Complaints over time
Complaints about the 2021 Vanleigh Vilano peaked in 2023, with 1 filed
Owner complaints about this model year, by the year they were filed with NHTSA.
Source: NHTSA ODI complaints file. The lighter column runs through October.
Model year
2021 Vanleigh Vilano
Trailer, Not Applicable, built in United States. Owner complaints on file from Jul 5, 2023 to Jun 12, 2026.
Recall campaigns covering this model year1366 vehicles or units across those campaigns
Owner complaints22.0 times the median 2021 trailer
Severity index0.02021 trailers average 7.7
First 24 months0Complaints in its first two years
Components
50% of complaints about the 2021 Vanleigh Vilano name tires
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Source: NHTSA ODI complaints file. A complaint can name more than one component; it is counted under the first.
Recalls
One recall campaign covers the 2021 Vanleigh Vilano
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 21V-355 | May 14, 2021 | Water heater housing may not have been properly sealed, allowing gas to enter the coach | Equipment | 366 | Repair or modification |
Source: NHTSA ODI recalls file.
Owner complaints
What owners reported about the 2021 Vanleigh Vilano
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
2 complaints on file, page 1 of 1.
- Filed Jun 12, 2026Failure Nov 20, 2024Flagstaff, AZFifth wheel assembly
The contact owns a 2021 Vanleigh Vilano RV. The contact stated that while driving at various speeds on two separate occasions, the contact observed excessive vertical movement in the pin box/fifth-wheel hitch assembly. Upon pulling to a gas station and inspecting the vehicle, the contact noticed that the mounting screws under the fifth wheel holding the fiberglass had ripped through the fiberglass. The RV was taken to the dealer, where it was diagnosed with a fractured frame. The RV was repaired, but the failure recurred approximately 18 months later. The RV was inspected by an independent mobile technician; however, a definitive diagnosis was currently pending. The failure mileage was unknown.
NHTSA complaint 11743741 - Filed Jul 5, 2023Failure May 30, 2023Mesa, AZTires
I’ve had three blow outs all westlake tires 215/75R 17.5 all on the freeway speed 60 Mph have been told by several tire companies that this is a low grade tire and I should replace them, the manufacturer is replacing them on the new models but would not on ours first one blow in south decota. The other was in az and the last was in Colorado speed and tire pressure was as per manufacturer
NHTSA complaint 11530505
Source: NHTSA ODI complaints file.
Investigations
NHTSA has not opened an investigation on this model year
Source: NHTSA ODI investigations file.
Service bulletins
4 manufacturer communications cover this model year
Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall.
- VRI-001 Sep 2, 2024 · Service Bulletin/Repair Instructions
This is repair instructions sent out to more than one dealer. This repair process is for the rear fender skirt panels (left and right hand) in the event of excessive movement. - 11-2021 Nov 3, 2021 · Service Bulletin/Repair Instructions
It has come to our attention that some 2021 Vilano and Beacon 5th wheel RV's were manufactured with the gate valves arranged in such a way that the black and the gray valves must be open to drain the gray tank. To correct this issue, we are asking owners t… - VSB-05 Feb 3, 2022 · Service Bulletin/Repair Instructions
It has come to our attention that some 2021 and 2022 Vilano, Pinecrest and Beacon 5th wheel RV's have skylights that are developing cracks. - VSB-04 Nov 3, 2021 · Service Bulletin/Repair Instructions
Some 2021 Vilano and Beacon 5th wheel RV's were manufactured with the gate valves arranged in such a way that the black and the gray valves must be open to drain the gray tank. To correct this issue, Tiffin is asking owners to arrange to take their RV into…
Source: NHTSA manufacturer communications files.