AutoStatsIQ
Data through Oct 2026
Model year

2016 NEW Flyer XT60

Body and fuel not decoded. Owner complaints on file from no date to no date.

Recalls (2)Complaints (0)Investigations (0)Bulletins (14)
Recall campaigns covering this model year21,654 vehicles or units across those campaigns
Owner complaints0Not enough peers on file
Severity indexNoneCrash, fire, injury or death per 100
First 24 months0Complaints in its first two years
Complaints over time

Complaints about the 2016 NEW Flyer XT60 by year filed

Owner complaints about this model year, by the year they were filed with NHTSA.

No campaigns match these filters.Reset filters
Source: NHTSA ODI complaints file. The lighter column runs through October.
Components

Complaints by component

Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.

No campaigns match these filters.Reset filters
Source: NHTSA ODI complaints file. A complaint can name more than one component; it is counted under the first.
Recalls

2 recall campaigns cover the 2016 NEW Flyer XT60

Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.

Recall campaigns for the 2016 NEW Flyer XT60
CampaignFiledSubjectComponentVehiclesRemedy
22V-943Dec 20, 2022Steering column connection to the upper steering shaft may become looseSteering746Part replacement
18V-394Jun 12, 2018Surface roughness of a guide pin in the radial brake calipers may cause the brake carriage guide pin support bolt to breakBrakes908Repair or modification
Source: NHTSA ODI recalls file.
Look up a VIN at NHTSA
Owner complaints

What owners reported about the 2016 NEW Flyer XT60

The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.

0 complaints on file.

    Source: NHTSA ODI complaints file.
    Investigations

    NHTSA has not opened an investigation on this model year

    Source: NHTSA ODI investigations file.
    All investigations
    Service bulletins

    14 manufacturer communications cover this model year

    Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall.

    • TSIB 22-13 Rev B Jul 16, 2024 · Service Bulletin/Repair Instructions
      Service bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
    • ITS59266 Sep 21, 2021 · Service Bulletin/Repair Instructions
      Technical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support brackets to the existing upper bulkhead structure at the articulation joint.
    • SMB187 Sep 13, 2019 · Service Bulletin/Repair Instructions
      Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
    • SMB186 Sep 20, 2019 · Service Bulletin/Repair Instructions
      Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
    • SMB188 Sep 20, 2019 · Service Bulletin/Repair Instructions
      Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
    • SMB-182 Sep 4, 2018 · Service Bulletin/Repair Instructions
      This Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support Frame Installed on your New Flyer Vehicle.
    • ITS6572 Jun 30, 2017 · Service Bulletin/Repair Instructions
      This Maintenance Instruction describes an inspection of ZF center axle hub/rotor bolt torque.
    • SMB178 Jan 5, 2018 · Service Bulletin/Repair Instructions
      This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
    • PMB049 Jan 5, 2018 · Service Bulletin/Repair Instructions
      This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
    • SMB176 Nov 15, 2017 · Service Bulletin/Repair Instructions
      This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
    • SMB173 Aug 11, 2017 · Service Bulletin/Repair Instructions
      This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
    • ITS6495 Feb 28, 2017 · Service Bulletin/Repair Instructions
      TECHNICAL INSTRUCTION TO INSTALL SPACER FOR ENTRANCE DOOR LOWER SHAFT PIVOT MOUNTING BRACKET.
    • ITS6420 Nov 30, 2016 · Service Bulletin/Repair Instructions
      TECHNICAL INSTRUCTION FOR AMEREX DISPLAY MODULE AND FIRMWARE VALIDATION
    • ITS6293 Jul 31, 2016 · Service Bulletin/Repair Instructions
      TECHNICAL INSTRUCTION TO APPLY SPECIFIC TORQUE TO ALL MOUNTING BOLTS FOR ROOFTOP COMPONENTS.
    Source: NHTSA manufacturer communications files.
    About service bulletins