2015 Ram 3500

136 complaints on file, page 1 of 7.

1. Filed Jun 5, 2026Failure Apr 1, 2021193,000 milesParadise, TXSteering

   The contact owns a 2015 Ram 3500. While attempting to have an alignment performed, the contact was informed that the steering drag link and the tie rod were both cracked. The failure caused rapid, premature wear on the tire. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 19V021000 (Steering); and believed that the welding that was performed in the recall repair had directly caused the current failure. The vehicle was taken to an authorized dealer, where the technicians diagnosed the vehicle and determined that the previous recall repair made it impossible to perform a proper wheel alignment. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 193,000.

   NHTSA complaint 11742354
2. Filed Mar 4, 2026Failure Mar 3, 2026Granada Hills, CAService brakes

   The output voltage to the Trailer Braking system is low, only 7.5 volts. Other owners have the same problem. From what I understand there is an issue with the computer that keeps the Original Equipment trailer brake controller from delivering full power at speeds below 30 MPH. This is a safety hazard in stop and go driving. There are many complaints about this same problem in the Ram Forumz. Ram should be able to do a software update to fix the problem. One of the posts in the forum stated that Ram has the software update available but will charge a lot of money for it. This is a safety issue and these trucks should be recalled to fix the problem.

   NHTSA complaint 11722035
3. Filed Mar 4, 2026Failure Mar 2, 2026klamath falls, ORService brakes, Steering

   humming from the hydroboost pump, actual issue is the high pressure steering line has a nylon tube inside the hose that breaks apart and moves throughout the system. Dodge had one revision of the hose on the early model years but this issue has gone unresolved. I am afraid if i cant get it fixed it may possibly cause the brakes or steering assistance to fail.

   NHTSA complaint 11721992
4. Filed Mar 4, 2026Failure Mar 16, 202350,000 milesOcala, FLElectrical system

   The contact owns a 2015 Ram 3500. The contact stated while driving approximately 70 MPH in the left lane, the check engine warning light illuminated, and the vehicle simultaneously went into LIMP Mode. The contact was able to pull over to the shoulder of the roadway. The contact was able to continue driving, but the vehicle failed to exceed 5 MPH. Upon arriving to the residence, the vehicle was scanned, and it was determined that the turbo charger actuator had failed and needed to be replaced. The contact purchased an aftermarket part and repaired the vehicle. The dealer was not contacted. The contact later became aware that the failure was related to Chrysler Extended Warranty Coverage Number: X99; however, the contact had not received a notification from the manufacturer. The contact requested reimbursement from the manufacturer; however, the reimbursement was denied because the vehicle was not repaired by a dealer. The failure mileage was approximately 50,000.

   NHTSA complaint 11721925
5. Filed Feb 17, 2026Failure Jan 1, 2026Ellington, CTSteering, Suspension

   There was a recall forced by the NTSB for a condition where the track bar adjustment nut would come loose and the truck would lose steering. The recall on the track bar was rectified by the dealer by welding the nut on the track bar. Now that the nut has been welded a proper alignment can not be preformed. There is no longer adjustment available due to the welded nut. The only way to properly fix this is to replace the track bar. I have had many communications with ram (stellantis) and they refuse to remedy this as they tell me they have complied with the NTSB’s resolution.

   NHTSA complaint 11718592
6. Filed May 2, 2025Failure Feb 4, 2025Cookeville, TNService brakes

   At about 3,000 miles I noticed a periodical head light flicker and intermittent radio issues. Shortly after that the truck has presented with periodical brake issues. My front brakes parodically drag and get hot. Typically on one front side or the other. However on [XXX] my wife and I took the truck out for a drive and both front brakes began dragging and heated up. I had to be towed 40+ miles back home. Two of my neighbors can verify I've had issues with the brakes on multiple occasions for several years now. I've had to limp the truck home on several occasions while in town and in Feb. 2025 it put my wife and I in what a consider a dangerous situation by stranding us on the side of the highway. I don't remember any warning lamps coming on but I did a scan after I got the truck back home. B170-15, B210A-16, B222C, B2861-15, P2509 & P2560 were present. I used my scanner to delete the codes and reset the EMC but am a bit hesitant to take the truck out on the road. Note: The truck has experienced a weird and harsh vibration on back of truck as well. I stop, shut engine off - do a walk around but haven't been able to pinpoint anything. Crank engine back up and problem has seemingly resolved itself. I think it's possibly a brake issue as well. At present this truck has less than 11,000 miles on it. Yes, LOL, less than 11,000 miles. Calipers and pads are in excellent functioning order. Fluid is easily pushed back into reservoir with no restrictions and no apparent degradation of flexible lines. I considered the brake fluid might have moisture built up in the system so I had a complete fluid replacement done but problem has persisted.I did read there's a recall on the the HCU/ABS unit and my truck seems to be in that category but haven't received anything from FCA. [XXX] Your attention and assistance would be greatly appreciated. Thank You. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11658341
7. Filed Dec 15, 2024Failure Dec 14, 2024Ely, NVElectrical system

   the instrument panel dash cluster went black and now I have no information like tire pressure, mph, engine oil temp, coolant temp, cruise control,parking sensor alert, ect. I have tried everything to reboot or see if there is loose connections and have come up with nothing. this could be a hazard.

   NHTSA complaint 11630799
8. Filed Nov 6, 2024Failure Nov 5, 2024166,000 milesManito, ILLugs/nuts/bolts/studs

   The contact owns a 2015 Ram 3500. The contact stated while driving 60 MPH, the steering started shuddering and the vehicle made an abnormal popping sound. The contact then noticed that the front driver's side wheel was wobbling. The contact pulled over to the side of the road and inspected the wheel. The contact noticed that two of the wheel studs of the front driver's side wheel had fractured. The contact stated that the vehicle was previously taken to the dealer to be repaired under NHTSA Campaign Number: 21V398000 (Wheels); however, the dealer informed the contact that the wheel studs did not need to be replaced. The dealer was notified of the failure and informed the contact that the VIN was no longer included in the recall because the recall had been marked completed. The vehicle was not repaired and remained on the side of the road. The manufacturer was not notified of the failure. The failure mileage was approximately 166,000.

   NHTSA complaint 11623871
9. Filed Nov 1, 2024Failure Jan 6, 2024Calabash, NCEngine, Unknown or other

   I am filing this report to highlight ongoing safety and warranty issues with my 2015 Dodge Ram 3500, which is severely impacted by Recall 67A. This recall was intended to address emissions tampering, involving significant obligations for Stellantis/Cummins Inc. under the emissions extended warranty, termed the "Special Extended Warranty." Since the completion of the recall in January 2024, my vehicle has been inoperable for a total of 148 days due to significant defects. The vehicle has required six service visits to address these issues, with the most recent visit occurring on October 31, 2024, when it was towed back to the dealership. Throughout this process, I have encountered a lack of effective communication from both Cummins and FCA, and my attempts to resolve these issues were largely ignored until I escalated the matter to federal authorities, including Randall Stone from the U.S. DOJ. The ongoing failure to address these defects has not only violated warranty obligations but also poses a risk to safety, as the vehicle remains inoperable. Impact of the Problem: The inability to use my vehicle has caused considerable disruption to my daily life, preventing me from performing essential tasks, including towing a camper and transporting heavy items. This situation has also led to significant emotional distress, given the prolonged nature of the issues and the lack of adequate responses from the manufacturer. Action Requested: I seek the NHTSA's assistance in investigating these ongoing issues with my vehicle and holding the manufacturer accountable for their failure to uphold warranty obligations and address safety concerns related to emissions defects.

   NHTSA complaint 11623214
10. Filed Sep 10, 2024Failure Sep 10, 2024Normangee, TXElectrical system, Service brakes, Vehicle speed control

    ABS and Traction control warning lights are on display. Cruise control and 4x4 will not engage due to this issue. Also causing malfunction while towing a trailer.

    NHTSA complaint 11613890
11. Filed Jun 26, 2024Failure Jun 20, 2024183,901 milesGranby, COWheels

    The contact owns a 2015 Ram 3500. The contact stated while driving 35-40 MPH, the vehicle started wiggling and wobbling abnormally. The contact was able to pull to the side of the road, where he noticed that the outer rear wheel had separated from the vehicle. Additionally, the contact noticed that the inner rear wheel had separated and pinched the axle, causing the wheel to support the vehicle. The vehicle was towed to the dealer, where an assessment was made. The dealer determined that the wheel studs needed be replaced under NHTSA Campaign Number: 21V398000 (Wheels); however, the wheel replacement was not covered. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 183,901.

    NHTSA complaint 11596921
12. Filed Feb 28, 2024Failure Nov 6, 2023Oakdale, PAPower train

    The contact owns a 2015 Ram 3500. The contact received notification of NHTSA Campaign Number: 17V821000 (Power Train). The contact had experienced the failure and paid for the repair before receiving the recall notification. The contact stated he received the notification in January 2024 and took the vehicle, the notification, and the receipt for the repair to the dealer to be reimbursed. The contact stated the manufacturer was made aware of the issue however, the contact was not reimbursed for the repair. The failure mileage was unknown.

    NHTSA complaint 11574562
13. Filed Feb 2, 2024Failure Jul 25, 201837,000 milesTamassee, SCTrailer hitches

    The contact owns a 2015 Ram 3500. The contact stated that the gooseneck ball hitch failed to remain secured. No warning light was illuminated. The vehicle was taken to dealer. The dealer confirmed the failure with the gooseneck ball hitch was related to the recall but did not replace the gooseneck ball hitch. The contact referenced NHTSA Campaign Number: 18E028000 (Trailer Hitches) as a possible solution however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.

    NHTSA complaint 11569479
14. Filed Nov 21, 2023Failure Nov 20, 2023Randleman, NCUnknown or other

    Backing up 11/20/23 in our driveway, the tailgate fell down, shut it and it occurred 2 more times before it could be re-parked.

    NHTSA complaint 11556176
15. Filed Oct 30, 2023Failure Sep 29, 2023Mims, FLService brakes

    ABS Module / HCU (Hydraulic Control Unit Failure) causing abs MIL on. Fault code C0020

    NHTSA complaint 11552694
16. Filed Oct 27, 2023Failure Oct 20, 2023112,000 milesMontrose, COPower train

    The contact owns a 2015 Ram 3500. The contact stated that after his wife started the vehicle, the transmission failed to shift into the intended gear because the gear shifter was loose. The vehicle was towed to the dealer, where the gear shifter bolt was tightened; however, after the repair was performed, the gear shifter detached while the contact was shifting into gear. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 17V821000 (Power Train); however, the failure occurred. The failure mileage was approximately 112,000.

    NHTSA complaint 11552210
17. Filed Dec 30, 2022Failure Dec 23, 2022110,000 milesKalispell, MTWheels

    The contact owns a 2015 Ram 3500. The contact stated while driving at approximately 30 MPH, the driver's front and driver's side rear wheels detached from the vehicle. The contact became aware of nine broken wheel studs. There was no warning light illuminated. The contact referenced the failure to NHTSA Campaign Number: 21V398000 (Wheels) however, the VIN was not included in the recall. The contact made a local dealer aware of the failure and confirmed that the VIN was not included in the recall. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the wheel studs and lug nuts needed to be replaced. The vehicle remained with the independent mechanic awaiting parts for the repair. The manufacturer was made aware of the failure. The approximate failure mileage was 110,000.

    NHTSA complaint 11499540
18. Filed Dec 17, 2022Failure Dec 1, 2022Sumner, WAService brakes

    ABS Module failed and is not reading rear wheel speed. Shop isolated issue to ABS module, and hydraulic control unit. Four safety components are no longer working as a result: ABS braking, traction control, 4wd, and rear back up sensors. This appears to be a common issue with Rams HD trucks as the parts are on back order causing me to drive my vehicle with no safety features.

    NHTSA complaint 11497892
19. Filed Dec 5, 2022Failure Aug 23, 2022Spring Run, PAAir bags, Electrical system, BodyFire

    Driving down turnpike my truck went up in flames, mopar sent investigator to determine cause of fire at dealership never called me to give me a report they emailed me to badly burnt to determine cause of fire.

    NHTSA complaint 11496055
20. Filed Jul 6, 2022Failure Jun 29, 2022Muskegon, MIService brakes, Unknown or other

    After I brought my truck in for recall Y26 they inspected the studs and said they were fine (not stretched which is what the recall is for). I took a trip and put 6,700 after the inspection and the dealer re-torqued the wheels. When I got back there seemed to be something wrong with the brakes and so I brought it back to the same dealer that inspected it before and verified the studs were not stretched, now found that the pads and rotors were damaged and the studs were studs now stretched. No problem before the recall but after the recall and new torque for the wheels the studs are stretched. Dodge said they will pay for the studs to be replaced but not the brakes. The brakes were fine before. If it were just the pads I would understand that this could be normal wear but the rotors being destroyed only on the wheels that now had stretched studs does not make any sense and given that it was inspected beforehand and only after the new torque did the studs stretch and damage the rotors it seems like they may not be fixing the issue that the recall was originally issued for, in fact, they may have made the problem worse. The representative from Dodge said they have not had any other complaints so the brake damage must not have been caused by the stretched studs.

    NHTSA complaint 11472537