SUV, gasoline, 4WD/4-Wheel Drive/4x4, built in United States. Owner complaints on file from Dec 15, 2014 to Sep 23, 2026.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 18E-107 | Nov 27, 2018 | Windshields have an attached wire harness that water may leak into, possibly causing damage to the vehicle's Engine Control Module (ECM) | Electrical system | 8,202 | Part replacement |
| 15V-144 | Mar 13, 2015 | Component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process | Steering | 110,085 | Part replacement |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
192 complaints on file, page 1 of 10.
The paint is severely peeling on the outside. This can likely flake off and damages other vehicles, property, and roadway infrastructure. This is the factory coat of paint. Color is Toyota Blizzard Pearl (070)
NHTSA complaint 11766542Blizzard White color - Car paint peeling on multiple areas.
NHTSA complaint 11763771The a/c condenser was damaged due to impact of road debris. This caused loss of proper system operation. The cost to repair was $1100+. The debris entered thru the front grill, which has nothing in place to prevent debris from entering the engine compartment.
NHTSA complaint 11760154The factory paint on my 2015 Toyota Highlander, Blizzard Pearl (Toyota code 070), is delaminating from the primer. The base coat lifts and peels in sheets, starting on the roof, fender, and pillars — the panels with the greatest UV exposure. There has been no collision, repaint, or chemical damage; this is spontaneous adhesion loss between the factory base coat and primer. First noticed 5/5/2026 at ~137,193 miles, it has spread across the roof and pillars, with the largest piece so far (~4"x2") flying off the vehicle. Delamination lines radiating under the paint indicate more will detach, and the defect affects all painted surfaces. On 7/20/2026, while driving at highway speed, a large paint chip detached from the passenger-side A-pillar and flew off, directly witnessed by my passenger. Paint released from a moving vehicle poses a road hazard to trailing vehicles, and further detachment events are likely. This is a known manufacturing defect in Toyota's 070 Blizzard Pearl paint. Toyota acknowledged the identical defect — UV-related adhesion failure between primer and base coat — in Customer Support Program ZKG, covering the Camry, Corolla, Avalon, 4Runner, Scion, and Lexus GX of the same era. The Highlander was painted with the same 070 formulation in the same period but was excluded, and that program has expired. CSP 23TE08 (Sept 2024), covering paint adhesion failure on 2016–2022 Tacomas in 040 Super White, shows Toyota continues to acknowledge this defect category on other models while Highlander owners remain excluded. The delamination exposes primer and bare metal, leading to panel corrosion. I contacted Toyota's Brand Engagement Center on 8/4/2026, case #260804002309, requesting goodwill assistance and was denied the same day; a case manager review is pending. I file this complaint to document the defect on a Highlander so NHTSA has an accurate record of affected models beyond those Toyota has chosen to cover.
NHTSA complaint 11754797The paint is severely peeling on the outside. This can likely flake off and damages other vehicles, property, and roadway infrastructure. This is the factory coat of paint. Color is Toyota Blizzard Pearl (070)
NHTSA complaint 11751753The contact owns a 2015 Toyota Highlander. The contact stated that the power liftgate consistently failed halfway through while opening and closing the liftgate. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact became aware of information online about Technical Service Bulletin: SB0023/16, NHTSA ID Number: 10134306 (Structure, Electrical System); and associated the failure with the TSB. The manufacturer was made aware of the issue and confirmed that the vehicle was not covered under warranty, TSB, or a recall. The failure mileage was approximately 133,000.
NHTSA complaint 11750990The contact owns a 2015 Toyota Highlander. The contact stated that while driving on several occasions at various speeds, the infotainment screen would go blank and the system would turn on inadvertently. This issue became more frequent, occurring approximately every 10 seconds. The power steering warning light also illuminated. The vehicle was taken to an auto parts store where a handheld diagnostic machine did not detect any failures or codes. The contact stated that while driving on several occasions at various speeds, the steering wheel became extremely stiff. On one occasion while his daughter was driving and turning the vehicle on a curved road, the vehicle veered into oncoming traffic. The contact stated that she managed to get the vehicle back to the correct side of the road, then stopped and inspected the vehicle. The vehicle was then taken to an auto parts store where a handheld diagnostic machine was used, but the failure was not detected. The vehicle was not diagnosed or repaired. The contact believes that the steering failure was associated with NHTSA Campaign Number: 15V144 (Steering). The manufacturer was notified of the failure. The failure mileage was approximately 99,800.
NHTSA complaint 11741329Door lock actuators, yes it is available for inspection. Doors cannot be locked or unlocked with a remote key fob or the interior power door locks. Lock defect poses a significant safety hazard in that a single or multiple doors may not lock at any time, whether the vehicle is on or off and despite actions or commands by the driver. The alleged defect is dangerous to passengers as it can cause unintentional door openings while a vehicle is in use, result in inoperable doors during emergency situations, and leave a vehicle and any contents therein more vulnerable to theft. This poses serious safety concerns, for example when vehicles are involved in vehicular accidents because the occupants may become entrapped when the Door Actuator Defect prevents an occupant from unlocking the doors. Furthermore, this defect jeopardizes the safety of vehicle occupants given that not all doors are capable of being manually unlocked from the exterior. Since owning my highlander I've taken it to the dealership several times for this issue. The front door driver and passenger were replaced and a lock switch however dealership claimed they could not recreate the issue for all doors yet the issue continued and is noted several times in service history. Even when under warranty they refused to change the parts despite multiple service notes and verbal compilations due to their claim of not being able to recreate the issue. There were no warning lights or messages or other symptoms prior to failure. I've had this car since 2019 and it's been an issue notably since 2021. I fear the safety of myself, my family and other passengers are compromised every time we enter the vehicle.
NHTSA complaint 11736019Exterior lights continually burn out.
NHTSA complaint 11725966The moon roof in my car completely shattered out of no where while I was driving down the road and fell all into my backseat. If my children were in the car, they would have had glass all over them.
NHTSA complaint 11725954The side mirrors are too large and located in a position that when the driver is turning left the driver's side mirror blocks the ability to see the crosswalk and also the center divider of the lane they are turning into and has almost caused me to strike a center divider and not see a pothole on a freeway on ramp causing damage to the left side strut and alignment. There were other multiple times I almost hit the smaller center dividers in town and the glare in the mirror causes glare that you can't see where you are going. terrible design
NHTSA complaint 11721079[XXX] battery light appeared on dash. [XXX] on my way to Limestone service station 399 Danbury rd Ridgefield ct ph203-438-8028 a warning appeared on dash stating i will lose steering.Luckily I managed to pull into a parking lot and lost all ability to steer. Thank God i was not on the highway and was not in a catastrophic accident.The dashboard went blank. The engine stayed on as I called Limestone and was told I needed to be towed..As I was calling Allstate for a tow the dashboard came back on and so did the steering. I drove to Limestone. After checking everything I was told they didn't find any codes and there must be a glitch in the system. Battery good, alternator good, serpentine belt good. We also found a recall NHTSA campaign number15V144000 for unexpected loss of electric power steering increasing the risk of a crash for 2015 Toyota Highlander. Jan2 2026 i drove to Brookfield Ct Toyota and was informed by a very helpful service manager Katelyn Hadden that Unbelievably my Vin number was not included in this recall and to come back when it happens again I am a [XXX] grandfather who takes his grandchildren everywhere and will not put their lives in danger in this car until this problem is fixed. I was told by Limestone to stay local and come back when it happens again. I would sincerely appreciate any help in correcting this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11713615Paint is peeling off my car, This is confirmed by Toyota it was covered by the Consumer Support program which expired in July however the paint did not start peeling off until last week.Toyota said that there wasn't anything they could do. this is clearly a manufacture defect and should be repair by Toyota at no charge to me.
NHTSA complaint 11705806When right front pax sits in seat and fastens seatbelt, the airbag indicator correctly says "ON." But after a few minutes, the airbag turns "OFF" and the driver's dash gets an "unfastened seatbelt" warning and a "faulty airbag" warning. All of these occur while the front right pax has remain seated and buckled. If the pax unbuckles and exits the seat, these incorrect warnings all remain the same. The right front pax seat belt buckle has been replaced with no effect. The seat has been recalibrated (seat sensors) with no effect. The wires under the seat have been disconnected, cleaned, and re-connected with no effect. This is a safety issue in that the airbag on that front right side de-activates when a passenger is in that seat. There is a Toyota Recall Campaign for this identical problem, but it does not include my model year (2015). Requesting NHTSA get Toyota to extend their recall to include 2015 models, please.
NHTSA complaint 11704027The blizzard pearl paint on my vehicle is peeling off of the roof and possibly the side of the vehicle.
NHTSA complaint 11677469I have noticed speed issues or high idling with this vehicle for a while. I committed a rear end collision with a vehicle on July 4, 2025, at approximately 2pm. My car rear ended his truck while it was stopped behind another vehicle. My vehicle sustained total damage to the front end. I was ticketed for not reducing speed to prevent a accident. The only warning light was that it need maintenance, which comes on prior to an oil change. My safety was put at risk because the car is idled too fast for the type of driving I do, which is small town and rural road driving. Due to the speed of this vehicle during normal driving, it's difficult to stop quickly to avoid an accident. If it was rainy and slippery, the situation could have been much worse.
NHTSA complaint 11671284On [XXX] my vehicle suffered an unintended acceleration on a very busy highway of The Dominican Republic, reaching a speed of 100 MPH. I was able to drive the car into the bushes of the highway service road hitting all king of obstacles such as trees, wall, advertising signs and safety barriers. The car damages resulted in a total loss. My life and my family life were in extremely dangerous situation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11665465Trunk keeps malfunctioning. During lift would not open all the way or at all and sometimes once open will not close.
NHTSA complaint 11630268Driving the car was hard to steer. Check engine light came on and check speed sensor. Went to a mechanic and disconnected the battery, the sensor reset and back driving ok for about two weeks. This went on for a few weeks. Been a month now and it hasn't come on but it was dangerous due to driving and turning issues.
NHTSA complaint 11630267Driving to take my son to work. Check engine light came on said check and system. Hard shifting put in manual drive and made it to destination.
NHTSA complaint 11630266Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.