2001 Nissan Frontier

134 complaints on file, page 1 of 7.

1. Filed May 5, 2024Failure Apr 1, 2024Lees Summit, MOFuel/propulsion system

   I am the original owner of the vehicle which has just 66,000 original miles. I have smelled fuel and had a service engine soon light on for years. I have taken the vehicle into various shops and dealerships who failed to find a fuel tank leak that now turns out to have been from corrosion of the tank flange as early as 5 years after manufacturing. A check of various online owners forums suggests this is a known defect on Nissan Frontier and XTerra trucks. Once gas began physically leaking out of my tank, I contacted the dealer who said my VIN was not part of any fuel tank recall and I would have to pay for any repairs myself. This is a dangerous and irresponsible situation for Nissan Frontier and XTerra drivers which Nissan needs to fix. Other examples of rusted fuel tank flanges. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11587013
2. Filed Dec 30, 2019Failure Dec 1, 2019132,000 milesFort Morgan, COSteering, Suspension

   TL* THE CONTACT OWNS A 2001 NISSAN FRONTIER. WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL WOULD NOT TURN PROPERLY AND WAS STIFF. WHEN TURNING THE STEERING WHEEL, IT WOULD NOT RETURN BACK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE TIE ROD AND BALL JOINTS, BUT THE FAILURE CONTINUED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 132,000.

   NHTSA complaint 11292026
3. Filed Jul 6, 2018Failure Jul 2, 2018280,000 milesLakewood, COPower train, Seat belts, Seats

   TRANSMISSION BURNING FLUID SMELL, WHEN DRIVING AT NORMAL SPEED SEAT BELTS DON'T RECOIL SEATS TOO LOW

   NHTSA complaint 11109775
4. Filed Aug 16, 2017Failure Aug 14, 20179 milesMiami Springs, FLVehicle speed control

   THE MOMENT I TURN THE SWITCH ON, THE VEHICLE SPEEDS UP WITHOUT CONTROL, NOT EVEN THE BRAKES RESPONDING. I STOPPED IT BY TURNING SWITCH OFF.

   NHTSA complaint 11015802
5. Filed Feb 22, 2017Failure Oct 2, 201598,903 milesColumbus, WIFuel/propulsion system

   HAD PROBLEM KEEPING TRUCK RUNNING SERVICE DEPARTMENT DID A TUNEUP ON 10/02/15 AND SAID IT WAS FIXED 7 DAYS LATER TRUCK STOPPED RUNNING AGAIN WENT BACK TO TRUCK SERVICE ON 10/09/15 RECHECKED AND SAID I HAD WATER IN GAS DRAINED GAS PUT IN NEW GAS RAN GOOD UNTIL IT RAINED TRUCK STOPPED RUNNING AGAIN WENT BACK TO TRUCK SERVICE ON 11/30/15 DID A SMOKE TEST ON GAS TANK FOUND TOP OF GAS TANK RUSTED OUT AROUND TOP SAID I NEED NEW GAS TANK MY TRUCK WAS KEPT IN GARAGE MOST OF THE TIME THAT I OWNED IT, LOOKED ON COMPUTER AND FOUND NISSAN TRUCKS BETWEEN 2000 AND 2005 OR 2006 HAVE BAD GAS TANKS WHY DO THEY NOT RECALL OR REPLACE GAS TANKS

   NHTSA complaint 10956413
6. Filed Jan 24, 2017Failure Oct 12, 201510 milesColumbus, WIFuel/propulsion system

   FUEL TANK TOP RUSTED AND WATER ENTERED THE FUEL , TRUCK STOPPED RUNNING AND WOULD NOT START TRUCK SERVICE DID TUNE UP DID NOT HELP AFTER A $1,200 DOLLARS THEY FOUND THE WATER IN TANK DID NOT FIND THE RUSTED TANK UNTILL THE THIRD TIME BACK,PUT A SEALER ON WHAT THEY COULD REACH AND NOW I DO NOT TAKE MY TRUCK OUT IN BAD WEATHER HELP!!!!

   NHTSA complaint 10947429
7. Filed Oct 26, 2016Failure Sep 3, 201388,000 milesMoundsville, WVFuel/propulsion system

   TL* THE CONTACT OWNS A 2001 NISSAN FRONTIER. WHILE THE VEHICLE WAS BEING REFUELED, FUEL LEAKED FROM THE FILLER NECK. THE DEALER DIAGNOSED THAT THE PART NEEDED TO REPAIR THE VEHICLE WAS NO LONGER IN PRODUCTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.

   NHTSA complaint 10919104
8. Filed Sep 8, 2015Failure Feb 16, 2015128,353 milesFresno, CAAir bags

   AIRBAG WARNING LIGHT ON THE DASH BLINKED ON AND OFF. PRIVATE GARAGE AND DEALERSHIP IDENTIFIED FAULTY PART AS A CLOCK SPRING IN THE STEERING COLUMN. WAS TOLD PART IS NO LONGER AVAILABLE. MANUFACTURER DID NOT MAKE ENOUGH PARTS FOR REPLACEMENT. NOT AVAILABLE NEW OR USED. I ASKED THE DEALER TO CONTACT THE MANUFACTURER TO SEE IF THEY HAVE A FIX FOR THE PROBLEM. NO RESPONSE. SO VEHICLE NO LONGER HAS WORKING AIRBAGS. IS THE MANUFACTURER NOT RESPONSIBLE TO BACK UP THE SAFETY OF THEIR VEHICLE AIRBAGS?

   NHTSA complaint 10762313
9. Filed Jan 25, 2015Failure Jan 18, 2006Newark, NJFuel/propulsion system

   ON ABOVE APPROXIMATE DATE I STARTED TO SMELL FUEL COMING OUT FROM MY TRUCK EVERY TIME THE TANK WAS AT FULL CAPACITY. SINCE THEN ENGINE LIGHT WILL NEVER COME OFF. I TOOK FOR REPAIR SEVERAL TIMES. CHANGE OXYGEN SENSOR, GAS CAP, THERMOSTAT, CARBON CANISTER AND SOLENOID. I CONTACTED NISSAN BUT I WAS TOLD THAT THERE WERE NO RECALLS FOR MY VEHICLE. *TR

   NHTSA complaint 10678751
10. Filed Nov 9, 2014Failure Jul 16, 2013120,000 milesVernon, CTAir bags, Engine, BodyCrash1 injured

    THIS VEHICLE WAS INVOLVED IN A MVA WHERE IT HIT THE BROADSIDE OF A MINIVAN (T-BONED) THAT RAN A RED LIGHT THROUGH AN INTERSECTION. THE TRUCK WAS GOING IN EXCESS OF 20MPH AT THE TIME, WHEN I CONTACTED THE MINI-VAN NO AIRBAG WAS DEPLOYED. I SUFFERED HITS TO MY HEAD, WHIPLASH RELATED DAMAGES, DAMAGE TO MY SHOULDER AND RIGHT LEG. THE IMPACT CAUSED SIGNIFICANT FRONT END DAMAGE TO THE TRUCK, THE ENGINE AND BODY WERE DAMAGED TO THE POINT WHERE I WAS NOT ABLE TO DRIVE THE TRUCK AND ENGINE WAS INOPERATIVE. NO AIRBAG DEPLOYMENT. *TR

    NHTSA complaint 10653665
11. Filed Jul 21, 2014Failure Jul 19, 2014149,000 milesN FT Myers, FLElectronic stability control (esc), Engine, Power train

    WHILE DRIVING, FELT A "SHUDDER" .. CHECK ENGINE LIGHT CAME ON, GEAR SHIFT INDICATOR WENT OFF. ONCE THE KEY WAS TURNED OFF, VEHICLE WOULD NOT START. TOWED HOME. STARTED CHECKING FUSES. CHECK FLUIDS, REALIZED TRANSMISSION FLUID WAS IN RADIATOR AND RADIATOR FLUID WAS IN TRANSMISSION. VEHICLE WILL NO LONGER DRIVE IN DRIVE, ONLY IN REVERSE. KNOWN ISSUE WITH NISSAN. *TR

    NHTSA complaint 10614902
12. Filed Nov 5, 2013Failure Jun 1, 2011110,000 milesBarnegat, NJFuel system, Gasoline

    I PURCHASED MY NISSAN FRONTIER FROM A NISSAN DEALER "AS IS" WHICH WAS FINE TIL THE FIRST TIME I FILLED IT UP. THE SMELL OF GAS MADE ME PULL OVER RIGHT AWAY. COULDN'T FIND OR SEE A LEAK BUT SURE COULD SMELL IT. SHORTLY AFTER CHECK ENGINE LIGHT GOES ON. HAD A MECHANIC LOOK AT IT TO FIND FUEL IS LEAKING FROM THE TOP OF THE FUEL TANK. I SEE I'M NOT THE ONLY PERSON TO COMPLAIN ABOUT IT. HOPEFULLY SOMEONE WILL INVESTIGATE BEFORE SOMEONE GETS HURT. I'M ON S.S.D. I CAN NOT AFFORD THIS PROBLEM THAT SHOULD BE RECALLED. TRIED TO LOCATE A NEW TANK FOR THE TRUCK. CAN'T FIND ONE. I CAN'T SEE PUTTING A RECYCLED DEFECT IN. ANYONE WITH THE SAME PROBLEM NEEDS TO CALL THE NHTSA SO WE CAN GET THE RECALL STARTED. NOW NISSAN CHANGED THE TANK AND ADDED ACCESS PANEL BEHIND THE BACK SEAT ON NEWER MODELS. SO I DON'T FILL MY TRUCK AND IT STILL SMELLS OF GAS BUT NOT AS BAD. HOPEFULLY HELP IS AROUND THE CORNER. *TR

    NHTSA complaint 10550944
13. Filed Jul 10, 2013Failure Jul 2, 2013130,000 milesDEL RIO, TXEngine

    SEVERAL WEB SITES I HAVE READ INDICATE A RECURRING PROBLEM WITH ENGINE/EXHAUST ACCUMULATION OF WATER VIA THE LEAKAGE IN WATER LINES AND/OR FAULTY MANUFACTURING HEADS/ENGINE SYSTEM. MY VEHICLE ACCUMULATED WATER IN ONE OF THE PISTON (4-5), AND PERHAPS WARPED THE ALUM HEADS OR MAYBE BLOWN GASKET. IF REPAIRED WILL THIS PROBLEM PERSIST, AND WHAT RECOURSE DO I HAVE WITH EITHER MANUFACTURE OR USED CAR DEALER (BOUGHT IN SAN ANTONIO, TEXAS). *TR

    NHTSA complaint 10524155
14. Filed Jan 29, 2013Failure Sep 3, 2012190,000 milesSouthbury, CTElectrical system, Fuel/propulsion system

    MY CAR WOULDN'T START. BATTERY WAS FINE..PASSENGERS HAD RECENTLY SAID THAT THEY NOTICED A FUEL SMELL, BUT I CAN'T SMELL (A PHYSICAL HANDICAP OF MINE).; CALLED AAA- IT WAS THEN THAT WE NOTICED THAT FUEL WAS LEAKING OUT OF THE TOP OF THE GAS TANK, THE FUEL PUMP WIRE THAT SUPPLIES POWER TO THE FUEL PUMP WAS BROKEN. CAR HAD TO BE TOWED TO A LOCAL GARAGE. CALLED NISSAN DEALER AND HE SAID 'YOUR CAR IS OLD, JUST REPLACE THE FUEL TANK. BUT, THE DESIGN OF THE GAS TANK IS SUCH THAT THERE IS A 'GULLY' WHERE WATER GETS TRAPPED ON THE DESIGN OF THE TOP OF THE FUEL TANK. NISSAN REFUSES TO ADMIT THAT THIS IS A DESIGN FLAW THAT IS CAUSING THE TOP OF THE FUEL TANKS TO CORRODE; AND THIS IS INDEED A SAFETY ISSUE! AS A MECHANICAL ENGINEER WHO SPECIALIZES IN METALS, IT IS DEFINITELY A POOR DESIGN; I HAVE OWNED AND WORKED ON CARS MY ENTIRE LIFE, AND HAVE NEVER SEEN A FUEL TANK CORRODE THROUGH. ALL OF THE LOCAL MECHANICS/GARAGES IN MY AREA TELL ME "THIS IS A COMMON PROBLEM IN NISSAN FRONTIERS- WE FIX THEM ALL OF THE TIME." *TR

    NHTSA complaint 10495059
15. Filed May 29, 2012Failure May 7, 2012105,000 milesChicopee, MAFuel system, Tank assembly

    TL* THE CONTACT OWNS A 2001 NISSAN FRONTIER CREW CAB. THE CONTACT STATED THAT AFTER REFUELING, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE MECHANIC CONFIRMED A FRACTURE IN THE FUEL TANK, WHICH WOULD REQUIRE REPLACEMENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 105,000. ....UPDATED 06/18/12 *BF UPDATED 06/22/12 UPDATED 7/19/12 *CN UPDATED 07/23/12.

    NHTSA complaint 10459886
16. Filed May 21, 2012Failure May 18, 201191,000 milesPocatello, IDFuel system, Gasoline

    TL* THE CONTACT OWNS 2001 NISSAN FRONTIER. THE CONTACT STATED THAT SHE WAS STOPPED AT A TRAFFIC LIGHT AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER STATED THAT THEY NEEDED TO REPLACE THE FUEL SENDING UNIT. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V230000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE FAILURE MILEAGE WAS 91,000 AND THE CURRENT MILEARE WAS 116,000.

    NHTSA complaint 10459191
17. Filed Mar 14, 2012Failure Mar 11, 201290,000 milesHana, Maui, HIFuel system, Gasoline

    ENGINE STOPPED WHILE ON HIGHWAY. UNABLE TO RESTART. ON CHECKING VEHICLE, DISCOVERED WATER IN FUEL TANK. AFTER REMOVING FUEL TANK FROM VEHICLE, NOTICED, ACCESS TO FUEL TANK FROM TOP SEVERELY CORRODED. THE FUEL TANK IS LOCATED DIRECTLY BELOW SPACE BETWEEN CAB OF TRUCK AND BED. THIS ALLOWS WATER TO ENTER THROUGH THE SPACE. THE ACCESS TO THE TANK HAS A RAISED RING AND A GROOVE THAT RUNS AROUND THE RING, WHICH ALLOWS WATER TO COLLECT. THE WHOLE RING IS CORRODED AND THEIR IS HOLES IN THE TOP OF THE TANK. I FEEL THIS IS A POORLY DESIGNED TANK AND POOR LOCATION OF TANK. MY SON AND MY FRIEND HAS THE SAME MAKE AND MODEL AND THE BOTH EXPERIENCED THE SAME PROBLEM. MY SON JUNKED HIS TRUCK AND MY FRIEND USED J-WELD TO MAKE MAKESHIFT REPAIRS. I LIVE IN A COMMUNITY WITH A POPULATION OF 2000 RESIDENCE, WHICH MAKES ME BELIEVE THAT THIS CANNOT BE A ISOLATED INCIDENT. THANK YOU *TR

    NHTSA complaint 10451575
18. Filed Feb 9, 2012Failure Jan 9, 2012121,900 milesSummerset, KYFuel system, Gasoline

    TL* THE CONTACT OWNS A 2001 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V230000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP). THE VEHICLE HAD SINCE STALLED WHILE DRIVING ON AN INTERMITTENT BASIS. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE NEEDED A NEW FUEL PUMP. THE CONTACT STATED THAT THE STALLING FAILURE WAS NOT PRESENT PRIOR TO THE RECALL REPAIRS. THE FAILURE MILEAGE WAS 121,900 AND CURRENT MILEAGE WAS 122,000.

    NHTSA complaint 10447264
19. Filed Jul 14, 2011Failure Jan 6, 2011120,000 milesSimsbury, CTSteering

    TL* THE CONTACT OWNS A 2001 NISSAN FRONTIER. THE CONTACT STATED THAT A CLUNKING NOISE COULD BE HEARD COMING FROM THE STEERING COLUMN. THE CONTACT ALSO EXPRESSED SERIOUS CONCERN OVER THE POSSIBILITY OF THE STEERING COLUMN CRACKING, INCREASING THE RISK OF A CRASH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, AND THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V554000 (STEERING:COLUMN) THAT MAY BE RELATED TO THE FAILURE. THE VEHICLE WAS NOT YET TAKEN IN TO HAVE THE FAILURE DIAGNOSED. THE FAILURE MILEAGE WAS 120,000.

    NHTSA complaint 10412298
20. Filed Jan 30, 2011Failure Jan 29, 2011116,000 milesSpanway, WAFront

    WHEN DRIVING OVER BUMPS AND TURNING, HEARD A KNOCKING SOUND. I INSPECTED THE VEHICLE AND FOUND OUT THAT THE SWAY BAR WAS DISCONNECTED. *TR

    NHTSA complaint 10379611