2005 Saab 9-2X

111 complaints on file, page 1 of 6.

1. Filed Feb 10, 2025Failure Feb 10, 2025Coram, NYAir bags, Suspension

   The contact owns a 2005 Saab 9-2X. The contact received notifications of NHTSA Campaign Numbers: 11V464000 (Suspension) and 15V323000 (Air Bags); however, the parts to do the recall repairs were not yet available. The local dealer and Chevrolet 112 (631) 317-2348) were contacted but referred the contact to Subaru for recall repair assistance. The Subaru manufacturer and GM manufacturer were notified of the issue, but no assistance was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

   NHTSA complaint 11641779
2. Filed Feb 10, 2025Failure Feb 10, 2025Coram, NYAir bags

   Does recall supposed to be done under the general motors they’re refusing to do this recall. And it’s the law they have to do this recall not my fault. It’s a sob that was made by Subaru, but it’s GM’s product 05-06.

   NHTSA complaint 11641772
3. Filed Jun 1, 2021Failure May 28, 202190,000 milesIndiana, PASuspension

   The contact owns a 2005 Saab 9-2x. The contact stated while attempting to park the vehicle, the control arm fractured. There was no warning light illuminated. The vehicle was taken to a local dealer and was told rubber bushings and rubber control arm links could be worn. The control could just break apart from rust. The vehicle was not repaired. The contact stated that the vehicle was repaired in 2012 under NHTSA campaign number: 11V464000 (Suspension) however, the failure still occurred. The manufacturer had been informed of the failure but offered no additional assistance. The failure mileage was approximately 90,000. The consumer is still waiting to have the vehicle repaired. The consumer stated after arguing with GM, the appoint was set for July 16, 2021.The consumer stated it was determined to be damage a broken control arm, broken sway bar link, broken sway bar and axle being pulled from the differential. There was a temporary control arm replaced in order for the vehicle to move, but the repairs have not been made for this vehicle. The vehicle will need an alignment and parts replaced upon inspection to see if there is more damage. than initial inspection showed.

   NHTSA complaint 11419165
4. Filed Oct 21, 2020Failure Oct 20, 2020104,000 milesSahuarita, AZBody, Suspension

   IT IS A KNOWN ISSUE IN THE SAAB 9-2X COMMUNITY THAT THE REAR STRUT TOWERS RUST OUT AND FALL APART. THIS IS AN ISSUE THAT SHOULD BE ADDRESSED AS IT IS SO COMMON WHETHER IN A RUST PRONE STATE OR NOT.

   NHTSA complaint 11365493
5. Filed Oct 16, 2020Failure Jan 1, 2018140,000 milesKennewick, WABody, Suspension

   METAL PLATE REAR STRUT TOWERS RUSTING OUT. CONSTANTLY, PRESENTS POTENTIAL FOR SUSPENSION TO FAIL AND REAR RUNNING GEAR TO PUNCTURE THE BODY

   NHTSA complaint 11364632
6. Filed Oct 16, 2020Failure Oct 16, 2020100,854 milesClarkston, MIBody

   BOTH REAR LEFT AND RIGHT STRUT TOWERS BEGAN RUSTING TO THE POINT THE REAR SUSPENSION ALIGNMENT WAS CONSTANTLY SHIFTING DUE TO THE LACK OF STRUCTURE REMAINING IN THE BODY

   NHTSA complaint 11364615
7. Filed Oct 15, 2020Failure Oct 15, 2020123,100 milesWalnut, CASuspension

   MY STRUT TOWERS HAVE BEGUN TO RUST, AND IF I DON'T REPAIR AND WELD IT SOON, MY REAR STRUTS MIGHT RIP THROUGH THE TOWERS. THE REAR STRUT TOWERS OF SAAB 92X RUST OUT OVER TIME DUE TO MOISTURE GETTING THROUGH THE TOWERS AND GETTING TRAPPED UNDER SOUND DEADENING MATERIAL. THIS CAUSES VIRTUALLY EVERY NON-FAIRWEATHER 92X TO UNDERGO A RUSTED STRUT TOWER ON THE FRAME. THIS IS SUCH A PROBLEM, THE FIRST RECOMMENDED STEP WHEN BUYING USED IS TO CHECK THESE FRAMES AS THE REAR STRUTS CAN RIP THROUGH WHEN THEY ARE RUSTED AND CAUSE A POTENTIALLY FATAL ACCIDENT. THE ONLY PROPER FIX IS WELDING.

   NHTSA complaint 11364592
8. Filed Oct 15, 2020Failure Oct 5, 2019120,000 milesColumbus, OHUnknown or other

   THE FOUR BOLTS THAT THE REAR SEATS ATTACH TO HOLD MOISTURE WHICH THEN INFILTRATES THE STRUT TOWERS AND CAUSES THEM TO ROT OUT. WHAT WILL HAPPEN IS YOU CAN BE DRIVING AND WITHOUT NOTICE, A WHEEL WILL DISCONNECT FROM THE BODY OF THE CAR AND IMMEDIATELY BECOME A HAZARD THAT FORCES YOU TO WRECK THE CAR SINCE THE WHEEL IS NO LONGER ATTACHED. EVERY SAAB 9-2X HAS THIS ISSUE AND EVERY OWNER EITHER PARTS THE CAR OUT OR HAS TO HAVE IT REPAIRED WHICH I RECENTLY DID TO THE TUNE OF $1,075. JUST TO KEEP THE CAR SAFE TO DRIVE. THE FIX REQUIRES THE RUSTED AREA TO BE CUT OUT AND THEN NEW METAL WELDED IN SO IT CAN REGAIN STRUCTURAL RIGIDITY.

   NHTSA complaint 11364561
9. Filed Oct 15, 2020Failure Oct 1, 2020100,000 milesFulshear, TXBody, Suspension

   STRUT TOWERS CORROSION

   NHTSA complaint 11364554
10. Filed Oct 15, 2020Failure Oct 15, 2020Ridgefield, CTBody

    SEVERE STRUT TOWER RUST WITH MANY PEOPLES COLLAPSING. THIS IS DIRECTLY DUE TO SUBARU AND GMS MANUFACTURING OF THE CAR.

    NHTSA complaint 11364551
11. Filed Oct 15, 2020Failure Oct 1, 2020Santa Barbara, CABody

    IT IS A WELL KNOWN ISSUE WITH 2005-2006 SAAB 9-2X'S, SUBARU WRX'S THAT THE REAR STRUT TOWERS ARE PRONE TO RUST THROUGH AND CAUSE A REAR STRUT TO COMPLETELY BREAK FREE FROM THE BODY OF THE VEHICLE. THIS IS A GENERAL MOTORS/SUBARU ISSUE, SINCE THE 9-2X IS ALL SUBARU PARTS WITH SAAB BADGING.

    NHTSA complaint 11364534
12. Filed Sep 25, 2020Failure Sep 12, 2020260,000 milesHolt, MISuspension

    CAR HAS HAD THE RECALL ACTIONS PERFORMED ON THE LOWER CONTROL ARMS. THE PASSENGER CONTROL ARM FAILED IN THE SAME PLACE ADDRESSED BY THE RECALL, DESPITE HAVING THE 'FIX'. IT FAILED WHILE I WAS DRIVING ON A PUBLIC ROAD, RESULTING IN LOSS OF CONTROL AND DAMAGE OF MULTIPLE OTHER COMPONENTS.

    NHTSA complaint 11361112
13. Filed Sep 16, 2020Failure Aug 9, 2020178,000 milesSouthbury, CTSuspension

    VEHICLE WAS BACKING OUT OF A DRIVEWAY WHEN RIGHT-FRONT SUSPENSION COLLAPSED. VEHICLE WAS NO LONGER DRIVE-ABLE AS ENTIRE WHEEL ASSEMBLY WAS LOOSE AND RUBBING AGAINST CAR BODY. LUCKILY, CAR WAS ONLY MOVING AT LOW SPEED AT THAT MOMENT AND WAS STOPPED WITHOUT INJURY TO DRIVER OR DAMAGE TO OTHER CARS OR PROPERTY. CAR HAD TO BE TOWED (TAKEN TO NEAREST CHEVROLET DEALER). CHEVY SERVICE DEPARTMENT ASSESSED ISSUE, STATING THAT RIGHT FRONT CONTROL ARM CORRODED AND BROKE. OTHER SUSPENSION COMPONENTS WERE DAMAGED, AS WELL, AS A RESULT OF CONTROL ARM COLLAPSE. CAR WAS SUBJECT TO SAAB RECALL NO. 15031 (11281). THIS IS ALSO NHTSA RECALL NO. 11V-464, DATED APRIL 2012. RECALL CONCERNS CORROSION OF CONTROL ARMS. THIS VEHICLE WAS SERVICED FOR THE RECALL IN SEPTEMBER 2012, WITH CONTROL ARMS BEING INSPECTED AND UNDER-COATED. (SERVICE RECEIPT AVAILABLE IF NEEDED FOR INVESTIGATION.) CHEVY AND SAAB WOULD NOT PROVIDE REPAIR REIMBURSEMENT AS RECALL WAS OFFICIALLY CLOSED OUT. CONCERN IS THAT MANY SAAB AND SUBARU CARS ARE STILL ON THE ROAD WITH POTENTIAL FOR A CATASTROPHIC FAILURE.

    NHTSA complaint 11355344
14. Filed May 12, 2020Failure Jan 3, 2020Baton Rouge, LAAir bags

    TL* THE CONTACT OWNS A 2005 SAAB 9-2X. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V001000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED THE ROYAL BUICK GMC LOCATED AT 11055 AIRLINE HWY, BATON ROUGE, LA 70816, AND WAS INFORMED THAT THERE WERE NO TOOLS NOR A QUALIFIED SAAB TECHNICIAN ON SITE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND THE CONTACT WAS ADVISED TO CONTACT ANOTHER GM, CHEVROLET, CADILLAC OR BUICK DEALER FOR ASSISTANCE. THE CONTACT WAS UNABLE TO FIND A DEALER WITH THE TOOLS NEEDED NOR A QUALIFIED TECHNICIAN TO DO THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

    NHTSA complaint 11324244
15. Filed Sep 30, 2019Failure Apr 1, 201997,800 milesAurora, ILAir bags, Service brakes

    MY CAR WAS REPAIRED AT PATRICK CADILLAC IN SCHAUMBURG, BUT STILL THE "AIRBAG" LIGHT IS ON AT THE DASHBOARD. THE MECHANIC OLD ME THAT THE LIGHT IS NOT PART OF THE RECALL. SINCE THE LIGHT IS ON, THAT MEANS THAT THERE IS A PROBLEM WITH THE SAFETY AIRBAG. ANOTHER ISSUE IS WITH THE ABS. WHENEVER I STEP ON THE BREAKS, THE ABS SHAKES AS IF IT'S BOUNCING ON THE BREAKS, AND THE WHOLE CAR SHAKES. IS THERE A PROBLEM WITH THE ABS SYSTEMS? I THOUGHT MY BREAKS NEEDED CHANGING, AND ALL FOUR BREAK PADS WERE CHANGED, BUT THE PROBLEMS PERSISTS.

    NHTSA complaint 11258942
16. Filed Jan 22, 2019Failure Jan 20, 2019112,000 milesWest Jordan, UTFuel/propulsion system, Unknown or other

    FUEL SMELL IN COLD WEATHER. THIS SEEMS TO HAPPEN IN COLD WEATHER ONLY. WHEN I START THE CAR, I GET A SMELL OF FUEL IN THE CABIN. THE CAR IS PARKED. WHEN I HAVE THE AIR RECIRCULATION BUTTON PRESSED, THE SMELL DOES NOT ENTER THE CABIN.

    NHTSA complaint 11171294
17. Filed Nov 16, 2018Failure Oct 19, 2018130,250 milesRED Wing, MNSuspension

    THE DRIVER'S SIDE CONTROL ARM FAILED, RESULTING IN A LOSS OF STEERING CONTROL. THE CONTROL ARMS WERE SUBJECT TO A RECALL IN 2012 (WHICH WAS PERFORMED BY A SAAB DEALERSHIP AT 99,992 MILES). AFTER THE FAILURE, A SPOKESPERSON FOR THE DEALERSHIP SAID THE CONTROL ARMS WERE NOT REPLACED, BUT RATHER A CLEAR RUST PROOFING AGENT WAS APPLIED BY A SUBCONTRACTOR.

    NHTSA complaint 11152748
18. Filed Dec 26, 2017Failure Dec 26, 2017150,000 milesOklahoma City, OKFuel/propulsion system

    THE SMELL OF RAW FUEL IN THE CABIN ON COLD WEATHER STARTS. FURTHER INVESTIGATION REVEALED A FUEL LEAK UNDERNEATH THE INTAKE AND FUEL SPRAYING AND POOLING ON TOP OF THE ENGINE BLOCK. SO MUCH FUEL LEAKING THAT IT RAN DOWN AND MADE A PUDDLE UNDER THE CAR.

    NHTSA complaint 11056615
19. Filed Jul 2, 2017Failure Jun 10, 2017Cuyahoga Falls, OHEngine, Wheels

    LAST DECEMBER I TOOK MY CAR TO MIDAS ON 2625 STATE ROAD, CUYAHOGA FALLS, OH BECAUSE OF THE CHECK ENGINE LIGHT ON. THEY FIXED MY CATAYTIC CONVERTER. MY CHECK RIGHT ENGINE LIGHT WOULD NOT GO OFF. ON 022716 INV 0143048 CHECK ENGINE LIGHT WAS STILL ON. I HAD TO DO 292.69 WORTH REPAIRS.03172017 INV 0151700 1329.39 WORTH REPAIRS.41517 INV 0152375 1152.39 WORTH REPAIRS.052217 INV 0148090 1000.00 WORTH REPAIRS.ON 061017 INV 0152375 THE CATALYTIC CONVERTERS WERE REPLACED FOR FREE. THE PAIRS WERE RECALLED. TOOK THE CAR TO MAZDA OF BEDFORD. THE CHECK ENGINE LIGHT IS STILL ON.PHONE NUMBER 440 439 2323. THEY SCANNED THE CAR. THE CATALYTIC CONVERTER STILL NOT RIGHT. TOOK THE CAR TO MECHANIC. MECHANIC CLEARS THE CODE. HE TOLD ME IT IS A HISTORY CODE. MY CHECK ENGINE LIGHT IS STILL ON.

    NHTSA complaint 11002686
20. Filed Jan 7, 2017Failure Jan 7, 2017Alexandria, VAAir bags, Suspension

    TAKATA RECALL I RECEIVED A NOTICE IN THE MAIL RECENTLY FROM GM THAT SAID I NEEDED TO MAKE A SERVICE APPOINTMENT TO GET THE PASSENGER AIRBAG INFLATOR REPLACED. IT SAID TO GO TO MY.GM.COM/RECALLS AND ENTER MY VIN. I DID THAT AND IT SHOWED TWO RECALLS: ONE FOR THE AIRBAG AND AN OLDER RECALL FOR THE CONTROL ARMS. I CALLED OURISMAN GMC IN ALEXANDRIA (HTTP://WWW.CHEVROLETOFALEXANDRIA.COM/) AND SPOKE WITH VON, WHO SAID HE WAS A SERVICE MANAGER. HE SAID THAT I DID NOT HAVE ANY OUTSTANDING RECALLS. I TOLD HIM I HAD GOTTEN A CARD AND THAT MY.GM.COM/RECALLS SAID I HAD A RECALL. HE SAID THAT THE FIX HAD NOT BEEN FIGURED OUT AND THAT'S WHY I WAS NOT SHOWING UP IN THEIR DATABASE. THIS IS NONSENSE - OTHER PEOPLE WITH THE SAME CAR HAVE HAD THIS FIX DONE. HE REFUSED TO LOOK IN MY.GM.COM/RECALLS AND KEPT REPEATING THAT HE COULD ONLY USE HIS SYSTEM. I THEN CALLED ROUTE 1 BUICK GMC (HTTP://WWW.ROUTE1BUICKGMC.COM/) AND SPOKE WITH A SERVICE PERSON NAMED DIANA. SHE GAVE ME THE SAME STORY BUT WAS AT LEAST MORE POLITE ABOUT IT. THIS RECALL HAS BEEN OUTSTANDING FOR 18 MONTHS AND THE SUSPENSION RECALL HAS BEEN OUTSTANDING FOR FIVE YEARS. THEY HAVE REFUSED TO HELP ME. I COULD GET INTO AN ACCIDENT TOMORROW AND BE KILLED BY MY CAR'S AIRBAG. NEITHER PERSON WAS INTERESTED IN RESEARCHING OR ATTEMPTING TO FIGURE OUT WHY THERE WAS A MISMATCH. THIS IS NOTHING SHORT OF NEGLIGENCE. I GOT A RECALL NOTICE IN THE MAIL AND IT IS ALSO REFLECTED ON SAFERCAR.GOV.

    NHTSA complaint 10940324