2025 Toyota Corolla

31 complaints on file, page 1 of 2.

1. Filed Aug 27, 2026Failure Jan 6, 2026Northport, NYTires

   225/40R18 88V

   NHTSA complaint 11759888
2. Filed Aug 24, 2026Failure Aug 23, 2026Delmar, DEElectrical system, Unknown or otherFire

   I pulled into XXX drive way at 6:53pm XXX. By 7:12 pm we were on the phone with 911. My car alarm when off. I went over to my car. It was smoking had a bad smell it smelt like it was about to explode. It wouldn’t let me unlock the car. Finally after 5 minutes it finally unlocked there is literal flames on the driver side dash and floor board. We used a fire extinguisher it was still smoking so we put water on it. When the fire department finally showed up the dash was still 182 degrees. They used their high water power fire extinguisher. The battery was also unplugs before the fire was completely out. And state farm called a tow truck to take it to pohanka in Salisbury Md.

   NHTSA complaint 11759279
3. Filed Aug 24, 2026Failure Jan 8, 20268,000 milesNorthport, NYTires

   The contact owns a 2025 Toyota Corolla equipped with Dunlop Tires, Tire Line: SP Sport 5000, Tire Size: 225/40/R18, DOT Number: 1EUT74MBR5024. The contact stated that while driving on several occasions at various speeds, there was an abnormal sound coming from each tire, and the tires were slick while driving in inclement weather. The vehicle was taken to the dealer, where it was determined that all four tires needed to be replaced due to uneven wear. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 8,000.

   NHTSA complaint 11759227
4. Filed Aug 24, 2026Failure Jan 15, 2026Northport, NYTires

   Premature wear and tear

   NHTSA complaint 11759196
5. Filed Jul 27, 2026Failure Jul 25, 2026Chelmsford, MAAir bags, BodyCrash1 injured

   I was broadsided at the front end of the drivers side on Saturday 07/25/2026 by a wayward vehicle drifting into my lane. After the crash, the airbags deployed and then I could not open the driver seat door. Three other passer-bys who kindly stopped to check on me could not open the door from outside either. Finally, after being stuck for at least 10 minutes in the car, the police arrived, who somehow managed to open the door and let me out. This is a serious safety hazard; if the car caught fire, I could be burnt alive.

   NHTSA complaint 11753117
6. Filed Jul 25, 2026Failure Jun 8, 2026Daytona Beach, FLAir bags, Service brakes, Visibility/wiperCrash2 injured

   It was heavy rain traffic came and when I slowed down the anti lock breaks effected me from stopping fast enough and were made me just slid into back off vehicle in front off me giving me injury's to my kneck due to the air bags did NOT deploy.

   NHTSA complaint 11752771
7. Filed Jun 29, 2026Failure Jun 18, 202628,000 milesSewickley, PATires

   The contact owns a 2025 Toyota Corolla equipped with Dunlop Tires, Tire Line: SP Sport, Tire Size; 225/40/R18, DOT Number: (N/A). The contact stated that while driving approximately 50–60 MPH, the rear end of the vehicle was uncontrollable. The vehicle was driven to the shoulder of the roadway. The contact inspected the vehicle and became aware that the rear driver's and passenger’s side tires were cupping. The contact stated that the tires were original equipment. The vehicle was towed to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 28,000.

   NHTSA complaint 11747184
8. Filed Jun 19, 2026Failure Apr 24, 2026Huntsville, ALService brakesCrash

   I performed a search on Google for any corolla's braking problem and found an incident "EXACTLY" like my daughter experienced! Here is the link to it on Reddit - Terrifying brake failure on my new 2025 Corolla Hybrid – Pedal went to the floor with zero warning! [XXX] BELOW IS THE VERBIAGE FROM TOYOTA CUSTOMER SERVICE SENT BACK TO ME 06/19/2026: Thank you for contacting our Brand Engagement Center regarding the incident that occurred on [XXX], and was reported to us on May 12, 2026. You reported that while your daughter was driving your 2025 Toyota Corolla Hybrid, she experienced a brake failure incident causing a collision to occur. You stated that she was exiting to the right and applied pressure to the brake pedal. However, the brakes made a loud noise, the brake pedal went to the floor, and your vehicle collided with the rear-end of another vehicle. You also expressed concern that the front Supplemental Restraint System (SRS) airbags failed to deploy. This is the summation. Of course they found nothing... Respectfully, [XXX] email- [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11745303
9. Filed Jun 17, 2026Failure Jun 16, 2026Round Rock, TXUnknown or other

   The glass on the instrument panel has an extreme glare in the sun. I have tinted all my windows including the windshield, but the issue persists. The hood on the instrument panel needs to be longer or the glass needs to be non glare. There is nothing on the market that will fix this issue.

   NHTSA complaint 11744746
10. Filed Apr 26, 2026Failure Apr 19, 2026Mulvane, KSWarnings, Automatic emergency braking

    I was driving west bound on I40 with the adaptive cruise control, and lane assist on at 75 MPH. It was around 8:30 PM when I seen the instrument panel flash, just drop for less than half a second, and then come back up but dimmer, like when the headlights come on, except they already were on. At that point all engine noises stopped and the car felt like it was actively braking. I literally lurched forward in my seat. I noticed that the RPM's had dropped to zero and I didn't see anything on the dash that indicated any warning. All green icons and nothing red. Stepped on the gas pedal, nothing. Tried hitting the cancel on the adaptive controls, nothing. I started turning the car from the inside lane to get to the outside shoulder while shifting the car into neutral to get more drift and tried toggling the key from off to start position and the engine. No rev, no RPM's. Car stalls in the outside lane. I turned on the flashers and then put the vehicle in park, removed the key and then re-entered the key and tried to start. Nothing. Attempted to push the car out of the lane in neutral but I wasn't able to get it to move. A couple semi's go by and I about pooped my pants. Waited for highway patrol to come by and get the car towed. Very fortunate no one was hurt or killed. I believe the automatic emergency braking activated or the electronic parking brake activated? All of the interior systems still had power.

    NHTSA complaint 11733816
11. Filed Apr 15, 2026Failure Feb 20, 20268,000 milesMarshall, ARAir bags, Service brakes, Hydraulic, Accelerator pedalCrash2 injured

    The contact owned a 2025 Toyota Corolla. The contact stated while attempting to drive from a complete stop, the accelerator pedal was depressed, but the vehicle failed to respond as intended. The front end of the vehicle lowered down while the rear-end rose and made an abnormal squealing sound. There was no warning light illuminated. The contact's husband assisted the contact in driving, and the vehicle was able to respond after several attempts; however, the contact's husband stated that the vehicle felt like the parking brake was engaged unintendedly. The vehicle was taken to the dealer, where the failure could not be duplicated; however, an unknown part was replaced. The contact stated that while driving 35-45 MPH, the vehicle in front of the contact's vehicle slammed on the brakes. The contact then depressed the brake pedal, but the pedal travelled down and rested on the floorboard. Additionally, the front end of the vehicle lowered while the rear end of the vehicle rose, and the vehicle crashed underneath the rear-end of the truck. There was no warning light illuminated. The air bags failed to deploy. Toyoya Safety Connect system automatically connected the contact to a representative. The contact was transported to the hospital by emergency units. The contact sustained a fractured sternum, three fractures on the back, and the contact was hospitalized for 3 days. The contact's husband later arrived at the hospital and received medical assistance. The contact's husband sustained headaches, neck pain, bruised stomach as the seat belt fractured. The other driver did not sustain injuries. A police report was filed. The vehicle was towed and totaled by the insurance company. The dealer and the manufacturer were contacted. The failure mileage was approximately 8,000.

    NHTSA complaint 11731330
12. Filed Apr 7, 2026Failure Apr 3, 20268,500 milesAiken, SCAir bags, Service brakesCrash

    The contact owns a 2025 Toyota Corolla. The contact stated that while driving approximately at 65 MPH, and applying the brake pedal to exit off a ramp, the vehicle failed to decelerate. The contact continued to press the brake pedal; however, the vehicle did not stop, causing them to rear-end another vehicle, which caused their vehicle to come to an abrupt stop. The air bags did not deploy. The contact did not receive any injuries, and no medical attention was needed. A police report was filed. The vehicle was towed by Georgia Carolina Recovery Services. The contact was informed by the adjuster that the vehicle may be totaled; however, the decision had not been finalized. The dealer was contacted and informed about the incident. The manufacturer was informed of the failure. The failure mileage was approximately 8,500.

    NHTSA complaint 11729611
13. Filed Mar 18, 2026Failure Mar 17, 2026Canton, GAAir bagsCrash

    Driving on the interstate. Did not see or feel anything in the road. Airbags deployed and wrecked.

    NHTSA complaint 11725229
14. Filed Mar 16, 2026Failure Feb 14, 2026Laveen, AZElectrical system, Automatic emergency braking, SteeringCrash1 injured

    On February 14th, my 2025 Toyota Corolla Hybrid (approx. 17,000 miles) experienced a catastrophic failure. Without warning, the steering wheel completely locked, preventing any control. Simultaneously, the automatic emergency collision braking system malfunctioned, locked the brakes, and would not disengage. This total loss of control forced the vehicle to crash into a median. Toyota Corporate has ignored my case for 30 days. This is a severe, life-threatening manufacturing defect that caused a crash and destroyed my sole source of income.

    NHTSA complaint 11724571
15. Filed Mar 4, 2026Failure Jan 21, 2026South Elgin, ILElectrical system

    Two incidents of rodent eating the wires of the car in a span of two weeks that cause a lot of money to repair. Dealership did mention that wires have soy based insulation which was the cause. Newer Toyota Cars have the same problem which a coworker of mine had last year and my brother as of this date have the same problem.

    NHTSA complaint 11722123
16. Filed Feb 13, 2026Failure Aug 1, 2025Annapolis, MOAdaptive cruise control, Service brakesCrash

    The contact rented a 2025 Toyota Corolla. The contact stated that while driving at unknown speeds and entering into a parking space, the contact applied the brake pedal; however, the adaptive cruise control system engaged unexpectedly, causing the vehicle to accelerate and crash into a building. The driver was unable to turn off the adaptive cruise control system. There were no reported injuries, fire, or airbag deployment. A police report was filed. The vehicle remained drivable after the incident. The contact also stated that the vehicle continued to surge forward at intersections following the crash. An unknown local dealer was contacted, where it was diagnosed and determined that reprogramming was needed. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. The VIN was not available.

    NHTSA complaint 11717840
17. Filed Feb 2, 2026Failure Jan 27, 2026Austin, TXService brakes

    I was driving at 2pm after an Ice Storm had hit texas and a majority of ice was missing but there was a small patch under a bridge. There were two stoplights once which was not under a bridge and one about 50-100 in front which was. I had accelerated to about 20 before the other light changed to red and I attempted to stop but due to ice I kept sliding forward adn the ABS was going wild and while I had the brake held down the pedal was going wild from the ice and after the car has stopped the brake pedal arm had bent so drasticly my brake lights wouldn't turn off due to the pedal arm being bent into the sensor below the dash. Toyota then refused to cover any part of the repair cost under the warrenty due to outside influence. I did not and could not have expected that using the brake pedal in an emergency situation would brake the brake pedal and they refuse to cover it under manufacturer warranty.

    NHTSA complaint 11715051
18. Filed Jan 30, 2026Failure Nov 16, 2025Anaheim, CATires, Pressure monitoring and regulating systems

    exactly one year after purchase and with approximately 18,000 miles on the vehicle — the original factory-installed front right tire catastrophically failed while I was driving under normal conditions. The tire blew out suddenly with complete sidewall separation, causing loss of vehicle control. There was no prior tire pressure warning before the failure occurred. Tire size: 225 /40R18 88V

    NHTSA complaint 11714382
19. Filed Dec 25, 2025Failure Aug 4, 2025Batavia, OHElectrical system, Engine, Fuel/propulsion system

    Driving on highway around 65mph, car shut down internally completely blacking out inside. Turned back on a few seconds later while still driving all lights were blinking. Pushed the SOS no-one answered pushed again then someone came on. Matches the same description on the other 2025-26 hybrids in the corolla cross and camry hybrid.

    NHTSA complaint 11707027
20. Filed Dec 12, 2025Failure Nov 29, 2025houston, TXWarnings, Engine, Service brakes

    I am writing to inform you of some recurring issues with my vehicle. The car has been displaying several (5) alerts, including those related to the parking brake system, drive-start control system, check engine light, vehicle stability control system, and secondary collision brake system. I took the car to a dealer for repairs, and they assured me that the issues were resolved. However, the following day, the problems reappeared. Additionally, when I start the car, it emits an unusual sound and begins to shake. Unfortunately, The dealer had 5 days my car to repair and denied to provide a rental car. I don't understand the reason if my car is new and the problem is manufacturing I would appreciate your assistance in addressing these ongoing concerns.

    NHTSA complaint 11704798