2003 Subaru Forester

189 complaints on file, page 1 of 10.

1. Filed Aug 23, 2025Failure Aug 23, 2025Boise, IDUnknown or other

   I bought a used vehicle and looked at it and they erased the codes I saw then erased it then I confronted them and was told nothing is wrong with the vehicle after telling them there is a recall on the suspension. Went to go get a alignment and was told it's severely unsafe to drive and the subframe is about to snap! The mechanic gave me photos and a report to return it imatelt but the used car lot said well u had every chance and I did it the mechanical stuff checked but the car place said everything is in good condition!

   NHTSA complaint 11682590
2. Filed May 23, 2025Failure May 23, 2023220,251 milesKansas City, MOSpeedometer/odometer

   Odometer Fraud. The contact purchased a 2003 Subaru Forester. The contact stated that while investigating the vehicle mileage at [XXX] , it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 21,084; however, the contact later discovered that on July 20, 2022, the mileage was 220,251. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11662835
3. Filed Dec 7, 2023Failure Oct 9, 2020117,000 milesDuluth, MNSuspension

   The contact owns a 2003 Subaru Forester. The contact stated that while driving at slow speeds, the contact heard an abnormal sound coming from the front of the vehicle and the contact became aware that the power steering was not functioning properly. After a visual inspection of the exterior of the vehicle, the contact observed that the passenger’s side wheel appeared to have detached from the vehicle. The vehicle was towed to an independent mechanic, who diagnosed failures with the frame rail, stabilizer, and lower control arm. The independent mechanic informed the contact that the lower control arm had fractured from the frame. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 11V464000 (Suspension). The VIN was included, and the vehicle was repaired in 2018. The manufacturer was not notified of the failure. The failure mileage was 117,000.

   NHTSA complaint 11558946
4. Filed Aug 18, 2022Failure Aug 17, 2022105,000 milesMount Prospect, ILSuspension

   The contact owns a 2003 Subaru Forester. The contact referenced NHTSA Campaign Number: 11V464000 (Suspension). The contact stated that the vehicle was taken to the dealer where an inspection was performed but nothing was replaced. The contact stated that while driving at unknown speed, the lower control arm cracked. The vehicle was towed to an independent mechanic where it was diagnosed that the lower control arm was rusted and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no further assistance was provided. The approximate failure mileage was 105,000.

   NHTSA complaint 11479996
5. Filed Feb 11, 2022Failure Feb 11, 2022Rockford, ILSuspension

   The 2003 Subaru Forester Sub Frame is rusted. I live in Illinois.

   NHTSA complaint 11451553
6. Filed Dec 31, 2021Failure Dec 30, 2021Bellaire, MISteering, Suspension

   Safety Recall: WVX34 NHTSA Campaign: 11V464000 The front lower passenger side control arm completely rusted in half. It occurred while parking vehicle, fortunately not driving at high speed. The recall was previously completed by Subaru dealership in Ann Arbor, Michigan, in 2011. According to service records, they had been treated with anti-corrosion coating... I purchased the vehicle from a family member of the original owner, weeks ago, December 2021. It had been serviced regularly by the dealership and now has 162,000 miles. This structural failure of the lower control arm could have been extremely disastrous if driving at speed on the road or highway! I contacted my local dealership in Traverse City, MI, and was told by the service advisor the recall had been completed and would not be covered again for subsequent replacement. My vehicle is undrivable and Subaru is not standing behind their parts or workmanship.

   NHTSA complaint 11445737
7. Filed May 17, 2021Failure May 11, 2021Port Angeles, WAFuel/propulsion system, Steering1 injured

   I bought the 2003 Forrester off Craig's list While driving the car the steering is very loose and sways on the road . I noticed a small it was funny I could not identify it. I woke latter that night with a headache at the base of my skull and was extremely dizzy and nausea. I felt that way. Through out. The day. I drove it a short. distance the next day with the windows down. I begin hearing a grinding. Thumping noise in the rear . tites or brakes .bur it sounded like it was going to fall apart. The inside of the car had a oily dust all over it. And the funny smell. I looked. At exhaust. Pipe to see. How it looked and I put my finger in what was coming. Our. And it was dark oil. I have not driven the car since. I found out the name on the tittle is not who sold me the car. He lied to me about every thing. He said buyers remorse. I believe the car unsafe to drive I could have bern killed.

   NHTSA complaint 11417380
8. Filed Feb 8, 2021Failure Feb 8, 2021133,000 milesSaint Paul, MNEngine, Unknown or other

   THE HEAD GASKET FAILED IN A MANNER WHICH CAUSED ENGINE OIL TO LEAK ONTO THE HOT EXHAUST MANIFOLD. A STRONG BURNING ODOR IS PRESENT AFTER THE ENGINE WARMS UP COMPLETELY.

   NHTSA complaint 11395140
9. Filed Feb 8, 2021Failure Feb 8, 2021133,000 milesSaint Paul, MNEngine, Fuel/propulsion system

   WHEN AMBIENT AIR TEMPERATURE IS COLD (BELOW ABOUT 20-30 F), THE VEHICLE GIVES OFF A STRONG GASOLINE SMELL. THIS IS CAUSED BY THE FUEL RAIL CONTRACTING TO THE POINT THAT SOME FUEL IS SPRAYED ONTO THE ENGINE COMPARTMENT. OBVIOUSLY, THIS IS A FIRE RISK.

   NHTSA complaint 11395139
10. Filed Feb 2, 2021Failure Feb 1, 2021Pleasantville, NYEquipment

    I HAVE A COMPLAINT ABOUT THE PROPOSED RECALL REMEDY FOR NHTSA ID: 21E002000 . THE NOTICE SAYS, "NINGBO WILL NOTIFY DISTRIBUTORS, AND OWNERS, AND WILL REPLACE THE BULB WITH HALOGEN BULBS, FREE OF CHARGE." THIS OFFERED REPLACEMENT OF THEIR DEFECTIVE LED BULB WITH A HALOGEN BULB IS NOT AN ACCEPTABLE RECALL REMEDY BECAUSE LED BULBS ARE FAR SUPERIOR TO HALOGEN BULBS. ESPECIALLY LED BULBS LAST MUCH LONGER AND DRAIN MUCH LESS POWER FROM THE CAR'S ELECTRICAL SYSTEM THAN HALOGEN BULBS. I ORIGINALLY BOUGHT THEIR LED BULBS BECAUSE OF THESE ADVANTAGES AND REPLACING THEM WITH INFERIOR HALOGEN BULBS DEFEATS THE PURPOSE OF HAVING BOUGHT LED BULBS TO BEGIN WITH.

    NHTSA complaint 11394379
11. Filed Nov 9, 2020Failure Nov 8, 2020190,000 milesCedar Knolls, NJSuspension

    TL* THE CONTACT'S DAUGHTER OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHILE HIS DAUGHTER WAS DRIVING 30 MPH, THE VEHICLE BEGAN TO SWAY FROM SIDE TO SIDE WITHOUT WARNING WHILE MAKING AN ABNORMAL METALLIC GRINDING SOUND. HIS DAUGHTER PULLED OVER AND CALLED HIM FOR ASSISTANCE UPON ARRIVAL, HE NOTICED THAT THE PASSENGER'S SIDE FRONT TIRE WAS NOT FACING FORWARD. THE CONTACT THEN INSPECTED THE VEHICLE AND DISCOVERED THAT THE FRONT PASSENGER'S SIDE TIRE WAS DETACHED FROM THE CONTROL ARM. THE CONTACT ALSO DISCOVERED THAT THE CV SHAFT WAS ALSO DETACHED FROM THE TRANSMISSION, WHICH RESULTED IN OIL LEAKING ONTO THE CROSS MEMBER. DUE TO THE FAILURE, THE CONTACT SLOWLY DROVE THE VEHICLE TO HIS RESIDENCE. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 11V464000 (SUSPENSION) WHICH HE LINKED TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE RECALL REMEDY WAS ALREADY PERFORMED ON THE VEHICLE. THE CONTACT WAS REFERRED TO A LOCAL DEALER AND NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000.*DT*JB*DT THE CONSUMER PROVIDED PHOTOS AND DOCUMENTS. *TR*DT

    NHTSA complaint 11373776
12. Filed Aug 28, 2019Failure Aug 9, 201972,000 milesBOW, NHAir bags, Vehicle speed controlCrash

    MY MOTHER WAS PULLING HER CAR OUT OF THE GARAGE WHEN IT SUDDENLY ACCELERATED & SHOT DOWN THE DRIVEWAY, ACROSS THE STREET, THRU THE NEIGHBOR'S HOUSE AND LANDED IN THEIR BACKYARD. THE CAR JUST MISSED MY FATHER IN THE DRIVEWAY AND THE NEIGHBORS IN THEIR HOUSE. THE INSURANCE ADJUSTER SAID THE CAR WAS AIRBORNE WHEN IT WENT THRU THE FRONT DOOR BASED ON THE DAMAGE TO THE FRONT DOOR & THE SKID MARKS ON THE TILE IN THE HALLWAY. THE AIR BAGS DIDN'T DEPLOY. THE CAR IS A TOTAL LOSS. A FEW MONTHS PRIOR TO THIS MY MOTHER WAS PARKING THE CAR WHEN IT SUDDENLY ACCELERATED. IT CROSSED THE SIDEWALK AT THE STORE & HIT ANOTHER CAR. AT THE TIME SHE THOUGHT THAT HER FOOT MUST HAVE SLIPPED OFF THE BRAKE. MY FATHER DROVE IT A FEW WEEKS AFTER THAT & SAID IT WANTED TO ACCELERATE WHILE HE WAS STOPPED AT A RED LIGHT WITH HIS FOOT ON THE BRAKE. THE FAILURE MILEAGE WAS APPROX. 72,000.

    NHTSA complaint 11252119
13. Filed Jun 15, 2019Failure Apr 5, 2019130,538 milesLake IN THE Hills, ILBody

    FRONT SUBFRAME ON THE DRIVER AND PASSENGER SIDE RUSTS AWAY CAUSING FAILURE. COULD RESULT IN LOSS OF CONTROL OF VEHICLE AND COULD INJURE PASSENGERS. TURNING OR HITTING BUMPS COULD CAUSE IT TO SNAP DUE TO EXTRA FORCE.

    NHTSA complaint 11220275
14. Filed Nov 1, 2018Failure Oct 20, 2018122,000 milesBoonton, NJSuspensionCrash

    TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHILE HIS DAUGHTER WAS DRIVING AT 65 MPH, THERE WAS AN ABNORMAL NOISE WHICH EMITTED FROM THE PASSENGER'S SIDE FRONT SUSPENSION OF THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE BECAME UNCONTROLLABLE, GOING FROM THE RIGHT LANE TO THE EXTREME LEFT LANE, DOWN AN EMBANKMENT INTO ONCOMING TRAFFIC. THE CONTACT STATED THAT THERE WAS NO OTHER VEHICLE INVOLVED. NO INJURIES WERE SUSTAINED. THE CONTACT STATED ON INSPECTING THE VEHICLE, THE CONTACT BECAME AWARE THAT THE PASSENGER'S SIDE FRONT LOWER CONTROL ARM FRACTURED WHICH CAUSED THE SEPARATION OF THE WHEEL FROM THE SUSPENSION. THE FRACTURE CAUSED DAMAGE TO THE INSIDE WHEEL WELL OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE RESIDENCE. MILLER SUBARU (1592 NJ-38, LUMBERTON, NJ 08048, (609) 267-4000) WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V464000 (SUSPENSION). THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED BUT WAS NOT GIVEN PROOF THAT THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.

    NHTSA complaint 11144642
15. Filed Aug 17, 2018Failure Aug 10, 2018Worcester, MAFrame and members, Suspension

    TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT NOTICED EXTENSIVE RUST, CORROSION, AND HOLES AROUND THE FRONT FRAME OF THE VEHICLE. AN INDEPENDENT MECHANIC REPLACED THE FRONT FRAME, AND THE PASSENGER AND DRIVER SIDE CONTROL ARMS. IN ADDITION, THE REAR FRAME AND DRIVER AND PASSENGER SIDE CONTROL ARMS WERE ALSO INSPECTED WITH THE EXPECTATION THAT THOSE PARTS HAD ALSO DETERIORATED AND MAY NEED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WAS INCLUDED OR EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 11V464000 (SUSPENSION) AND WAS NOT INCLUDED IN NHTSA ACTION NUMBER: PE11011 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

    NHTSA complaint 11120592
16. Filed Mar 23, 2018Failure Mar 13, 2018190,000 milesBates City, MOSuspension

    THE PASSENGER SIDE FRONT LOWER CONTROL ARM SEPARATED AT THE WELD SEAM WHILE MY DAUGHTER WAS DRIVING THE CAR. THE PASSENGER SIDE FRONT TIRE SWUNG REARWARD AND OUTWARD BECAUSE THE FRONT PORTION OF THE LOWER CONTROL ARM SEPARATED FROM THE REST OF THE CONTROL ARM. THIS PULLED THE CAR OFF THE ROAD BUT LUCKILY SHE WAS TRAVELING AT A SLOW SPEED ON A SIDE ROAD ON HER WAY TO GET ON THE INTERSTATE AND WAS ABLE TO GET THE CAR STOPPED BEFORE CRASHING. HAD THIS HAPPENED AT ANY NORMAL ROAD SPEED SHE WOULD LIKELY HAVE DIED FROM A COMPLETE LOSS OF CONTROL OF THE CAR AT A HIGH RATE OF SPEED. THERE WAS A RECALL IN 2011 ON THESE CARS FOR THIS VERY CONDITION. MY CAR SHOWS "COMPLETE" IN THEIR SYSTEM FOR THIS RECALL BUT IT WAS EITHER NOT ACTUALLY COMPLETED OR THE REPLACEMENT PARTS ARE EQUALLY AS DANGEROUS AND NEED TO BE RECALLED AGAIN. I NOTIFIED SUBARU OF AMERICA AND TOOK THE CAR TO A SUBARU DEALERSHIP FOR THEM TO REVIEW BUT SUBARU OF AMERICA WAS NOT CONCERNED SAYING IT SHOWED COMPLETE SO THERE WAS NOTHING THEY COULD DO. SINCE THIS HAS HAPPENED TO ME I HAVE FOUND OTHERS ONLINE WHO HAD SUBARU DEALERS COMPLETE THE RECALL WITHOUT CHANGING SEVERELY CORRODED LOWER CONTROL ARMS JUST LIKE MINE. I AM AFRAID THAT OTHER PEOPLE OR THEIR CHILDREN ARE IN DANGER OF LOSING THEIR LIVES DUE TO SUBARU'S NEGLIGENCE. MANUFACTURER: SUBARU OF AMERICA, INC. MFR'S REPORT DATE: SEP 06, 2011 NHTSA CAMPAIGN ID NUMBER: 11V464000 NHTSA ACTION NUMBER: PE11011 COMPONENT: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM POTENTIAL NUMBER OF UNITS AFFECTED: 295,123 THIS IS SUBARU'S SAFETY RECALL NUMBER WVX-34.

    NHTSA complaint 11081121
17. Filed Jan 5, 2018Failure Jan 5, 2018Jericho, NYFuel/propulsion system

    FUEL LEAKS FROM THE FUEL LINES AROUND THE ENGINE WHEN IT'S COLD.

    NHTSA complaint 11060857
18. Filed Jan 4, 2018Failure Dec 23, 2017135,600 milesCarlisle, PAFuel/propulsion system

    FUEL LINE LEAKING UNDER 20 DEGREE TEMPS, SMELLS STRONGLY OF GAS INSIDE AND OUTSIDE OF THE VEHICLE WHILE IDOLING AS WELL AS DRIVING

    NHTSA complaint 11058454
19. Filed Dec 29, 2017Failure Dec 1, 2014114,000 milesShepherdsville, KYFuel system, Gasoline

    TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE DURING COLD WEATHER, AN ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE. THE FAILURE WOULD ONLY OCCUR IN TEMPERATURES BELOW 25 DEGREES. THE VEHICLE WAS TAKEN TO NEIL HUFFMAN SUBARU DEALER LOCATED AT 4916 DIXIE HWY, LOUISVILLE, KY 40216 WHO TIGHTEN AND RE-CLAMPED THE FUEL LINES BUT THE FAILURES CONTINUED TO OCCURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000. *TT *TR

    NHTSA complaint 11057291
20. Filed Jun 3, 2017Failure May 26, 2017115,000 milesBethel, CTSuspension

    VEHICLE WAS ORIGINALLY RECALLED IN 2011/2012 FOR NHTSA CAMPAIGN ID NUMBER: 11V464000 NHTSA ACTION NUMBER: PE11011. AT TIME, DEALER CONDUCTED PUNCH TEST AND DETERMINED LOWER CONTROL ARM TO "PASS" AND USED SOME TYPE OF ANTI-CORROSION SPRAY. FAST FORWARD TO 2017 AND LOWER CONTROL ARMS HAVE "FAILED" PUNCH TEST WITH SIGNIFICANT CORROSION. I ONLY DETECTED THIS FAILED, AND POTENTIALLY LIFE THREATENING CONDITION OF VEHICLE, BY PERSONALLY INSPECTING UNDER CARRIAGE PRIOR TO GIVING VEHICLE TO 16 YEAR-OLD SON AS FIRST CAR. I CAN ONLY IMAGINE HOW MANY OF THESE SUBARU FORESTERS THAT WERE PREVIOUSLY, AND QUITE CONVENIENTLY DETERMINED TO PASS BY PUNCH TEST, ARE OUT THERE ON THE STREETS AND HIGHWAYS WITH POTENTIAL SERIOUS CONSEQUENCES TO THE UNKNOWING OWNERS OF THESE VEHICLES. I RESPECTFULLY SUBMIT THAT SUBARU SHOULD NEVER HAVE BEEN GIVEN THE OPTION TO "PUNCH" TEST THESE LOWER CONTROL ARMS AND SHOULD HAVE BEEN MADE TO REPLACE THESE CRITICAL PARTS. I WOULD LIKE TO SEE SUBARU ADDRESS THE ISSUE. TO DATE, I HAVE CONTACTED SUBARU OF AMERICA AND HAVE BEEN DENIED ANY REMEDY, NOR ALLOWED TO TALK TO A SUPERVISOR.

    NHTSA complaint 10992972