2020 Subaru Outback

899 complaints on file, page 1 of 45.

1. Filed Sep 28, 2026Failure Aug 1, 2026Austin, TXPower train

   Noticed minor hesitation in the reverse down our driveway Aug 2024. By Aug 2026, the transmission hesitation has turned into very noticeable shudder and slip. In reverse down the driveway, the TR580 CVT was showing premature initial failure resulting in unexpected loss of motive power control as well as acceleration hesitation in forward. This transmission defect compromised the ability to safely navigate down the driveway and through traffic, creating an risk of a rear end collision and stranding the vehicle in a hazardous roadway position. The vehicle was driven to Austin Subaru dealer early September 2026 where certified technicians inspected it. They diagnosed a catastrophic internal failure that is pending and stated the entire transmission assembly requires complete replacement. We were quoted an out of pocket retail repair cost of $9,774. Additional consideration: This defect occurred at exceptionally low mileage (<37,000) on a well maintained vehicle as it included Subaru provided services through April 2025. Only had a single oil change at a third party. Furthermore, Subaru of America Corporate Customer Advocacy was contacted regarding this exact VIN. Despite Subaru previously issuing a warranty extension program for identical transmission "judder" and slipping defects on 2019-2020 models (extending coverage to 10 years/100,000 miles), corporate formally denied coverage for my vehicle. This indicates that the dangerous premature CVT failure defect extends beyond the specific manufacturing batches Subaru has currently acknowledged, leaving drivers exposed to sudden loss of propulsion at highway speeds. I am requesting the NHTSA investigate the 2020 Subaru Outback TR580 CVT for inherent safety defects leading to sudden loss of motive power.

   NHTSA complaint 11767432
2. Filed Sep 27, 2026Failure Sep 26, 2026Cody, WYUnknown or other

   Unknown. Best assessment between 2:09 and 2:15 pm on the XXX pass outside of [XXX] heading west. There were wind gusts up to 27 mph. I was traveling highway speeds 75-80mph. I had been driving highway speeds since 10:30 am coming from [XXX] No warning. As in: no flutter of the hood, hood not popped, no warning lights. The hood flew open and smashed my windshield during a gust at 80mph. I believe that even though the hood was closed, the latch either failed or was not fully catching, but there is no way to know that since it is completely closed, does not rattle and there are no indicator lights. You can not see under the hood when it is closed. I have all fluids changed at dealerships. The last time the hood was opened was literally months ago. I have driven 3-6 hour highway trips since then, never an issue. The secondary latch failed immediately bending backwards about 45 degrees. It is quite soft metal. I have photos of this. The tow truck driver had to bend it backwards to get the hood to latch for towing. She did this with her index and middle finger… the secondary latch should not be that easy to bend. I believe this is a failure of components. I am very lucky to be alive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11767264
3. Filed Sep 20, 2026Failure Sep 20, 2026Davis, CAElectrical system, Steering, Unknown or other

   9/20/26 my 2020 Subaru Outback experienced repeated electrical failures followed by loss of power-steering assistance. The underlying failed component is unknown. The vehicle is parked and available for inspection. While driving, the vehicle intermittently lurched/jerked as the center display went completely black and restarted and EyeSight repeatedly became unavailable and returned. After stopping for fuel, I attempted to restart the vehicle. It initially started and then became completely electrically unresponsive: no response from the push-button start and no accessory power. Electrical power unexpectedly returned after I opened the driver's door, and I was able to restart the vehicle. Later, while the engine was continuously running in a parking lot, the display repeatedly blacked out and restarted while EyeSight repeatedly became unavailable and returned. When I shifted into reverse, the vehicle began jerking and power-steering assistance failed. The steering wheel became extremely difficult to turn and jerked in my hands, preventing me from properly completing the reverse maneuver. I shut the vehicle off and restarted it, which temporarily restored steering. This unpredictable steering failure put me, my two children, and other road users at serious risk. After restarting, I had to travel 65 mph on a highway to get home. Had steering assistance failed again at highway speed, I could have lost lane control or been unable to avoid other vehicles or road users, potentially causing a serious or fatal crash. The vehicle has not yet been inspected for this incident. The repair facility has been notified and I intend to have it towed because I consider it unsafe to drive. Six weeks earlier, the facility inspected the battery, terminals and cables and marked them satisfactory. Prior warnings included EyeSight becoming unavailable, the display blacking out/restarting, and vehicle lurching. I observed no separate steering warning before steering assistance failed.

   NHTSA complaint 11765713
4. Filed Aug 19, 2026Failure Dec 1, 202119,000 milesBoston, MAEngine

   The contact owns a 2020 Subaru Outback. The contact stated that on various occasions upon bringing the vehicle to a stop or upon acceleration the vehicle had experienced a total loss of automotive power, and all of the warning lights would remain illuminated. The vehicle was taken to a local dealer where it diagnosed and the contact was advised that the battery, and thermal valve were faulty and needed to be replaced. The battery had been replaced five times however the contact noted that the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 19,000.

   NHTSA complaint 11757956
5. Filed Aug 11, 2026Failure Jul 28, 2026Brookhaven, MSElectrical system

   In the first 2 weeks after financing vehicle it started having passenger window issues when it rained it caused window to not wat to go up or would try coming down when trying to let it up when it rained next qas battary kept killing my battery I've replaced 4 batteries in 2.5 years and then my rear gate door would sometimes not want to open til it just stopped all together as if it had something stuck in it to keep from opening then while driving the assistant in 2 events tried to take me off rd when going in a curb and while driving the car would just randomly act like it was shuddering and would shut off and then come right back on screen would shut off and everything until it just electrically just shut down completely nothing working complete electrical shut down in the 2.5 years I've had car ive taken it to the used lot where I git car and to two different subaru dealerships and no body had helped me and I know it had a settlement case for the battary for my year car and no body is honoring anything and now I have a shut down car with still 3 years of notes to pay and its completely factory issues but they expect me to pay large deposits to even look at this issues I just need some help on this cause I've tried all I can do and I need a car please help me or direct me to someone who can please thanks oh and the cat is a 2020 subaru outback premium trim thanks

   NHTSA complaint 11756314
6. Filed Aug 5, 2026Failure Jun 1, 2012willoughby, OHPower train

   From when we purchased this car new until the day we traded it. There were many times on the freeway at 60-65 MPH that you would need to move over a couple of lanes and went to wide open throttle and the car would simply do nothing for 1 to 2 seconds. I recently learned that in 22' Subaru had a software update to rectify this issue. Meaning there are plenty of Subaru owners who are driving around in cars that put their safety at risk. When you step on the gas you need and expect the car to accelerate .

   NHTSA complaint 11754978
7. Filed Jul 22, 2026Failure Jul 6, 2026Lexington, KYSeats

   The driver’s power-seat lift motor failed intermittently, leaving the seat stuck in its lowest position. The component remains installed in the vehicle and is available for inspection. The seat could not be raised high enough for my wife to obtain adequate forward visibility, making the vehicle unsafe for her to drive. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Quantrell Subaru confirmed the lift motor failure. The technician tapped the motor, it worked briefly, and then failed again. It was inspected by an authorized Subaru dealer. It has not been inspected by Subaru of America, police, or insurance representatives. There were no warning lamps or messages. The first symptom was that the seat would no longer raise and became stuck at its lowest position. The issue was documented by the dealer on July 21, 2026.

   NHTSA complaint 11752019
8. Filed Jul 21, 2026Failure Jul 14, 2026Brooklyn, NYEngine, Fuel/propulsion system, Wheels

   The warning lights on our 2020 Subaru Outback have lit intermittently for the past 2 years. When bringing the vehicle into the dealer for service and oil changes, this was reported. Recently the TPMS light began to light intermittently. Tire pressure was checked and adjusted but the problem persisted. When we brought the vehicle in for service, it turned out that all tire pressure sensors needed to be replaced BUT the service techs identified other problems that surfaced JUST AS THE CAR WAS NOT COVERED BY WARRANTY - the most serious being an oil leak caused by FAILURE OF CAM CARRIER SEALS. This caused a dangerous condition where oil was leaking onto the engine and into the spark plugs. I find it odd that this EXPENSIVE issue was not discovered sooner. Subaru and only Subaru has been servicing this vehicle since new and they should have caught it.

   NHTSA complaint 11751812
9. Filed Jul 10, 2026Failure May 24, 2026Williamsburg, VAEngine, Fuel/propulsion systemFire

   What component or system failed or malfunctioned, and is it available for inspection upon request? - Car fire, originating under the hood. Unknown if vehicle is available for inspection. Last reported by Insurance company to be at IAA; [XXX]; PH#: [XXX]. How was your safety or the safety of others put at risk? - Car fire began while in the car after moving through an intersection with a stop light. Four of us in the car, ages raging from [XXX] old. Fire quickly spread; however, we were able to exit the car without injury. Has the problem been reproduced or confirmed by a dealer or independent service center? - NO, car was totaled and Subaru, NA Consumer Advocacy agent assigned claims that the vehicle is no longer available for inspection. Both insurance company (Travelers Auto) and Subaru, N.A. consumer advocacy group made aware of our concern as to why the vehicle caught fire. One or both demonstrated nonchalance of this concern. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - YES - Just prior to the start of the fire, the vehicle stalled and cut-off with CHECK ENGINE LIGHT. Also, we smelled an unusual exhaust at the time prior to, and at the time of the cut-off. This occurred at the intersection of where the car caught fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11749535
10. Filed Jun 30, 2026Failure Jun 30, 2026Rochester, NYUnknown or otherFire

    Vehicle stalled out, stopped and promptly caught fire.

    NHTSA complaint 11747515
11. Filed May 9, 2026Failure May 8, 2026Valencia, PAPower train

    My transmission has started to fail. The check engine light came on the error code read p0867, transmission fluid pressure. Other lights came on as well because it tripped the rest of the sensors because of the CVT failure. This seems to be a common problem in Subarus

    NHTSA complaint 11736752
12. Filed Apr 19, 2026Failure Apr 10, 2026Greendale, WIPower train

    I was reversing out of a residential driveway onto a county highway when the I had a complete loss of movement. Shortly after the total loss of power, the CEL illuminated. If I had been on the highway, the driveway is near a blind curve, I would've been sitting in the road with no way to move putting me in a dangerous situation. The transmission failed at right at the end of the driveway so I was able to put it in neutral and move the vehicle by hand. There were no symptoms or warning lights prior to the failure. I had it towed to the nearest dealership where they diagnosed a complete transmission failure and recommend a complete transmission replacement.

    NHTSA complaint 11732229
13. Filed Mar 30, 2026Failure Mar 24, 2026Sewell, NJEngine

    Vehicle: 2020 Subaru Outback Onyx/Limited/Touring XT (2.4L Turbo FA24) Component: Engine Lubrication / Oil Pan Sealant I am reporting a manufacturing defect involving the engine oil pan seal on the 2020 Subaru Outback 2.4L Turbo. Upon inspection of fluid accumulation at the transmission joint, a Subaru dealership diagnostic confirmed that the engine oil pan seal has failed. The dealership noted that engine oil is leaking and being forced rearward by airflow while the vehicle is in motion, saturating the transmission assembly. Technician Admission: The service department at the Subaru dealership explicitly stated that this is a "known manufacturing issue" with the FA24 engine series. Financial Concession: To acknowledge the nature of this premature failure, the dealership waived the $185 diagnostic fee, resulting in a $0 invoice (attached). Inadequate Coverage: Despite the dealership’s admission and a repair quote exceeding $1,100 (file is attached), Subaru has not yet issued a recall or extended warranty for this specific 2020+ turbo application, though similar issues with RTV sealant have plagued the brand’s newer engine platforms. The technician confirmed that the leak is significant enough that oil is traveling the length of the transmission. This presents a potential fire hazard if oil contacts high-temperature exhaust components (such as the turbocharger or catalytic converter) and contributes to environmental contamination. This is the Turbo (XT) model. Turbochargers generate much higher heat, which makes an oil leak significantly Subaru National Customer Service has advised me to file this complaint with the NHTSA. I am requesting that the NHTSA investigate the frequency of oil pan seal failures on the 2020+ 2.4L Turbo (FA24) engine to determine if a mandatory recall or extended warranty (similar to past CVT or engine seal settlements) is warranted to protect consumers from the high cost of a documented manufacturing flaw.

    NHTSA complaint 11728037
14. Filed Mar 19, 2026Failure Mar 18, 2026Daly City, CAWarnings, Automatic emergency brakingCrash

    I was parking my car slowly until it suddenly accelerated. I hit a wall and car got totaled.

    NHTSA complaint 11725434
15. Filed Feb 22, 2026Failure Feb 3, 2026Eagan, MNPower train

    I'm writing to request assistance with my recall. This recall was first reported to the local dealership over one year ago. They have had me take the car back 4 times for inspection. Since that time as the problem has proceeded to get worse, which will now cost even more to repair, and increase the likelihood of the transmission damaging other parts of the drivetrain. Now I just received notification that they will not perform the recall as my vehicle doesn’t qualify. It has the problem of transmission slipping which is what the recall is for. I saw the pictures they took that looked exactly like the problem specified. I do not have $7000 dollars plus to fix the transmission. I can’t sell the car because the VIN will show the recall (which I’m sure they will try to just remove). All they have done is waste my time for the last year to do what? Gather enough evidence to try and get out of the recall?

    NHTSA complaint 11719700
16. Filed Feb 14, 2026Failure Feb 13, 2026Pequannock, NJFuel/propulsion systemFire

    No warning lamps or messages. A driver in a pickup truck behind me came up close and signaled me to pull over. He got out of his truck, ran up to my window and yelled to me "get out of your car, it is on fire". I was completely unaware of any problem. I got out and could see fire coming from under the front of the car. We moved away and he called 911.

    NHTSA complaint 11718035
17. Filed Jan 29, 2026Failure Dec 28, 2025Winston Salem, NCPower train

    On December 28, 2025, my 2020 Subaru Outback lost the ability to engage any gear (Drive, Reverse, or otherwise) while maneuvering at low speed to make a U-turn. The vehicle became inoperable immediately and was towed to the dealer. The dealer confirmed via text and written estimate that there was no external damage, the failure was internal to the CVT transmission, and the transmission requires replacement. This vehicle has approximately 90,023 miles. The failure occurred under the mileage and age range covered by Subaru CVT warranty extensions for similar vehicles. Subaru of America reviewed the case and denied coverage, citing VIN exclusion and prior service gaps that predated my ownership. The vehicle is currently inoperable and presents a safety risk due to loss of propulsion. I am reporting this to NHTSA because it may indicate a systemic defect in CVT transmissions on this model year Outback.

    NHTSA complaint 11714318
18. Filed Jan 27, 2026Failure Dec 10, 2025Brooklyn, NYAir bags

    I am reporting a safety-related defect involving the Supplemental Restraint System (SRS) on my 2020 Subaru Outback with approximately 20,480 miles. Multiple SRS and occupant detection system warning lights illuminated. Dealer diagnostics showed multiple SRS-related faults including airbag ECU malfunction, occupant detection sensor communication failures (lost communication/mismatch), and SRS power/voltage-related faults. These systems directly control airbag deployment and passenger safety. The vehicle has not been involved in any accidents and has not been misused. The dealer advised the vehicle is not safe until repaired. Subaru of America declined assistance and closed my case, stating it is outside goodwill parameters, and is requiring me to pay approximately $1,200 to repair the airbag-related system. In November of the prior year, the vehicle had a battery failure and was serviced by a Subaru-certified dealer. During that repair, wiring work was also performed. Given the current SRS faults and the prior wiring/battery service, I am concerned this may be a systemic or related defect rather than normal wear. I am requesting NHTSA review this issue as a potential safety defect involving the SRS/occupant detection system.

    NHTSA complaint 11713606
19. Filed Jan 13, 2026Failure Jan 13, 202637,168 milesSacramento, CAElectrical system, Adas

    The contact owns a 2020 Subaru Outback. The contact stated that while driving 65 MPH on the highway, the contact was alerted by the message “Eyesight Technology Failure”, before the battery shut down, causing the steering wheel to seize, forcing the contact to come to a complete stop in the middle of the highway. The check engine, air bags, and oil warning lights were illuminated. The contact stated that several other unknown warning lights and alerts were displayed on the instrument panel. The vehicle was jump-started, and the contact was escorted by a tow truck operator to the nearest dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 37,168. The VIN was invalid.

    NHTSA complaint 11710788
20. Filed Nov 2, 2025Failure Nov 1, 2025South Pasadena, CAEngine, Unknown or otherFire

    A fire started under the hood of my car while I was driving. There were no warning lights on in my car and the temperature gauge was in the middle where it usually is. Earlier in the day, I smelled gas, but I thought it was a different car as the smell of gas went away after a car that had a lot of exhaust coming out was no longer in sight.

    NHTSA complaint 11697021