2002 Mini Cooper

187 complaints on file, page 1 of 10.

1. Filed Feb 26, 2025Failure Dec 20, 2023Albany, GAElectrical system, Exterior lighting

   Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.

   NHTSA complaint 11644969
2. Filed Feb 26, 2025Failure Dec 20, 2023Albany, GAAir bags, Electrical system, Seats

   I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

   NHTSA complaint 11644968
3. Filed Nov 16, 2024Failure Aug 27, 2024Stanley, NCAir bags

   Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It was night, I was sitting in middle of my lane, unable to start Mini. Good samaritans helped push it into parking lot while waiting for assistance. After 15 minutes, car started and was driven home. I had slight injuries from being hit by hard material projectiled across cabin. Very thankful I was the only occupant because if a passenger had been in the seat, they would have most definitely sustained injuries. I had to cut the airbags out in order to have clear lines of sight before driving the following day. I’m fearful that the drivers side air bags may do this as well. I have owned this vehicle since 2004. Not aware of history prior to 2004;(accidents, original airbags?). only know it came from a Dealer in CA. (Possibly “Friendship” may be name of town or dealership). I have not had repairs made yet. I don’t drive this vehicle daily. There are no police reports since there was no need. No insurance claims since 2002 model. There were no malfunctions with the warning light prior to incident. However, the following day when I drove, the airbag indicator light came on for passenger side. I did not find a recall but not sure if I would for a 22 year old vehicle.

   NHTSA complaint 11625676
4. Filed Mar 11, 2021Failure Mar 11, 2021Billings, MTUnknown or other

   MY MINI COOPER NEEDS RECALL WORK DONE. I AM IN BILLINGS, MT AND 392 MILES FROM THE CLOSEST CERTIFIED PLACE TO GET IT REPAIRED. I CAN'T TRAVEL THAT FAR IN A 2002 VEHICLE WITH HIGH MILES DURING A PANDEMIC. I AM A SENIOR CITIZEN AND HAVE ISSUES THAT DO NOT ALLOW ME TO TRAVEL THAT FAR. I AM STUCK WITH A VEHICLE THAT MAY HAVE A POTENTIAL STEERING ISSUE WITH NO WAY TO RESOLVE IT. I NOW CAN'T SELL THIS VEHICLE EITHER BECAUSE IT WOULD BE MORALLY WRONG TO PASS THIS PROBLEM ON TO A NEW OWNER. I CAN'T AFFORD THIS KIND OF SAFETY AND FINANCIAL PROBLEM. I NEED HELP TO GET THIS WORK DONE AND MINI COOPER CALLED ME AFTER MY INQUIRY AND SAID I AM BASICALLY OUT OF LUCK. THEY HAVE NO RESOLUTION FOR ME OR ANY OTHER MINI COOPER OWNERS THAT LIVE IN RURAL STATES AND ARE NOT NEAR A CERTIFIED DEALERSHIP. I NEED THIS REPAIRED AND AM HOPING YOU CAN HELP ME AND ALL THE OTHER MINI COOPER OWNERS IN THIS DANGEROUS SITUATION. THE NUMBER THE MINI REPRESENTATIVE CALLED ME FROM WAS 800-831-1117.

   NHTSA complaint 11400410
5. Filed Jun 26, 2019Failure Jun 15, 201975,000 milesPlano, TXSteering

   SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICANT DING AND SCRATCH.

   NHTSA complaint 11222671
6. Filed Mar 9, 2018Failure Jan 17, 2018120,000 milesSpringdale, ARSteering

   TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. THE CONTACT, A CERTIFIED MECHANIC, DIAGNOSED THAT THE STEERING PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

   NHTSA complaint 11078341
7. Filed Feb 24, 2017Failure Jan 1, 2017118,000 milesOgden, UTBody

   TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WATER WAS ENTERING THE VEHICLE FROM THE SUN ROOF, WHICH CAUSED THE COMPUTER IN THE VEHICLE TO GET MOIST AND NOT OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF RUBBER CONNECTOR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

   NHTSA complaint 10956781
8. Filed Aug 16, 2016Failure Aug 16, 2016Litchfield, OHPower train

   TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 15 MPH OUT OF A PARKING LOT, THE VEHICLE MADE A LEFT TURN AND THE GEAR SHIFTER FAILED. IN ADDITION, THE GEAR SHIFTER CABLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V201000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

   NHTSA complaint 10896429
9. Filed Jun 29, 2016Failure Mar 15, 2016140,000 milesMidlothian, VAWheels

   THE DASH LOW TIRE AIR LIGHT SUDDENLY CAME ON; IT COMES ON AFTER DRIVING FOR ABOUT 5 MINUETS. I'VE CHECKED ALL TIRES AND THEY ARE IN COMPLIANCE. I SEE THAT ON-LINE BLOGS THIS IS A MAJOR ISSUE

   NHTSA complaint 10881466
10. Filed Jun 29, 2016Failure Mar 15, 2016140,000 milesMidlothian, VAService brakes

    ABS DASH LIGHT AND BREAK LIGHT SUDDENLY CAME ON. IN ADDITION TO THE AIR BAG LIGHT THAT SUDDENLY CAME ON, THE DEALER SAID THE COMPUTER MODULE FOR THE ABS WILL COST $1,000 (IN ADDITION TO THE AIRBAG MODULE OF $1.000). I SEE ON INTERNET BLOGS AND NHTSA THAT THIS IS A COMMON INCIDENT TOTAL AIR BAG AND ABS COST WILL BE $2,000

    NHTSA complaint 10881464
11. Filed Jun 29, 2016Failure Mar 15, 2016140,000 milesMidlothian, VAAir bags

    AT 140,000 MILE: + AIR BAG LIGHT CAME ON. DEALER SAID THAT THE AIRBAG COMPUTER MODULE WILL COST $1,000 TO REPLACE. I SEE ON-LINE BLOGS AND NHTSA HAVE HAD NUMEROUS COMPLAINTS ON THE AIR BAG DASH LIGHT COMING ON AND NHTSA IS STILL INVESTIGATING.

    NHTSA complaint 10881458
12. Filed Mar 31, 2016Failure Jan 2, 200630,000 milesPortsmouth, NHSteering

    TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE POWER STEERING WOULD SUDDENLY MALFUNCTION CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE POWER STEERING PUMP HAD OVER HEATED CAUSING THE POWER STEERING FLUID TO EVAPORATE. THE CONTACT INDICATED THAT SINCE 2012 THE POWER STEERING PUMP HAD BEEN REPLACED FIVE SEPARATE TIMES AND RECENTLY WITH THE NEW REDESIGN PUMP BUT THE VEHICLE CONTINUED TO HAVE THE SAME FAILURE OCCUR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000.

    NHTSA complaint 10852727
13. Filed Mar 24, 2016Failure Jan 1, 2012118,457 milesWest Hartford, CTEngine, Power train

    TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE ELECTRONIC LEARNING MODULE AND THE PYRAMID WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT SEVERAL COMPONENTS WERE REPLACED DUE TO MANUFACTURER DEFECTS. THE GEAR LEVER, TRANSMISSION, BRAKE PEDAL, MOTOR, CLUTCH, FRONT AND REAR AXLES, AND THE ACCELERATOR PEDAL POSITION SENSOR WERE ALL REPLACED. THE FAILURE MILEAGE WAS 118,457.

    NHTSA complaint 10851347
14. Filed Aug 11, 2015Failure Aug 1, 201398,000 milesEdmonds, WAAir bags

    THE VEHICLE WAS PURCHASED USED IN 2011, SOON THERE AFTER THE AIR BAG LIGHT CAME ON, IT WAS TAKEN TO A LOCAL REPAIR SHOP AND THE AIR BAG LIGHT WAS RESET, I WAS ADVISED BY THE SHOP OWNER THAT THIS IS A COMMON PROBLEM IN THE OLDER MINI. HE ALSO ADVISED THAT IT IS EXTREMELY EXPENSIVE, AS MINI USA BASICALLY THROWS ALL NEW PARTS AT IT AT THE OWNERS EXPENSE WITHOUT REALLY GETTING TO THE BOTTOM OF THE PROBLEM. THE AIR BAG LIGHT ILLUMINATED AGAIN IN JULY OF 2015, RIGHT AFTER I HAD RETURNED FROM VACATION, APPARENTLY THE PARKING VALET HAD SLID THE SEAT BACK AND MOST LIKELY STRETCHED THE AIR BAG SEAT HARNESS. THIS IS A PROVEN DEFECT WHICH MINI USA HAS FINALLY ADDRESSED WITH A RECALL OF 2005 TO 2008 MODELS ONLY. IT IS RELATED TO A FAULTY SEAT HARNESS THAT CANNOT DETECT WHETHER A PASSENGER IS IN THE RIGHT SEAT. IT IS ALSO BEEN SHOWN THAT IN MOST CASES THE AIRBAGS WILL NOT DEPLOY IN AN ACCIDENT.

    NHTSA complaint 10747792
15. Filed Jul 28, 2015Failure Jul 27, 2012126,000 milesLemon Grove, CASteering

    DRIVING CAR NORMALLY WHEN POWER STEERING WENT OUT CAUSING A GREAT DEAL OF LOSS OF VEHICLE CONTROL, MAKING TURNING VERY DIFFICULT. ENDED UP SWERVING INTO OTHER LANE, FORTUNATELY NO CARS WERE IN THE LANE AT THE TIME. HAD TO RE-START VEHICLE TO GAIN STEERING BACK. HAS HAPPENED NUMEROUS TIMES SINCE THIS DATE. MINI USA KEEP DODGING THE ISSUE FOR A FULL ON RECALL, INSTEAD EXTENDING THE WARRANTY, BUT MY VEHICLE MISSED THE WARRANTY BY 3 MONTHS SO THEY WILL NOT REPLACE WITHOUT A HEFTY AMOUNT OF MONEY INVOLVED.

    NHTSA complaint 10744346
16. Filed Mar 20, 2015Failure Feb 9, 2015136,000 milesBear, DEPower train

    TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE TRANSMISSION FAILED ON THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE AND STATED THAT THE TRANSMISSION WAS FAILING. THE VEHICLE WAS NOT REPAIRED. WHILE DRIVING HOME, THE TRANSMISSION SEIZED. THE VEHICLE WAS THEN TOWED BACK TO THE DEALER, WHO DETERMINED THAT THE DRIVE SHIFT CABLE FAILED. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 02V201000 (POWER TRAIN). HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 136,000.

    NHTSA complaint 10695554
17. Filed Dec 1, 2014Failure Nov 10, 201480,346 milesRochester, NYSteering

    POWER STEERING PUMP IS VERY LOUD WHEN TURNING THE VEHICLE. CAN BE VERY HARD TO TURN WHEEL AT TIMES AND SOMETIMES THE POWER STEERING HAS CUT OUT WHILE DRIVING. MINI HAS A RECALL BUT WONT FIX FOR ME. *JS

    NHTSA complaint 10661487
18. Filed Nov 13, 2014Failure Jan 30, 2012100,000 milesDunellen, NJAir bags

    EVER SINCE BUYING THIS CAR USED IN JANUARY OF 2012, THE SRS WARNING LIGHT HAS BEEN ON. THE CAR STORE WE BOUGHT THE VEHICLE FROM DID CANCEL THE CODE WHEN WE DISCOVERED IT WAS ON AFTER PURCHASE. HOWEVER, THE CODE CAME BACK. WE BROUGHT IT TO BE FIXED, AND I BELIEVE SOMEONE ELIMINATED THE COUPLER UNDER THE PASSENGER SEAT, WIRING THE SEAT TO THE ECU DIRECTLY, BY CRIMPING WIRES TOGETHER. STILL, THE LIGHT CAME BACK ON. IT HAS BEEN ON CONSTANTLY FOR OVER A YEAR NOW. I HAVE SOLDERED THE WIRES UNDER THE PASSENGER SEAT TOGETHER, AS ONE CONNECTION SEEMED BROKEN, HOPING THIS WOULD ELIMINATE THE LIGHT. I BOUGHT A CODE READER TO RESET THE LIGHT, BUT THE CODES ONLY TEMPORARILY DISAPPEAR AND AFTER BLINKING A FEW TIMES THE LIGHT IS BACK ON. I DO NOT KNOW, NOR DO I HAVE CONFIDENCE IN KNOWING, WHETHER OR NOT THE AIR BAG WOULD DEPLOY IN CASE OF AN ACCIDENT. I HOPE NEVER TO FIND OUT, OF COURSE. BUT I DO KNOW THAT THE AIR BAG LIGHT BEING ON IS A CONSISTENT AND PERSISTENT PROBLEM WITH MINI COOPERS BUILT FROM 2002 - 2006. AND I KNOW THAT THERE HAS BEEN NO RECALL, NOR AN EXTENDED WARRANTY THAT WOULD COVER WORK THAT APPARENTLY WILL COST AROUND $2,000 AT A DEALER REPAIR SHOP. WITH THE RECENT RECALL OF AIR BAGS MADE BY JAPANESE AIR BAG MAKER TAKATA, INCLUDING THOUSANDS OF BMWS MADE IN A SIMILAR TIME FRAME AS THE AIR BAGS IN MY MINI COOPER, I AM ALSO WONDERING IF THE MINI AIR BAGS ARE MADE BY TAKATA, AND SENSIBLY WORRY ABOUT THEIR SAFETY SHOULD THE IN FACT DEPLOY AS DESIGNED. BMW HAS RECALLED SOME OF THEIR OWN CARS FOR AIR BAG LIGHT ISSUES, INVOLVING SEAT SENSORS, BUT NOT ON THE MINI, EVEN THOUGH BOTH CARS USE IDENTICAL COMPONENTS. IT IS TIME FOR BMW TO TAKE OWNERSHIP OF A SERIOUS PROBLEM THE AIR BAG SYSTEMS IN THEIR EARLY MINI COOPERS. I WOULD HOPE THAT YOU CAN FORCE THE ISSUE, AS THIS CERTAINLY IS A SAFETY ISSUE WHICH EXISTS/PERSISTS ON THOUSANDS OF VEHICLES SOLD IN THE US. *TR

    NHTSA complaint 10654841
19. Filed Oct 17, 2014Failure Mar 5, 2014120,000 milesChesterfield, MOPower train

    WHILE DRIVING MY MINI COOPER ON A MAJOR ROAD IN HEAVY TRAFFIC MY MINI COOPER EXPERIENCED A COMPLETE LOSS OF POWER TO THE WHEELS (SUDDEN TRANSMISSION FAILURE). MY ONLY OPTION TO AVOID BEING REAR-ENDED WAS TO STEER THE CAR OFF THE ROAD ( WITH THE REMAINING FORWARD MOMENTUM INTO A FAST FOOD PARKING LOT IN ORDER TO AVOID BEING INVOLVED IN AN ACCIDENT. DESCRIPTION OF FAILED COMPONENT/AFFECTED PART: MINI COOPER'S CVT TRANSMISSION HAVE A KNOWN HISTORY OF SUDDEN FAILURE AT 80K-120K. BMW THE MANUFACTURER OF THE MINI HAS KNOWN ABOUT THE DEFECTIVE TRANSMISSION IN THEIR VEHICLE FOR YEARS, AND HAS NEVER INFORMED OWNERS OF THEIR VEHICLES OF THE TRANSMISSION PROBLEM OR THE POTENTIAL RISK FOR ACCIDENTS, INJURY, OR DEATH THAT COULD RESULT FROM THE SUDDEN FAILURE OF THE MINI'S TRANSMISSION AND RESULTING TOTAL LOSS OF POWER. BMW HAS NEVER ISSUED A RECALL OR OFFER TO REPLACE THE DEFECTIVE TRANSMISSION UNDER THE VEHICLE WARRANTY. ADDITIONALLY, BMW HAS ISSUED SERVICE ADVISORIES TO THEIR SERVICE MANAGERS ABOUT THE PROBLEMS ASSOCIATED WITH THEIR MINI COOPER'S CVT TRANSMISSION, BUT AS MENTIONED HAS NOT COMMUNICATED THIS PROBLEM TO MINI OWNERS. *TR

    NHTSA complaint 10648437
20. Filed Aug 5, 2014Failure May 1, 201422,000 milesChevy Chase, MDPower train

    2002 MINI COOPER, MANUAL TRANSMISSION. LOW MILEAGE, ONLY 22,000 MILES ON IT. WHILE DRIVING IS CITY TRAFFIC, THE TRANSMISSION FAILED TO ENGAGE WHEN I SHIFTED INTO 1ST AND LIFTED THE CLUTCH TRYING TO START FROM A RED LIGHT. THERE WAS A SMALL "SPUTTER" AND THEN THE CAR COULD NOT BE DRIVEN. I WAS ABLE TO PUSH IT TO THE SIDE OF THE ROAD AND THOUGHT THAT THE CLUTCH WAS OUT. THE REPAIR SHOP FOUND OUT THAT THE ENTIRE MANUAL TRANSMISSION HAD DISINTEGRATED. IT HAD TORN ITSELF APART OVER THE YEARS. THE REPAIR SHOP SAID THAT HE WAS AWARE THAT THIS IS A COMMON FLAW WITH THE EARLY MINI COOPERS. THIS WAS A $2500 REPAIR. *TR

    NHTSA complaint 10619044