update or related work to be done. I plan to seek that out next!
NHTSA complaint 11758663Electronic parking brake switch has failed. Yes the switch is available for inspection. Electronic parking brake can no longer be manually activated. Failure of the electronic parking brake switch has been confirmed by a dealer (Citrus Kia, Ontario, CA). Electronic parking brake switch has not yet been inspected by the manufacturer, police, insurance representatives or others. No warnings have been given regarding function of the electronic parking brake switch.
NHTSA complaint 11756367My 2023 Kia Sportage EX Hybrid has experienced repeated engine-related failures since October 2022, requiring multiple dealer repairs. The safety issue escalated in 2026 when the vehicle experienced sudden loss of acceleration while driving on highways. In April/May 2026, the vehicle lost acceleration twice within approximately 10–15 minutes. Warning messages appeared, including Check Engine Light and "Check Hybrid System – Stop Safely." The accelerator became unresponsive, requiring the vehicle to be moved to the shoulder. The dealer diagnosed P0030 and P1120 and replaced the Bank 1 Sensor 1 oxygen sensor and valve cover assembly with manufacturer technical support involved. Several months later, another highway loss-of-acceleration event occurred. The vehicle would not respond to the accelerator, RPM remained around 1,000, and it had to be safely moved off the road. The dealer diagnosed P2138 and replaced the accelerator pedal assembly. The repeated unexpected loss of acceleration creates a serious safety risk. The root cause remains unknown despite multiple repairs.
NHTSA complaint 11754862The contact owns a 2023 Kia Sportage. The contact stated that while driving at an undisclosed speed, there was smoke coming from the engine compartment and the vehicle stalled. The check engine and battery warning lights were illuminated. The vehicle was towed to a dealer to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 104,000.
NHTSA complaint 11754033The contact owns a 2023 Kia Sportage. The contact stated that while driving 75 MPH, the engine seized. The hybrid engine message was displayed. The vehicle was driven to the shoulder of the road and parked. The contact stated that while attempting to restart the vehicle, the vehicle started. The contact reset the instrument cluster. The contact stated that the failure had occurred while driving on a busy four-lane highway. The failure was a persistent failure. The dealer was made aware of the failure. The vehicle was taken to the dealer. The contact stated that no diagnostic information was provided. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the vehicle had experienced an EVAP leak in April 2026. The vehicle was at the dealer for two months and was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,445.
NHTSA complaint 11752684On XXX and XXX, while driving on the highway, the vehicle suffered a sudden, complete loss of motive power. Flashing warning lights appeared on the instrument cluster, accompanied by a safety warning message instructing the driver to pull over and "Check Hybrid System" immediately. This sudden, uncommanded drop in propulsion on active, high-speed roadways created an immediate safety hazard, forcing emergency maneuvering to coast the vehicle safely to the shoulder. The vehicle was delivered to an authorized franchise dealer (Arapahoe Kia in [XXX]) on XXX, where it has now remained grounded for 31 consecutive days. The service department has verbally communicated extreme diagnostic confusion, stating they lack an on-site hybrid specialist to properly diagnose the high-voltage powertrain/HPV/hybrid battery system. The vehicle has historically received software updates under Campaign SC335A, and the symptoms reported here closely align with the loss of motive power issues addressed in Voluntary Emissions Service Campaign SC338. To date, neither the dealership nor the manufacturer (under Case #XXX) has provided a formal written diagnosis, a repair schedule, or an active resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11750948The car's transmission became unresponsive and caused the car to lose the ability to accelerate. This happened twice on the highway before I could get it to the dealer. In order to recover, I had to pull over on the shoulder and turn the car off, wait, and turn it back on. The dealer, through the Kia warranty service, would only 'recalibrate' the transmission and refused to service it. After the recalibration, the dealership wanted to give me back the car. I insisted that they took it for an extended test drive in which it stalled for them as well. Kia warranty then authorized the replacement, and I am awaiting its completion.
NHTSA complaint 11748310Over the past 11 weeks, my 2023 Kia Sportage has experienced sudden, complete loss of acceleration on at least three separate occasions while driving at highway speeds. Each incident is accompanied by the battery gauge dropping to zero. I was forced to stop on the highway to restart my vehicle in order to drive it again. No error codes are stored because the fault clears on restart. I have taken the vehicle for inspection to a mechanic and Kia Dealership Marin, neither were able to diagnose or repair the issue.
NHTSA complaint 11742981REAR PASSENGER SEAT BELTS ON BOTH DRIVERS AND PASSENGER SIDE: The seat belt would not fully pull out/extend, and allow the passenger OR the child safety seat to be properly secured. It would lock up, and once the belt was pulled out, it would lock up on the retraction and not allow any extension. I took to the KIA dealership - which took a total of 3 visits- DEMONSTRATED and recreated the issue- which confirmed there was a problem. This did not happen on each use, but once I realized the child safety seat could not be installed properly (fully extended seat belt, retraction/ratcheting of belt to secure seat) I returned, and asked the service manager also observe along with at least one of the service techs. They were skeptical and not even fully aware of how a child seat should be installed, and the full extension of the seat belt, and the SOUND of the ratcheting/locking of the belt once fully extended. A repair/replacement was eventually done- parts had to be ordered and I could not find this “defect” on any KIA or other websites. It took a number of days for the replacement/repair. There were no warning lights that there were any problems with the safety belts. I (retired) police officer with NHTSA safety seat instructor certification (not current) and have knowledge of this, and it wasn’t until I explained and demonstrated the system to these dealership employees the proper function did they “believe” me. I just read of the a KIA recall on their Telluride models, and it sounds like a similar problem. Until it was fixed, I had a couple of occasions where the passenger was unable to secure their belt, which was before I realized that there was a manufactured problem with this system.
NHTSA complaint 11742895I am filing a safety complaint regarding my 2023 Kia Sportage Hybrid. The vehicle developed a “Check Hybrid System” warning and was diagnosed by a Kia dealership as having a failure involving the high-voltage hybrid system, specifically the MCU (Motor Control Unit). The dealership informed me that the vehicle may be unsafe to drive due to the possibility of fire risk associated with the high-voltage system. I was told technicians had to use specialized protective equipment while diagnosing the issue and that the diagnosis process took nearly a week. The repair estimate was approximately $5,000, in addition to approximately $750 charged for diagnostics alone. The vehicle is reportedly out of warranty due to mileage, even though this appears to involve a major hybrid system component and a potential safety defect. This concerns me because: - the vehicle is a relatively new 2023 model, - the failure involves the high-voltage hybrid system, - Kia advised the vehicle may catch fire, - and independent mechanics generally cannot service or repair these proprietary hybrid components. I believe this may represent a broader safety issue or defect involving the hybrid system or MCU components in Kia hybrid vehicles. I am requesting that this matter be investigated for possible safety defects, recall eligibility, or manufacturer responsibility.
NHTSA complaint 11739664When driving on the highway, warning lights activated on the dash with the message "Check Hybrid System. Stop Safely." Seconds later, the vehicle lost all propulsion power. The hybrid battery indicated it had a half charge and the combustion engine was running. Depressing the accelerator caused the engine to increase RPMs but little to no power was output to the wheels. I turned the car off and all electrical systems were disconnected and the car would not start. I pressed the "12V Battery Reset" button and electrical systems were restored and I was able to start the car. The failure then repeatedly occurred. This issue has presented multiple times now, all while driving on the highway.
NHTSA complaint 11738039I would welcome making my vehicle available for inspection on this issue. Year/Make/Model: 2023 Kia Sportage EX HEV AWD 4-Door SUV Color: Black Powertrain: Hybrid Electric Vehicle (HEV) Number of occupants: 2 (driver and passenger) Injuries: None, but fatalities could have occurred. Vehicle turned off completely – no power, no hazard lights, and although driver miraculously made it to the shoulder, most of it was blocked by a snowbank and sat in a dead car with no hazard lights. Passenger (recovering from leg surgery in full leg brace) was forced to exit onto a snow bank and enter a tow truck cab, risking re-injury. Crash: No — vehicle was somehow brought to shoulder and aid protected by two state trooper vehicles until a tow arrived. Our car suddenly emitted a loud alarm at highway speed on I-84 -the instrument panel displayed an "stop vehicle immediately" warning. There was no prior warning, unusual noise, or dashboard indication of any problem. The car shut completely down while still on the highway. Car was towed to the nearest KIA dealer - Columbia Ford/Kia [XXX] ). After diagnosis, the authorized Kia dealer documented the following on Repair Order Invoice W7403: • Concern: "TOW IN. DIED WHILE DRIVING. SEPARATED" • Diagnostic fault code: BMS P1BB20 • Failed/replaced parts: ◦ DECOUPLER-BASFILTR, Part No. SPO 25290 2MHD0 ◦ BOLT-CRANKSHAFT, Part No. KIA 23127 2MHA0 ◦ BATTERY MODULE ASSY, Part No. SPO 37507 L5000 • Parts total: $835.54 • Vehicle in dealer possession: March 5, 2026 – March 20, 2026 (15 days) complete loss of motive power at highway speed. Based on my subsequent research, this failure mode appears consistent with a documented similar issue in the United Kingdom and European markets - which did result in a recall. -hybrid belt/tensioner system. Kia issued revised parts and ECU updates in those markets. No equivalent safety recall or consumer notification has been issued in the US. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.
NHTSA complaint 11736258The AC compressor failed on my 2023 Kia Sportage Hybrid after 2 1/2 years of service and 59,800, mostly highway, miles. This affected the vehicle's drivetrain and it ground to a halt many times with a message "Check Hybrid System" displayed on the dashboard. The problem occured randomly and initially every few minutes when the vehicle was stopped at traffic lights, creating a real danger of being rear-ended by other cars.
NHTSA complaint 117321003 times in the last two days, and dozens of times over the last six months, while driving or while idling, the "check hybrid system" warning has flashed. When it happens the car does into limp mode, where it will go no faster than 13mph. this has happened in the left lane of a highway where there is no where to pull over except the lane, since there is no time to get over before the vehicle shuts down. the car essentially will shut down in the middle of driving, no matter where it is. Especially with my kids in the car it is terrifying hazard. I have brought the car to the Kia service and since its not easily reproducible they have not been able to help and have offered no solutions.
NHTSA complaint 11719154The vehicle frequently fails to engage gas engine when depressing gas pedal to any degree. A full push of the gas pedal does not result in gas engine engagement. This has happened over 15 ties since the recall computer update last summer (2025). This creates extreme danger because the operator expects the full power of the engine to engage when pulling out of intersections or crossing oncoming traffic, but the engine does not engage causing a slow, creeping acceleration from the electric motor only. I took it into the Kia dealer and they found nothing wrong. No warning lights occur when the malfunction happens. And no check engine lights occur either. The only correction is to fully turn the vehicle off and back on. Doing that resets everything back to normal. This malfunction usually occurs within the first 25-30 minutes of vehicle operation.
NHTSA complaint 11713478While driving, the vehicle repeatedly displays “Check Hybrid System – Stop Safely”, followed by loss of acceleration and shutdown of the 12V system, rendering the vehicle unable to drive. These incidents occurred on both freeways and local roads. To avoid a collision, I was forced to activate hazard lights, pull over, shut the vehicle off, and attempt recovery using the 12V reset procedure or an external jump starter. The issue has persisted despite multiple dealer inspections and repairs and presents a serious safety risk.
NHTSA complaint 11712146Ev battery system threw up back back to earnings and codes of overcharge and then all lights on dash came on started beeping and then dash went red saying check hybrid system , hybrid system failure stop vehicle. Engine wouldn’t kick back on. I had literally just left my local Kia for a routine checkup and there report is nothing is wrong. Even tho I’ve called them now a few times about it shaking and idling super hard and going limp very often. Towed back to Kia and they have now had it for 4 days and still no results.
NHTSA complaint 11710264Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.