2001 Saab 9-3

59 complaints on file, page 1 of 3.

1. Filed Nov 25, 2024Failure Nov 20, 2024150,000 milesMemphis, TNElectrical system, Fuel system, Gasoline

   The contact owns a 2001 Saab 9-3. The contact stated that the vehicle was overheating while driving. Additionally, the contact stated that the vehicle failed to start. A mobile independent mechanic diagnosed the vehicle and determined that the failure was related to NHTSA Campaign Numbers: 05V399000 (Electrical System) and 06V126000 (Fuel System, Gasoline). The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure. The failure mileage was approximately 150,000.

   NHTSA complaint 11627255
2. Filed Oct 11, 2021Failure Oct 11, 2021Rochester hills, MIAir bags1 injured

   unexpected and unrequested deployment of driver side seat air bag. i was driving the vehicle at a speed of 0-5mph attempting to back the vehicle into a parking spot when the driver seat air bag deployed. a report was made with the local police department. no indicator or failure lights were present, the vehicle is able to be inspected at this time for further information. It is unknown about any other inspections by anyone other than the local police department.

   NHTSA complaint 11436277
3. Filed May 17, 2021Failure May 10, 2021Durham, NCAir bags1 injured

   I left my home with my daughter in the afternoon to go to the bank and hardware store. I drove to the bank to make a deposit. We had to wait for quite awhile in the drive-through line at the bank, so I turned off my engine a couple of times rather than having the car idle. After making the deposit at the bank, I pulled out of the bank lot and began driving to the hardware store. I had driven for about two minutes and was driving along at approximately 25-30 miles an hour, and suddenly there was a terrible explosion at my left ear and massive pain in my left arm. I thought the car had been shot at and my arm hit. I was terrified we were still being shot at and looked at my daughter whose hands were over her ears. I could tell by that time that I was not bleeding and so was worried that the bullet had hit her. I could hear only faintly out of my left ear. There was smoke and the smell of an explosion. I could see by this time that an airbag had come out of my driver's seat and thought that it had been hit too. My daughter told me she was o.k. and to pull the car over so that we could see what had happened. I was shaking with fear and pain in my arm but finally calmed down enough to park the car and get out to see what had happened. It became clear that the car had not been shot at and that the driver's side seat airbag had simply spontaneously exploded without any warning whatsoever. The driver's seat side seam was completely ripped, multiple pieces of seat foam were lying about, and the air bag in the seat was out and ripped. The seat was still smoking. Luckily I had had my window completely down, or the explosion would have been louder in the car, and my arm and left side could have been more badly injured. I called my longtime Saab repairman who told me that what happened to me was extremely rare. He said I would need a new seat and that the computer system would need to be reset for the airbag system to work again. Insurance will examine soon. I may try GM too.

   NHTSA complaint 11417447
4. Filed Apr 7, 2020Failure Mar 4, 2020Bath, MEAir bags, Engine, Service brakes

   NO INCIDENT

   NHTSA complaint 11320371
5. Filed Feb 18, 2019Failure Feb 5, 2019119,800 milesChicago, ILFuel/propulsion system

   EXCESSIVE LEAKING. WAS DRIVING ON E-WAY AND ENGINE STOPPED OR SOMETHING OCCURED WHERE IT SOUNDED AS IF THE CAR TURNED OFF. THE BATTERY WAS WORKING BUT, WHEN I PRESSED ON ACCELERATOR IT DIDN'T PROPEL FORWARD. I CAREFULLY STEERED WITH HAZARD LIGHTS TO SIDE OF THE ROAD. IGNITION CRANKS BUT, CAR WON'T TURN OVER. REPLACED DIRECT IGNITION COIL, CRANKSHAFT SENSOR BUT, ISSUE SEEMS TO BE THE FUEL PUMP. A RECALL WAS ISSUED REGARDING THIS: RECALL 06V126000 AFFECTED CARS SAAB 9-3 2001 ENGINE, MAY 12, 2006 ORIGINAL RECALL FROM THE NHTSA MANUFACTURER'S REPORT DATE MAY 12, 2006 NHTSA ACTION NUMBER RQ05003 POTENTIAL NUMBER OF UNITS AFFECTED 11,886 NHTSA CAMPAIGN ID NUMBER 06V126000 COMPONENT FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS SUMMARY ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION. CONSEQUENCE OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.

   NHTSA complaint 11180926
6. Filed Sep 1, 2016Failure Aug 25, 2016114,000 milesAstoria, NYElectronic stability control (esc), Fuel/propulsion system, Unknown or other

   WHEN I CHANGED THE BATTERY OF THE CAR KEY, ITS DOORS AND TRUNK STOPPED LOCK AND UNLOCK. THE BELT OF THE GAS TANK WAS BROKEN ALSO. I REPLACED ALSO THE FUEL TANK.

   NHTSA complaint 10903028
7. Filed Feb 4, 2016Failure Jan 1, 2016186,000 milesMethuen, MAElectrical system

   TL* THE CONTACT OWNS A 2001 SAAB 9-3. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHILE THE BATTERY WARNING INDICATOR WAS ILLUMINATED. IN ADDITION, THE VEHICLE WOULD STALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION DISCHARGE MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V399000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 186,000.

   NHTSA complaint 10824221
8. Filed Aug 6, 2014Failure Oct 9, 201092,800 milesLawrenceville, GAAir bags, Roof and pillarsCrash1 injured1 killed

   TL * THE CONTACT OWNED A 2001 SAAB 9-3. THE CONTACT WAS INVOLVED IN A CRASH AND THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DESTROYED. THE DRIVER DIED AND A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE SPEED WAS 40-45 MPH. THE FAILURE MILEAGE WAS 98,000. UPDATED 09/11/14*LJ THE CONSUMER STATED THE 7 YEAR OLD PASSENGER WAS RUSHED TO THE HOSPITAL. THE A PILLAR AS WELL AS THE ROOF CAVED IN. POLICE DETERMINED VEHICLE SPEED WAS NOT A FACTOR. UPDATED 1/13/2015 *JS

   NHTSA complaint 10619311
9. Filed Jul 13, 2014Failure Jul 1, 201395,000 milesBoyertown, PASeat belts

   WHEN COMING TO A STOP AT AN INTERSECTION, THE DRIVERS SIDE SEAT BELT LOCKS REPEATEDLY MAKING IT IMPOSSIBLE TO LEAN FORWARD TO SEE IF THE INTERSECTION IS CLEAR. EVEN AFTER SLOWLY LEANING ALL OF THE WAY BACK AND TRYING TO LEAN FORWARD AGAIN, IT LOCKS. THE SEAT BELT MUST BE REMOVED TO AVOID BEING HELD BACK IN THE SEAT AND UNABLE TO SEE. IN ADDITION, WHEN TRYING TO REMOVE THE SEAT BELT, THE BUTTON STICKS AND MUST BE PRESSED SEVERAL TIMES BEFORE IT RELEASES. *TR

   NHTSA complaint 10610224
10. Filed Nov 6, 2013Failure Nov 2, 2011100,000 milesSunset, MEVehicle speed control

    TL* THE CONTACT OWNS A 2001 SAAB 9-3 CONVERTIBLE. THE CONTACT STATED WHILE ATTEMPTING TO ENGAGE THE BRAKE PEDAL, THE ACCELERATOR PEDAL EXTENDED TO THE FLOOR WITH OUT ANY WARNING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 108,000.

    NHTSA complaint 10551077
11. Filed Nov 23, 2012Failure Nov 21, 201289,801 milesSAN Ramon, CAElectrical system, Module

    BROUGHT MY 2001 SAAB 9-3 FOR CAMPAIGN RECALL 05V399000 IDM TO DIRITO BROTHERS SAAB OF WALNUT CREEK, CALIFORNIA. DEALER STATED NOT REQUIRED TO CHANGE THE IDM. IF MY IDM FAILS AT A LATER DATE, I COULD BE SUSCEPTIBLE TO INJURY OR DEATH. NEED TO KNOW IF DEALER IS REQUIRED TO CHANGE IDM. *TR

    NHTSA complaint 10485860
12. Filed Mar 12, 2011Failure Mar 5, 201185,000 milesBarrington, ILSeats

    SAAB 93 - HEATED DRIVER SEAT MELTED A HOLE IN THE SEAT. *TR

    NHTSA complaint 10389949
13. Filed Sep 18, 2010Failure Mar 10, 200975,000 milesFairmont, WVEngine and engine cooling

    AT APPROXIMATELY 75,000 MILES, DRIVING ON THE INTERSTATE AROUND 70MPH, OIL LIGHT BEGINS FLICKERING. AFTER SLOWING DOWN TO 60 THE LIGHT STOPPED FLICKERING AND INSTEAD STAYED ON. FROM THE TIME I WAS ABLE TO SLOW DOWN TO PULL OFF THE ROAD A KNOCKING SOUND COULD BE HEARD FROM THE ENGINE PROGRESSIVELY GETTING LOUDER. THE CAR WAS THEN TAKEN HOME AND INSPECTED. REMOVING THE OIL PAN REVEALED THAT THE OIL PICK-UP TUBE WAS CLOGGED AND THE PAN WAS CAKED WITH BURNT OIL. A LOCAL MECHANIC ESTIMATED $3,000 TO REPAIR THE INTERNAL DAMAGE. CALLED SAAB, THEY SAID THE CAR WAS BEYOND ANY WARRANTY AND THAT IT WAS MY FAULT FOR NOT TURNING THE CAR OFF IMMEDIATELY AFTER SEEING THE LIGHT. FURTHERMORE AFTER RESEARCHING THIS ISSUE, I SPOKE WITH 3 SAAB REPRESENTATIVES WHO CLAIMED TO KNOW NOTHING OF THIS OIL SLUDGE ISSUE AND WERE NOT ABLE TO BRING IT UP AS IT DOES NOT HAVE A RECALL NUMBER, A FOURTH ONE WAS ABLE TO PULL UP A RECORD BASED ON MY V.I.N. SHOWING THAT THIS KNOWN OIL SLUDGE PROBLEM WAS "REPAIRED" BACK IN 2006 UNDER THE NAME "SPECIAL POLICY" WHICH WAS GOOD FOR 8 YEARS AFTER THE IN SERVICE DATE SO LONG AS ALL RECORDS OF THE CAR WERE KEPT. ACCORDING TO THIS REPORT MY ARGUMENT WAS POINTLESS CONSIDERING I WAS APPROXIMATELY 5 MONTHS OUT OF WARRANTY AND DID NOT HAVE THE REQUIRED SERVICE LOGS. *TR

    NHTSA complaint 10356233
14. Filed Aug 4, 2010Failure May 16, 2010110,048 milesBoise, IDElectrical system, Power train

    DRIVING ON FREEWAY ON RAMP, WITHOUT WARNING VEHICLE LOST ALL POWER IN THE MIDDLE OF TRAFFIC, ALMOST CAUSING A SERIOUS CRASH. TOOK VEHICLE TO MECHANIC AND IT WAS DISCOVER THAT THERE WAS A FAULTY THROTTLE BODY. PART WAS REPLACED. *TR

    NHTSA complaint 10347341
15. Filed Apr 26, 2010Failure Sep 15, 200995,000 milesStamford, CTEngine and engine cooling

    TL*THE CONTACT OWNS A 2001 SAAB 9-3. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE OIL PRESSURE LIGHT ILLUMINATED. THE CONTACT TURNED THE VEHICLE OFF AND THE LIGHT TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE MECHANIC FLUSHED THE OIL SLUDGE OUT. THE CURRENT MILEAGE WAS APPROXIMATELY 102,500. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. UPDATED 07/15/10 *BF THE CONSUMER STATED HE RECEIVED A LETTER FROM SAAB ACKNOWLEDGING A PROBLEM WITH SEVERAL YEAR MODELS REGARDING INTERNALLY LUBRICATED ENGINE PARTS. THE LETTER STATED THEY WERE EXTENDING THE WARRANTY FOR A TOTAL OF EIGHT YEARS FROM THE SERVICE DATE WITH UNLIMITED MILEAGE. THE CONSUMER STATED HIS COVERAGE EXPIRED. THE COST TO REPAIR THE PROBLEM WAS $2500. UPDATED 07/19/10*JB

    NHTSA complaint 10327518
16. Filed Jul 28, 2008Failure Jun 24, 200875,000 milesCincinnati, OHFuel system, Hoses, Lines/piping, And fittings

    NHTSA CAMPAIGN ID # 04V557000 AND 06V126000 ARE RECALLS WHICH NECESSITATED SAAB TO INSPECT THE FUEL PUMP BRACKETS. THE 2001 SAAB 9-3, WHICH I OWN, WAS FIRST REPAIRED BECAUSE THE FUEL LINES WERE CORRUPTED AND CAUSED FUEL TO PUMP OUT INTO THE OPEN ON TOP OF THE GAS TANK. THIS WAS REPAIRED UNDER WARRANTY AND WAS NOT UNDER RECALL AT THAT TIME. MUCH LATER, I RECEIVED A RECALL NOTICE FOR AN INSPECTION OF THE FUEL PUMP BRACKET TO MAKE SURE THE A "NEW" BRACKET HAD BEEN INSTALLED. THESE TWO INSPECTIONS REQUIRED THE LOWERING OF THE FUEL TANK. I RECEIVED A CODE 0442 A FEW MONTHS LATER AND HAD THE SAAB DEALER INSPECT POSSIBLE CAUSE. IT WAS DISCOVERED THAT THE VENT HOSE FILLER PIPE HAS A LEAK AS DETERMINED BY A "SMOKE" CHECK. LATER, AT A DIFFERENT SHOP, WHILE HAVING A TIRE ROTATION, THE TECHNICIAN HAD ME COME OUT AND CHECK THE RIGHT WHEEL AREA WITH THE WHEEL ASSEMBLY REMOVED. WHAT WAS REVEALED WAS A "RUB" HOLE IN THE VENT HOSE CAUSED BY CONTACT WITH THE SHOCK ABSORBER. I HAVE DIGITAL PHOTOS OF THE DAMAGE. THE DAMAGED VENT LINE IS EITHER 1) POOR ENGINEERING OF THE VENT LINE IN RELATION TO THE SHOCK ABSORBER, OR 2) THE DAMAGE WAS THE ACT OF POOR RE-INSTALLMENT OF THE FUEL TANK EITHER ON THE REPAIR OR LATER INSPECTION. MY QUESTION IS THIS, " HAS THERE BEEN ANY REPORTS OF SHOCK ABSORBERS, OR OTHER PARTS, CAUSING HOLES IN THE VENT LINES WHICH PASS NEAR THE RIGHT WHEEL ASSEMBLY?" SAAB HAS NOT BEEN VERY HELPFUL IN TRYING TO RESOLVE THIS ISSUE. *TR

    NHTSA complaint 10236004
17. Filed Jul 9, 2008Failure Jul 8, 200760,000 milesPittsburgh, PAInstrument cluster/panel, Service brakes, Hydraulic

    TL*THE CONTACT OWNS A 2001 SAAB 9-3. WHILE DRIVING AT ANY SPEED, THE INSTRUMENT PANEL STOPPED FUNCTIONING AND THE BRAKE PEDAL HAD TO BE APPLIED WITH MORE PRESSURE THAN NORMAL TO STOP THE VEHICLE. THE FAILURE OCCURS EVERY TIME THE VEHICLE IS DRIVEN. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO THE FAILURE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 70,000 AND FAILURE MILEAGE WAS 60,000.

    NHTSA complaint 10233628
18. Filed Apr 28, 2008Failure Dec 14, 200693,000 milesMcallen, TXElectrical system

    THE DIRECT IGNITION CASSETTE HAS BEEN REPLACED FOUR DIFFERENT TIMES. THE INITIAL REPLACEMENT WAS ONLY 8,000 MILES INTO THE ORIGINAL OWNERSHIP. THE LAST TWO WERE IN 2006 WITH 80,000 MILES. IT IS APPARENT CONTINUED PROBLEMS HAVE BEEN EXPERIENCED WITH THIS VEHICLE. *TR

    NHTSA complaint 10225893
19. Filed Apr 18, 2008Failure Apr 18, 200882,347 milesMadison, ALModule, Engine and engine cooling, Latch

    TL*THE CONTACT OWNS A 2001 SAAB 9-3. WHILE DRIVING 70 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT DROVE TO THE DEALER AND THEY STATED THAT THE IGNITION CASSETTE FAILED. SHE THEN FOUND A RECALL ON HER VEHICLE FOR THE SAME FAILURE HER VEHICLE WAS EXPERIENCING; HOWEVER, THE DEALER STATED THAT HER VIN WAS NOT INCLUDED. THE CONTACT BELIEVES THAT HER VEHICLE SHOULD BE INCLUDED IN THE RECALL BECAUSE IT IS EXPERIENCING THE SAME FAILURE. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 82,347. UPDATED 05/20/08. *LJ THE DOOR HANDLE WAS REPLACED. UPDATED 05/20/08

    NHTSA complaint 10224915
20. Filed Mar 11, 2008Failure Dec 19, 200761,300 milesFairfield, CTEngine

    2001 SAAB 9-3 WITH OIL LIGHT ILLUMINATED. CONSUMER STATES THAT THE VEHICLE WOULD NOT RESTART WHEN PULLED TO THE SIDE OF THE ROAD. CONSUMER STATED THAT THERE WERE A LOT OF REPORTS OF OIL SLUDGE ON THIS MAKE AND MODEL. *KB THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER AND WAS INFORMED THE VEHICLE NEEDED A NEW ENGINE, DUE TO SLUDGE BUILD-UP IN THE OIL PAN.

    NHTSA complaint 10220651