2019 Ram 3500

136 complaints on file, page 1 of 7.

1. Filed Sep 29, 2026Failure Sep 25, 2026San Marcos, CAElectrical systemCrash

   On my 2019 RAM 3500, I reported a problem with th eNHSTA back in 2023, and NO response yet. This is about the integrated brake controller, that provides NO electrical signal to stop the towed trailer at speeds what apear to be below 35MPH. This is a very dangerous failure on these trucks.

   NHTSA complaint 11767624
2. Filed Sep 23, 2026Failure Mar 7, 2026Eastover, SCEngine

   1. Engine failed while driving. 2.This could have caused an accident if I were at highway speeds. 3. The cause of failure was a spent bearing on piston #3 due to lack of oil. 4. Per my mechanic an engine or rebuild kit is needed. This was a reported complaint in March of this year with a complaint number of #11724554. Their was no warning or low oil lamp which was a recall for some 2019 Rams, however my VIN was not included in that recall.

   NHTSA complaint 11766553
3. Filed Jun 15, 2026Failure Jun 11, 2026Olympia, WAFuel/propulsion system

   HAD RECALL FOR HIGH PRESSURE FUEL PUMP COMPLETED IN 12/2022 AND THE NEW PART HAS PREMATURELY FAILED CAUSING DEBRIS TO GO INTO THE FUEL SYSTEM. THE NEW PART WAS TO PREVENT THIS ISSUE FROM HAPPENING AND IT SEEMS THAT FAILURE AFTER ONLY 3 YEARS MEANS THAT A DEFECTIVE PART WAS INSTALLED OR SOME FORM OF IMPROPER INSTALLATION OCCURRED.

   NHTSA complaint 11744287
4. Filed May 14, 2026Failure Mar 18, 2026West Wareham, MAPower train

   While driving transmission just died would only go in reverse. lucky it happened at midnight so there was no traffic and was able to pull over safely. I drove truck home in reverse has I was only about 1000ft from house. Checked transmission fluid was burnt and all black. there was no warning signs check engine light came on just has it happened. I then ordered a aftermarket transmission and had it installed . When old transmission was sent back for core was told under drive and overdrive clutch packs are welded together. Was not brought to dealer because warranty was already up. didn't think to keep codes that populated when check engine light came on there was about six all seemed to do with shift solenoids. I am filling this out in case others have had same issue and maybe its a defect seems like low miles for this to have happened.

   NHTSA complaint 11737771
5. Filed Mar 23, 2026Failure Mar 6, 2003150,000 milesHuntersville, NCEngineFire

   The contact owned a 2019 Dodge Ram 3500 towing an empty container. The contact stated that while the vehicle was being driven uphill at unknown speeds, it unexpectedly caught fire. No warning lights illuminated. There were no reported injuries, air bag deployment, or police report. The fire department was on the scene, extinguished the fire, and provided a fire report. The fire chief was unable to determine the cause of the fire due to the extensive damage. The vehicle was towed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 150,000. The vehicle was deemed a total loss by the insurance company.

   NHTSA complaint 11726482
6. Filed Mar 16, 2026Failure Feb 20, 2026Taylor, PAEngine

   Driving along normal and the engine started knocking, then the noise went away and about three miles later the engine started knocking extremely loud as I attempted to get off the road safely the engine locked up, I opened th hood and seen the engine connecting rods broke out of the engine and it now has holes in the block, and needs a total replacememt

   NHTSA complaint 11724799
7. Filed Mar 16, 2026Failure Mar 8, 2026108,000 milesEastover, SCEngine and engine cooling

   The contact owns a 2019 Ram 3500. The contact stated that while driving at an undisclosed speed, the engine made an abnormal rattling sound. The vehicle was towed to an independent mechanic; however, the vehicle was not yet diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 108,000.

   NHTSA complaint 11724554
8. Filed Mar 9, 2026Failure Mar 6, 2026214,000 milesSan Jose, CAEngine, Fuel system, Diesel

   The contact owns a 2019 Ram 3500. The contact stated that while driving approximately 55 MPH, a warning light for the exhaust system illuminated, and the vehicle stalled. The vehicle was pulled over to the side of the road, and the vehicle failed to restart. The vehicle was towed to an independent mechanic, where it was diagnosed, but the vehicle was not repaired. An unknown dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was notified of the failure and confirmed that an unknown recall repair was previously completed on the vehicle. Upon investigating the failure online, the contact related the failure to NHTSA Action Number: EA23001(Fuel System, Diesel). The failure mileage was approximately 214,000. The VIN was not available.

   NHTSA complaint 11723090
9. Filed Feb 24, 2026Failure Feb 18, 2026Minerva, OHPower train

   While entering the interstate highway and accelerating to merge into traffic the transmission would not shift properly and check engine light came with code p0871. I could not fully control the speed to keep up with traffic due to the erratic shifting of the transmission and was nearly rear ended by another vehicle also merging into traffic. This could have caused a multi vehicle accident at highway speed of 65 MPH. The p0871 code is transmission fluid pressure sensor / switch c circuit range/performance. There have been previous recalls with this transmission for the same problem but my vin was not listed. Transmission would not shift properly until code is reset with scan tool.

   NHTSA complaint 11720125
10. Filed Jan 23, 2026Failure Dec 31, 2025Navassa, NCAir bags, Seat belts, Service brakes

    I lost trailer brakes, hydraulic controller not working. traction control light is on along with my airbag and my abs light comes on at times. NO REPAIRS WERE DONE YET. DEALER STATES ORC MODULE NEEDS REPLACEMENT. I believe this is an reoccurring issue.

    NHTSA complaint 11712870
11. Filed Oct 21, 2025Failure Feb 22, 2022Virginia Beach, VAAir bags, Electrical system, Service brakes

    Recurring water intrusion through firewall/wiper cowl causes electrical corrosion and loss of vehicle communication (CAN bus). Dealer repeatedly documented: • 05/19/2022: “Cowl drains clogged; water entering passenger side” (Invoice #XXX). • 08/15/2025: “Water intrusion through firewall due to wiper cowl drains being clogged with organic debris; water found in passenger kick-panel connector” (Invoice #XXX). Resulting failures include: • BCM shorted (02/16/2022 – replaced). • HVAC module failure (10/15/2022 – replaced). • Intermittent CAN bus, loss of gauges while driving (09/04/2025 – Invoice #XXX; dealer suspects internal corrosion from prior water leaks). • 10/16/2025: Dealer states “old water damage to BCM causing corrosion on circuit board and disrupting bus circuits”; BCM replaced again (Invoice #XXX). • 10/20/2025 (current): Dealer states “ORC (airbag module) dead on bus; ABS module loss-comm with ORC; replace airbag module” (Workorder #XXX). The truck has lost instrumentation and safety systems in rain, with airbag and ABS communication currently inoperative. This is a safety defect; seeking investigation and manufacturer remedy/reimbursement. Injuries/Crashes: None, near-miss due to loss of gauges. Dealer: Hall Chrysler Dodge Jeep Ram, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11694823
12. Filed Jul 22, 2025Failure Jul 21, 2025Columbia, SCPower train

    sometimes when I first start the truck and drive off, I find out that I have no throttle response at all. No smoke or abnormal noises, just a dead pedal. Then after I stop the truck and take off again it works perfectly normal. I've heard of others having this problem but haven't heard of a fix. I also can't duplicate the problem; it has only happened a couple times. I did check for any codes which I did not have any.

    NHTSA complaint 11675246
13. Filed Jun 24, 2025Failure May 2, 202555,000 milesRansomville, NYElectrical system, Engine and engine cooling

    The contact owns a 2019 Ram 3500. The contact stated that after accelerating from a red light and while driving approximately 30 MPH, there was an abnormal ticking sound coming from underneath the hood, and the vehicle started to decelerate. The contact coasted to the side of the road and inspected the engine while attempting to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to the dealer, who diagnosed that a rod had fractured in cylinder #1, causing the engine to fail. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact became aware of NHTSA Campaign Number: 20V511000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included. The manufacturer was informed of the failure and informed the contact that the VIN was not included. The failure mileage was approximately 55,000.

    NHTSA complaint 11668824
14. Filed Apr 27, 2025Failure Apr 27, 2025Pecos, TXElectrical system, Power train

    Radio some time turns off by it's self. Transmission has locked up in park after driving and put in park ,and will not go into any other gear, unless truck is turned off. After turning truck back on it will engage into preferred gear. It has done this for few time since February.

    NHTSA complaint 11657073
15. Filed Apr 2, 2025Failure Nov 15, 2023Coeur d'alene, IDAutomatic emergency braking, Unknown or otherCrash

    Firstly, I have contacted Ram about the issue and they said I can't do anything about it. It's a safety feature and it absolutely is the total OPPOSITE of a safety feature! When on icy roads, with traction control off, and in four-wheel drive, if the truck starts sliding, it cuts the power to the wheels when I need power to pull out of the slide. I've been driving in icy / snowy conditions since I was 14 years old and I'm now [XXX] . Since it cut power to the wheels, the truck continued to slide off into the ditch causing major front end damage. If there had been a person walking their dog there, they would have been killed. This happened at about 15 mph and was totally preventable if I had had control of the vehicle instead of a computer! I don't even understand what the traction control button being turned off actually does because apparently it doesn't do anything. Also, I about got thrown through the windshield when the automatic brakes came on thinking I was going to rear-end some one who was not going to be there by the time I got there! Again, not a safety feature! There definitely needs to be a way to turn these systems off completely. If I remove the fuse for the traction control system it unfortunately affects other systems as well. So that is not an acceptable fix. In my opinion, people are putting far too much trust in computer systems. I do not believe there should be a computer in control of a vehicle at any time. You will never get me in a" "self-driving car!" It's complete lunacy! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11652365
16. Filed Jan 21, 2025Failure Jan 20, 2025133,000 milesLas Cruces, NMElectrical system, Electronic stability control (esc)

    The contact owns a 2019 Ram 3500. The contact stated while driving at approximately 45 MPH, the Cruise Control was unintendedly disabled and remained inoperative. The failure occurred on several occasions. No warning light was illuminated; however, the "Electronic Stability Control System Malfunctioning" message was displayed on the instrument panel. The vehicle was taken to a dealer to be diagnosed; however, the result was unknown. The contact researched and was made aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 133,000.

    NHTSA complaint 11637478
17. Filed Jan 2, 2025Failure Jan 1, 202260,000 milesNiagara Falls, NYEngine, Diesel

    The contact owns a 2019 Ram 3500. The contact stated while driving at undisclosed speeds, there was an abnormal ticking sound coming from the vehicle. There was no warning lights illuminated. Additionally, the vehicle went into LIMP Mode, and the turbo charger became inoperable. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 60,000.

    NHTSA complaint 11633631
18. Filed Nov 15, 2024Failure Nov 13, 2024135,000 milesCarlton, GAElectrical system, Engine and engine cooling

    The contact owns a 2019 RAM 3500. The contact stated that while driving at 45 MPH, he heard an abnormal squealing sound emanating from the engine compartment, after which the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle was able to restart. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V511000 (Engine and Engine Cooling, Electrical System), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 135,000.

    NHTSA complaint 11625532
19. Filed Nov 12, 2024Failure Nov 12, 2024Whittier, CASuspension

    Front driver side. The chassis weld is broken. It’s a weld that holds the coil spring bucket. I also notice bad welds on the frame.

    NHTSA complaint 11624849
20. Filed Oct 2, 2024Failure Oct 2, 2024Sarasota, FLExterior lighting, Body

    I have problem with rear window light water leak. This light has water leak and I have a lot of water after each rain. Many of my things were destroyed because of this. I know RAM has reacalls for this huge problem, but they denied to fix my car, because there is no this recall under my VIN. But I read a lot of comments on RAM forums and many people complaining about this issue. I also saw that some people were able to fix it under the recall but I don't have any idea who I should contact for help. I need them to fix this issue in my car also, because this is manufacture issue not because of me

    NHTSA complaint 11617719