2016 Toyota 4RUNNER

79 complaints on file, page 1 of 4.

1. Filed Aug 31, 2026Failure Jul 4, 2020Kingwood, TXBody

   I have a 2016 Metallic Gray Toyota 4Runner and there appears to be a clear-coat defect on the hood and roof.

   NHTSA complaint 11761113
2. Filed Aug 11, 2026Failure Aug 9, 2026Chesapeake, VACarry handle, Shell, Base

   Swivel motion has started to jam when half locked, base will show half red/half green and refuse to lock. Unlock handle becomes hard to lift to swivel the car seat back to attempt to lock it again. I’ve contacted Evenflo, but waiting to hear back.

   NHTSA complaint 11756359
3. Filed Jun 2, 2026Failure Jun 2, 2026Mitchell, NEBody

   The paint is failing on this vehicle. The color is 8S6 Nautical Blue Metallic. The paint is peeling on the roof, hood, and two doors. The failure has been confirmed by a body shop.

   NHTSA complaint 11741642
4. Filed May 26, 2026Failure May 22, 2026Bismarck, ARAir bags, Service brakesCrash1 injured

   We were traveling down the mountain of Mt. Nebo in Dardanelle, AR, around 1:08pm on Friday, May 22, 2026. It had been misty rain for a few hours. As we were traveling down the switchbacks of the mountain, we pressed on the brake to slow the vehicle; however, the vehicle did not slow down any. Since we were coming to the next curve in the switchback, the decision was made to drive the car into a tree vs. risking flipping the car over the side of the mountain. When the vehicle collided with the tree, none of the air bags deployed. The point of impact was the front driver corner of the car. The car was traveling around 20 MPH at the time of impact (to the best of our knowledge). Problem #1-brake system failure Problem #2-Air bags failed to deploy -What component or system failed or malfunctioned, and is it available for inspection upon request? The brake system & air bags. Both are available for inspection. -How was your safety or the safety of others put at risk? Risk of death associated with the crash. -Has the problem been reproduced or confirmed by a dealer or independent service center? Unavailable at this time due to the extensive damage caused from the crash. -Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not to my knowledge since this happened a few hours before a holiday weekend. -Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? None that we seen.

   NHTSA complaint 11740147
5. Filed Mar 24, 2026Failure Mar 6, 2026Charlottesville, VAAir bagsCrash

   On March 6, I was on South bound on Rt 29 in Culpeper County VA at the posted speed limit of 55mph when I hit a debris item on the road. I do not know what it was but it impacted the front skid plate and seems to be no other damage from the impact. There was no contact with the bumper, wheels or otherwise. There was no sudden change in speed or loss of control at all. The most dangerous result of this was the deployment of all the airbags (except passenger front airbag, there were no passengers). A police report was filed with Culpeper County Sheriff (case# 2603-0033) and my insurance agency (USAA claim # 016632631-800). The shop where the vehicle was towed (Ace Collision in Madison, VA) expressed surprise at the total deployment of the air bags given the scenario. There were no warning lamps on, the vehicle was in perfect operating condition and all recalls have been addressed according to CarFax

   NHTSA complaint 11726606
6. Filed Feb 16, 2026Failure May 30, 2025Advance, NCBody

   I am reporting premature clear coat failure on a 2016 Toyota 4Runner in Magnetic Gray Metallic. The vehicle has approximately 120,000 miles and has been properly maintained, including regular washing and professional ceramic coating. The clear coat on the hood and roof (horizontal panels) is severely peeling and delaminating. The protective clear layer has failed, and the base coat is beginning to oxidize. This is not the result of neglect, damage, or improper care. The condition appears to be premature material or manufacturing failure of the clear coat. I have contacted Toyota corporate and opened a case. I was informed there are currently no other documented cases for gray paint and that additional complaints would be required before further investigation. I have read numerous reports in online owner forums indicating this is a common issue affecting 4Runners and other Toyota models, particularly on sun-exposed horizontal panels. However, Toyota has not formally addressed this issue for gray paint vehicles. I am submitting this complaint to document a potential widespread clear coat defect and to request further review.

   NHTSA complaint 11718254
7. Filed Feb 12, 2026Failure Feb 1, 2026Truckee, CAFuel/propulsion system

   My 4Runner is hard starting all the time. I’ve replaced the battery, tested the alternator etc. It sounds exactly like the problem of the fuel pump recall. The 4Runner was recalled from 2014-2015, my car was technically put together in Sept 2015, but is labeled a 2016. I believe my fuel pump is failing. I am extremely nervous it is going to not start one day while I am out camping.

   NHTSA complaint 11717449
8. Filed Jan 31, 2026Failure Jan 26, 2026Goodyear, AZCamera

   Rear view camera / backup camera randomly displays blanks screen. Screen has no other issues noted. Has been occurring over the past couple years.

   NHTSA complaint 11714728
9. Filed Nov 10, 2025Failure Dec 15, 2024Phoenix, AZCamera

   I have a 2016 Toyota 4Runner at 143,011 miles. When it hit 125,000 mile mark the backup camera stopped working intermittently. The screen in the car goes blank. Turning the car on/off or changing gears does not affect this issue. It’s random and seems to becoming more frequent as more miles are put on. I will take it in however when I called them they said since it’s not a known issue I will have to replace it and it’s not cheap!

   NHTSA complaint 11698672
10. Filed Oct 7, 2025Failure Sep 22, 2025125,293 milesParker, COBack over prevention

    The contact owns a 2016 Toyota 4Runner. The contact stated that while attempting to reverse, the rearview camera displayed a blank screen. An independent mechanic or dealer was not contacted. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 125,293.

    NHTSA complaint 11691933
11. Filed Sep 29, 2025Failure Sep 29, 2025Cape May Court House, NJBody

    PAINT CLEAR COAT BUBBLING ISSUES REGARDING ROOF AND REAR BUMPER

    NHTSA complaint 11690324
12. Filed Jul 15, 2025Failure Jul 3, 2025Mooresville, INVisibility/wiper

    Wiring harness to rear window defogger melted causing the rear window to crack and shatter. Safe lite replaced the window and recommended the harness not be reconnected. Told me it was not uncommon. Vehicle was not being used at the time. It was in my driveway when the window blew outward. Inspected by Safe lite, Reported to Liberty Mutual. No warning light, rear defogger was not in use, car was off.

    NHTSA complaint 11673719
13. Filed May 16, 2025Failure May 11, 2025Vinton, VAService brakes, Unknown or otherCrash1 injured

    On 5/11/2025, my husband and I were returning home from the grocery store. I was operating the vehicle at the time of the incident. Upon arriving at our residence, I pulled into our driveway, which has a slight downward incline. As in our usual practice, I attempted to stop in front of the garage to unload groceries before entering, as the hatch of our vehicle can come in contact with the garage door when opened inside. While aligning the vehicle with the garage door, I began breaking and turning slightly to the left. However, as I attempted to come to a complete stop in front of the closed garage door, the vehicle unexpectedly accelerated forward. Despite applying the brakes, the vehicle continued moving and crashed through the closed garage door. Due to the steering wheel being slightly turned, the vehicle veered left upon entering the garage, striking the left interior wall and a 32 foot ladder that was leaning against it. The impact with the wall and ladder brought the vehicle to a stop although the engine continued to rev and the vehicle attempted to move forward. My husband instructed me to shut off the engine, which I did immediately. My husband was not injured in the incident. I sustained pain in my left shoulder and upper left back. A medical evaluation indicated that the pain is expected to subside within a few weeks; imaging will be conducted if symptoms persist. I have filed both auto and homeowner's insurance claims regarding the incident. Additionally, I contacted the dealership, which advised me to report the issue to the manufacturers corporate office. They noted that the vehicle is equipped with a fail-safe system designed to prevent simultaneous engagement of the brake and accelerator. This was a very scary incident that I don't want to have happen to someone else.

    NHTSA complaint 11661467
14. Filed Apr 29, 2025Failure Apr 27, 2025Winston Salem, NCSuspension

    This vehicle has experienced the front coil spring cracking on the right front, the left front cracked at 114K miles. This is a very common issue with 2015-2017 Toyota 4Runner TRD-Pro, it is a design defect in the way the coil spring terminates and sits on the top hat and bottom spring perch. Toyota has discontinued the defective parts and redesigned the spring perch on the updated strut and uses a different spring, but it is not recalled and should be as this is a safety defect. A broken coil spring can cause sudden loss of control of the vehicle resulting in a crash and even death.

    NHTSA complaint 11657438
15. Filed Feb 24, 2025Failure Feb 23, 2025Athens, TXElectrical system

    I drive for a living and yesterday I was driving while this happened 3 separate times. I was going 70 mph on the highway when my radio, usb ports blower motor and dash cluster power went out. I was terrified that my car would shut off while driving. Upon checking the car over, I noticed the battery mount was broken/missing pieces. The upper portion had become lose due to the broken parts and had stuck itself to my positive battery terminal. Lots of sparks when I tried to remove it. I finally got it broke loose using a piece of wood instead of my hands. Very scary.

    NHTSA complaint 11644480
16. Filed Aug 8, 2024Failure Jan 1, 2023West Sacramento, CABody

    The entire exterior body clear coat is peeling off. This started about 1.5 years ago on the tailgate. It has now spread to the hood and the top of the vehicle. I called Toyota customer care, and they indicated this a known widespread problem with this vehicle make and model. So far, only the pearl white color has been recalled as the result of numerous consumer complaints. My vehicle color is nautical blue- Toyota indicated there has not been enough consumer complaints yet for this color for it to be recalled. Toyota suggested I log a complaint here in hopes it will result in a recall.

    NHTSA complaint 11607303
17. Filed Feb 25, 2024Failure Feb 24, 2024Stgeorge, UTElectrical system, SeatsFire

    Picked up a Gal to go out on a date. Turned the vehicle on and got about 1 mile down the road when I started to smell , like a hot , burning electrical smoke . My Date , sitting in the passenger seat says Her seat is get warm , then says , it's getting really hot ! I looked at the seat warmer switch and noticed and said , weird , the switch isn't even on . Then the smoke became very apparent as we got onto the Freeway and we were compelled to pull over as the electrical components or wiring were on the verge of catching fire , where the Electic Seat switch is located .

    NHTSA complaint 11573843
18. Filed Nov 28, 2023Failure Nov 27, 2023Virginia Beach, VASuspension

    X-REAS sport enhancement system is failing in a vehicle (2016 Toyota 4 Runner) with 58,000 miles that has always been driven on city streets. Front struts and rear shock absorbers are both leaking and require replacement.

    NHTSA complaint 11557202
19. Filed Sep 21, 2023Failure Sep 21, 2023Jacksonville, FLSuspension

    The contact owns a 2016 Toyota 4Runner equipped with an Ironman 4x4 USA, Part: Pro Forge upper control arm. The contact received notification of NHTSA Campaign Number: 23E051000 (Suspension) however, the contact stated that after calling and leaving messages with the manufacturer regarding the recall, the contact had not received a call back. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Parts distribution disconnect.

    NHTSA complaint 11545810
20. Filed Jul 24, 2023Failure Nov 1, 2022mobile, ALPower train

    This vehicle transmission is demonstrating transmission shuddering problems, We have returned this car three time for the same repair. The highly reputable transmission has cited direct purchases of this part from Toyota has constantly have quality issues with the torque converter, This problem was inspected and confirmed by dealer and independent service center. They both concluded the same diagnose, There were no warning messages. We fear travelling on interstate roads is hazardous.

    NHTSA complaint 11534002