2019 Toyota Tundra

74 complaints on file, page 1 of 4.

1. Filed Sep 29, 2026Failure Jul 20, 2026Conway, ARWarnings, Unknown or other

   The Forward Recognition Camera on my 2019 Toyota Tundra has suffered an internal failure. The vehicle was inspected by an authorized Toyota dealership, which diagnosed and documented:"FOUND INTERNAL FAULT IN FORWARD RECOGNITION CAMERA." The failed component is available for inspection. This camera is a critical safety component that supports forward collision warning, automatic emergency braking, and other driver-assistance systems. Because of this internal failure, the vehicle's ability to detect potential hazards may be reduced or disabled, leaving the driver without safety features that were designed to help prevent or mitigate crashes. This failure places not only the occupants of my vehicle at risk but also other motorists, pedestrians, and cyclists sharing the roadway. The condition was reproduced and confirmed by an authorized Toyota dealer. The dealer determined that the camera itself had internally failed and requires replacement. The failure was not attributed to an accident, impact, misuse, modification, or outside damage. It was diagnosed as an internal fault of the camera assembly. Prior to diagnosis, warning messages and safety-system malfunction alerts appeared on the vehicle, indicating that the driver-assistance systems were not functioning properly. These warnings prompted me to seek service. The dealership subsequently confirmed the internal camera failure. I am concerned that this component failed under normal operating conditions in a relatively modern vehicle and that other Toyota Tundra owners may be experiencing the same defect. A safety-critical camera system should not experience an internal failure that disables key crash-avoidance technologies. I am requesting that NHTSA investigate whether this defect is affecting other 2019 Toyota Tundra vehicles and determine whether corrective action, including a recall, is warranted. The dealer diagnosis specifically states:"FOUND INTERNAL FAULT IN FORWARD RECOGNITION CAMERA."

   NHTSA complaint 11767811
2. Filed Sep 28, 2026Failure Sep 24, 2026Benton, ARFuel/propulsion system

   The fuel pump and the fuel pump control module system failed. Before the failure, I drove my 2019 Toyota Tundra on XXX from [XXX] to [XXX] with no prior check engine light warning. It was parked for all 3 days at a campground in [XXX]. However, on XXX the vehicle would not start. The truck ignition was moved to the RUN position and then the check engine light came on, which was the first notification of a potential problem. So, I attempted to start the vehicle, there was a crank but not a start incident. The ignition was moved back to the OFF position. I'm also an experienced mechanic, so I lifted the hood to diagnose the issue and search where the malfunction was occurring. I inspected the battery, all the fuses, the relays controlling the fuel pump, and the fuel pump control module. Using a Voltmeter Tester, the battery had a full charge. The relays and the fuses were also replaced with no success in starting the vehicle. The fuel line was disconnected from the fuel rail so I could verify if fuel was getting to the engine. The truck ignition was again moved to the RUN position and then the Start Position with NO success of fuel getting to the fuel rail. The vehicle was then towed to a local auto shop and the problem has been reproduced only by Crawford Auto Repair shop in [XXX]. The auto mechanic mentioned two error codes were presented: 1. The fuel pump 2. The fuel pump control module. Thankfully, there was no immediate risk to my family's safety but it could have occurred while driving back through the [XXX] mountains on our way home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11767425
3. Filed Jul 27, 2026Failure Dec 31, 1969Frankville, ALFuel/propulsion system

   We had just exited the interstate when my Toyota Tundra stopped. We had it towed to the closest Toyota dealer. We had to have fuel pump replaced. They said the previous year Tundra was recalled for this issue, but ours was not. I just found out that some of the 2019 models had been recalled for this issue. They said my VIN was not recalled. That does not make sense. It was the same problem, same year, just at a different plant. Now we are having other fuel issues and the dealer says it all stems from the replacement of the pump, which we had to pay out of pocket. If we had not just exited the interstate it could have caused a major accident.

   NHTSA complaint 11753016
4. Filed Apr 14, 2026Failure Mar 15, 2026100,500 milesNew Braunfels, TXElectrical system, Exterior lightingFire1 injured

   The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the fire with water bottles. The contact drove to a water hose, which the contact also used to extinguish the fire. The contact sustained minor smoke inhalation. No police report was filed. The contact was able to drive to the nearby residence. The contact related the failure to NHTSA Campaign Number: 21V688000(Exterior Lighting, Electrical System), which included the VIN. The manufacturer was notified of the failure and sent a field inspector, who inspected the vehicle and informed the contact that the inspection report would be completed on the same day; however, the manufacturer would follow up with the contact within 45-60 days. The contact followed up with the manufacturer three days later and was provided with the same information. The dealer was not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 100,500.

   NHTSA complaint 11731104
5. Filed Feb 23, 2026Failure Feb 9, 2026104,000 milesStanford, MIFuel system, Gasoline

   The contact owns a 2019 Toyota Tundra. The contact stated that while starting the vehicle, the engine sounded rough. The check engine warning light was illuminated. The vehicle was turned off and failed to restart. The vehicle was towed to an independent mechanic, where the ECU was reset; however, the failure reoccurred. The mechanic referenced NHTSA ID Number: 20V682000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 104,000.

   NHTSA complaint 11719942
6. Filed Jan 22, 2026Failure Dec 11, 2025Houston, TXFuel/propulsion system

   My toyota tundra is having issues with the fuel pump. It is saying I am using e85 fuel when that is not the case. As a result I am having issues with cold start. There are recalls however I am being told that my truck is listed among them despite having the same issue.

   NHTSA complaint 11712672
7. Filed Jan 21, 2026Failure Dec 19, 202580,000 milesPrinceton, TXFuel system, Gasoline

   The contact owns 2019 Toyota Tundra. The contact stated that while attempting to start the vehicle, the vehicle failed to respond immediately. The contact stated that while driving 40 MPH and depressing the accelerator pedal, the vehicle stalled, and approximately thirty seconds later the vehicle worked as intended. A dealer was contacted. The vehicle was taken to a dealer and was diagnosed and determined that the fuel pump needed to be replaced, and codes were in the recall. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V682000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 80,000.

   NHTSA complaint 11712354
8. Filed Dec 18, 2025Failure Dec 31, 1969Pembroke Pines, FLUnknown or other

   I bought this car in January 2019, and even though it had 210 miles, they sold it to me as new. I think they did something illegal because I have the purchase contract and they didn't put that information there. They put 10 miles and I didn't notice at the time. Also, I have the window sticker and it says the car comes standard with a remote key for entry, and the dealer removed it to make it without one. I'm ashamed I didn't report this sooner. It must be a form of consumer theft, something they only do to protect themselves.

   NHTSA complaint 11705766
9. Filed Aug 18, 2025Failure Aug 18, 2025Wenatchee, WAElectrical system, Service brakes

   Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes

   NHTSA complaint 11681433
10. Filed Jul 24, 2025Failure Jul 24, 2025Louisville, COElectrical system, Warnings

    Keep getting the messages "Trailer brake error, if towing come to a stop with manual controls" And "Pre-collision system malfunction" The messages go away usually after restarting the vehicle but eventually comes back on

    NHTSA complaint 11676036
11. Filed Jul 22, 2025Failure Jul 17, 2025Orchard, TXSteering

    I had to have the steering rack assembly replaced in my vehicle due to a leak. This is one of the complaints and a recall but I never got a notification.

    NHTSA complaint 11675485
12. Filed Jun 7, 2025Failure Jun 3, 2025Show Low, AZUnknown or other

    The built-in navigation system in my 2019 Toyota Tundra is dangerously outdated and cannot be updated over-the-air (OTA). Recently, it misrouted me into a remote, unfamiliar area with no cell service and incorrect road data. If I hadn’t had enough fuel, I could have been stranded in potentially life-threatening conditions. Toyota continues to install these systems with outdated maps and no OTA functionality, while presenting them as part of a reliable, intelligent driving experience. This is not a minor tech issue—it is a safety failure. Drivers are led to trust a system that cannot be trusted. I want to be clear: this experience has completely changed how I view Toyota as a brand. What seemed like a small, fixable flaw turned into a moment of genuine danger. That moment told me everything I needed to know about Toyota’s priorities—and Toyota is no longer in my future because of it. I urge NHTSA to investigate this as a potential recall-level issue. A navigation system that actively misleads the driver and offers no timely updates is not just broken—it’s hazardous.

    NHTSA complaint 11665435
13. Filed May 1, 2025Failure Mar 1, 202030,000 milesGalena, MOService brakes, Hydraulic

    The contact owns a 2019 Toyota Tundra. The contact stated that while replacing the shocks, the contact noticed that the shocks were oily. The vehicle was taken to the local dealer for warranty repair, and the contact was informed that the brake pads on the rear axle were soaked with oil. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 30,000.

    NHTSA complaint 11658206
14. Filed Apr 2, 2025Failure Jan 1, 2025102,000 milesLugoff, SCElectrical system, Fuel system, Gasoline

    The contact owns a 2019 Toyota Tundra. The contact stated while driving at an undisclosed speed on several occasions, the vehicle stalled. There was no warning light illuminated. The vehicle failed to restart and was towed to the dealer on two occasions. The dealer diagnosed that the fuel pump had failed and needed to be replaced; however, the fuel pump part #770200C170 was on backorder. The dealer reprogrammed the fuel pump system twice as temporary repairs; however, the failure persisted. The contact stated while driving 35 MPH, the vehicle stalled. There was no warning light illuminated. The contact was unable to pull over to the side of the road. The vehicle failed to restart and was towed to the residence, where it was diagnosed by a mobile mechanic. The mechanic diagnosed that that the fuel pump was burned, causing the electrical connector part #9098010844 to burn and melt. The dealer was contacted and informed the contact that the electrical connector part had been discontinued. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the factory warranty. The failure mileage was approximately 102,000.

    NHTSA complaint 11652378
15. Filed Mar 20, 2025Failure Mar 14, 2025Flemington, NJFuel/propulsion system

    Truck shut off while driving fuel pump connector in the tank was melted and could have started a fire. Was told my tundra doesn’t fall under the recall but is having the same problem

    NHTSA complaint 11649561
16. Filed Feb 7, 2025Failure Jan 15, 2023117,000 milesSan Antoino, TXFuel system, Gasoline

    The contact owns a 2019 Toyota Tundra. The contact stated while attempting to start the vehicle at the residence, the contact stated that the engine was shaking abnormally. No warning lights were illuminated. The contact stated that a dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that the fuel pump needed to be replaced, and that the electrical fuel module needed to be reset. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 20V682000 (FUEL SYSTEM, GASOLINE). The manufacturer was notified of the failure and opened a case. The failure mileage was 117,000.

    NHTSA complaint 11641325
17. Filed Jan 25, 2025Failure Jan 15, 2025Dagsboro, DEEngine, Warnings, Fuel/propulsion system

    Having fuel pump issue. Car stalls very badly and pre collision light and engine lights start flashing. Severe jumping by car driving down the road. When accelerating the car has no acceleration and hesitates very badly.

    NHTSA complaint 11638468
18. Filed Dec 5, 2024Failure Dec 5, 2024Wichita Falls, TXFuel/propulsion system

    When refueling this vehicle, gasoline will flow out of the filler tank onto the ground and will shoot out onto the person filling the truck up. Have had the charcoal canister replaced twice and this has not fixed the problem for any length of time. Dealer claims that vent tubes are getting clogged up but cannot explain how or why they are plugged up. Last repair lasted one week before fueling issues showed up again. The gas shooting out of the filler hose onto people standing nearby and onto the ground is an extreme fire and explosion issue and is an environmental issue. This problem seems to be a common issue based on internet search for Toyota Tundra refueling issues. There has been a service bulletin published by Toyota on this issue. I have been having this problem for over 2 years.

    NHTSA complaint 11629077
19. Filed Nov 23, 2024Failure Nov 20, 2024Cashmere, WAExterior lighting

    Factory installed OEM LED HEADLIGHTS: While driving in WET SNOW and SNOW conditions, headlights get covered in snow and visibility is greatly reduced to almost zero.

    NHTSA complaint 11627040
20. Filed Oct 21, 2024Failure Oct 10, 202475,000 milesAustin, TXAir bagsCrash3 injured

    The contact owned a 2019 Toyota Tundra. The contact stated that while driving at approximately 45 MPH, an oncoming vehicle did not obey a stop sign and proceeded to crash into the rear driver's side of the contact's vehicle. As a result, the contact lost control of the vehicle and crashed into the platform of an 18-wheeler. No air bags deployed. No warning lights were illuminated. The vehicle was towed to his residence. A police report was filed. The vehicle was deemed destroyed by the insurance company. The contact who was the driver sustained severe back pain and an injured left knee pending further treatment at a clinic. The front passenger sustained bruising to the left arm and back pain but did not seek medical attention. The rear passenger sustained bruising to the right arm and back pain but did not seek medical attention. The other vehicle occupants did not sustain injuries. A dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 75,000.

    NHTSA complaint 11621063