2005 Subaru Baja

37 complaints on file, page 1 of 2.

1. Filed Dec 8, 2023Failure Dec 6, 2023174,000 milesGreenfield Township, PAStructure

   The contact owns a 2005 Subaru Baja. The contact stated that while driving at 35 MPH, the contact noticed an unusual squeaking sound coming from the vehicle. The contact drove the vehicle to a safe location and parked the vehicle. The contact exited the vehicle and inspected the vehicle. The contact walked around the vehicle, and while inspecting the exterior of the vehicle, he became aware that the rear driver’s side tire was leaned in toward the vehicle. Upon further inspection, the contact noticed that the rear subframe was fractured and missing parts. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 174,000.

   NHTSA complaint 11559168
2. Filed May 20, 2022Failure May 20, 2022Pleasant Hills, CAAir bags

   2005 SUBARU BAJA. CONSUMER WRITES IN REGARD TO AIRBAG SAFETY RECALL. THE CONSUMER STATED THE RECALL NOTICES RECEIVED WERE FRAUDULENT.

   NHTSA complaint 11465414
3. Filed May 21, 2020Failure May 20, 2020121,000 milesWest Dennis, MAService brakes

   TL* THE CONTACT OWNS A 2005 SUBARU BAJA. THE CONTACT STATED THAT UPON TAKING HIS VEHICLE TO AN INDEPENDENT MECHANIC FOR AN OIL CHANGE, THE MECHANIC DISCOVERED THAT BRAKE FLUID WAS LEAKING FROM THE BRAKE LINE. DUE TO THE BRAKE FLUID LEAK, CORROSION DEVELOPED AROUND THE BRAKE LINE. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 121,000. THE VIN WAS UNAVAILABLE.

   NHTSA complaint 11325421
4. Filed Apr 17, 2019Failure Apr 1, 2019240,000 milesNorth Augusta, SCService brakes

   TL* THE CONTACT OWNS A 2005 SUBARU BAJA. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED AND THE BRAKE ALARM INDICATOR ILLUMINATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO THE DEALER. THE VEHICLE WAS TAKEN TO GERALD JONES SUBARU (706-760-4102, LOCATED AT 4022 WASHINGTON RD, AUGUSTA, GA 30907) WHERE IT WAS DETERMINED THAT THERE WAS NO RECALL FOR THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 240,000.

   NHTSA complaint 11196900
5. Filed Feb 9, 2019Failure Feb 8, 2019100,900 milesFayetteville, PAFuel/propulsion system

   THE VEHICLE IS LEAKING FUEL. WHEN TANK IS FULL THE PRESENCE OF THE FUMES ARE OVERWHELMING. OTHER 2005 BAJA'S HAVE BEEN REPAIRED UNDER A RECALL, BUT MINE HAS NOT BEEN FIXED. I CAN'T PARK IN A GARAGE DUE TO LIFE THREATENING REASONS AND IT COULD IGNITE RIGHT NOW. PLEASE HELP ME.

   NHTSA complaint 11175853
6. Filed Mar 17, 2017Failure Mar 17, 2017Dansville, MIAir bags

   TL* TAKATA RECALL. THE CONTACT OWNS A 2005 SUBARU BAJA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V016000 (AIR BAGS) HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED ANY FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. VIN TOOL CONFIRMS REMEDY NOT YET AVAILABLE.

   NHTSA complaint 10966549
7. Filed Feb 27, 2017Failure Feb 26, 2017230,000 milesClinton, TNFuel/propulsion system

   FUEL SMELL WHEN STARTING VEHICLE FOR SEVERAL MONTHS REPORTED TO DEALERSHIP AND SERVICE REFUSED TO DO CHECK FOR CAUSE, THOUGH THEY WERE PAID TO.

   NHTSA complaint 10957381
8. Filed Dec 13, 2016Failure Jul 15, 2016Morrow, OHAir bags

   TL* TAKATA RECALL. THE CONTACT OWNS A 2005 SUBARU BAJA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V359000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

   NHTSA complaint 10935024
9. Filed Oct 12, 2016Failure Jul 10, 2016Sherman, NYAir bags

   TL* TAKATA RECALL. THE CONTACT OWNS A 2005 SUBARU BAJA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V359000 (AIR BAGS). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

   NHTSA complaint 10915484
10. Filed Oct 5, 2016Failure Oct 5, 2016Dania Beach, FLAir bags

    TL* THE CONTACT OWNS A 2005 SUBARU BAJA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V358000 (AIR BAGS). THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

    NHTSA complaint 10913974
11. Filed Sep 27, 2016Failure Jul 9, 2016Norfolk, VAAir bags

    TL* TAKATA RECALL. THE CONTACT OWNS A 2005 SUBARU BAJA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V359000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOLS CONFIRMS PARTS NOT AVAILABLE.

    NHTSA complaint 10909875
12. Filed Aug 10, 2016Failure Aug 1, 2016Gulfport, FLAir bags

    RECEIVED A LETTER 8-1-16 PASSENGER SIDE AIR BAG STATING THAT PARTS ARE UNAVAILABLE AND NOT TO LET ANYONEDRIVE IN THE FRONT PASSENGER SIDE. MFG CAN NOT GIVE A DATE. WILL THIS HAVE NO END? THEY JUST NOTIFIED ME NOW AND NOTHING CAN BE RESOLVED?

    NHTSA complaint 10894817
13. Filed Aug 3, 2016Failure Jul 25, 201685,000 milesHillsdale, NJBody, Suspension

    I RECENTLY HAD ISSUES WITH THE SUSPENSION WHILE THE CAR WAS IN MOTION, SO TOOK THE VEHICLE TO MY MECHANIC. I WAS INFORMED THAT THE REAR SUB FRAME AND UPPER CONTROL ARM MOUNTING EARS HAVE ROTTED OUT.

    NHTSA complaint 10892762
14. Filed May 16, 2016Failure Dec 24, 2015100 milesSAN Carlos, CAFuel/propulsion system

    IT IS A COMMONLY KNOWN PROBLEM WITH SUBARUS OF THIS ERA THAT THE HIGH PRESSURE RUBBER FUEL LINES UNDERNEATH THE INTAKE MANIFOLD WILL BEGIN TO LOSE THEIR ELASTICITY AS THEY AGE AND LEAK PROFUSELY WHEN THE TEMPERATURE DROPS BELOW 30 DEGREES FAHRENHEIT. MECHANICS KNOW THIS AND IT IS DISCUSSED EXTENSIVELY ON THE SUBARU FORUMS. THIS HAPPENED TO MY 2005 SUBARU BAJA WHEN I WAS TRAVELING IN THE MOUNTAINS. WHEN I STARTED THE VEHICLE IN THE MORNING, FUEL WOULD BEGIN PUDDLING ON THE TOP OF THE ENGINE. IT WAS VERY NOTICEABLE DUE TO THE FUEL VAPORS PRODUCED. AS THE ENGINE WARMED THE RUBBER WOULD SWELL AND STOP THE LEAK AFTER A GOOD 30 MINUTES OR LONGER DEPENDING ON THE OUTSIDE TEMPERATURE. I HAD TO TRAVEL WITH A FIRE EXTINGUISHER AT THE READY AND COULD NOT KEEP ANY VENTS OPEN IN THE CABIN. IT WAS EXTREMELY DANGEROUS AND COULD NOT BE REMEDIED UNTIL I WAS BACK FROM MY TRIP. SUBARU ISSUED A RECALL A FEW YEARS AGO FOR A SMALL PART NEAR THE FUEL PUMP AND TANK BECAUSE IT HAD THE POTENTIAL TO LEAK, BUT THEY HAVEN'T ADDRESSED THIS FAR MORE PERVASIVE ISSUE AT ALL. THE REMEDY REQUIRES A DIFFICULT AND COSTLY REMOVAL OF THE INTAKE MANIFOLD AND THE REPLACEMENT OF ALL THE RUBBER LINES THAT RUN BETWEEN THE HARD PIPES ON THE HIGH PRESSURE FUEL CIRCUIT. I SUSPECT THIS IS WHY THEY ARE NOT ISSUING A RECALL. IT IS A VERY REAL PROBLEM AND NEEDS TO BE ADDRESSED IMMEDIATELY.

    NHTSA complaint 10865217
15. Filed Mar 7, 2016Failure Jan 31, 2013Bakersfield, CAFuel/propulsion system

    TL* THE CONTACT OWNS A 2005 SUBARU BAJA. AFTER STARTING THE VEHICLE, A STRONG FUEL ODOR ENTERED THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09277000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

    NHTSA complaint 10840380
16. Filed Mar 4, 2016Failure Jan 1, 2014130,000 milesBakersfiels, CAEngine, Fuel/propulsion system, Unknown or other

    STRONG GASOLINE SMELL IN PASSENGER COMPARTMENT, DEALER CAN NOT LOCATE PROBLEM,PROBLEM PERSISTS. AFRAID CAR WILL CATCH ON FIRE

    NHTSA complaint 10839990
17. Filed Oct 14, 2015Failure Jan 1, 201050,000 milesCanyon Country, CAEngine, Power train, Unknown or other

    MY VEHICLE HAS HAD SEVERAL DEFECTS/PROBLEMS. THE ENGINE VALVE LEAKED, CHECK ENGINE LIGHTS, AUTO TRANSMISSION PROBLEMS SINCE FIRST PURCHASED INHERENT TO VEHICLE. VEHICLE BURNS ENGINE OIL AND TOO HOT.. I AM AFRAID TO DRIVE CAR LONG DISTANCES I CURRENTLY HAVE 113,000 MILES ON AUTO.

    NHTSA complaint 10782176
18. Filed May 20, 2015Failure Apr 7, 201495,000 milesCitrus Heights, CAEngine

    MY CAR BEGAN OVERHEATING, SO I HAD MY NEPHEW (A MECHANIC) REPLACE THE THERMOSTAT - TWICE. MY NEXT STEP WAS TO TAKE IT INTO THE DEALER, AND HAVE THEM CHECK IT OVER. THEY TOLD ME I NEEDED A NEW WATER PUMP, AND HAD DROPLETS AROUND MY HEAD GASKET, BUT IT WAS NOTHING TO WORRY ABOUT (THAT WAS AT 98,000 MILES). I EXPLAINED THAT I WAS TAKING MY 91 YEAR OLD MOM, AND 17 YEAR OLD DOG TO L.A. FROM SACRAMENTO, AND WANTED TO MAKE SURE IT WAS SAFE. THEY SENT ME ON MY WAY WITH THE ASSURANCE THE CAR WOULD BE FINE. I OVERHEATED GOING OVER THE GRAPEVINE. SUBSEQUENTLY, I'VE HAD THE WATER PUMP, RADIATOR, TIMING BELT REPLACED, AND IT'S STILL OVERHEATING. IN THE LAST MONTH OR SO, IT STARTED LEAKING SO I LOOKED UP ONLINE ANY COMPLAINTS AND FOUND MULTIPLE COMPLAINTS REGARDING HEAD-GASKETS, AND THAT SUBARU HAD EXTENDED THE WARRANTY TO 100,000 MILES OR 8 YEARS. TOO BAD FOR ME, HUH? WHEN I TOOK IT BACK INTO THE DEALER (AT 104,000 MILES) THEY TOLD ME THE EXTENSION DIDN'T APPLY TO MY CAR. NOT ONLY DO I RESENT THE FACT THAT I FEEL RIPPED OFF, I RESENT THEM SENDING ME OUT THE DOOR WHEN IT WASN'T SAFE TO BE STUCK ON THE FREEWAY WITH AN ELDERLY PARENT, AND ELDERLY DOG.

    NHTSA complaint 10717466
19. Filed Jan 31, 2015Failure Jan 13, 2015107,000 milesWestfield, MAFuel/propulsion system

    IT'S BEEN COLD IN MA LIKE PAST WINTERS AND THIS IS THE FIRST TIME THIS HAPPENED SINCE OWNING MY BAJA FOR 10 YEARS NOW, WHICH I BOUGHT NEW. I NOTICED THAT WHEN I FIRST START UP MY CAR WITH THE HEAT VENTS OPEN TO WARM IT INSIDE, THE CAR FILLS WITH STRONG FUEL/GAS FUMES. I TOOK MY CAR TO BE SERVICED AT A SUBARU DEALER AND THEY CHECKED ALL THE FUEL LINES; TIGHTENED THEM, BUT COULD NOT FIND WHAT IS CAUSING THIS PROBLEM. SO NOW I RECIRCULATE THE CABIN AIR AND DON'T DRAW IN FRESH AIR TO TRY TO KEEP THE FUMES OUT. IT STILL CONTINUES TO EMIT FUMES WHEN IT'S COLD OUT, BUT IT NEVER HAPPENED IN THE PAST...10 YEARS OF COLD WINTERS AND NOW THERE'S A PROBLEM WITH GAS FUMES? SOMETHING IS VERY WRONG AND I DO FEAR A FIRE. *TR

    NHTSA complaint 10680293
20. Filed Jan 8, 2015Failure Dec 21, 2014148,000 milesBIG SKY, MTEngine, Body, SuspensionCrash1 injured

    DURING THE AFTERNOON OF THE DECEMBER 21ST ICE STORM IN BOZEMAN MONTANA, MY 2005 SUBARU BAJA SLID OFF THE ROAD AND DOWN A STEEP INCLINE. ALTHOUGH I ONLY SUSTAINED BUMPS AND BRUISES, THE CAR WAS TOTALED. THE ACCIDENT COULD HAVE EASILY BEEN FATAL. THE WINDSHIELD WAS HEAVILY DAMAGED, THE CAR AXLES WERE BROKEN, THERE WAS SEVERE DAMAGE TO THREE SIDES OF THE VEHICLE. I WONDERED WHY THE AIRBAGS HAD NOT DEPLOYED. WHEN I RESEARCHED THE SITUATION I FOUND THERE WAS A RECALL ON 2005 SUBARU AIRBAGS. SUPPOSEDLY A FAULTY RELEASE SWITCH AND POTENTIALLY A RELEASE OF METAL SHARDS UPON DEPLOYMENT. MAYBE I WAS LUCKY THE AIRBAGS DIDN'T GO OFF. I CONTACTED SUBARU TO SEE IF IN LIGHT OF THIS SITUATION, THEY WOULD POTENTIALLY CONSIDER ASSISTING ME WITH A REPLACEMENT VEHICLE. AFTER A 2 WEEK DELAY, ROB THE CSR TOLD ME THAT PER PAGE XXX OF THE OWNER?S MANUAL THE AIRBAG WOULD NOT DEPLOY UNLESS THE VEHICLE WAS HIT FROM THE FRONT OR BACK. ALSO, ALTHOUGH I READ THAT MY CAR WAS INCLUDED IN THE RECALL, HE SAID IT WAS NOT. APPARENTLY, THE COMPANY FEEL NO OBLIGATION WHAT SO EVER TO ASSIST WITH THE SITUATION. POSSIBLY THEY WOULD HAVE PAID MORE ATTENTION IF I WAS INJURED OR DEAD. I AM NOW AN EX-SUBARU CUSTOMER. I WILL BE SEEKING AN ATTORNEY TO SEE IF OTHERS HAVE HAD SIMILAR EXPERIENCES. *TR

    NHTSA complaint 10670946