2016 Toyota Tundra

120 complaints on file, page 1 of 6.

1. Filed Sep 25, 2026Failure Nov 5, 202577,000 milesEustis, FLEngine, Fuel system, Gasoline, Accelerator pedal

   The contact owns a 2016 Toyota Tundra. The contact stated that upon starting the vehicle, the vehicle hesitated and shuddered. While driving approximately 65-70 MPH and depressing the accelerator pedal, the vehicle stalled. There was an unknown warning light was displayed after the failure. There was an abnormal fuel odor before and after the failure. The vehicle stalled and failed to restart and was towed. A service repair had been scheduled. Upon research the contact associated the failure with TSB: 0166-19. The failure mileage was approximately 77,000.

   NHTSA complaint 11766932
2. Filed Jul 23, 2026Failure Jul 2, 2026Caballo, NMEngine, Fuel/propulsion system

   2016 flex fuel toyota tundra with 118,00 miles was towed to toyota dealer in Las cruces with a no fuel issue. After the analysis it was determined the fuel pump over heated burning out conector and wiring ,but the pump was still working. According to toyota TSB 0166-19 this is a problem the can arise if the alcohol fuel density ID is not updated. I told the dealer to due repairs on vehicle even though a fuel pump was installed and reflashed at 114,000 miles. Viva toyota of las cruses advicate stated that a reflash is all the vehiles needs and does not desire to change the alchol fuel density to updated ID as per TSB-0166-19, so I am worried I will be operating a vehicle with a fuel pump that will over heat and burn out connectors again. I called Toyota complaints and they told me they cannot make a dealer do any repairs.

   NHTSA complaint 11752420
3. Filed Jun 14, 2026Failure Jun 5, 2026Missoula, MTBody

   Bed is rusting out from the bottom in a fashion that looks very similar to a previous Tundra bed rusting issue that had a TSB and remedy from Toyota. On the driver's side bed bolt closest to the cab, the sheet metal tack welded to the bed has separated and is rusting out. Approximately 7 inches to the drivers side from that bolt. The seam sealer is also cracking. Additionally, the drivers side bed bolt closes to the tailgate has rust bubbling up from underneath approximately 1 inch to the passenger side from the bolt and also along where that sheet metal is tack welded onto the bed.

   NHTSA complaint 11744041
4. Filed May 22, 2026Failure May 21, 2026Cleveland, GAFuel/propulsion system

   The fuel pump component or system failed or malfunctioned the engine tried cranking but would not start. The problem has been reproduced to an independent service center, where I was notified of a safety recall on Toyota Tundra. No other inspections have been performed. There are no warning lamps messages visible on the vehicle in question. The vehicle will not start until repeated starts are performed. Vehicle idles roughly before regaining normal idle. One other past similar incident of this type has occurred. No other

   NHTSA complaint 11739464
5. Filed Apr 21, 2026Failure Apr 8, 202667,000 milesWest Palm Beach, FLEngine, Fuel system, Gasoline

   The contact owns a 2016 Toyota Tundra. The contact stated that while driving at slower speeds, the vehicle stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and other fuel pump-related parts needed to be replaced. The vehicle was not repaired because the parts were on back order. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.

   NHTSA complaint 11732710
6. Filed Feb 19, 2026Failure Jan 24, 2026Oregon City, ORSteering

   The steering rack internal seal inside the steering rack failed/ "blew" per mechanic and is leaking. I could lose my ability to steer at any time while driving my vehicle and wreck. It is currently at the Toyota services center in Gladstone, OR and has been diagnosed. No other representatives have inspected the vehicle. There were no warnings or signs of failure. I had originally taken my truck in to have an oil change and have it checked for a "slow" start up.

   NHTSA complaint 11719220
7. Filed Dec 16, 2025Failure Dec 4, 2025Boise, IDSteering

   The power steering went out during routine around-town driving. One moment it was steering fine, the next moment it became extremely difficult and sluggish. There were no warning lights or warning of any sort until the steering wheel started jerking unevenly as I tried to turn. I was able to get control of the vehicle and pull it to the side of the road. There was no difference in the engine noise, and I couldn't see any noticeable fluid leak. I was able to drive the vehicle home, make an appointment with the Toyota dealer, and get the vehicle to the dealership for inspection. The dealership told me after inspection, that the rack and pinion steering was binding internally, and that there was seepage from the right boot. Initially, they told me that the pump should be fine. I authorized them to replace the rack and pinion steering. After which, they told me that the problem seemed to still persist some, and that the pump would have to be replaced also. My total bill came to $3,200, which seemed not unfair. But this whole issue seemed like something that should be noticed as part of a recall. I found the NHTSA recall number. 21V-920, and my truck seemed to match exactly the symptoms spelled out is this recall , but Toyota refused to acknowledge it. My VIN number did not fall within the specified VIN for this recall. I've driven several Toyotas, including another Tundra, a Tacoma, 2 Highlanders and a Sienna, and have been pleased with each vehicle. This Tundra is 10 years old with 95,000 miles, and I've only done expected maintenance and a couple of occasional minor repairs. Those being: - Having the brakes resurfaced - Changing out the alternator In the end, it wasn't a devastating amount of money, but it was an issue that I felt Toyota should have taken care of. I did reach out to them, but because I had already paid for the repairs on the vehicle I needed to drive for work, they refused to talk to me any further. I have the estimate and final bill.

   NHTSA complaint 11705412
8. Filed May 24, 2025Failure May 24, 2025Crosby, NDExterior lighting

   My right front headlamp is getting moisture inside the headlamp assembly. It can be inspected any time. Chance that headlamp will not work. Did not take to a dealer.

   NHTSA complaint 11662959
9. Filed May 7, 2025Failure May 6, 2025250,000 milesAlbuquerque, NMSpeedometer/odometer

   Odometer Fraud. The contact purchased a 2016 Toyota Tundra. The contact stated while going through prior service paperwork found in the vehicle, he discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact also stated that the vehicle was once sold at a private auction. At the time of purchase, the vehicle mileage was 158,000; however, upon discovery of the service paperwork, the contact discovered that the vehicle mileage was once 250,000.

   NHTSA complaint 11659434
10. Filed Mar 20, 2025Failure Mar 18, 2025Ashville, ALHood

    I have had multiple incidents where the front hood bulge has blown off going down the interstate and nearly hit other cars. It’s not been worth buying a new one with the risk of them flying off. It’s definitely a saftey concern and a hazard.

    NHTSA complaint 11649615
11. Filed Feb 20, 2025Failure Feb 5, 2025Mckees Rocks, PAService brakes

    The trailer brake controller went out. It does not supply electronic braking and the truck no longer recognizes the controller on the dashboard. Multiple on line chats and forums, along with my trailer provider, show awareness of this defect. Online individuals learned of the issue during emergency stopping. This appears to be known and wide spread.

    NHTSA complaint 11643867
12. Filed Feb 17, 2025Failure Jan 29, 2025Mandeville, LABody, Unknown or other

    The frame of the truck is extremely rusted. I am unsure if it can be fixed. It is available for inspection. This 2016 Tundra has 71,000 miles and is used as a third car. It has been serviced at the same dealership (Northshore Toyota, Covington, LA) and we were never informed of the damage by the dealership. My safety is at risk because the extensive rust could cause the frame to fail. Previous Tundra models have been recalled because of the same issues. No warnings were issued even after the dealership serviced the truck on a lift numerous times (approximately 9 years). The only previous warning by the dealership was on 1/29/2025 when the dealership informed us of a rusty trailer hitch. The truck was brought to 4 body shops in the local area after the owner went to work on the trailer hitch and saw the damage. All 4 shops confirmed that the rust was extensive. 3 shops would not fix the damage because it would be an expensive/extensive fix. We are waiting on what shop #4 says.

    NHTSA complaint 11643127
13. Filed Nov 14, 2024Failure Jan 1, 2023Prescott, AZEngine

    Problem Parts?? At around 70,000 miles I was told that there was an engine oil leak ... camshaft area... and the engine needs to pulled out with a repair cost of about $5,000 dollars. (Reseal both cam towers, replace gaskets, etc.) A bit ridiculous. Is there now a possible engine fire risk? At 70,000 miles there was obviously a manufacturing mistake or a defective part used during assembly.

    NHTSA complaint 11625264
14. Filed Nov 5, 2024Failure Jul 8, 2024Chesapeake, VABody

    Peeling paint. White paint is separating from primer on hood, and adjacent to windshield on a pillars and the leading edge if the roof.

    NHTSA complaint 11623575
15. Filed Jun 5, 2024Failure Jun 4, 2024East Greenville, PAElectrical system, Service brakes, Steering

    1)Over 60 MPH with new tires the vehicle pulses & shakes on front end, checked alignment everything OK per Mechanic. Just started to occur 2)Bluetooth when on iPhone will at any time cut out guaranteed to occur when using at any time been occurring for 2 + years. 3)Trailer brake warning light (Idiot light) comes on dashboard does not recommend trailering due to electrical issue. occurring for 2+ years Bought vehicle used in 2017 with 13k on Truck now 2024 has 91K on truck love the truck but zero recalls for any of the above?

    NHTSA complaint 11592560
16. Filed Sep 7, 2023Failure Dec 15, 202299,000 milesDanbury, NHStructure

    The contact owns a 2016 Toyota Tundra. The contact stated that while driving at an undisclosed speed, the vehicle ran off the road during a thunderstorm, causing the driver's and passenger's side curtain air bags to deploy. The vehicle was towed to the dealer, who informed the contact that the headliner needed to be replaced; however, the part to complete the repair was not available. The manufacturer was made aware of the failure and confirmed that parts were not yet available. The failure mileage was approximately 99,000.

    NHTSA complaint 11543094
17. Filed Sep 6, 2023Failure Sep 6, 2023South Jordan, UTElectrical system

    Seat heater stopped working. Turns out there is a burnt connector leading to part number 87501-0C020, which appears to be a seat heater amp. One pin of the connector is completely melted. I've purchased this truck brand new from Toyota. Nobody has ever touched this part. Scared that it could have caught fire.

    NHTSA complaint 11543017
18. Filed Aug 9, 2023Failure Aug 7, 2023Chico, CASteering

    I was stopped at a turn light to merge left onto freeway and the truck steering went out when trying to turn, it led me into oncoming traffic that was just coming to a stop light, I was able to crank my wheel with all my strength to get to the side of the uphill freeway merge ramp. There were no warning signs. It was so scary and thank goodness I hadn't merged onto the freeway. The component that failed was the power steering assembly, rack and pinion with inner and outer tie rods. I don't believe the parts will be available for inspection since the truck was towed to repair shop. Overall, I was lucky to be alive. My safety was put at risk being unable to properly steer, if I had been going any faster, or even on the freeway there would be no way to control the vehicle. Initially, I was put into oncoming traffic that was coming to a stop. It put myself and everyone around me in danger. The problem has been confirmed by an independent repair shop that truck was towed to. They immediately saw the problem and took several days to fix. Even questioned what I was doing at the time of this event, because something like this just doesn't typically happen. It concerned them so much, that United Wheels and Tires suggested I reach out to Toyota. The vehicle has not been inspected by anyone but the dealer and the tow truck services. Insurance was notified of situation and services dispatched, since the truck was not drivable. There were NO warming lamps, messages or anything on truck. Truck is in perfect condition and drove only on roads (no off-roading or towing, etc.).

    NHTSA complaint 11537568
19. Filed Jul 3, 2023Failure Jul 3, 2023Creswell, ORService brakes

    The integrated brake controller does not apply enough power to the trailer brakes.

    NHTSA complaint 11530257
20. Filed Jun 26, 2023Failure Jun 1, 2023Aurora, COFuel/propulsion system

    Gas tank no longer fills completely in a single squeeze. Each squeeze of the pump only fills up maybe a .25 gallon at a squeeze if I am lucky, but typically less. This results in a complete fill up taking close to a half hour. There are numerous posts on forums such as https://www.tundras.com/threads/gas-filling-problem.38449/, https://www.tundras.com/threads/gas-tank-roll-over-valve-stuck-causes-hard-fuelling-anyone-else.42535/, and many others regarding this issue, with no response from dealers other than sorry. This sounds like a pure manufacturing issue if so many people have issues with their tanks, in a similar fashion.

    NHTSA complaint 11528967