Complaints over time
Complaints about the 2005 Rexhall Rexair peaked in 2008, with 1 filed
Owner complaints about this model year, by the year they were filed with NHTSA.
Source: NHTSA ODI complaints file. The lighter column runs through October.
Model year
2005 Rexhall Rexair
Other, 4x2, built in United States. Owner complaints on file from Sep 1, 2008 to Sep 1, 2008.
Recall campaigns covering this model year22,381 vehicles or units across those campaigns
Owner complaints1Below the median 2005 other
Severity index0.02005 others average 8.5
First 24 months0Complaints in its first two years
Components
100% of complaints about the 2005 Rexhall Rexair name electrical system
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Source: NHTSA ODI complaints file. A complaint can name more than one component; it is counted under the first.
Recalls
2 recall campaigns cover the 2005 Rexhall Rexair
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 08V-319 | Jul 15, 2008 | Refrigerator may have a defect in the boiler tube | Equipment | 36 | Repair or modification |
| 07V-417 | Sep 5, 2007 | On certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the… | Equipment | 2,345 | Repair or modification |
Source: NHTSA ODI recalls file.
Owner complaints
What owners reported about the 2005 Rexhall Rexair
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
1 complaint on file, page 1 of 1.
- Filed Sep 1, 2008Failure Jul 14, 200835,928 milesST. Augustine, FLInstrument cluster/panel, Service brakes, Hydraulic
BRAKES ON 2005 REXHALL REXAIR WITH 35,298 MILES HAD BRAKE SYSTEM FAILURE. BRAKE CALIPERS SEIZED CAUSING DAMAGE TO ENTIRE BRAKE SYSTEM. BRAKES PROVED TO HAVE EXTREMELY OVERHEATED CAUSING DAMAGE TO ROTORS, PADS AND SENSORS. ALSO ELECTRICAL CLUSTER ON STEERING WHEEL FOR READING GEARS AND MILEAGE INFORMATION ALSO FAILED AND HAD TO BE REPLACED. REXHALL REFERRED US TO WORKHORSE FOR REIMBRUSEMENT. WORKHORSE REFUSED TO ACKNOWLEDGE A DEFECT AND INDICATED THAT OUR UNIT WAS OUT OF WARRANTY AND THEREFORE NOT COVERED BY THEM. THE FAILURE OF THE BRAKES COULD HAVE CAUSE A MAJOR ACCIDENT AND POSSIBLY SERIOUS OR FATAL INJURIES TO MY FAMILY. WE ARE NOT ALONE WITH THIS BRAKE PROBLEM AND WORKHORSE NEEDS TO BE HELD ACCOUNTABLE AND REIMBURSE THEIR CUSTOMERS FOR THESE FAILURES. THE COST TO US WAS $5,284.91 BUT COULD HAVE BEEN MUCH HIGHER HAD DEATH OCCURED FROM THESE FAILURES. PLEASE HELLP US RECOUP THIS REPAIR AND ADVISE OTHER RV OWNERS OF THESE DEFECTS. *TR
NHTSA complaint 10240536
Source: NHTSA ODI complaints file.
Investigations
NHTSA has not opened an investigation on this model year
Source: NHTSA ODI investigations file.
Service bulletins
No manufacturer communications on file
Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall.
Source: NHTSA manufacturer communications files.