2023 Toyota Tundra

408 complaints on file, page 1 of 21.

1. Filed Oct 1, 2026Failure Nov 18, 2025Trumbull, CTEngine, Power train

   Recall 25V-767 (Toyota 25TB14) is open on my VIN with no remedy available. Full statement and sources attached. XXX 12 days after the recall was filed and before I had any notice, my check engine light was on at an oil change at Colonial Toyota, [XXX]. The tech showed me the dealer's video of it and the light was cleared. I reported rough running and hesitation pulling away, and fear of a stall in traffic. The only rental offered was a subcompact, which cannot replace my full-size truck or tow my trailer. I was told nothing could be done until Toyota released a fix. None of this is on the repair order. I stopped driving the truck; by mid-XXX it had 19,923 miles. I asked the dealer in writing on XXX for the video, the cleared-code record and their retention policy. No response. Toyota says the video was auto-deleted and that it found no codes, but produced no code report and no deletion record. Toyota met NHTSA about rising failures XXX my CT lemon law protection ended XXX; the recall was filed XXX. The first recall (24V-381) replaced engines; this one uses inspection software, and is still not available for my truck. Six owners sued over this engine ([XXX] v. Toyota Motor North America, D. Vt. No.XXX. In XXX Toyota paid NHTSA $48.8 million in penalties, including for late defect reporting. Please review whether: the remedy is timely and adequate; dealers are clearing codes without recording them, keeping warnings out of recall data; owners get usable transportation; and Toyota reported this defect as promptly as required. I am also preparing a formal complaint to the United States Department of Justice. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11768384
2. Filed Sep 28, 2026Failure Nov 15, 2025Greenville, NCEngine

   Toyota seems in no hurry to resolve the engine issue. Now they are not wanting to replace these engines as first promised.. What happens where there is a catastrophic failure later on. Dealerships are no help. When were they made aware of the engine issue and continue to sell these trucks. We as truck owners need someone to be our voice.

   NHTSA complaint 11767617
3. Filed Sep 26, 2026Failure Sep 21, 2026Greenville, SCAir bags, Seats

   The driver's side front seat lower plastic shield/trim panel completely fractured under normal, everyday usage conditions. The material failed and cracked into sharp, jagged pieces that protrude out into the cabin entryway/exitway. While exiting the vehicle at approximately 57,00, this broke plastic snagged and nearly caused a severe puncture or laceration injury to my leg. The component houses seat controls and sits adjacent to the side airbag module. Toyota has acknowledged this design flaw in Technical Service Bulletin T-SB-0007-24, but the component has fractured into a sharp, physical hazard inside the cabin, creating an immediate risk of occupant injury. Bottomline: The factory driver-side seat panel broke into sharp pieces and caused imminent leg injury hazard during vehicle exit.

   NHTSA complaint 11767089
4. Filed Sep 23, 2026Failure Aug 15, 2026Sheffield Village, OHFuel/propulsion system

   Vehicle: 2023 Toyota Tundra TRD Pro Hybrid, VIN [XXX], approximately 40,000 miles. The electronic fuel door release failed due to a corroded fuel door sensor/connector (diagnosed by Premier Toyota, XXX). When the fuel door system does not engage, the tank's refueling valve does not open. As a result, gasoline spits back out of the filler neck during refueling, spilling fuel onto the vehicle and the ground. This creates a fire hazard at fuel stations. Many other owners of 2022-2024 Tundra Hybrid trucks report the identical failure. I believe this is a manufacturing defect in a sealed electrical component that creates a fuel-spill safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11766277
5. Filed Sep 21, 2026Failure Sep 16, 202645,000 milesEvansville, INEngine and engine cooling

   The contact owns a 2023 Toyota Tundra. The contact stated that while driving 65 MPH, the vehicle stalled with an audible beeping sound. The engine symbol with an exclamation mark was illuminated for approximately 2 seconds. The message "Engine Stopping - Get to safe side of Road" was immediately displayed on the instrument panel. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling) and associated the failure with the recall; however, the part to do the recall repair was not yet available. The vehicle was towed to the local dealer. The diagnostic result was inconclusive. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 45,000.

   NHTSA complaint 11765969
6. Filed Sep 20, 2026Failure Aug 21, 2026Kempner, TXEngine

   On August 21, 2026, I was driving South on US HWY 281 going approximately 70 miles per hour in the middle lane. Approximately near mile marker 540, the engine shut off and the truck rapidly decelerated. I luckily navigated the truck off the highway in heavy traffic. I attempted to restart the engine and it would not start. I had the truck towed to Shottenkirk Toyota and they diagnosed it as failed main crank bearings.

   NHTSA complaint 11765691
7. Filed Sep 18, 2026Failure Sep 18, 2026Arnold, MOEngine and engine cooling

   The contact owns a 2023 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted by phone and was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experience a failure.

   NHTSA complaint 11765291
8. Filed Sep 18, 2026Failure Sep 11, 202639,660 milesCape Charles, VAEngine and engine cooling

   The contact owns a 2023 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The vehicle was taken to the local dealer for the recall repair and was diagnosed with engine failure. In addition, the contact stated that the local dealer had not released the vehicle and the vehicle remained at the local dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 39,660.

   NHTSA complaint 11765245
9. Filed Sep 14, 2026Failure Sep 14, 2026Allison Park, PAUnknown or other

   turbo's have to be replaced because of a wastegate failure. This is a well known issue. My vehicle is at 66700 miles and Toyota has denied a good will claim. Though they admit there is nothing I could have done differently because its a defective part. My safety is put at risk because the truck goes into limp mode and a "reduced power" message is displayed. The dealership has confirmed the issue but because its 7k outside of warranty they are unwilling to do anything even though its a defect. Vehicle has only been inspected by dealership. they also have a diagnostic test for the total engine recall and its very subjective. I don't believe they are keeping safety in mind. I think they are trying to deny as many of those claims as possible.

   NHTSA complaint 11764040
10. Filed Sep 13, 2026Failure Jul 1, 2026Kennewick, WAUnknown or other

    The component that is failed/malfunctioning is the mode function of the HVAC blower system. After thorough online research this appears to be related to either the gear door actuator or the blend door being stuck or broken (gears, etc.). This prevents air from blowing out of any vents other than the defrost and feet modes. While it appears to be a common issue online the two Toyota dealerships will not provide any helpful information unless I agree to a minimum $250 diagnostic fee. I've replaced all the gear door actuators thus I believe it has to do with the blend door. The dealerships default response is "that's just how they are". There were no warnings, messages, etc. prior to failure. Failure was noticed upon start and longer than usual startup of the HVAC system, it now takes 30-60 seconds to attempt to calibrate before any air starts moving. And as stated earlier it just blows out of the defrost and foot functions, nothing out of the face vents.

    NHTSA complaint 11763966
11. Filed Sep 11, 2026Failure Sep 3, 2026Phoenix, AZPower train, Unknown or other

    My radiator leaked engine coolant fluid while driving. The fan shroud warped from heat and rubbed against the radiator and punctured a hole in the radiator causing a slow leak. My vehicle became inoperable and had to pull over. It's been confirmed by the dealership and has a report No warnings prior to failure, though the leak look to have been a slow leak that was in the engine bay and on driveway just faintly so it had been an issue that had been progressing over time. The warnings first appeared for high temp when the coolant was totally out and mentioned the vehicle was overheating and to pull over.

    NHTSA complaint 11763727
12. Filed Sep 10, 2026Failure Aug 31, 2026Jarrettsville, MDPower train

    On XXX my 2023 Toyota Tundra Limited’s check engine light came on and after consulting with my service center, Jones Toyota in Bel Air, MD, via phone I brought the truck into Jones to be assessed. Jones diagnosed the problem and determined a physical failure of the passenger-side turbocharger. The vehicle is currently disabled and located at Jones Toyota in Bel Air, MD, undergoing service for the turbo failure. My vehicle is also subject to active safety Recall Campaign 25TA14 for manufacturing debris in the V35A engine block, but the dealership and manufacturer are treating the turbo failure as a separate repair item and have not linked it to the recall in writing. Operating a twin-turbo V6 platform experiencing sudden propulsion and turbo loss—while an open, un-remedied main bearing engine recall remains pending on the same vehicle—presents a severe underlying safety and mechanical failure pattern putting anyone in the vehicle or on the road with the vehicle when its being operated at risk

    NHTSA complaint 11763394
13. Filed Sep 2, 2026Failure Jan 22, 2026Manor, TXEngine

    I was leaving work one day and pulled out in traffic and my engine stalled causing the car behind me to slam on their brakes to avoid crashing into me from the back my engine completely stalled and I got no gas to accelerate I then went to the dealership and stated what happened and they told me they could not help me at the moment so I wrote a letter to corporate Toyota and they put me in the loaner in the following week. I’ve been in the loaner for the past four months with no remedy on my truck and no answer to when it’s gonna be fixed or this problem is gonna be resolved.

    NHTSA complaint 11761574
14. Filed Sep 1, 2026Failure Aug 24, 202657,000 milesLoganville, GAElectrical system, Engine control module (ecu/ecm), Active shutters/grill

    The contact owns a 2023 Toyota Tundra. The contact stated that while starting the vehicle, the check engine, Auto Start/Stop, and another unknown warning light illuminated. The message "Grill Shutter Malfunction Low Voltage" was displayed. The vehicle was taken to the dealer, who determined that the battery sensor, alternator, and ECU had short-circuited. The dealer replaced the battery sensor, alternator, and ECU; however, the failure persisted with the check engine and another unknown warning light illuminated. The vehicle was taken back to the dealer, who determined that the grill shutter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 57,000.

    NHTSA complaint 11761331
15. Filed Aug 27, 2026Failure May 15, 2025Auburn, GAEngine, Exterior lighting

    2023 Toyota Tundra CrewMax SR5 4x4, VIN [XXX], approximately 79000 miles. This vehicle has two open safety recalls. Both show "Recall Incomplete, remedy not yet available" on NHTSA's VIN lookup as of XXX NHTSA 25V322 (Toyota 25TB06) was filed XXX for moisture intrusion causing both reverse lamps to fail. Toyota's remedy notice estimated that the remedy would begin to be available in the fourth quarter of 2025. That estimate is now approximately nine months past and no remedy is available for this VIN. NHTSA 25V767 (Toyota 25TB14) was filed XXX for machining debris causing number one main bearing failure, with symptoms including engine knocking, rough running, no-start, and loss of motive power. Interim notices were mailed XXX. The remedy has been postponed and remains unreleased for this VIN, with rollout phased by vehicle age. I am filing because the manufacturer has been unable to provide a remedy for either recall within a reasonable time. I have owned this vehicle since XXX and have been unable to obtain repair for a known safety defect for more than fifteen months on the first campaign. I am requesting that NHTSA record this delay and address the manufacture's remedy timeline. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11759976
16. Filed Aug 24, 2026Failure Jun 28, 2026Sugar Land, TXEngine

    My 2023 Toyota Tundra iForceMAX truck has been out of commission for 56 days (Since June 29, 2026). I have experienced a "shroud rub" issue which is a widely documented design flaw in 2022–2025 Tundras. It happens when pressure from the transmission lines warps the passenger-side plastic fan shroud, pushing it straight into the radiator fins until it rubs a hole right through them. The dealer (Fred Haas Toyota World, Spring TX) has stated that they are still waiting for a new fan shroud to arrive and have NO firm date when it will arrive. This is a safety issue as the vehicle sends a clear warning on the dashboard gauge cluster of the dangerous condition to over heating and advises the driver to immediately pull over, switch offthe engine and let it cool down or risk catastrophic failure.

    NHTSA complaint 11759134
17. Filed Aug 21, 2026Failure Aug 1, 2026Norfolk, MAEngine, Fuel/propulsion system, Service brakes

    Ive been waiting for years for the previous recalls I have been informed about to get fixed. Feul system,brake lights.Was told by Toyota that someone would call me to come to get them taken care of. In the meantime, constantly checking that my brake lights are working before departing on any excursions in truck & patiently waiting for toyota to reach out when they were gonna fix the first 2 recalls that I was notified about. I can't recall the date exactly, but I was driving on the highway w/ my still backward carseat, facing 2y.o. baby safely strapped in,ThankGod.As accelerating into my lane, heard huge BOOM like an IED. Immediately, the check engine light among others came on.Truck immediately lost power & was violently shaking.Felt it in the steering wheel, but largely in engine compartment.@this time,I tried to get over to shoulder to a safe place.I turned the car off.Let it rest checked on my infant in back made sure he was ok. After letting car rest, turn back on to my surprise All lights were off.I was w/in few miles of home so went directly back, never getting to my intended destination. Shortly before driveway, all lights came back on & multiple service messages.Since then the truck has not been driveable,As we have specifically looked up recalls,thusly Nov.recall matched lights on the dash for the specific make,year, model of truck. From my understanding, it says that there is no remedy for such recall. But that is untrue. The remedy is an entirely new engine. They just haven't rolled out the recall info to everyone applicable. I am unable to work. My home is without a vehicle and this is unacceptable.Along w/ safety risk to me and infant. I'm sure Toyota doesn't want to admit or remedy Because that is very costly. But this was a mistake made by the company. And it should be remedied, because our family is suffering in various ways. Lost revenue. Inability to respond if emergency etc.I need a new engine.& in the interim,I need a car supplied while fixed.

    NHTSA complaint 11758505
18. Filed Aug 19, 2026Failure Dec 25, 202570,000 milesMidlothian, TXEngine and engine cooling

    The contact owns a 2023 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling). The contact stated that while driving 40 MPH, there was white smoke coming from the exhaust pipe. The vehicle was taken to a dealer to be diagnosed, and the head gasket needed to be replaced. The vehicle was not repaired under the recall because there was sludge found inside the engine. The manufacturer was notified of the failure. The failure mileage was 70,000.

    NHTSA complaint 11758060
19. Filed Aug 18, 2026Failure Apr 23, 2025Woodbridge, VAEngine

    While I was driving on Highway 459, the vehicle suddenly experienced a complete engine failure and lost power in the middle of the roadway. The vehicle could no longer accelerate or maintain its speed, leaving me stranded in an active traffic lane. This sudden failure placed me and other motorists at serious risk of a collision. Vehicles approaching from behind had to slow down, stop or change lanes to avoid hitting my disabled vehicle. I activated the hazard lights and attempted to move the vehicle to a safer location, but because the engine was no longer functioning, I was unable to safely remove it from the roadway. Before the incident, the vehicle displayed the following warning lights, messages or symptoms: NO PRIOR WARNING The vehicle was transported to OURISMAN TOYOTA OF WOODBRIDGE for inspection. The facility determined that ENGINE WAS BAD. The engine and vehicle remain available for inspection upon request. This was an abrupt and dangerous loss of engine power in active traffic. A vehicle should not experience a sudden engine failure that leaves it immobilized in the middle of a highway, especially without sufficient warning to allow the driver to reach a safe location. I am reporting this incident because the failure created a serious safety hazard for me and other motorists, and I am concerned that the same defect could affect other vehicles.

    NHTSA complaint 11757819
20. Filed Aug 18, 2026Failure Jul 24, 2026Pacific Palisades, CAEngine, Power train, Vehicle speed control

    -Our Toyota Tundra Hybrid suffered total catastrophic engine failure due to metal shavings found throughout the engine and oil system. This is the same issue that prompted NHTSA ID Number: 25V767000 recall of Toyota's V35A engines. The tundra is available for inspection. -Statement regarding safety put at risk by my husband: I felt a vibration from the engine compartment (seeming to come from the front right side) and then I suddenly lost complete power. I was traveling in the number one lane (the fast lane). I immediately put my hazards on and had to navigate to the number two lane and then over to the narrow shoulder under no power whatsoever. I had to navigate around multiple semi-trucks. This was a very dangerous situation and I barely got it over to the shoulder. If my teenage daughters were driving this car they likely wouldn't have been able to safely navigate it across two lanes with no power in the setting of multiple semi-trucks on a two-lane divided highway. Again, a very dangerous situation. I shut down the engine and waited five minutes and restarted it. Shifting into gear the warning indicator said 'hybrid system disconnected'. -The total catastrophic engine failure has been confirmed by the Toyota Dealership. Th4ey Confirmed multiple shavings of metal in the entire oil system and the engine has seized. He said that the engine needed to be replaced. -The tundra has not been inspected by the manufacturer, police, insurance (yet) or others besides the Toyota dealership. -There were no warning lamps, messages, or other symptom of the pending catastrophic total engine failure.

    NHTSA complaint 11757587