SUV, gasoline, 4WD/4-Wheel Drive/4x4, built in Japan. Owner complaints on file from Oct 21, 2016 to Jun 7, 2025.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 20V-741 | Nov 30, 2020 | Rust prevention coating on the rear brake operating shafts could have been peeled off during the assembly process | Brakes | 21,758 | Part replacement |
| 20V-279 | May 18, 2020 | Front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use | Structure | 141,200 | Part replacement |
| 18V-103 | Feb 9, 2018 | Water may enter between the hood and windshield and cause the front wiper link ball joint to corrode, possibly resulting in the wiper link… | Visibility and wipers | 158,651 | Part replacement |
| 18V-070 | Jan 26, 2018 | Water may enter the rear brake calipers causing the parking brake actuator shafts to corrode and possibly bind | Brakes | 170,354 | Part replacement |
| 17V-609 | Sep 29, 2017 | These vehicles may have defective relays that can result in an engine stall, reduced engine power or the engine overheating | Electrical system | 132,552 | Part replacement |
| 17V-233 | Apr 6, 2017 | Inside door latch mechanisms may not latch securely in high temperatures, allowing the doors to open while vehicle is in motion | Latches and locks | 35,674 | Part replacement |
| 16V-867 | Dec 2, 2016 | Lift gate support outer tube on the affected vehicles may have insufficient anti-corrosion treatment that can allow the outer tube to corrode due… | Structure | 50,228 | Part replacement |
| 16V-563 | Jul 28, 2016 | Affected vehicles are equipped with a constant velocity transmission (CVT) that, in certain driving conditions, may cause a delay in the vehicle… | Powertrain | 82,436 | Software update |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
26 complaints on file, page 1 of 2.
I have a CVT system on my SUV and the transmission keeps slipping. A transmission light comes on and the car starts to stall. It happens mostly in stop and go traffic.
NHTSA complaint 11665436In less than one year with this car, 2016 MITSUBISHI OUTLANDER SPORT, is hesitating when accelerating then jerking forward into 4th gear, while driving at various speeds, the steering column vibrates makes loud sound, I’ve replaced the headlights at least 6x, water is getting in the vehicle somehow even a car wish will leave the floorboards soaking wet, the steering sways. This car had given me more issues in a year than all my cars throughout my lifetime combined and vehicle's vin number was NOT INCLUDED IN MANY SAFETY RECALLS. CAN INCREASE THE RISK OF THE CRASH.
NHTSA complaint 11640158Transmission light frequently comes on, car stalls/sluggish to respond. Has occurred while driving or at rest. No change despite several transmission servicing/towing expenses. Per online research, others experiencing same issues. Often resolves temporarily by turning off engine and restarting car. Recalls issued for other Mitsubishi models, but not for this car. Needs to be addressed to prevent injury or loss of life.
NHTSA complaint 11637509The parking brake is sticking when the vehicle is in motion, and it may fails to keep the vehicle stationary when engaged. It has been occurring for a few months. There is a current recall for this issue but my VIN is not included even though it’s the same issue.
NHTSA complaint 11617097The parking brake is sticking when the vehicle is in motion, and it fails to keep the vehicle stationary when engaged. The car cannot operate correctly with the emergency brake engaged. Also it’s not safe since the car cannot be secured. There is an open recall for this issue however my VIN isn’t included but the issue is the same. This has been occurring for a few months, we just were able to figure out the issue last night and then I found the recall.
NHTSA complaint 11617095Unknown. The transmission service light comes on and the vehicle drags until you turn the car off and restart it. I noticed online there's a CVT transmission recall and was wondering if this is what is happening to my vehicle.
NHTSA complaint 11617093The contact owns a 2016 Mitsubishi Outlander Sport. The contact stated that while driving at an undisclosed speed, the contact depressed the accelerator pedal, and the vehicle failed to respond as intended. The vehicle was taken to the dealer where it was diagnosed with a failed catalytic converter. The contact was informed that the catalytic converter needed to be replaced. The contact was also informed that the current catalytic converter was not the correct part for the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 51,000.
NHTSA complaint 11564632The contact owns a 2016 Mitsubishi Outlander Sport. The contact stated while driving 15 MPH, the vehicle hesitated upon depressing the accelerator pedal, and the engine revved. The transmission warning light illuminated and the message "Transmission Hot" was displayed. The contact continued driving, and the message "Transmission Fluid Low" was displayed. The contact pulled to the side of the road and allowed the vehicle to cool down. The contact then checked the transmission fluid level and noticed that there was enough transmission fluid in the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission needed to be replaced. The vehicle was then taken to the dealer, where the failure was confirmed. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 16V563000 (Power Train) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 67,700.
NHTSA complaint 11544279The contact owns a 2016 Mitsubishi Outlander Sport. The contact stated while accelerating at various speeds, the vehicle failed to shift into the intended gear. The contact then stated that the vehicle hesitated and stalled. The check engine and the transmission warning lights were illuminated. The contact was able to restart the vehicle. The vehicle was taken to the dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 16V563000 (Power Train). The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 78,000.
NHTSA complaint 11507487The contact owns a 2016 Mitsubishi Outlander Sport. The contact stated that the passenger side headlight was inoperable and upon inspection it was discovered that the inside headlight assembly casing had melted and was damaged and the light bulb could not be replaced. Repairing the failure required replacing the entire headlight assembly. The contact indicated that approximately three weeks later the same failure occurred on the driver side headlight. The cause of the failure was not determined. the local dealer was notified of the failure. The manufacturer was not notified. The vin was not available. The failure mileage was 80,000.
NHTSA complaint 11459504The contact owns a 2016 Mitsubishi Outlander Sport. The contact stated that while driving approximately 75 MPH, the service transmission warning light illuminated. The failure caused the gear to downshift inadvertently from 4th gear to 1st gear within seconds. The contact managed to pull over to attempt to regain control however, the transmission failed intermittently. The contact took the vehicle to the dealer who diagnosed that the vehicle needed valve body replacement. The vehicle was repaired however, the failure persisted. The manufacturer was made aware of the failure and stated that due to the vehicle not being included under recall, and the warranty was expired, they were unable to assist. The approximate failure mileage was 119,000.
NHTSA complaint 11429237The contact owns a 2016 Mitsubishi Outlander Sport. The contact stated while driving 35 mph, the transmission warning light illuminated on the instrument panel. The contact also stated that while at a complete stop, a slight hesitation would occur upon depression of the accelerator pedal. The contact had taken the vehicle to an independent mechanic and the mechanic discovered a defect in the transmission solenoid valve. The dealer was contact about the failure and offered no assistance. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was 41,122.
NHTSA complaint 11428064VEHICLE STALLED ON CITY ROAD, WAS ABLE TO RESTART. AND PULL INTO PARKING LOT WHEN IT STALLED AGAIN, ALL WARNING LIGHTS WERE ILLUMINATED IN VEHICLE. WAS NOT ABLE TO RESTART THIS TIME, VEHICLE WAS COMPLETELY DEAD.COULD NOT MOVE SHIFTER TO ANY POSITION, STUCK IN PARK VEHICLE WAS TOWED TO MITSUBISHI DEALERSHIP. VEHICLE WAS AT DEALERSHIP FOR 7 DAYS, DEALERSHIP SAID IT WAS A BAD RELAY THAT PREVENTED COMMUNICATION WITH COMPUTER.
NHTSA complaint 11219579LOCKS STOPPED WORKING 1 YEAR AFTER PURCHASING MY VEHICLE, THE DRIVERS SIDE FRONT AND BANK LOCKS STOPPED WORKING FIRST THEN THE PASSENGER SIDE FRONT DOOR LOCK STOPPED WORKING
NHTSA complaint 11208419EMERGENCY BRAKE DOES NOT ENGAGE DUE TO ACTUATOR LEVER ON CALIPER BEING STUCK. THERE IS AN OPEN RECALL FOR THIS ISSUE WITH VEHICLES MATCHING MY MAKE, MODEL AND YEAR BUT MY VEHICLE DOES NOT SEEM TO BE INCLUDED IN SAID RECALL. THIS ISSUE WAS NOTICED WHEN THE EMERGENCY BRAKE WAS LIFTED BUT THE VEHICLE CONTINUED TO BE ABLE TO ROLL WHILE IN MY DRIVEWAY.
NHTSA complaint 11195953WHEN IT RAINS OR AFTER CAR WASH GAS FILL COMPARTMENT IS FULL OF WATER. THERE IS NO DRAIN IN THERE AND THE WATER SLOSHES AROUND UNTIL IT FINALLY EVAPORATES. WORRIED ABOUT WATER ENTERING FULL TANK. MY GUESS IS THAT THEY FORGOT TO INSTALL A DRAIN HOLE OR TUBE. SINCERELY:[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA complaint 11194467HESITATIONS DURING ACCELERATION, ENGINE STALLS, ELECTRICAL DOESNT WORK PROBERLY LIKE USB
NHTSA complaint 11180065TL* THE CONTACT OWNS A 2016 MITSUBISHI OUTLANDER SPORT. WHILE DRIVING 5 MPH AND MAKING A TURN, THE STEERING WHEEL JERKED AND THE VEHICLE CRASHED INTO A POLE. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE FACE AND RIBS. MEDICAL ATTENTION WAS PROVIDED AT THE HOSPITAL. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (ARNIE BAUER BUICK GMC CADILLAC, 5525 MILLER CIRCLE DRIVE, MATTESON, IL 60433), BUT WAS NOT DIAGNOSED. THE DEALER ADVISED THE CONTACT TO TAKE THE VEHICLE TO AN AUTO BODY REPAIR SHOP. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 16,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint 11112196AT TIMES, WHEN PRESSING THE GAS TO GO FROM A STOP MY VEHICLE WILL TRY TO STALL AND NOT GO, I HAVE TO LET OFF THE GAS AND PRESS AGAIN AND HOPE IT PICKS UP THAT TIME
NHTSA complaint 11078339WHEN I GO TO PULL OUT IT WILL NOT ACCELERATE ALMOST COMING TO A DEAD STOP AND IT WILL NOT CHANGE GEARS IT WILL ALMOST RED LINE.. YOU HAVE TO LET OFF THE GAS TO GET IT TO CHANGE GEARS AND WHILE DRIVING ON AN INTERSTATE MY CAR JUST STOPPED ALSO WHEN YOU HIT YOUR BREAKS OR HIT A BUMP IN THE ROAD IT PULLS TO ONE SIDE. ALSO WHEN I FIRST PURCHASED MY CAR THE IGNITION WAS BROKEN ON THE INSIDE WHICH CAUSED MY KEY TO GET STUCK. AND TO THIS DAY I AM STILL HAVING PROBLEMS WITH MY CAR PLUS THE BEVELS ON MY DASH BOARD WAS BROKEN
NHTSA complaint 11066890Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.