2012 Volvo C30

10 complaints on file, page 1 of 1.

1. Filed Feb 16, 2026Failure Jan 8, 2026Tallahassee, FLUnknown or other

   On Jan. 8, 2026, and February 10, 2026, while driving on I-75 and 1-10 at approximately 70 miles an hour, my passenger door lock disengaged multiple times ---it came open -- while was driving on the highway at top speeds. It has done this at least 8 other times since then. When the door disengages, it is partially open, the wind comes into the car and all of the lights inside come on, the dash caution sign lights up and the dash reads that the door is open. The locks are still in lock position as they are when it automatically locks when you pull off in the car. So none of the doors are previously open. This may be what keeps the door from swinging fully open when driving. I have reported this happening to my Volvo dealer and they have not been able to find any electronic reading or figure out what is happening to tell them what is going on. Nor have they been able to duplicate the door opening in driving mode when they take it out, probably because it happens when I am driving on the highway. But the passenger door lock continues to disengage, breaching the vacuum sealed protection the car once offered. I understand this has happened with other Volvos, the S60 and possibly other P1 platform Volvos. I understand there have been door latch recalls on the Volvo product. Now it is happening with the C30 and must be addressed.

   NHTSA complaint 11718235
2. Filed Nov 27, 2023Failure Nov 14, 2023Austin, TXVisibility/wiper

   The top corners of the windshield have come loose from the seal. The risk is losing a windshield at highway speed. The vehicle was taken to the dealership who referred us to a body shop. The vehicle was then taken to Gerber Collision & Glass - Austin where the problem was confirmed.

   NHTSA complaint 11557020
3. Filed Nov 11, 2023Failure Nov 8, 2023Euless, TXWindshield

   The seal around the front windshield of the car is leaking. The leak lets water in the car while driving, it’s dripping down the windshield which is very distracting. The excess amount of water being let into the vehicle also fogs up the front windshield and side windows. This causes a huge visual impairment putting myself and others at risk on the road. There are many other Volvos from similar years and models that I’m seeing have the same issue. I have never had the issue looked at, but Volvo representatives say they know about the issue. However, there is no recall in place to fix the issue and to keep drivers safe on the roads.

   NHTSA complaint 11554638
4. Filed Feb 14, 2022Failure Dec 6, 2021Iron Mountain, MIVisibility/wiper

   My windshield has become loose and makes a very loud noise when going over any bumps. Im very concerned that at some point, it will shatter while driving.

   NHTSA complaint 11451805
5. Filed Jun 2, 2021Failure Jun 1, 2021Jersey City, NJUnknown or other

   - The front windshield leaks - This allowed water to fall into the footwells and enter the CEM which controls basically the whole car and made my car turn off while I was driving nearly 45mph which was very dangerous, the sudden surprise made me turn my attention away from the road - I don't have any details on it being inspected before but it has never leaked before and after a heavy rainstorm the problem with the leak arose and damaged my CEM, it was wet and corroded a bit and I figured that this water damaged the CEM - The electrical system was acting a bit funky like the radio not working right and my turn signals flashing faster than normal and the right headlight not working, it all happened in pretty much one day, I didn't really think it was anything serious until the car shut off - Volvo needs to recall this on pretty much all year C30s and possibly other Volvo models made around this year because this little leak can easily cause someone to lose control of their car

   NHTSA complaint 11419292
6. Filed Feb 2, 2016Failure Jan 21, 201644,700 milesGreenville, TXElectrical system

   ON JANUARY 21, 2016, MY VOLVO C30'S FAULTY FACTORY-INSTALLED, BLEMISH-FREE, WINDSHIELD LEAKED WHICH PERMITTED WATER TO FLOW DOWN THE A PILLAR AND INTO THE CAR'S ELECTRONICS. AS A CONSEQUENCE, THE CAR BECAME QUICKLY DEBILITATED BECAUSE OF ELECTRICAL FAILURE. SMOKE BILLOWED FROM THE ENGINE COMPARTMENT BEFORE THE BATTERY CABLE WAS QUICKLY REMOVED. ON JANUARY 21, 2016, THE C30 WAS TOWED VIA FLAT BED TRUCK TO VOLVO OF DALLAS FOR REPAIR. THE COURTEOUS AND KNOWLEDGEABLE MAINTENANCE TECHNICIAN, KENNY, IMMEDIATELY IDENTIFIED THE PROBLEM AS A LEAKING WINDSHIELD AND STATED THAT 'THIS IS A KNOWN PROBLEM IN VOLVOS.' HE STATED, THE 'SEALANT/PRIMER MAY SEPARATE CAUSING A LEAK.' VOLVO OF DALLAS HELD THE CAR FOR A WEEK DURING REPLACEMENT OF THE LEAKING WINDSHIELD. I REQUESTED A FULL INSPECTION. APPARENTLY, THAT WAS COMPLETED. THE 4 YEAR WARRANTY IS DUE TO EXPIRE SOON. I DO NOT TRUST THAT THIS CAR, WHICH NOW HAS AN ELECTRICAL 'HISTORY,' IS ANY LONGER IN THE CAREFUL AND METICULOUS CONDITION IN WHICH I HAVE ALWAYS KEPT IT PRIOR TO THE LEAK. MY RESEARCH ONLINE AND THROUGH OTHER RESOURCES INFORMS ME THAT THE LEAKING WINDSHIELD IS A KNOWN SAFETY ISSUE IN LATER MODEL VOLVOS.

   NHTSA complaint 10823665
7. Filed Feb 23, 2015Failure Feb 22, 201593,500 milesTemple, TXEngine, Vehicle speed control

   WHILE DRIVING MY VOLVO C30 REDESIGN, I STOPPED AT A STOP SIGN BEFORE I ENTERED MAIN ROAD FROM PARKING LOT AREA VEHICLE BEGAN TO ACCELERATE TO A HIGH SPEED INDEPENDENTLY CAUSING THE CAR TO MOVE TOWARDS THE INTERSECTION. NO CARS WERE APPROACHING SO I CONTINUED TURNING BUT IT WAS VERY UNSAFE. IT HAPPENED BEFORE AT FORT HOOD AND NEAR MY HOUSE IN TEMPLE TX. ALWAYS SAME CONDITIONS; AS I START TO ACCELERATE THE VEHICLE JUMP INTO A HIGH SPEED OR GEAR. THIS MORNING THE VEHICLE WAS ON HIGH REV IDLE, DID NOT WENT DOWN UNTIL I CHANGE TO MANUAL AND BACK TO AUTOMATIC. PLEASE ADVICE. *TR

   NHTSA complaint 10690020
8. Filed Aug 12, 2014Failure Aug 11, 2014Sidney, NYVehicle speed control

   WHILE STOPPED AT A RED LIGHT, MY 2012 VOLVO C30 RDESIGN BEGAN TO ACCELERATE TO A HIGH SPEED INDEPENDENTLY CAUSING THE CAR TO MOVE INTO THE INTERSECTION. I IMMEDIATELY JAMMED THE BRAKE PEDDLE TO STOP THE CAR FROM MOVING ANY FURTHER AND PUT THE CAR INTO PARK CAUSING THE CAR TO STOP. THE CAR CONTINUED TO REV FOR AN ADDITIONAL 5 SECONDS, THEN DROP DOWN TO A NORMAL IDLE. PLEASE HELP, WHAT'S WRONG? *TR

   NHTSA complaint 10621843
9. Filed Apr 23, 2014Failure Mar 19, 201423,328 milesPortland, ORService brakes

   A MESSAGE THAT READ "ABS BRAKE SYSTEM NEEDS SERVICE" CAME ON IN MY 2012 VOLVO C30 TUESDAY, MARCH 18. I CALLED THE SERVICE DEPT OF THE DEALERSHIP - HE SAID HE KNEW WHAT IT WAS AND TO BRING IT IN EITHER THURS OR FRI. I CHOSE FRIDAY MORNING. WEDNESDAY ABOUT 3PM AS I WAS DOWNSHIFTING TO SLOW THEN APPLIED MY BRAKES THERE WAS NO BRAKING ACTION. I WAS ABLE TO PULL INTO THE LEFT TURN LANE TO AVOID RUNNING INTO THE CAR AHEAD OF ME AND THEN THE BRAKES ENGAGED. I PULLED OVER AND CALLED THE DEALERSHIP. THEY SAID BRING IT IN RIGHT THEN. I WAS A BIT FLUSTERED AND SO STUPIDLY DROVE THE CAR INTO DEALERSHIP ABOUT 4 OR 5 MILES AWAY FROM WHERE I WAS. WHEN I PICKED THE CAR THE NEXT MORNING, I ASKED WHAT THE ISSUE WAS. THE SERVICE PERSON SAID THAT SOME COMPONENT OF THE BRAKE CAME APART (I DON'T RECALL IF HE SAID THE NAME OF THE PART) AND THEY PUT A CLAMP ON IT. I ASKED HOW LONG THIS ISSUE HAD BEEN OCCURRING - HE SAID FOR "MORE THAN A YEAR". I'VE SUBSEQUENTLY CALLED THE OWNER OF THE DEALERSHIP AND HE WAS AWARE OF THE ISSUE BUT SAID THERE WAS NO RECALL FROM VOLVO AND HE COULDN'T AFFORD TO REPAIR THE PROBLEM ON ALL THE C30S UNTIL THE ISSUE AROSE AND VOLVO WOULD THEN REIMBURSE HIS DEALERSHIP FOR THE REPAIR. I THEN CALLED VOLVO CUSTOMER CARE APRIL 16TH AND COULD NOT GET A STRAIGHT ANSWER FROM THE PERSON I SPOKE WITH ABOUT WHETHER OR NOT THEY WERE AWARE OF THIS ISSUE. CLEARLY I WILL BE SELLING THIS CAR BUT WANT TO ENSURE THE PUBLIC IS MADE AWARE OF THE POSSIBILITY OF A BRAKE FAILURE ON THE 2012 C30S. UPDATED 5/21/14*CN UPDATED 06/03/2014 *JS

   NHTSA complaint 10584502
10. Filed Sep 18, 2012Failure Sep 4, 2012361 milesGaines, VAVehicle speed control

    TL* THE CONTACT OWNS A 2012 VOLVO C30. THE CONTACT STATED THAT WHILE THE BRAKES WERE BEING DEPRESSED, THE VEHICLE ACCELERATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER TWICE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 361 AND THE CURRENT MILEAGE WAS 1200. ...UPDATED 10/10/12 *BF THE CONSUMER STATED THE VEHICLE SPONTANEOUSLY AND RANDOMLY FAILS TO RESPOND FOR THREE OR FOUR SECONDS UPON PRESSING THE ACCLERATOR AND THEN IT SURGES. AFTER ABOUT THREE SECNDS IT FALLS BACK TO NORMAL SPEED. UPDATED 10/17/2012 *JS

    NHTSA complaint 10475872