2002 Saturn VUE

167 complaints on file, page 1 of 9.

1. Filed Feb 23, 2021Failure Jul 26, 2020107,257 milesChicopee, MAElectrical system, Engine, Fuel/propulsion system

   CAR POWER SHUTS DOWN WHILE DRIVING, UNABLE TO START AGAIN IN ANY TRAFFIC OR ROAD CONDITIONS TO MOVE CAR TO A SAFE AREA. FULL LOSS OF POWER UNEXPECTED, VEHICLE SIMPLY STOPS RUNNING. THIS VEHICLE WAS PURCHASED 'USED' FROM A PRIVATE SELLER I SUSPECT WAS WELL AWARE OF THE SITUATION BUT DIDN'T EXPOSE IT. $2300 SPENT SO FAR WITH NO FINDINGS AS TO WHY THE PROBLEM OCCURS. ONLY AN ADDED 30 MILES TO THE ODOMETER SINCE PURCHASE. PRESENT READING IS 107,251.

   NHTSA complaint 11397618
2. Filed Jun 5, 2020Failure Jun 1, 2020Columbus, OHFuel/propulsion system

   AIR INTAKE THROTTLE IS FAULTY. MAKING THE ENGINE RUN ROUGH AND CAUSING OTHER PROBLEMS SUCH AS EXCESSIVE FUEL CONSUMPTION. *TR

   NHTSA complaint 11327414
3. Filed Jun 2, 2020Failure Feb 14, 2020Loveland, COElectrical system, Unknown or other

   THE IGNITION IS FAULT. THE KEY CAN BE REMOVED WHEN VEHICLE IS IN ON POSITION. *TR

   NHTSA complaint 11326985
4. Filed Jan 6, 2020Failure Dec 23, 2019120,000 milesSEA Grit, NJElectrical system

   TL* THE CONTACT OWNS A 2002 SATURN VUE. WHILE DRIVING 30 MPH, SEVERAL DASHBOARD WARNING INDICATORS ILLUMINATED, INCLUDING THE BATTERY WARNING INDICATOR. SIMULTANEOUSLY, THE POWER STEERING SEIZED OPERATION TEMPORARILY AND CAUSED THE VEHICLE TO SWERVE. ALSO, WHILE TRAVELING UP AN INCLINE, THE BATTERY WARNING INDICATOR FLASHED AND THEN TURNED OFF WHEN DRIVING ON LEVELED GROUND. A FAX WAS SENT TO THE VICE PRESIDENT OF SAFETY AT GENERAL MOTORS IN REGARDS TO THE FAILURE; HOWEVER, THERE WAS NO RESPONSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. *JS

   NHTSA complaint 11297354
5. Filed Sep 13, 2018Failure Jul 31, 2018Bremerton, WAStructure

   2002 SATURN VUE. CONSUMER IS SEEKING REIMBURSEMENT FOR VEHICLE AMOUNT. CONSUMER STATES THAT THE FRAME WAS BROKEN AND RUSTED MAKING VEHICLE UNSAFE TO DRIVE. *LD THE CONSUMER STATED THE VEHICLE WAS LOCATED AT AN IMPOUND YARD. THE CONSUMER WAS INFORMED THE VEHICLE WAS NOT ABLE TO BE REPAIRED. *JS

   NHTSA complaint 11128990
6. Filed Apr 3, 2017Failure Mar 31, 2017151,000 milesConnelly Springs, NCEngine

   TL* THE CONTACT OWNS A 2002 SATURN VUE. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD AN ABNORMAL NOISE UNDERNEATH THE HOOD OF THE VEHICLE. THE TEMPERATURE WARNING INDICATOR ILLUMINATED AND THE VEHICLE STARTED TO OVERHEAT. THE CONTACT STOPPED TO CHECK THE ENGINE AND NOTICED THAT THE ANTI-FREEZE CONTAINED OIL. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 151,000.

   NHTSA complaint 10970331
7. Filed Jan 3, 2017Failure Jan 2, 2017130,000 milesLindenhurst, NYEngine

   WHILE DRIVING AT HIGHWAY SPEEDS, VEHICLE STALLED,AND WOULD NOT RESTART. VEHICLE COASTED TO LANE OFF TRAFFIC. VEHICLE WOULD NOT MOVE. FAMILY OF FOUR IN VEHICLE. HAD A POLICE OFFICER SHUT DOWN LANE OF TRAFFIC. VERY VERY DANGEROUS. DIAGNOSIS: TIMING CHAIN. *TR

   NHTSA complaint 10939543
8. Filed Sep 30, 2016Failure Sep 30, 2016155,000 milesMorongo Valley, CAUnknown or other

   STARTED THE CAR, TURNED AROUND IN MY DRIVEWAY AND STARTED PULLING OUT ONTO THE ROAD, VEHICLE JUST STALLED AND REFUSED TO START AGAIN, ENGINE CRACKS AND TURNS OVER BUT WONT START. THANK GOD THERE WASNT ANY TRAFFIC OR I WOULD HAVE BEEN T BONED. I WAS ABLE TO PUSH THE VEHICLE BACK OFFF THE ROAD. VEHICLE STILL WONT START

   NHTSA complaint 10910890
9. Filed Jul 1, 2016Failure Jun 18, 2016146,000 milesFredonia, KSEngine

   MY CAR SEIZED UP WHILE GOING DOWN THE ROAD I COULD BARELY TURN OR PUSH ON THE BRAKES! THANKFULLY I HAD JUST LEFT WORK SO I WAS ONLY DOING 10 MPH. I TOOK IT TO A MECHANIC WHOM SAID THE TIMING CHAIN WENT OUT, AND THAT WITH THAT TYPE OF MOTOR A V6 THAT IT MOST LIKELY BENT THE VALVES AND ID HAVE TO GET A NEW ENGINE!!! IM CURIOUS IF THIS HAPPENS OFTEN?????

   NHTSA complaint 10881941
10. Filed Jan 20, 2016Failure Dec 15, 201585,000 milesCocoa Beach, FLElectrical system

    I HAD SEVERAL PROBLEMS WITH MY IGNITION SWITCH SINCE BUYING THIS VEHICLE AS NEW, SO THE SWITCH WAS REPLACED ON DEC 2008 AT THE DEALERSHIP, WHICH I PAID FOR. I BROUGHT THIS VEHICLE TO A GM DEALER PER THE RECALL IN 2015 AND WAS TOLD ALL IS GOOD, SO I COULD CLAIM REIMBURSEMENT FOR THE 2008 REPAIR. TO DATE, AFTER FILLING IN THE REQUIRED FORMS AND SUBMITTING THEM TO A LOCAL GM DEALER, AND CORRESPONDING WITH GM CORPORATE, THEY REFUSE TO REIMBURSE ME FOR THE REPAIR BECAUSE THEY DID NOT KEEP ANY SATURN MAINTENANCE RECORDS WHEN THE DIVISION WAS SHUTTERED, EVEN THOUGH CORPORATE WAS THE OFFICE THAT NOTIFIED ME OF THE EXACT DATE OF THE IGNITION SWITCH REPAIR SO I COULD SUBMIT MY CREDIT CARD STATEMENT AS PROOF. THE LAST CONTACT FROM CORPORATE WAS 15 DEC 2015 WITH NO RESPONSE FROM SEVERAL MESSAGES LEFT WITH THEIR CASE MANAGER, PAULA (866-790-5700, EXT. 5913223).

    NHTSA complaint 10821179
11. Filed Dec 28, 2015Failure Sep 15, 2015200,000 milesSavannah, GAElectrical system, Fuel/propulsion system, Service brakes

    ABS LIGHT REMAINS ON; MY ELECTRICAL SYSTEM IS FAULTY; MY BLINKERS WORK AT WILL. MY FUEL LINE SENSOR CAUSES MY VEHICLE TO SHUT OFF AFTER DRIVING A DISTANCE. THERE IS A NOISE WHEN I REVERSE. MY SERVICE ENGINE LIGHT IS NOW APPEARING AND THE WHEEL LOCKS AND HARD TO TURN. READ THE MANUAL; VEHICLE DOES NOT REQUIRE POWER STEERING FLUID. MUST CONTACT A DEALER PER THE MANUAL. WILL CALL TODAY. FUEL LINE ISSUES SEPTEMBER 2015 OTHER ISSUES TO DATE 12/28/2015.

    NHTSA complaint 10816439
12. Filed Oct 5, 2015Failure Oct 4, 2015350 milesMorongo Valley, CAAir bags

    I JUST BOUGHT THIS CAR FROM A USED CAR DEALER. NEVER IN MY 40 YEARS OF DRIVING HAVE I EVER "TESTED" HORN OPERATION... SEEMS I SHOULD HAVE AS THE HORN DOESNT WORK. I FOUND AND REPLACED THE FUSE FOR THE HORN AND AFTER RESEARCHING I FOUND THAT THIS IS A KNOWN PROBLEM ON ALL 2002 SATURN VUE VEHICLES.... WHY THIS ISNT A RECALL ISSUE I HAVE NO IDEA BECAUSE THE HORN AND AIR BAG WORK OFF THE SAME POWER LINE AND THE CONTACT FOR THE HORN IS THE PROBLEM HORN WISE. I TOOK MY CAR TO A CHEVY DEALER TO GET AN ESTIMATE ON THE "FIX" AND IT WOULD COST ME 1100 BUX TO REPLACE THE FAULTILY DESIGNED UNIT GUARANTEED TO FAIL WITH ANOTHER FAULTILY DESIGNED UNIT GUARANTEED TO FAIL.

    NHTSA complaint 10779626
13. Filed Jul 23, 2015Failure Dec 2, 2014160,000 milesSeaside, ORElectrical systemFire

    TL* THE CONTACT OWNS A 2002 SATURN VUE. AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM), THE KEY FAILED TO RELEASE FROM THE IGNITION SWITCH AND HEARD A CLICKING NOISE WHEN REMOVING THE KEY. A COUPLE OF DAYS LATER, THE TURN SIGNALS FAILED INTERMITTENTLY. IN ADDITION, THE CONTACT MENTIONED THAT SMOKE EMITTED FROM THE TOP OF THE STEERING WHEEL ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER STATED THAT THE TURN SIGNAL ARM WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000. MA 10/5 UPDATED 10/8/15*JB

    NHTSA complaint 10736046
14. Filed Jul 1, 2015Failure Jun 30, 201584,000 milesMount Sterling, KYEngine

    TL* THE CONTACT OWNS A 2002 SATURN VUE. WHILE DRIVING 45 MPH, THE TIMING CHAIN FAILED AND THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE AN INDEPENDENT MECHANIC DIAGNOSED THAT THE TIMING CHAIN FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

    NHTSA complaint 10731534
15. Filed Jun 15, 2015Failure Jun 12, 2012Little Falls, NJElectrical system

    2002 SATURN VUE. CONSUMER WRITES IN REGARDS TO IGNITION CYLINDER AND KEYS REPLACEMENT RECALL ISSUES. *SMD THE CONSUMER STATED HE RECEIVED A RECALL NOTICE IN THE MAIL IN OCTOBER 2014 REGARDING AN ISSUE WITH THE IGNITION SWITCH. THE WORK HAD ALREADY BEEN DONE AND THEREFORE, THE CONSUMER SENT IN THE NECESSARY PAPERWORK FOR REIMBURSEMENT. EVEN THOUGH THE GM HAD THE PROOF THE WORK WAS DONE, THEY INFORMED THE CONSUMER TO HAVE THE VEHICLE INSPECTED, TO MAKE SURE THE IGNITION SWITCH WAS INSTALLED PROPERLY. ONCE IT WAS VERIFIED, THE CONSUMER NEVER HEARD BACK FROM THE GM REPRESENTATIVE. *JB

    NHTSA complaint 10694534
16. Filed May 12, 2015Failure May 8, 2015145,000 milesHartville, OHEngine

    LOSS OF POWER AND EVENTUALLY JUST STOPPED RUNNING. TOWED IT HOME. SUSPECTED TIMING CHAIN. TOOK OFF VALVE COVER AND TC COVER. NOTICED THAT BLACK PLASTIC GUIDE WAS BROKEN IN MAIN PIECES AND MUST HAVE BEEN FOR SOME TIME, FOR CHAIN WORE INTO SOME BOLTS AND COVER. CHAIN LOOKS BRAND NEW AND NO ISSUES WITH IT. REPLACED ALL TIMING COMPONENTS (TWO SPROCKETS, CHAIN, GUIDE, TENSION ARM, TENSIONER, CAM SPROCKET, ETC)., BUT IT WOULD NOT START. CHECKED COMPRESSION (0 PSI AT ALL CYLINDERS), DOUBLE CHECKED TIMING AND WAS CORRECT. ROLLER ROCKERS WERE LOOSE WHEN CAM IS NOT PRESSING ON THEM, SO SUSPECT ALL VALVES ARE BENT. FIX IS TO REBUILD THE "HEAD". I PRESUME THAT IF THE BLACK PLASTIC CHAIN GUIDE DID NOT BREAK, IT WOULD NOT HAVE GOTTEN OUT OF TIME AND BENT VALVES. THE RECALL SHOULD NOT BE ON THE TIMING CHAIN BUT THE PLASTIC GUIDE THAT IS USED FOR THE TIMING CHAIN. HAD THIS PART BEEN METAL, THIS WOULD NOT HAVE HAPPENED. HAVE PICTURE TO SEND IF NEEDED.

    NHTSA complaint 10715965
17. Filed Mar 5, 2015Failure Feb 25, 2015110,000 milesPortland, OREngine, Power train

    THE TIMING CHAIN RUINED THE ENTIRE ENGINE AS A RESULT OF THE CHAIN TENSIONER FAILING FROM LACK OF OIL BEING APPLIED. APPARENTLY AS SOON AS I HEARD THE CLANGING SOUNDS IT WAS TOO LATE. I AM BUYING A WHOLE NEW ENGINE WHICH HAS REPLACED THE OILING MECHANISM THAT WAS FAULTY IN THE 2002-2003 MODELS OF THE SATURN VUE. *TR

    NHTSA complaint 10692389
18. Filed Feb 4, 2015Failure Jan 21, 2015154,000 milesFairport, NYElectrical system

    TL* THE CONTACT OWNS A 2002 SATURN VUE. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN THE IGNITION SWITCH AND NUMEROUS ATTEMPTS HAD TO BE MADE BEFORE THE VEHICLE WOULD START. THE FAILURE RECURRED CONTINUOUSLY. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM). HOWEVER, THE DEALER REFUSED TO REPAIR THE VEHICLE BECAUSE THEY WERE UNABLE TO LOCATE A FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 154,000.

    NHTSA complaint 10681148
19. Filed Dec 3, 2014Failure Jul 3, 2013Huntsville, ALEngine

    I WAS DRIVING ON A ROAD WITH A 50 MPH LIMIT WHEN THE ENGINE SHUT OFF. I LOST ALL POWER TO THE CAR AND THANKFULLY WAS ABLE TO STEER IT INTO THE DRIVE WAY OF A BUSINESS ON THAT ROAD. THERE WERE NO RECALLS ON MY CAR AT THAT TIME AND THERE STILL ARE NO ENGINE RECALLS ON THIS CAR DESPITE THE OTHER RECALLS WHERE THE EXACT SAME THING HAPPENED. THE LOCAL DEALER SAID I HAD A BAD SENSOR IN THE ENGINE AND CHARGED ME OVER $400 TO FIX. I AM LUCKY TO HAVE SURVIVED THE INCIDENT AND CHARGING ME WAS WRONG. *JS

    NHTSA complaint 10661939
20. Filed Nov 10, 2014Failure Jun 9, 2014120,000 milesRome, GASwitch, SteeringCrash

    TL* THE CONTACT OWNS A 2002 SATURN VUE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE IGNITION KEY RELEASED FROM THE IGNITION SWITCH AND THE STEERING WHEEL SEIZED WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO A TREE. NO INJURIES WERE REPORTED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED IF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

    NHTSA complaint 10653979