2008 Saab 9-3

184 complaints on file, page 1 of 10.

1. Filed Jun 26, 2026Failure Jun 26, 2026Farmington, NYAir bags, Electrical system, Seat belts

   I have been trying to get this recall done for many years and with no luck. Most recently June 26th 2026 I was informed my recall was not fixable again and I hope for the last time. Enough is enough! Van Bortel Chevrolet in Macedon Ny tried again today which is there 2nd attempt. I had to buy a software card to give them the tool they didn’t have to fit in there tech 2 scanner and even with the card they were unable to fix. It’s a major safety issue I have been more than patient with and can’t even begin to tell you over the years how much time and money spent trying to fix. I think at this point they need to replace car with similar or purchase from me.

   NHTSA complaint 11746834
2. Filed Dec 6, 2025Failure Dec 6, 2025Mölndal, AKAir bags

   Hello, I know the Takata airbag has to be replaced on my car. However now I do live abroad, in Gothenburg Sweden in Europe. How do I get the replacement done? Should I go to GM here in Europe? Thanks

   NHTSA complaint 11703471
3. Filed Aug 30, 2024Failure Aug 30, 2024Lapine, ALAir bags

   The contact owns a 2008 Saab 9-3. The contact received notifications of NHTSA Campaign Numbers: 14V318000 (Seat Belts) and 16V063000 (Air Bags); however, the parts to do the recall repairs were not yet available. The local dealer was contacted; however, the dealer declined to service the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

   NHTSA complaint 11611827
4. Filed Feb 18, 2023Failure Feb 18, 2023East Stroudsburg, PAPower train

   at about 98,000 miles the starts to fail transmission fails Also when the car gets too cold in the winter it refuses to start and it is not a battery issue. the cylinders get to cold to start. When the warm weather comes back around it starts again.

   NHTSA complaint 11508009
5. Filed Jul 28, 2021Failure Dec 31, 2015Eagle, COSeat belts

   Driver seat belt fails to retract. When retraction failure occurs, it is obvious to the seat occupant immediately. If a crash were to occur with a seat belt in this condition, the result could increase the risk of injury to the driver. The seat belt retraction failure has been reproduced and confirmed. No warning lamps but, the seat belt showed earlier symptoms of not working properly, by not engaging when hard braking occurred. I will have the tensioner replaced.

   NHTSA complaint 11426755
6. Filed Jan 25, 2021Failure Aug 2, 2020Ledbetter, TXAir bags, Electrical system, Seats

   AIRBAG MALFUNCTION CONTACT SERVICE

   NHTSA complaint 11389921
7. Filed Dec 30, 2020Failure Dec 29, 2020NEW Hartford, NYEngine

   HAD TO HAVE VALVE JOB DONE DUE TO BAD /DEFECTIVE/INFERIOR INTAKE VALVES, FROM MANUFACTURER. HAD TO HAVE ALL INTAKE VALVES REPLACED, WITH MODIFIED/UPGRADED INTAKE VALVES. OBTAINED PO300 - RANDOM MISFIRE CODES, HAD ROUGH IDLE, CHECKED ENGINE COMPRESSION, HAD 45PSIG IN CYLINDER NUMBER 4. ENGINE HAD 72862MILES, ON IT, THIS SHOULD BE COVERED UNDER WARRANTY BY SAAB/GM.

   NHTSA complaint 11385659
8. Filed Dec 3, 2020Failure Nov 11, 2020160,000 milesGreenwich, NYEngine, Fuel/propulsion system

   MY VEHICLE DOESN'T START/IDLE WELL IN THE COLD DUE TO THE AIR INTAKE MANIFOLD BOLTS SLOWLY BECOMING LOOSE. **WHEN DRIVING AND SHIFTING** THE VEHICLE CANNOT HANDLE THE EXTRA UNCLEAN AIR ENTERING THE SYSTEM AND WILL STALL OUT WHILE GOING ANYWHERES FROM 0-60+ MPH, ONCE THE ENGINE SHUTS OFF ALL POWER STEERING ALSO SHUTS DOWN. THE SECONDARY ISSUE IS AN ACCELERATION PROBLEM BECAUSE THE SEALS ON THE AIR INTAKE VALVES INTO THE COMBUSTION CHAMBER HAVE BECOME FAULTY RESULTING IN CYLINDER MISFIRES AND A HIGH AMOUNT OF VIBRATION INTERMITTENTLY WHILE DRIVING, THE SYMPTOMS COME AND GO WITH INCREASING FREQUENCY AS TIME GOES ON. THIS SECONDARY ISSUE TIES INTO THE FIRST ISSUE BECAUSE OF SHIFTING WITH A STANDARD MY VEHICLE TODAY (12/3/2020) SHUT OFF WHILE DRIVING 7 TIMES TO AND FROM MY JOB.

   NHTSA complaint 11377764
9. Filed Jul 5, 2020Failure Jul 5, 2020101,000 milesWilmington, DEEngine, Fuel/propulsion system, Unknown or other

   MY CAR WOULDN'T START SO I REPLACED THE BATTERY AND THE CRANKSHAFT SENSOR. IT DROVE FINE AND THEN I PARKED IT AND WENT OUT A LITTLE LATER AND IT WOULD JERK AND TRY TO STALL WHILE I WAS DRIVING, SPUTTERING LIKE I WAS RUNNING OUT OF GAS. IF I PRESSED THE ACCELERATOR, IT WOULDN'T ACCELERATE AND THEN IT WOULD SURGE FORWARD. I RAN SOME ERRANDS AND IT DROVE FINE. AFTER MY FINAL ERRAND, THE CAR STRUGGLED TO START BUT DID AND IDLED REALLY ROUGHLY. I PUT IT INTO GEAR AND IT DIED. I COULDN'T GET IT STARTED AGAIN. AFTER READING OTHER POSTS, THIS SEEMS LIKE AN ISSUE WITH THESE YEARS AND VEEY DANGEROUS.

   NHTSA complaint 11337573
10. Filed May 6, 2020Failure May 5, 2020157,000 milesMerrimack, NHEngine

    I BROUGHT MY 08 SAAB 9-3 TO A SHOP FOR A COMPRESSION TEST CAUSE IT KEPT STALLING WHEN I WOULD GO TO START IT, IT'S AN AUTOMATIC. I WAS TOLD MY INTAKE VALVES WERE WEARING DOWN AND IT'S DUE TO GMS FAULTY VALVES. YESTERDAY MY CAR STARTED TICKING WHILE I WAS DRIVING AND I LOST ALMOST ALL MY POWER, COME TO FIND OUT MY VALVES WERE ABOUT TO SNAP. NOW I'M MAKING PAYMENTS ON A CAR I CAN'T DRIVE AND GM REFUSES TO FIX THIS ISSUE AND THERE ARE MULTIPLE CASES OF THIS HAPPENING TO 08-10 SAAB 9-3 WITH THE GM FACTORY VALVES. *TR

    NHTSA complaint 11323555
11. Filed Apr 21, 2020Failure Jan 16, 2020109,500 milesPort Orchard, WAEngine

    EXPERIENCED HARD STARTING IN COLD WEATHER IN THE PACIFIC NORTHWEST THE PAST FEW YEARS. DID RESEARCH AND FOUND A TSB REGARDING THE INTAKE VALVES FOR 2.0 ECOTEC 4 CYLINDER. HAD A COMPRESSION TEST FOLLOWING SEVERAL CHECK ENGINE LIGHTS AND MULTIPLE READINGS DIAGNOSE A P0300 ENGINE CODE . COLD AND WARM COMPRESSION TEST SHOWED CYLINDER 2 COMPRESSION WELL OUT OF SPECIFICATION. DOCUMENTS AVAILABLE UPON REQUEST. QUOTED $4000 FOR ENGINE REBUILD.

    NHTSA complaint 11321867
12. Filed Feb 20, 2020Failure Feb 1, 201780,000 milesPhoenixville, PAEngine

    THE VALVES ON THESE CARS ARE DEFECTIVE AND START FAILING AROUND 60K MILES. THIS IS A WIDELY KNOW ISSUE AFFECTING THE 2008 SAAB 9-3 2.0L ENGINES. GM NEEDS TO TAKE RESPONSIBILITY FOR THESE REPAIRS GIVEN THE KNOWN MANUFACTURING DEFECTS. CAR WILL NOT START WHEN COLD AND THERE IS NOTHING THE DEALER CAN DO OTHER THAN PERFORM A MAJOR VALVE JOB (+$2300) => HTTPS://WWW.SAABCENTRAL.COM/THREADS/08-SAAB-COLD-START-ROUGH-IDLE.327778/

    NHTSA complaint 11310390
13. Filed Feb 9, 2020Failure Feb 9, 2020109,700 milesPort Orchard, WAEngine, Fuel/propulsion system, Power train

    SIGNIFICANT DECREASE IN AVERAGE MPG (PROBLEM FROM RESEARCH ONLINE SUGGESTS IT IS FROM LOWERED COMPRESSION FROM INTAKE VALVE DESIGN/MATERIAL USED). 109700 MILES ON ENGINE. METICULOUSLY MAINTAINED BY US NAVY SUBMARINER. HAVEN'T CONTACTED GM OR SAAB AFFILIATE YET. FORUMS USED INFER THIS PROBLEM IS WIDESPREAD FOR 2007-2009 SAAB 9-3 2.0T WITH B207 ENGINE. SUMMER TIME MPG IS AROUND 32-33, WINTER MPG IS 30-31 IN THE PACIFIC NORTHWEST. LAST 3 FILL UPS, AVERAGE MPG HAS DROPPED STEADILY FROM 30.5 TO 26 ON THE MOST RECENT FILL UP. RESPECTFULLY REQUEST TO KNOW IF A RECALL OR FINANCIAL COMPENSATION BY THE MANUFACTURER TO CONSUMERS HAS BEEN ORDAINED?

    NHTSA complaint 11308102
14. Filed Sep 25, 2019Failure Dec 8, 2018100,000 milesHowe, TXEngine

    ROUGH IDLE AND START ON COLD STARTS. THIS ISSUE IS WELL KNOWN IN THE SAAB COMMUNITY DUE TO GM PUTTING WEAK MATERIAL IN FACTORY FUEL INJECTOR VALVES. ENGINE LOSES COMPRESSION UNTIL CAR IS WARM, BUT MAY RESULT IN STALLS OR LIMP MODE

    NHTSA complaint 11258196
15. Filed Feb 7, 2019Failure Jan 29, 2019150,000 milesHartland, MIEngine

    VEHICLE EXHIBITS ALL SIGNS OF PREMATURE INTAKE VALVE WEAR CAUSING LOSS OF COMPRESSION AND/OR HARD START/NO START WHEN AMBIENT AIR TEMP IS BELOW 40 DEGREES. SEE ALL PREVIOUS COMPLAINTS OF THE SAME ISSUE!

    NHTSA complaint 11174994
16. Filed Dec 10, 2018Failure Dec 10, 2018129,200 milesBriarcliff Manor, NYEngine

    JUST PURCHASE VEHICLE FROM A FRIEND 2008 SAAB 9-3 2.0T CONVERTIBLE . WHEN I FIRST START UP THE VEHICLE (IT IS NOW COLD OUTSIDE) THE ENGINE IS RUNNING RUFF UNTIL IT WARMS UP. I UNDERSTAND MANY OTHER SAAB 2008 OWNERS HAVE THE SAME COMPLAINT AND HAVE READ THAT THE INTAKE VALUES USED BY GM ARE FAULTY.

    NHTSA complaint 11160594
17. Filed Jun 3, 2018Failure Aug 10, 201669,030 milesAvon, COSuspension

    BOTH FRONT COIL SPRINGS WHILE DRIVING, SNAPPED IN HALF, AND DISLOCATED FROM VEHICLE, 6 MONTHS APART. WAS DRIVING AT 30 MPH, AND THE PASSENGER FRONT SPRING SNAPPED IN TWO. HAD NO FOREWARNING, BEFORE IT EXPLODED APART. THE PASSENGER-SIDE COIL-SPRING SNAPPED OFF THE VEHICLE, IN TWO+ PLACES, AND WAS RETRIEVED FROM THE HIGHWAY. METAL SHOWED A CLEAR SNAP. THE METAL APPEARED CORRODED AND AS IF THE METAL WAS NOT STRONG ENOUGH TO WORK LONG-TERM. SIX MONTHS LATER, THE DRIVER SIDE FRONT-COIL-SPRING SNAPPED AND DISLODGED IN THE EXACT SAME MANNER, AND WHEN THE FAILED PIECE WAS RETRIEVED FROM THE HIGHWAY, IT SHOWED THE SAME CLEAR SNAP LINES, AS ITS PREDECESSOR. BOTH INSTANCES CAUSED THE CAR TO LOSE CONTROL. CLEARLY A MANUFACTURING DEFECT WITH SUB-PAR METALLOIDS THAT LIKELY WILL KILL SOMEONE IF THEY ARE TRAVELING FAST. PLEASE RECALL AS ITS THE SAME DEFECT THAT APPEARS IN 2003 - 2006 SAAB MODELS. IN 2010, GENERAL MOTORS OFFERED AN EXTENDED WARRANTY ON ABOUT 66,000 2003 - 2006 SAAB 9-3 VEHICLES TO COVER THE COST OF REPLACING FRONT SPRINGS THAT BREAK DUE TO CORROSION. THE MECHANIC STATED THAT THIS WAS A COMMON OCCURRENCE ON FOR SAAB 9-3 MODELS, BUT IS NOT COVERED BY GM SPECIAL COVERAGE #15917 BECAUSE THAT EXTENDED WARRANTY ONLY APPLIES TO 2003-2006 VEHICLES.

    NHTSA complaint 11099432
18. Filed Jun 3, 2018Failure Jul 5, 201774,653 milesAvon, COElectrical system1 injured

    ACCIDENT HAPPENED AFTER HEADLIGHT LOW-BEAM FAILED.WAS TOLD AND SHOWN A MELTED HEADLIGHT MODULE THAT OVERHEATED AND CAUSED THE LOW-BEAM HEADLIGHTS TO GO OUT. THE ENTIRE HEADLAMP ASSEMBLY WAS REPLACED. AS WERE OTHER CRASH INVOLVED PARTS

    NHTSA complaint 11099428
19. Filed Mar 29, 2018Failure Mar 23, 2018100,050 milesAtlanta, GAUnknown or other, Vehicle speed control

    CONCERN 1 AS A FEMALE IT IS A SAFETY ISSUE TO BE STRANDED IN MY VEHICLE, RECENTLY WHAT I THOUGHT WAS A BATTERY ISSUE TURNED OUT TO BE A KEY FOB ISSUE. I HAVE BEEN STRANDED WITH A WELL CARED FOR VEHICLE THAT HAS KEYS THAT START AND GET TO DESTINATION, BUT HAVE GOTTEN BACK IN MY VEHICLE AND THE CAR DOES NOT RECOGNIZE THE FOB. CONCERN 2 I HAVE NOTICED THAT THE CRUISE CONTROL IS AUTOMATICALLY COMING ON, AND I HAVE TO MANUALLY TURN IT OFF, THERE HAVE BEEN TIMES WHEN I WAS NOT AWARE UNTIL UNTIL I TOOK FOOT OFF ACCELERATOR AND THE CAR STILL TRAVELED AT THE CRUISE SPEED, TAPPING THE BRAKE DID NOT DISENGAGE THE CRUISE SETTING.

    NHTSA complaint 11082035
20. Filed Mar 7, 2018Failure Feb 2, 2018Lenexa, KSEngine

    CAR STRUGGLED TO START WHEN THE TEMPERATURE WAS BELOW 40 DEGREES. AFTER A NUMBER OF TRIPS TO THE SHOP THAT MAINTAINS MY CAR THEY RESEARCHED ONLINE THAT THIS WAS A COMMON PROBLEM FOR SAAB WITH THIS ENGINE AND GM ISN'T WILLING TO DO ANYTHING ABOUT IT. PLEASE DO SOMETHING!

    NHTSA complaint 11076793